| Most common failures | No# failures |
|---|
| Registration plate lamp issues | 16 |
| Brakes imbalanced across an axle | 11 |
| Nearside Headlamp aim beam image kick up to the offside |1.8| | 10 |
| Brake pipe excessively corroded | 10 |
| Offside Headlamp aim beam image kick up to the offside |1.8| | 9 |
| Offside Rear fog lamp not working |1.3.2b| | 9 |
| Headlamp aim out of alignment | 9 |
| Horn not working |1.6.2a| | 8 |
| Windscreen wiper does not clear the windscreen effectively | 8 |
| Rear brake application uneven | 6 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 5 |
| Rear brake binding | 5 |
| Rear fog lamp not working |1.3.2b| | 5 |
| Offside Rear Rear fog lamp not working |1.3.2b| | 3 |
| Registration plate issues | 3 |
| Brake hose excessively deteriorated | 3 |
| Offside Front constant velocity joint gaiter split |2.5.C.1a| | 3 |
| Nearside Front Steering rack gaiter split |2.2.D.2d| | 3 |
| Rear fog lamp not working (4.5.1 (a) (ii)) | 3 |
| Nearside Rear Shock absorber has a serious fluid leak |2.7.3| | 2 |
| Nearside Front Headlamp aim beam image kick up to the offside |1.8| | 2 |
| Offside Front Headlamp aim beam image kick up to the offside |1.8| | 2 |
| Nearside Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 2 |
| rear brakes release unevenly |3.7.B.4| | 2 |
| Emissions not tested |7.0| | 2 |
| Nearside Headlamp not working on dipped beam |1.7.5a| | 2 |
| Centre Exhaust system not adequately supported |7.1.1| | 2 |
| Nearside Stop lamp not working |1.2.1b| | 2 |
| Fuel system component leaking |7.2.3| | 2 |
| Speedometer cannot be illuminated. |6.7.3| | 2 |
| Nearside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 2 |
| Offside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
| Power steering pump drive system defective |2.3.6| | 2 |
| Nearside Front wheel bearing rough when rotated |2.5.A.2| | 2 |
| Rear fog lamp tell tale not working |1.3.1b| | 2 |
| Offside Stop lamp not working |1.2.1b| | 2 |
| Offside Rear Service brake excessively binding |1.2.1 |f|| | 2 |
| Battery insecure |1.9.1| | 2 |
| Headlamp switch faulty |1.7.1| | 2 |
| Horn not working (7.7 (a) (ii)) | 2 |
| Main beam tell-tale not working (4.9.1 (a) (ii)) | 2 |
| Nearside Front Position lamp not working (4.2.1 (a) (ii)) | 2 |
| Nearside Front Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Front Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Brake pedal creeps down when held under pressure |3.3.B.1a| | 1 |
| Offside Rear fog lamp missing |1.3.2a| | 1 |
| Nearside Driver`s seat fore and aft adjustment mechanism not functioning as intended. |6.2.A.3| | 1 |
| Nearside Front Upper Front suspension ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Rear fog lamp obviously incorrectly positioned |1.3.2a| | 1 |
| Offside Rear Direction indicator not working |1.4.A.2c| | 1 |
| Nearside Obligatory mirror insecure |8.1.1| | 1 |
| Offside Headlamp insecure |1.7.3| | 1 |
| Offside Front Suspension arm ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Nearside Front Obligatory mirror insecure |8.1.1| | 1 |
| Parking brake lever has no reserve travel |3.1.6b| | 1 |
| Headlamp aim beam image kick up to the offside |1.8| | 1 |
| Front Exhaust has part of the system excessively deteriorated |7.1.1a| | 1 |
| Offside Front front brake binding |3.7.B.1| | 1 |
| Nearside Steering rack gaiter split |2.2.D.2d| | 1 |
| front brake binding |3.7.B.1| | 1 |
| Offside Front Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Front Upper Suspension arm ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Offside Front Brake lining|s| insecure |3.5.1g| | 1 |
| Horn sounds harsh or grating |1.6.2e| | 1 |
| Front Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Rear fog lamp insecure |1.3.2a| | 1 |
| Nearside Outer Front constant velocity joint gaiter split |2.5.C.1a| | 1 |
| Horn not working |7.7 |a| |ii|| | 1 |
| Nearside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength outer sill |5.3.6 |a| |i|| | 1 |
| Offside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
