Most common failures | No# failures |
---|
Parking brake: efficiency below requirements |3.7.B.7| | 51 |
Registration plate lamp issues | 25 |
Headlamp aim out of alignment | 20 |
Parking brake lever has no reserve travel |3.1.6b| | 19 |
Windscreen wiper does not clear the windscreen effectively | 19 |
Rear parking brake recording little or no effort | 18 |
Offside Rear fog lamp not working |1.3.2b| | 15 |
Brake pipe excessively corroded | 11 |
Windscreen has damage | 10 |
Nearside Stop lamp not working |1.2.1b| | 9 |
Nearside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 8 |
Service brake: efficiency below requirements |3.7.B.7| | 8 |
Offside Headlamp not working on dipped beam |1.7.5a| | 8 |
Offside Headlamp not working on main beam |1.7.5a| | 7 |
Offside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 6 |
Offside Front Headlamp not working on dipped beam |1.7.5a| | 6 |
Nearside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 6 |
Nearside Headlamp not working on dipped beam |1.7.5a| | 6 |
Rear brake binding | 6 |
Offside Front Suspension arm has excessive play in a ball joint |2.4.G.2| | 5 |
Offside Front Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 5 |
Brakes imbalanced across an axle | 5 |
Brake load sensing valve linkage seized |3.6.E.3| | 5 |
Offside Stop lamp not working |1.2.1b| | 5 |
Registration plate issues | 5 |
Anti-lock braking system warning lamp indicates an ABS fault | 4 |
Offside Front Headlamp not working on main beam |1.7.5a| | 4 |
Offside Front position lamp|s| not working |1.1.A.3b| | 4 |
Nearside Front Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 4 |
Nearside rear brake recording little or no effort |3.7.B.5a| | 4 |
Offside Front Front position lamp|s| not working |1.1.A.3b| | 3 |
Nearside Front Anti-roll bar linkage rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 3 |
Offside Front Anti-roll bar linkage rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 3 |
Offside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 3 |
Nearside Front position lamp|s| not working |1.1.A.3b| | 3 |
Nearside Front Shock absorber has a serious fluid leak |2.7.3| | 3 |
Offside Front Shock absorber has a serious fluid leak |2.7.3| | 3 |
Nearside Front Anti-roll bar linkage has excessive play in a pin/bush |2.4.G.2| | 3 |
Parking brake efficiency below requirements |1.4.2 |a| |i|| | 3 |
Offside Rear position lamp|s| not working |1.1.A.3b| | 3 |
Nearside Rear Rear position lamp|s| not working |1.1.A.3b| | 3 |
Nearside Headlamp not working on main beam |1.7.5a| | 3 |
Front Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 3 |
Offside Outer Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 2 |
Nearside Front Suspension arm has excessive play in a ball joint |2.4.G.2| | 2 |
Offside Rear position lamp|s| incorrect colour |1.1.A.3e| | 2 |
Nearside Front Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 2 |
Offside Front Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 2 |
Nearside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 2 |
Offside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 2 |
Centre Exhaust has a major leak of exhaust gases |7.1.2| | 2 |
Nearside Front Anti-roll bar linkage rubber mounting deteriorated resulting in excessive movement |2.4.G.2| | 2 |
Offside Front Anti-roll bar linkage has excessive play in a pin/bush |2.4.G.2| | 2 |
Offside rear brake recording little or no effort |3.7.B.5a| | 2 |
Brake load sensing valve seized |3.6.E.3| | 2 |
Rear Exhaust has a major leak of exhaust gases |7.1.2| | 2 |
Rear fog lamp switch inoperative |4.5.3 |a| |ii|| | 2 |
