| Most common failures | No# failures |
|---|
| Brake hose excessively deteriorated | 20 |
| Brake pipe excessively corroded | 19 |
| Headlamp aim out of alignment | 18 |
| Windscreen wiper does not clear the windscreen effectively | 16 |
| Registration plate lamp issues | 12 |
| Brakes imbalanced across an axle | 8 |
| Nearside Headlamp aim beam image kick up to the offside |1.8| | 5 |
| Offside Headlamp aim beam image kick up to the offside |1.8| | 5 |
| Exhaust has a major leak of exhaust gases |7.1.2| | 5 |
| Rear fog lamp tell tale not working |1.3.1b| | 4 |
| Parking brake: efficiency below requirements |3.7.B.7| | 4 |
| Windscreen washer not working | 4 |
| Rear fog lamp not working (4.5.1 (a) (ii)) | 4 |
| Offside Steering rack gaiter split |2.2.D.2d| | 3 |
| Horn not working |1.6.2a| | 3 |
| Rear Exhaust has part of the system excessively deteriorated |7.1.1a| | 3 |
| Rear parking brake recording little or no effort | 3 |
| Nearside front brake binding |3.7.B.1| | 3 |
| Offside Rear wheel bearing has excessive play |2.6.2| | 3 |
| Exhaust emissions carbon monoxide content excessive |7.3.B.1a| | 3 |
| Exhaust emissions carbon monoxide content excessive (8.2.1.2 (b)) | 3 |
| Offside Rear fog lamp missing |1.3.2a| | 2 |
| Rear fog lamp switch missing |1.3.1a| | 2 |
| Service brake: efficiency below requirements |3.7.B.7| | 2 |
| Registration plate issues | 2 |
| Nearside Steering rack gaiter split |2.2.D.2d| | 2 |
| Offside Rear Rear fog lamp not working |1.3.2b| | 2 |
| Offside Rear position lamp|s| not working |1.1.A.3b| | 2 |
| Offside Front front brake binding |3.7.B.1| | 2 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 2 |
| Nearside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
| Offside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
| Emissions not tested |7.0| | 2 |
| Parking brake: efficiency below requirements |3.7.C.1b| | 2 |
| Offside Rear Rear wheel bearing has excessive play |2.6.2| | 2 |
| Front brake application uneven | 2 |
| Offside Rear Rear fog lamp not working (4.5.1 (a) (ii)) | 2 |
| Offside Rear Service brake effort inadequate at a wheel (1.2.1 (a) (i)) | 2 |
| Drivers seat fore and aft adjustment mechanism not functioning as intended. (6.2.5 (b) (i)) | 2 |
| Nearside Front Braking system leaking brake pipe corroded through |3.6.A.1| | 1 |
| Nearside Rear coil spring broken likely to demount |2.4.C.1a| | 1 |
| Offside Front Upper Suspension arm has excessive play in a pin/bush inner bushes |2.4.G.2| | 1 |
| Rear fog lamp missing |1.3.2a| | 1 |
| Fuel system component leaking |7.2.3| | 1 |
| Nearside Front Upper Ball joint has excessive play |2.2.B.1f| | 1 |
| Offside Front wheel bearing has excessive play |2.5.A.3c| | 1 |
| Nearside Rear Brake pipe leaking |3.6.A.1| | 1 |
| Offside Front Brake pipe inadequately clipped |3.6.B.1| | 1 |
| Offside Rear Lower Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Nearside Rear Brake hose leaking |3.6.A.1| | 1 |
| Nearside Upper Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Exhaust has part of the system excessively deteriorated |7.1.1a| | 1 |
| Nearside Front Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
| Offside Front Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
| Offside Rear Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Front Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
| rear brakes release unevenly |3.7.B.4| | 1 |
| Offside Front Front suspension has excessive play in a upper suspension ball joint |2.5.B.1a| | 1 |
| Front Headlamp aim beam image kick up to the offside |1.6.B1| | 1 |
| Nearside Front Direction indicator not working |1.4.A.2c| | 1 |
| Steering column top mounting bracket insecure |2.1.2d| | 1 |
| Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Offside Front Fuel system component insecure |7.2.1| | 1 |
| Nearside Front Headlamp aim beam image kick up to the offside |1.8| | 1 |
| Offside Front Headlamp aim beam image kick up to the offside |1.8| | 1 |
| Steering system has excessive free play detected at the steering wheel |steering rack fitted| |2.2.A.1b| | 1 |
| Steering rack insecure |2.2.B.1a| | 1 |
| Offside Rear coil spring broken |2.4.C.1a| | 1 |
| Nearside Front Front position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Seat belt insecurely fixed to the vehicles structure |5.2.1a| | 1 |
| Battery insecure |1.9.1| | 1 |
| Parking brake: efficiency below requirements |3.7.D.4| | 1 |
| Nearside Front Brake hose bulging under pressure |3.6.B.3| | 1 |
| Rear brake binding | 1 |
| Nearside Outer Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Rear Exhaust has a part missing |7.1.1a| | 1 |
| Rear Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Nearside Inner Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Inner Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Steering rack insecure |2.2.B.1a| | 1 |
| Nearside Rear Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Nearside Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Nearside Rear Seat belt adjustment fitting badly deteriorated |5.2.3| | 1 |
| Offside Rear Seat belt adjustment fitting badly deteriorated |5.2.3| | 1 |
| Nearside Rear Shock absorber has a serious fluid leak |2.7.3| | 1 |
| Offside Rear Shock absorber has a serious fluid leak |2.7.3| | 1 |
| Nearside Rear An item not tested |Manual| | 1 |
| Nearside Front Steering column universal joint has excessive play |2.1.5| | 1 |
| Offside Rear Stop lamp not working |1.2.1b| | 1 |
| Nearside Front Track rod end ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Offside Front Track rod end ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| An item not tested |Manual| | 1 |
| Fuel tank leaking |7.2.3| | 1 |
| Parking brake efficiency below requirements |1.4.2 |a| |i|| | 1 |
| Hazard warning switch faulty |1.4.B.1d| | 1 |
| Nearside Headlamp aim aimed so that it dazzles other road users |1.8.A.1a| | 1 |
| Nearside Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Front Vehicle structure is damaged, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Exhaust engine idle speed too high |7.3.A.2a| | 1 |
| Nearside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Nearside Front Tie bar/rod rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Front Tie bar/rod rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Nearside Front Anti-roll bar attachment bracket/mounting corroded and its strength is seriously reduced |2.4.G.1| | 1 |
| Offside Front Anti-roll bar attachment bracket/mounting corroded and its strength is seriously reduced |2.4.G.1| | 1 |
| Brake pipe inadequately supported |3.6.B.1| | 1 |
| Mechanical brake component has restricted free movement | 1 |
| Nearside Rear coil spring broken |2.4.C.1a| | 1 |
| Rear Braking system leaking |3.6.A.1| | 1 |
| Nearside Rear Statutory seat belt missing |5.1.1| | 1 |
| Offside Rear Statutory seat belt missing |5.1.1| | 1 |
| Offside Front Power steering component|s| leaking steering rack |2.3.3b| | 1 |
| Offside Rear Lower Suspension component mounting prescribed area excessively corroded significantly reducing structural strength on outer sill |5.3.6 |a| |i|| | 1 |
| Nearside Parking brake inoperative on one side |1.4.1 |a|| | 1 |
| Nearside Rear Brake pipe likely to become detached or damaged |1.1.11 |d| |ii|| | 1 |
| Nearside Front Service brake has no recorded effort at a wheel |1.2.1 |a| |ii|| | 1 |