| Centre Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Emissions not tested |7.4.B.1| | 1 |
| Brake load sensing valve linkage seized |3.6.E.3| | 1 |
| Brake pedal anti-slip provision missing |3.3.A.1b| | 1 |
| Offside Front Direction indicator missing |1.4.A.2b| | 1 |
| Front Fuel system component leaking |7.2.3| | 1 |
| Front Exhaust system not adequately supported |7.1.1| | 1 |
| Offside Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
| Offside rear brake grabbing severely |3.7.A.5b| | 1 |
| Centre Seat belt locking mechanism does not secure or release |5.2.5a| | 1 |
| Nearside Anti-roll bar linkage rubber mounting deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Anti-roll bar linkage rubber mounting deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
| front brakes release unevenly |3.7.B.4| | 1 |
| Offside rear brake recording little or no effort |3.7.B.5a| | 1 |
| Service brake: efficiency below requirements |3.7.B.7| | 1 |
| Offside Direction indicator not working |1.4.A.2c| | 1 |
| Nearside Front Front wheel bearing has excessive play |2.5.A.3c| | 1 |
| Exhaust mounting missing |7.1.1b| | 1 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Outer Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Offside Front Lower Suspension arm ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Nearside Outer Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Outer Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Nearside Front Seat belt retracting mechanism defective |5.2.5b| | 1 |
| Nearside front brake grabbing severely |3.7.A.2b| | 1 |
| Front brake application uneven | 1 |
| Offside front brake binding |3.7.B.1| | 1 |
| Nearside Rear wheel cylinder leaking |3.6.A.1| | 1 |
| Parking brake: efficiency below requirements |3.7.B.7| | 1 |
| Nearside Front Seat belt anchorage prescribed area strength or continuity significantly reduced outer sill |7.1.1 |a| |i|| | 1 |
| Nearside Front Seat belt anchorage prescribed area strength or continuity significantly reduced inner sill |7.1.1 |a| |i|| | 1 |
| Nearside Rear Position lamp not working |4.2.1 |a| |ii|| | 1 |
| Offside Rear Outer Suspension component mounting prescribed area excessively corroded significantly reducing structural strength sill |5.3.6 |a| |i|| | 1 |
| Offside Outer Suspension component mounting prescribed area excessively corroded significantly reducing structural strength sill / step |5.3.6 |a| |i|| | 1 |
| Offside Front Suspension component mounting prescribed area excessively corroded significantly reducing structural strength outrigger to front corner |5.3.6 |a| |i|| | 1 |
| Nearside Front Suspension component mounting prescribed area excessively corroded significantly reducing structural strength outrigger to front corner |5.3.6 |a| |i|| | 1 |
| Nearside Front Road wheel fixing missing |5.2.1 |a| |i|| | 1 |
| Offside Front Road wheel fixing missing |5.2.1 |a| |i|| | 1 |
| Nearside Rear Road wheel fixing missing |5.2.1 |a| |i|| | 1 |
| Offside Rear Road wheel fixing missing |5.2.1 |a| |i|| | 1 |
| Nearside Front Position lamp not working |4.2.1 |a|| | 1 |
| Offside Front Front position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Front Windscreen wiper blade deteriorated |8.2.2| | 1 |
| Offside Front Windscreen wiper blade deteriorated |8.2.2| | 1 |
| Nearside Front Outer Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt |6.1.7 |g| |ii|| | 1 |
| Rear Mechanical brake component has restricted free movement | 1 |
| Steering wheel retaining device insecure |2.1.6| | 1 |
| Nearside Outer Front Anti-roll bar linkage rubber mounting deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Outer Front Anti-roll bar linkage rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Rear Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Rear Exhaust tailpipe not capable of allowing the emission probe to be inserted |7.4.B.1| | 1 |
| Nearside Rear coil spring incomplete |2.4.C.1a| | 1 |
