| Most common failures | No# failures |
|---|
| Headlamp aim out of alignment | 21 |
| Windscreen wiper does not clear the windscreen effectively | 17 |
| Registration plate lamp issues | 14 |
| Offside Rear fog lamp not working |1.3.2b| | 7 |
| Service brake efficiency below requirements (1.2.2 (a) (i)) | 6 |
| Horn not working |1.6.2a| | 4 |
| Parking brake lever has no reserve travel |3.1.6b| | 3 |
| Nearside Front Anti-roll bar linkage has excessive play in a pin/bush |2.4.G.2| | 3 |
| Brakes imbalanced across an axle | 3 |
| Brake pedal has no servo assistance |3.3.B.2| | 3 |
| Brake hose excessively deteriorated | 3 |
| Exhaust emissions exceed manufacturers specified limit (8.2.2.2 (a)) | 3 |
| Horn not working (7.7 (a)) | 3 |
| Offside Front Anti-roll bar linkage has excessive play in a pin/bush |2.4.G.2| | 2 |
| Registration plate issues | 2 |
| Nearside Rear Stop lamp not working |1.2.1b| | 2 |
| Rear fog lamp not working |1.3.2b| | 2 |
| Brake pipe excessively corroded | 2 |
| Nearside Rear Rear position lamp|s| not working |1.1.A.3b| | 2 |
| Nearside Rear coil spring broken |2.4.C.1a| | 2 |
| Nearside Stop lamp not working |1.2.1b| | 2 |
| Offside Stop lamp not working |1.2.1b| | 2 |
| Offside Rear coil spring broken |2.4.C.1a| | 2 |
| Offside Headlamp not working on main beam |1.7.5a| | 2 |
| Brake hose damaged | 2 |
| Nearside Rear Body has a sharp edge caused by damage |6.1.C.1| | 2 |
| Offside Obligatory mirror insecure |8.1.1| | 2 |
| Offside Front Service brake lagging in operation (1.2.1 (d)) | 2 |
| Nearside Front Steering rack gaiter missing or no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 2 |
| Offside Rear Service brake effort inadequate at a wheel (1.2.1 (a) (i)) | 2 |
| Brake servo defective or ineffective (1.1.10 (a) (i)) | 2 |
| Offside Rear Coil spring fractured or broken (5.3.1 (b) (i)) | 2 |
| Offside Rear Stop lamp(s) not working (4.3.1 (a) (ii)) | 2 |
| Nearside Front Headlamp aim projected beam image is obviously incorrect |4.1.2 |c|| | 1 |
| Offside Front Headlamp aim projected beam image is obviously incorrect |4.1.2 |c|| | 1 |
| Exhaust emits an excessive level of metered smoke for a turbo charged engine |7.4.B.3b| | 1 |
| Nearside Headlamp aim aimed so that it dazzles other road users |1.8.A.1a| | 1 |
| Offside Headlamp aim aimed so that it dazzles other road users |1.8.A.1a| | 1 |
| Nearside Headlamp aim beam image kick up to the offside |1.8| | 1 |
| Offside Headlamp aim beam image kick up to the offside |1.8| | 1 |
| Parking brake: efficiency below requirements |3.7.B.7| | 1 |
| Nearside Rear Direction indicator not working |1.4.A.2c| | 1 |
| Nearside Front Headlamp aim beam image kick up to the offside |1.8| | 1 |
| Offside Front Headlamp aim beam image kick up to the offside |1.8| | 1 |
| Nearside Front Anti-roll bar attachment bracket/mounting fractured |2.4.G.1| | 1 |
| Offside Front Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
| Headlamp switch faulty |1.7.1| | 1 |
| Nearside Rear Shock absorber has an excessively worn bush |2.7.4| | 1 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Seat belt has a cut which has significantly weakened the webbing |5.2.2a| | 1 |
| Offside Rear Rear fog lamp not working |1.3.2b| | 1 |
| Battery insecure |1.9.1| | 1 |
| Offside Front Seat belt locking mechanism does not secure or release |5.2.5a| | 1 |
| Offside Rear Direction indicator not working |1.4.A.2c| | 1 |
| Offside Outer Front constant velocity joint gaiter deteriorated to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Rear Exhaust has a major leak of exhaust gases box |7.1.2| | 1 |
| Rear Mechanical brake component has restricted free movement | 1 |
| Central Rear Exhaust has a major leak of exhaust gases |6.1.2 |a|| | 1 |
| Nearside Rear coil spring incomplete |2.4.C.1a| | 1 |
| Nearside Front Direction indicator incorrect colour |4.4.3 |a|| | 1 |
| Nearside Side repeater missing Non factory head light/indicator unit fitted, removing side repeater |4.4.1 |a| |ii|| | 1 |
| Offside Side repeater missing Non factory head light/indicator unit fitted, removing side repeater |4.4.1 |a| |ii|| | 1 |
