| Most common failures | No# failures |
|---|
| Headlamp aim out of alignment | 26 |
| Windscreen wiper does not clear the windscreen effectively | 25 |
| Brake pipe excessively corroded | 22 |
| Exhaust emissions carbon monoxide content excessive |7.3.B.1a| | 13 |
| Brake hose excessively deteriorated | 12 |
| Rear brake application uneven | 9 |
| Windscreen washer not working | 6 |
| Offside Headlamp aim beam image kick up to the offside |1.8| | 5 |
| Rear brake binding | 5 |
| Rear parking brake recording little or no effort | 5 |
| Registration plate lamp issues | 5 |
| Offside Rear fog lamp not working |1.3.2b| | 4 |
| Offside Stop lamp not working |1.2.1b| | 4 |
| Parking brake: efficiency below requirements |3.7.B.7| | 4 |
| Nearside Headlamp aim beam image kick up to the offside |1.8| | 4 |
| Rear Exhaust has a major leak of exhaust gases |7.1.2| | 4 |
| Brakes imbalanced across an axle | 3 |
| Horn not working |1.6.2a| | 3 |
| Nearside Front Brake hose bulging under pressure |3.6.B.3| | 3 |
| Offside Front Brake hose bulging under pressure |3.6.B.3| | 3 |
| Service brake: efficiency below requirements |3.7.B.7| | 3 |
| Exhaust has a major leak of exhaust gases |7.1.2| | 3 |
| Nearside rear brake recording little or no effort |3.7.B.5a| | 3 |
| Parking brake efficiency below requirements (1.4.2 (a) (i)) | 3 |
| Offside Rear coil spring broken |2.4.C.1a| | 2 |
| Offside Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 2 |
| Front Exhaust has a major leak of exhaust gases |7.1.2| | 2 |
| Nearside Stop lamp not working |1.2.1b| | 2 |
| Rear Brake load sensing valve linkage seized |3.6.E.3| | 2 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 2 |
| Nearside Front Upper Suspension arm ball joint dust cover no longer prevents the ingress of dirt |5.3.4 |b| |ii|| | 2 |
| Offside Steering rack gaiter split |2.2.D.2d| | 2 |
| Nearside Rear position lamp|s| not working |1.1.A.3b| | 2 |
| Nearside Exhaust has a major leak of exhaust gases |7.1.2| | 2 |
| Offside Front Tie bar/rod rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 2 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 2 |
| Nearside Front Brake hose leaking |3.6.A.1| | 2 |
| Emissions not tested |7.0| | 2 |
| Rear Exhaust mounting missing |7.1.1b| | 2 |
| Battery insecure |1.9.1| | 2 |
| Hazard warning switch faulty |1.4.B.1d| | 2 |
| Nearside Front Upper Suspension arm ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 2 |
| Brake hydraulic reservoir fluid level below minimum level |3.6.G.1b| | 2 |
| Nearside Rear brake drum contaminated by brake fluid |3.5.1h| | 2 |
| Front Windscreen washer jets misaligned and not providing sufficient fluid to the windscreen (3.5 (a)) | 2 |
| Exhaust emissions carbon monoxide content excessive (8.2.1.2 (b)) | 2 |
| Rear Exhaust system insecure (6.1.2 (a)) | 2 |
| Offside Front suspension ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Steering system fouling |2.2.D.2a| | 1 |
| Steering column shaft has excessive end float |2.1.3| | 1 |
| Offside Front Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 1 |
| Nearside Headlamp aim beam image kick up to the offside |1.6.B1| | 1 |
| Offside Headlamp aim beam image kick up to the offside |1.6.B1| | 1 |
| Offside Rear Upper Suspension component mounting prescribed area is excessively corroded sill |2.4.A.3| | 1 |
| Offside Rear Lower Suspension component mounting prescribed area is excessively corroded sill |2.4.A.3| | 1 |
| Nearside Front Steering arm has relative movement at its fixings |2.2.B.1h| | 1 |
| Front Steering system fouling |2.2.D.2a| | 1 |
| Power steering malfunctioning |2.3.3a| | 1 |
| Driver`s seat fore and aft adjustment mechanism not functioning as intended. |6.2.A.3| | 1 |
| Offside Rear wheel bearing has excessive play |2.6.2| | 1 |
| Nearside Rear wheel bearing has excessive play |2.6.2| | 1 |
| Offside Front Outer Seat belt anchorage prescribed area strength or continuity significantly reduced |7.1.1 |a| |i|| | 1 |
| Nearside Front Position lamp not working |4.2.1 |a|| | 1 |
| Exhaust emissions carbon monoxide content excessive |8.2.1.2 |b|| | 1 |
| Nearside Rear rear brake recording little or no effort |3.7.B.5a| | 1 |
| Offside Rear rear brake recording little or no effort |3.7.B.5a| | 1 |
| Front Brake pipe leaking |3.6.A.1| | 1 |
| Nearside Rear Seat belt locking mechanism does not secure or release |5.2.5a| | 1 |
| Offside Obligatory mirror insecure |8.1.1| | 1 |
| Windscreen has damage | 1 |
| Nearside Exhaust has part of the system excessively deteriorated |7.1.1a| | 1 |
| Offside Front Suspension arm pin or bush excessively worn top arm rear bush |5.3.4 |a| |i|| | 1 |
| rear parking |secondary| brakes imbalanced | 1 |