| Offside Front Obligatory mirror seriously damaged, affecting the rear view |8.1.2a| | 1 |
| Fuel pipe leaking filter |7.2.3| | 1 |
| Power steering pump drive system defective belt loose |2.3.6| | 1 |
| Offside Lower Front suspension ball joint dust cover insecure so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Hazard warning switch faulty |1.4.B.1d| | 1 |
| Windscreen has a sticker or other obstruction encroaching by more than 10mm within zone `A` |8.3.1b| | 1 |
| Windscreen has a sticker or other obstruction encroaching into the swept area by more than 40mm outside zone `A` |8.3.1e| | 1 |
| Offside Obligatory mirror seriously deteriorated, affecting the rear view |8.1.2a| | 1 |
| Offside Headlamp not working on dipped beam |1.7.5a| | 1 |
| Nearside Headlamp not working on main beam |1.7.5a| | 1 |
| Offside Headlamp not working on main beam |1.7.5a| | 1 |
| Nearside Body has a sharp edge caused by damage |6.1.C.1| | 1 |
| Offside Obligatory mirror missing |8.1.1| | 1 |
| Offside Obligatory mirror is incapable of being adjusted to provide an adequate view to the rear |8.1.2b| | 1 |
| Offside Obligatory mirror not clearly visible from the drivers seat or incapable of being adjusted to be clearly visible from the driver`s seat |8.1.1d| | 1 |
| Offside Obligatory mirror seriously damaged, affecting the rear view |8.1.2a| | 1 |
| Stop lamp not working |1.2.1b| | 1 |
| Offside Rear reflector missing |1.5.1a| | 1 |
| Offside Front Upper Suspension arm pin or bush excessively worn |5.3.4 |a| |i|| | 1 |
| Offside Front Lower Suspension arm ball joint dust cover no longer prevents the ingress of dirt |5.3.4 |b| |ii|| | 1 |
| Exhaust emissions exceed level of metered smoke for a non-turbo charged engine |8.2.2.2 |b|| | 1 |
| Nearside Front Steering rack gaiter insecure |2.2.D.2d| | 1 |
| Offside Rear Suspension component mounting prescribed area is excessively corroded trailing arm mount ,wheel arch and inner sill |2.4.A.3| | 1 |
| Nearside Rear Suspension component mounting prescribed area is excessively corroded Trailing arm mount |2.4.A.3| | 1 |
| Offside Rear Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Nearside Front Front position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Front Radius arm cracked |2.4.G.1| | 1 |
| Nearside Front Brake hose bulging under pressure |3.6.B.3| | 1 |
| Offside Front Brake hose bulging under pressure |3.6.B.3| | 1 |
| Brake performance not tested |3.7.A.1| | 1 |
| Service brake: efficiency below requirements |3.7.C.1a| | 1 |
| Parking brake: efficiency below requirements |3.7.C.1b| | 1 |
| Nearside Outer Subframe mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Outer Subframe mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Nearside Rear Wheel bearing rough when rotated |5.1.3 |b| |i|| | 1 |
| Nearside Front constant velocity joint gaiter split |2.5.C.1a| | 1 |
| Offside Rear Shock absorber has a serious fluid leak |2.7.3| | 1 |
| Oil leaking excessively from engine (8.4.1 (a) (i)) | 1 |
| Horn not working (1.6.2a) | 1 |
| Headlamp levelling device inoperative (4.1.5 (a)) | 1 |
| Fuel system component leaking fuel pump (6.1.3 (b) (i)) | 1 |
| Nearside Seat belt anchorage prescribed area strength or continuity significantly reduced inner sill (7.1.1 (a) (i)) | 1 |
| Offside Seat belt anchorage prescribed area strength or continuity significantly reduced inner sill (7.1.1 (a) (i)) | 1 |
| Nearside Front Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced (6.1.1 (c) (i)) | 1 |
| Parking brake lever has excessive movement indicating incorrect adjustment (1.1.6 (c)) | 1 |
| Stop lamp(s) adversely affected by the operation of another lamp no stop lights when position lights are on (4.3.3 (b)) | 1 |
| Position lamp adversely affected by the operation of another lamp (4.2.3 (c)) | 1 |
| Offside Rear Upper Shock absorbers has an excessively worn bush (5.3.2 (c)) | 1 |
| Nearside Front Steering rack has excessive free play detected at the steering wheel to the extent that safe steering is affected (steering rack fitted) (2.3 (a) (ii)) | 1 |