| Offside Rear fog lamp not working |4.5.1 |a| |ii|| | 1 |
| Offside Obligatory mirror insecure Adjustment mechanism broken allowing mirror to fold unaided |3.3 |b| |ii|| | 1 |
| Spare wheel insecure in carrier |6.1.5 |b| |i|| | 1 |
| Offside Front Anti-roll bar linkage damaged and seriously weakened |2.4.G.1| | 1 |
| Offside Front Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
| Nearside Front Brake hose twisted |found during steering lock to lock check| |2.2.D.2b| | 1 |
| Windscreen wiper blade insecure | 1 |
| Nearside Front Headlamp insecure |1.7.3| | 1 |
| Nearside Front Direction indicator incorrect colour |1.4.A.2f| | 1 |
| Offside Front Direction indicator incorrect colour |1.4.A.2f| | 1 |
| Horn is a siren |1.6.2c| | 1 |
| Rear brake disc in such a condition that it is seriously weakened | 1 |
| Front Anti-roll bar linkage has excessive play in a pin/bush |2.4.G.2| | 1 |
| Nearside Headlamp insecure |1.7.3| | 1 |
| Offside Headlamp insecure |1.7.3| | 1 |
| Nearside Steering rack gaiter split |2.2.D.2d| | 1 |
| Offside Steering rack gaiter split |2.2.D.2d| | 1 |
| Rear Exhaust system not adequately supported hanger broken |7.1.1| | 1 |
| Nearside Rear position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
| Nearside Rear fog lamp adversely affected by the operation of another lamp |1.3.2f| | 1 |
| Offside Headlamp not working on dipped beam |1.7.5a| | 1 |
| Offside Headlamp aim not tested |1.8.A.1c| | 1 |
| Nearside Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Coil spring fractured or broken |5.3.1 |b| |i|| | 1 |
| Brake servo vacuum pipe split |3.6.C.1b| | 1 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Front Direction indicators not working |1.4.A.2c| | 1 |
| Service brake: efficiency below requirements |3.7.B.7| | 1 |
| Offside Rear Body has a sharp edge caused by damage |6.1.C.1| | 1 |
| Fuel cap/sealing device does not fasten securely maintaining the sealing arrangement |7.2.4b| | 1 |
| Exhaust has a major leak of exhaust gases from centre box to tail pipe |7.1.2| | 1 |
| Offside Front Anti-roll bar insecure bracket missing |2.4.G.1| | 1 |
| Nearside Rear Lower Shock absorber has an excessively worn bush |2.7.4| | 1 |
| Offside Rear Lower Shock absorber has an excessively worn bush |2.7.4| | 1 |
| Nearside Outer Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Offside Outer Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Offside Rear Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Nearside Obligatory mirror insecure |8.1.1| | 1 |
| Nearside Front Anti-roll bar linkage rubber mounting deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Nearside Front Lower Front suspension ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Offside Front Lower Front suspension ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Nearside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Nearside Front Steering rack gaiter insecure |2.2.D.2d| | 1 |
| Nearside Rear Body panel corroded and likely to cause injury wheel arch (6.2.1 (a) (i)) | 1 |
| Nearside Steering rack gaiter missing or no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |
| Offside Front Lower Suspension component ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Rear Fuel hose leaking (6.1.3 (b) (i)) | 1 |
| Offside Front Outer Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 1 |
| Nearside Front Front passenger door cannot be opened from inside the vehicle (6.2.3 (a)) | 1 |
| Nearside Front Headlamp not working on main beam (4.1.1 (a) (ii)) | 1 |
| Offside Front Headlamp not working on main beam (4.1.1 (a) (ii)) | 1 |
| Offside Front Dipswitch operation does not deflect all main beam headlamps to make them dipped beams turns off, o/s dip beam (4.1.3 (b)) | 1 |
| Nearside Front Seat belt anchorage loose passenger seat buckle loose (7.1.1 (b)) | 1 |
| Front Oil leaking excessively from engine underside of engine, leaking on workshop floor at time of test (8.4.1 (a) (i)) | 1 |
| Nearside Front Inner Steering rack has excessive free play detected at the steering wheel (steering rack fitted) tie rod arm joint (2.3 (a) (i)) | 1 |