| Offside Rear Outer Suspension component mounting prescribed area is excessively corroded rear swing arm mount detached from body |2.4.A.3| | 1 |
| Offside Rear Brake cable has wires broken and is significantly weakened |3.5.1b| | 1 |
| Offside Rear Vehicle structure has a fracture which adversely affects braking or steering unable to perform brake test due to condition of structure |6.1.A.1| | 1 |
| Offside Front wheel bearing has excessive play |2.5.A.3c| | 1 |
| Offside front brake binding |3.7.B.1| | 1 |
| Nearside Rear coil spring incomplete |2.4.C.1a| | 1 |
| Exhaust system not adequately supported |7.1.1| | 1 |
| Offside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Horn not working |7.7 |a| |ii|| | 1 |
| Nearside Headlamp aim projected beam image is obviously incorrect Left hand drive |4.1.2 |c|| | 1 |
| Offside Headlamp aim projected beam image is obviously incorrect Left hand drive |4.1.2 |c|| | 1 |
| Offside Front Outer Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt |6.1.7 |g| |ii|| | 1 |
| Nearside Front Lower Suspension arm ball joint dust cover no longer prevents the ingress of dirt |5.3.4 |b| |ii|| | 1 |
| Offside Rear Rear fog lamp excessively damaged so that it is not visible from a reasonable distance |1.3.2d| | 1 |
| Offside Outer Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Nearside Upper Front suspension ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Body has a sharp edge caused by damage Nearside door mirror outer casing |6.1.C.1| | 1 |
| Power steering inoperative |2.3.3a| | 1 |
| Headlamp aim beam image kick up to the offside |1.8| | 1 |
| Nearside Front constant velocity joint gaiter split |2.5.C.1a| | 1 |
| Nearside Rear Direction indicator not working |1.4.A.2c| | 1 |
| Offside Rear fog lamp insecure |1.3.2a| | 1 |
| Nearside Rear Direction indicator incorrect colour |1.4.A.2f| | 1 |
| Offside Rear Direction indicator incorrect colour |1.4.A.2f| | 1 |
| Driver`s view of the road through the swept area of the windscreen materially affected by an obstruction |3.1 |a| |ii|| | 1 |
| Offside Rear Direction indicator not working |1.4.A.2c| | 1 |
| Offside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
| Steering column top bearing excessively worn |2.1.2c| | 1 |
| Offside Front Steering column top bearing excessively worn |2.1.2c| | 1 |
| Exhaust has a major leak of exhaust gases at the manifold |7.1.2| | 1 |
| Emissions not tested due to the exhaust |7.3.A.1| | 1 |
| Offside Rear Lower Suspension component mounting prescribed area is excessively corroded inner wheel arch |2.4.A.3| | 1 |
| Nearside Obligatory mirror missing |8.1.1| | 1 |
| Offside Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings around rear shock absorber upper mounting point |6.1.B.2| | 1 |
| Rear Brake load sensing valve linkage defective and function impaired |3.6.E.3| | 1 |
| Offside Rear Braking system leaking |3.6.A.1| | 1 |
| Nearside Track rod end ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| front brake recording little or no effort |3.7.B.5a| | 1 |
| rear brake recording little or no effort |3.7.B.5a| | 1 |
| Service brake: efficiency below requirements |3.7.C.1a| | 1 |
| Brake hose has insufficient room to move | 1 |
| Rear Body has a sharp edge caused by damage |6.1.C.1| | 1 |
| Offside Obligatory mirror seriously damaged, affecting the rear view |8.1.2a| | 1 |
| Windscreen washer jets misaligned and not providing sufficient fluid to the windscreen |3.5 |a|| | 1 |
| Brake lever has insufficient reserve travel Hand lever. |1.1.2 |a|| | 1 |
| Nearside Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings marked with yellow chalk |6.1.B.2| | 1 |
| Nearside Front Body or chassis has an unsatisfactory modification, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Rear Body or chassis has an unsatisfactory modification, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Centre Fuel pipe insecure |7.2.1| | 1 |
| Fuel system component leaking |7.2.3| | 1 |
| Offside Rear Direction indicator incorrect colour |4.4.3 |a|| | 1 |
| Rear Exhaust has a major leak of exhaust gases box |7.1.2| | 1 |
| Nearside Front Tie bar/rod rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Exhaust tailpipe not capable of allowing the emission probe to be inserted |7.3.B.1| | 1 |
| Offside Rear coil spring fractured |2.4.C.1a| | 1 |
| Nearside Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Offside Rear Stop lamp adversely affected by the operation of another lamp |1.2.1f| | 1 |
| Nearside Front Upper Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Indicator tell tale inoperative |1.4.A.2a| | 1 |
| Exhaust has part of the system excessively deteriorated |7.1.1a| | 1 |