| Offside Front Service brake has no recorded effort at a wheel |1.2.1 |a| |ii|| | 1 |
| Offside Rear Service brake excessively fluctuating |1.2.1 |e|| | 1 |
| Offside Brake cable insecure |1.1.15 |c|| | 1 |
| Offside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength crossmember |5.3.6 |a| |i|| | 1 |
| Service brake efficiency less than 50% of the required value |1.2.2 |a| |ii|| | 1 |
| Nearside Steering locking device missing |2.2.C.1g| | 1 |
| Offside Rear Subframe mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Nearside Rear wheel bearing has excessive play |2.6.2| | 1 |
| Nearside Rear Suspension arm corroded and seriously weakened |2.4.G.1| | 1 |
| Nearside Front Body has a sharp edge caused by corrosion |6.1.C.1| | 1 |
| Nearside Rear Body has a sharp edge caused by corrosion |6.1.C.1| | 1 |
| Offside Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Body has a sharp edge caused by damage |6.1.C.1| | 1 |
| Tie bar/rod rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Nearside Ball joint has excessive play |2.2.B.1f| | 1 |
| Nearside Front Shock absorber has a serious fluid leak |2.7.3| | 1 |
| Fuel hose leaking |7.2.3| | 1 |
| Offside front brake binding |3.7.B.1| | 1 |
| Offside Front Lower Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Nearside Front Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Nearside Obligatory mirror seriously damaged, affecting the rear view |8.1.2a| | 1 |
| Offside front brake juddering severely |3.7.A.2b| | 1 |
| Nearside front brake grabbing severely |3.7.A.2b| | 1 |
| Offside Rear Brake hose bulging under pressure (1.1.12 (d)) | 1 |
| Offside Front Upper Suspension arm pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Front Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 1 |
| Nearside Front Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
| Rear fog lamp tell-tale not working (4.9.1 (a) (ii)) | 1 |
| Seat belt buckle not functioning as intended not releasing (7.1.2 (d)) | 1 |
| Front brake disc in such a condition that it is seriously weakened | 1 |
| Offside Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced inner middle sill (6.1.1 (c) (i)) | 1 |
| Nearside Front Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Offside Front Service brake excessively binding (1.2.1 (f)) | 1 |
| Nearside Rear Service brake effort inadequate at a wheel (1.2.1 (a) (i)) | 1 |
| Service brake efficiency below requirements (1.2.2 (a) (i)) | 1 |
| Offside Rear fog lamp not working (4.5.1 (a) (ii)) | 1 |
| Fuel cap/sealing device ineffective (6.1.3 (b) (i)) | 1 |
| Nearside Rear Lower Suspension component mounting prescribed area excessively corroded significantly reducing structural strength on inner lower wheel arch (5.3.6 (a) (i)) | 1 |
| Offside Rear Lower Suspension component mounting prescribed area excessively corroded significantly reducing structural strength on inner lower wheel arch (5.3.6 (a) (i)) | 1 |
| Nearside Drivers seat fore and aft adjustment mechanism not functioning as intended. (6.2.5 (b) (i)) | 1 |
| Offside Passengers seat insecure (6.2.6 (a) (ii)) | 1 |
| Rear fog lamp switch inoperative (4.5.3 (a)) | 1 |
| Offside Rear Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Nearside Front Shock absorbers has a serious fluid leak | 1 |
| Offside Front Shock absorbers has a serious fluid leak | 1 |
| Nearside Front Integral body structure corroded to the extent that the rigidity of the assembly is significantly reduced b pillar lower (6.1.1 (c) (i)) | 1 |
| Offside Front Integral body structure corroded to the extent that the rigidity of the assembly is significantly reduced b pillar lower (6.1.1 (c) (i)) | 1 |
| Nearside Rear Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting (6.2.2 (d) (i)) | 1 |