Nearside Rear Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 2 |
Offside Rear Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 2 |
Parking brake efficiency less than 50% of the required value (1.4.2 (a) (ii)) | 2 |
Power steering component|s| leaking |2.3.3b| | 2 |
Parking brake efficiency below requirements (1.4.2 (a) (i)) | 2 |
Brake pedal spongy |3.3.B.1b| | 2 |
Service brake efficiency below requirements |1.2.2 |a| |i|| | 2 |
Brake pedal has insufficient reserve travel (1.1.2 (a)) | 2 |
Exhaust emits an excessive level of metered smoke for a turbo charged engine |7.4.B.3b| | 2 |
Offside Rear Stop lamp not working |1.2.1b| | 2 |
Offside Rear Rear fog lamp not working |1.3.2b| | 2 |
Offside Rear Rear position lamp|s| not working |1.1.A.3b| | 2 |
Nearside Front Headlamp not working on dipped beam |1.7.5a| | 2 |
Exhaust has a major leak of exhaust gases |7.1.2| | 2 |
Offside Rear Body has a sharp edge caused by damage |6.1.C.1| | 2 |
Front brake excessively fluctuating | 2 |
Stop lamp not working |1.2.1b| | 2 |
Offside Rear position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 2 |
Offside Stop lamp adversely affected by the operation of another lamp |1.2.1f| | 2 |
Nearside Front Outer Seat belt damaged sufficient to significantly weakened the webbing |5.2.2a| | 2 |
Rear fog lamp not working (4.5.1 (a) (ii)) | 2 |
Nearside Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
Nearside Steering rack gaiter split |2.2.D.2d| | 1 |
Offside Front Ball joint has excessive play |2.2.B.1f| | 1 |
Centre Front Seat belt retracting mechanism defective |5.2.5b| | 1 |
Offside Rear Rear position lamp|s| incomplete |1.1.4a| | 1 |
Front brake disc excessively pitted |3.5.1h| | 1 |
Nearside Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
Nearside Anti-roll bar linkage has excessive play in a pin/bush |2.4.G.2| | 1 |
Horn sound not in accordance with requirements (7.7 (c)) | 1 |
Brake hose excessively deteriorated | 1 |
Centre Upper Stop lamp not working |1.2.1b| | 1 |
Hazard warning lamps inoperative |1.4.B.1b| | 1 |
Hazard warning switch faulty |1.4.B.1d| | 1 |
Rear fog lamp switch faulty |1.3.1a| | 1 |
Nearside Inner Front Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 1 |
Offside Inner Front Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 1 |
Nearside Rear reflector missing |1.5.1a| | 1 |
Offside Rear reflector missing |1.5.1a| | 1 |
Nearside Rear position lamp|s| incorrect colour |1.1.A.3e| | 1 |
Rear passenger door cannot be opened from outside the vehicle |6.2.B.1c| | 1 |
Front brake disc in such a condition that it is seriously weakened | 1 |
Rear Parking brake lever has no reserve travel |3.1.6b| | 1 |
Offside Headlamp aim not tested |1.8.A.1c| | 1 |
Offside Front Driver`s door cannot be opened from inside the vehicle |6.2.B.1b| | 1 |
Offside Front Lower Anti-roll bar linkage has excessive play in a pin/bush |2.4.G.2| | 1 |
Brake pedal anti-slip provision incomplete |3.3.A.1b| | 1 |
Nearside Outline marker lamp not working (4.2.1 (a) (ii)) | 1 |
Nearside Rear Shock absorbers has an excessively worn bush upper bush (5.3.2 (c)) | 1 |
Exhaust has a major leak of exhaust gases flexi (6.1.2 (a)) | 1 |
Offside Rear Direction indicator incorrect colour due to holed lens |1.4.A.2f| | 1 |
Offside Rear fog lamp not working |4.5.1 |a| |ii|| | 1 |
Nearside Headlamp not working on dipped beam |4.1.1 |a| |ii|| | 1 |
Offside Headlamp not working on dipped beam |4.1.1 |a| |ii|| | 1 |
Nearside Rear Direction indicator not working |4.4.1 |a| |ii|| | 1 |
Rear Exhaust has a major leak of exhaust gases Silencer fell off during test. |7.1.2| | 1 |