| Nearside Front Direction indicator incorrect colour (4.4.3 (a)) | 1 |
| Nearside Rear Inner Suspension component mounting prescribed area excessively corroded significantly reducing structural strength (5.3.6 (a) (i)) | 1 |
| Offside Front Inner Subframe mounting prescribed area excessively corroded significantly reducing structural strength Lower wheel arch (5.3.6 (a) (i)) | 1 |
| Offside Headlamp insecure (4.1.1 (c)) | 1 |
| Front passenger door cannot be opened from outside the vehicle (6.2.3 (a)) | 1 |
| Nearside Front Integral body structure corroded to the extent that the rigidity of the assembly is significantly reduced (6.1.1 (c) (i)) | 1 |
| Offside Rear Integral body structure corroded to the extent that the rigidity of the assembly is significantly reduced (6.1.1 (c) (i)) | 1 |
| Offside Rear Service brake grabbing severely (1.2.1 (c)) | 1 |
| Offside Rear Service brake lagging in operation (1.2.1 (d)) | 1 |
| Rear Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 1 |
| Exhaust silencer insecure (8.1.1 (b) (i)) | 1 |
| Emissions not tested (8.2.2.2 (e)) | 1 |
| Nearside Front Upper Suspension arm ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Horn not working (7.7 (a) (ii)) | 1 |
| Offside Rear fog lamp not working (4.5.1 (a) (ii)) | 1 |
| Exhaust has a major leak of exhaust gases centre section (6.1.2 (a)) | 1 |
| Nearside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength inner sill within 12 inch radius arm. (5.3.6 (a) (i)) | 1 |
| Rear Stop lamp(s) all not working (4.3.1 (a) (iii)) | 1 |
| Steering rack insecure fixing bolts loose (2.1.3 (a) (i)) | 1 |
| Nearside Rear Service brake effort inadequate at a wheel (1.2.1 (a) (i)) | 1 |
| Nearside Front Inner Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 1 |
| Nearside Rear Position lamp adversely affected by the operation of another lamp fault when indicator applied (4.2.3 (c)) | 1 |
| Nearside Rear Coil spring fractured or broken (5.3.1 (b) (i)) | 1 |
| Stop lamp(s) all not working (4.3.1 (a) (iii)) | 1 |
| Nearside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength outer sill (5.3.6 (a) (i)) | 1 |
| Rear brake excessively fluctuating | 1 |
| Rear brake application uneven | 1 |
| brake disc in such a condition that it is seriously weakened both rear (3.5.1i) | 1 |
| Rear Exhaust has a major leak of exhaust gases (7.1.2) | 1 |
| Rear Exhaust has part of the system excessively deteriorated (7.1.1a) | 1 |
| Offside Front Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Offside Front Lower Steering linkage ball joint ball joint dust cover excessively damaged or deteriorated so that it no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |
| Nearside Rear Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Offside Rear Direction indicator incorrect colour (4.4.3 (a)) | 1 |
| Offside Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
| Nearside Outer Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced middle of sill (marked) (6.1.1 (c) (i)) | 1 |
| Nearside Rear Service brake effort inadequate at a wheel below minimum requirements when applied (1.2.1 (a) (i)) | 1 |
| Stop lamp(s) not working both (4.3.1 (a) (ii)) | 1 |
| Nearside Rear coil spring broken (2.4.C.1a) | 1 |
| Nearside Headlamp aim beam image kick up to the offside (1.8) | 1 |
| Offside Headlamp aim beam image kick up to the offside (1.8) | 1 |
| Nearside Front Service brake excessively binding (1.2.1 (f)) | 1 |
| Trailer electrical socket (13 pin) not functioning at all (4.10 (c) (ii)) | 1 |
| Offside Front Suspension arm pin or bush excessively worn Rear bush (5.3.4 (a) (i)) | 1 |
| Offside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength Outer sill (5.3.6 (a) (i)) | 1 |
| Front Exhaust system insecure (6.1.2 (a)) | 1 |
| Nearside Front Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 1 |
| Offside Front Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 1 |
| Nearside Front Headlamp aim unable to be tested (4.1.2 (b)) | 1 |
| Offside Front Headlamp aim unable to be tested (4.1.2 (b)) | 1 |