| Offside Rear Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting (6.2.2 (d) (i)) | 1 |
| Hazard warning switch inoperative (4.4.2 (a) (ii)) | 1 |
| Nearside Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
| Offside Rear Inner Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced Floor Section (6.1.1 (c) (i)) | 1 |
| Nearside Rear Inner Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced Floor Section (6.1.1 (c) (i)) | 1 |
| Emissions not tested Coolant Leak (8.2.1.2 (d)) | 1 |
| Battery insecure and likely to cause a short circuit (4.13 (a) (ii)) | 1 |
| Offside Rear Suspension arm likely to become detached front of arm corroded and rusted broken away from bush (5.3.3 (a) (ii)) | 1 |
| Nearside Front Upper Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Brake performance not tested OVER HEATING (1.2.1 (g)) | 1 |
| Emissions not tested OVER HEATING (8.2.1.2 (d)) | 1 |
| Offside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength suspension arm mount ( outer sill) (5.3.6 (a) (i)) | 1 |
| Brake lever has insufficient reserve travel (1.1.2 (a)) | 1 |
| Exhaust emissions hydrocarbon content excessive adjusted at time of test (8.2.1.2 (b)) | 1 |
| Offside Rear Direction indicator not working (4.4.1 (a) (ii)) | 1 |
| Offside Brake pipe at imminent risk of failure or fracture transverse pipe to o/s/f flexi (1.1.11 (a)) | 1 |
| Offside Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
| Fuel tank leaking (7.2.3) | 1 |
| Exhaust emissions carbon monoxide content excessive (7.3.B.1a) | 1 |
| Offside Headlamp aim beam image obviously incorrect (1.8.A.1b) | 1 |
| Nearside Exhaust has a major leak of exhaust gases (7.1.2) | 1 |
| Nearside Rear Exhaust has a major leak of exhaust gases (7.1.2) | 1 |
| Front Exhaust has part of the system excessively deteriorated (7.1.1a) | 1 |
| Front Exhaust has a major leak of exhaust gases (7.1.2) | 1 |
| Fuel pipe leaking to carb and from carb (6.1.3 (b) (i)) | 1 |
| Fluid leak harmful to the environment or a risk to other road users coolant leak from header bottle (8.4.1 (a) (i)) | 1 |
| Nearside Rear Bumper damaged and likely to cause injury when grazed or contacted CORNER MISSING (6.1.4 (a) (i)) | 1 |
| Nearside Front Seat belt not functioning as intended not returning (7.1.2 (c)) | 1 |
| Front Windscreen wiper not working (3.4 (a)) | 1 |
| Nearside Front Headlamp lens seriously defective (4.1.1 (b) (ii)) | 1 |
| Nearside Front Position lamp light intensity significantly reduced (4.2.3 (a) (ii)) | 1 |
| Offside Front Obligatory mirror missing (3.3 (a)) | 1 |
| Offside Rear Suspension arm corroded and seriously weakened (5.3.3 (b) (i)) | 1 |
| Rear Vehicle structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting floor holed within prescribed area engine mount bracket both sides (6.2.2 (d) (i)) | 1 |
| Offside Rear Vehicle structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting cross member holed and corroded near suspension arm mount (6.2.2 (d) (i)) | 1 |
| Nearside Front Anti-roll bar linkage pin or bush excessively worn front bush perished (5.3.4 (a) (i)) | 1 |
| Offside Front Anti-roll bar linkage pin or bush excessively worn front bush perished (5.3.4 (a) (i)) | 1 |
| Nearside Rear Brake pipe likely to become detached or damaged pipe and flex insecure (1.1.11 (d) (ii)) | 1 |
| Brake pipe likely to become detached or damaged front part of front to rear insecure and fouling pipe above fuel tank (1.1.11 (d) (ii)) | 1 |
| Rear Brake cable insecure | 1 |
| Fuel pipe insecure and fouling various components no grommets fitted (6.1.3 (a) (i)) | 1 |
| Emissions unable to be completed engine misfire and cutting out (8.2.1.2 (d)) | 1 |