| Offside Front Steering rack has excessive free play detected at the steering wheel to the extent that safe steering is affected (steering rack fitted) (2.3 (a) (ii)) | 1 |
| Offside Front Steering rack gaiter missing or no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |
| Offside Front Upper Suspension arm ball joint likely to become detached (5.3.4 (a) (ii)) | 1 |
| Offside Front Upper Suspension arm pin or bush likely to become detached (5.3.4 (a) (ii)) | 1 |
| Position lamp with a multiple light source more than 1/2 not functioning (4.2.1 (a) (ii)) | 1 |
| Offside Steering rack gaiter missing or no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |
| Nearside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength (5.3.6 (a) (i)) | 1 |
| Offside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength (5.3.6 (a) (i)) | 1 |
| Offside Front Upper Suspension arm pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Headlamp not working on dipped beam both front (4.1.1 (a) (ii)) | 1 |
| Front Headlamp aim not tested (4.1.2 (b)) | 1 |
| Offside Rear Rear fog lamp does not emit a steady red light (4.5.4 (a)) | 1 |
| Nearside Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
| Nearside Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 1 |
| Offside Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 1 |
| Service brake efficiency below requirements (1.2.2 (a) (i)) | 1 |
| Power steering inoperative and steering adversely affected (2.1.5 (c) (ii)) | 1 |
| Nearside Rear Coil spring fractured or broken (5.3.1 (b) (i)) | 1 |
| Nearside Front Suspension arm pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Rear Wheel bearing has excessive play (5.1.3 (a) (i)) | 1 |
| Nearside Rear Suspension component mounting prescribed area is inadequately repaired upper shocker mount repair (5.3.6 (a) (i)) | 1 |
| Nearside Rear Integral body structure inadequately repaired such that structural rigidity is significantly reduced inner wheel arch (6.1.1 (d) (i)) | 1 |
| Offside Rear Integral body structure inadequately repaired such that structural rigidity is significantly reduced inner wheel arch (6.1.1 (d) (i)) | 1 |
| Nearside Rear Integral body structure corroded to the extent that the rigidity of the assembly is significantly reduced inner wheel arch (6.1.1 (c) (i)) | 1 |
| Nearside Rear Integral body structure corroded to the extent that the rigidity of the assembly is significantly reduced (6.1.1 (c) (i)) | 1 |
| Offside Rear Integral body structure corroded to the extent that the rigidity of the assembly is significantly reduced (6.1.1 (c) (i)) | 1 |
| Nearside Front Integral body structure corroded to the extent that the rigidity of the assembly is significantly reduced inner wheel arch (6.1.1 (c) (i)) | 1 |
| Offside Front Integral body structure corroded to the extent that the rigidity of the assembly is significantly reduced inner wheel arch (6.1.1 (c) (i)) | 1 |
| Nearside Integral body structure corroded to the extent that the rigidity of the assembly is significantly reduced sill section (6.1.1 (c) (i)) | 1 |
| Emissions unable to be completed due to coolant leak and engine over heating (8.2.2.2 (e)) | 1 |
| Horn not working (7.7 (a)) | 1 |
| Nearside Front Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
| Offside Front Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
| Front Headlamp incorrect colour (4.1.4 (a)) | 1 |
| Offside Seat belt anchorage prescribed area strength or continuity significantly reduced inner and outer sill (7.1.1 (a) (i)) | 1 |
| Nearside Front Upper Suspension arm ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Offside Front Lower Suspension arm ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Horn sound not in accordance with requirements Became louder with use (7.7 (c)) | 1 |
| Offside Front Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Front Coil spring fractured or broken Upper coil (5.3.1 (b) (i)) | 1 |
| Rear Seat belt buckle missing n/s and o/s (7.1.2 (d)) | 1 |