| Offside Rear Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt |6.1.7 |g| |ii|| | 1 |
| Offside Front Horn not working |1.6.2a| | 1 |
| Offside Rear Vehicle structure has excessive corrosion which adversely affects braking or steering |6.1.A.1| | 1 |
| Nearside Front Vehicle structure has excessive corrosion which adversely affects braking or steering |6.1.A.1| | 1 |
| Nearside Vehicle structure has excessive corrosion which adversely affects braking or steering center |6.1.A.1| | 1 |
| Offside Front Direction indicator incorrect colour |1.4.A.2f| | 1 |
| Nearside Front Direction indicator incorrect colour |1.4.A.2f| | 1 |
| Nearside Front Headlamp excessively deteriorated so that the light output is severely reduced |1.7.5a| | 1 |
| Offside Front Headlamp excessively deteriorated so that the light output is severely reduced |1.7.5a| | 1 |
| Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
| Nearside Headlamp not working on dipped beam |1.7.5a| | 1 |
| Offside Headlamp not working on dipped beam |1.7.5a| | 1 |
| Nearside Headlamp not working on main beam |1.7.5a| | 1 |
| Offside Headlamp not working on main beam |1.7.5a| | 1 |
| Steering system has excessive free play detected at the steering wheel |steering box fitted| |2.2.A.1a| | 1 |
| Registration plate issues | 1 |
| Rear Exhaust has a major leak of exhaust gases silencer (6.1.2 (a)) | 1 |
| Nearside Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
| Offside Rear Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Offside Rear Inner Brake pipe leaking on a hydraulic braking system (1.1.11 (b) (ii)) | 1 |
| Offside Front Steering rack gaiter missing or no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |
| Horn not working (7.7 (a) (ii)) | 1 |
| Nearside Obligatory mirror missing (3.3 (a)) | 1 |
| Offside Front Direction indicator light intensity significantly reduced (4.4.3 (a)) | 1 |
| Offside Rear Rear reflector missing (4.8.2 (a) (ii)) | 1 |
| Offside Front Lower Suspension arm ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Offside Front Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Offside Front Upper Suspension arm ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Offside Front Inner Suspension component mounting prescribed area excessively corroded significantly reducing structural strength (5.3.6 (a) (i)) | 1 |
| Exhaust emissions hydrocarbon content excessive (8.2.1.2 (b)) | 1 |
| Rear Exhaust system insecure Rear clamps corroded and insecure.......... (6.1.2 (a)) | 1 |
| Offside Rear Suspension arm corroded and seriously weakened Trailing arm (5.3.3 (b) (i)) | 1 |
| Offside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength sill (5.3.6 (a) (i)) | 1 |
| Nearside Windscreen wiper not working (3.4 (a)) | 1 |
| Nearside Rear Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Offside Front Service brake excessively binding (1.2.1 (f)) | 1 |
| Nearside Front Upper Suspension arm ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Offside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength lower arm (5.3.6 (a) (i)) | 1 |
| Offside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength outer sill (5.3.6 (a) (i)) | 1 |
| Nearside Front position lamp(s) not working (1.1.A.3b) | 1 |
| Nearside Rear Exhaust has a major leak of exhaust gases (7.1.2) | 1 |
| Nearside Rear Exhaust has part of the system excessively deteriorated (7.1.1a) | 1 |
| Offside Front brake caliper leaking (3.6.A.1) | 1 |
| Offside Rear Service brake excessively fluctuating (1.2.1 (e)) | 1 |
| Nearside Rear Service brake excessively fluctuating (1.2.1 (e)) | 1 |
| Offside Front Lower Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Nearside Front Service brake excessively binding (1.2.1 (f)) | 1 |
| Nearside Parking brake inoperative on one side very low (1.4.1 (a)) | 1 |
| Offside Parking brake inoperative on one side low (1.4.1 (a)) | 1 |
| Oil leaking excessively from engine (8.4.1 (a) (i)) | 1 |
| Offside Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 1 |
| Offside Rear Coil spring fractured or broken (5.3.1 (b) (i)) | 1 |
| Nearside Front Suspension component pin or bush excessively worn torsion bar bush split (5.3.4 (a) (i)) | 1 |
| Offside Steering rack gaiter missing or no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |
| Offside Front Upper Suspension component ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Rear Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 1 |
| Central Brake pipe leaking on a hydraulic braking system Metal Brake Pipe Burst During Test (1.1.11 (b) (ii)) | 1 |
| Parking brake lever has excessive movement indicating incorrect adjustment (1.1.6 (c)) | 1 |