Centre Seat belt locking mechanism does not secure or release |5.2.5a| | 1 |
Nearside Front Seat belt affected by an insecure seat fixing |5.2.1b| | 1 |
Nearside Front Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 1 |
Offside Front Headlamp not working on main beam (4.1.1 (a) (ii)) | 1 |
Nearside Rear Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
Offside Rear Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
Bonnet cannot be secured in the closed position (3.1 (b) (i)) | 1 |
Exhaust has a major leak of exhaust gases rear exhaust box pipe is broken. (6.1.2 (a)) | 1 |
Nearside Front Anti-roll bar pin or bush excessively worn D bush. (5.3.4 (a) (i)) | 1 |
Offside Front Anti-roll bar pin or bush excessively worn D bush. (5.3.4 (a) (i)) | 1 |
Offside Front Track rod end ball joint has excessive play (2.1.3 (b) (i)) | 1 |
Nearside Front Track rod end ball joint has excessive play (2.1.3 (b) (i)) | 1 |
Rear Service brake excessively binding (1.2.1 (f)) | 1 |
Brake load sensing valve seized but ABS functioning (1.1.17 (c) (i)) | 1 |
Brake linkage has restricted free movement handbrake centre pivot siezed (1.1.15 (e)) | 1 |
Nearside Front Direction indicator not working (4.4.1 (a) (ii)) | 1 |
Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 1 |
Nearside Seat belt damaged sufficient to significantly weakened the webbing |5.2.2a| | 1 |
Nearside Seat belt flexible stalk deteriorated likely to lead to failure under load |5.2.4a| | 1 |
Offside Seat belt flexible stalk deteriorated likely to lead to failure under load |5.2.4a| | 1 |
Nearside Front Direction indicator missing |4.4.1 |a| |ii|| | 1 |
Nearside Rear Body panel corroded and likely to cause injury wheel arch |6.2.1 |a| |i|| | 1 |
Exhaust emissions exceed level of metered smoke for a turbo charged engine |8.2.2.2 |b|| | 1 |
Nearside Rear Suspension spring mounting prescribed area excessively corroded significantly reducing structural strength |5.3.6 |a| |i|| | 1 |
Nearside Stop lamp not working 1x LLB380 |1.2.1b| | 1 |
Nearside Rear position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
Offside Front Lower Ball joint has excessive play |2.2.B.1f| | 1 |
Front Body has a sharp edge caused by damage |6.1.C.1| | 1 |
Nearside Rear Rear position lamp|s| excessively damaged so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
Windscreen damaged and affecting the driver`s view of the road |3.2 |a| |ii|| | 1 |
Offside Steering rack has excessive free play detected at the steering wheel to the extent that safe steering is affected |steering rack fitted| inner rack arm excessive movement |2.3 |a| |ii|| | 1 |
Offside Power steering component leaking |2.1.5 |a|| | 1 |
Central Rear Exhaust has a major leak of exhaust gases pipe broken and corroded |6.1.2 |a|| | 1 |
Offside Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 1 |
Nearside Front Direction indicator not working |1.4.A.2c| | 1 |
Fuel pipe leaking |7.2.3| | 1 |
Brake pedal anti-slip provision worn smooth |3.3.A.1b| | 1 |
Rear Rear fog lamp not working |1.3.2b| | 1 |
Nearside Rear wheel bearing rough when rotated |2.6.1| | 1 |
Nearside Rear brake disc contaminated by oil |3.5.1h| | 1 |
Nearside Front Obligatory mirror missing |8.1.1| | 1 |
Rear fog lamp not working |4.5.1 |a| |ii|| | 1 |
Nearside Obligatory mirror seriously damaged, affecting the rear view |8.1.2a| | 1 |
Centre Exhaust has a part missing |7.1.1a| | 1 |
Nearside Rear Stop lamp|s| not working |4.3.1 |a| |ii|| | 1 |
Offside Rear Position lamp not working |4.2.1 |a|| | 1 |
Nearside Front Position lamp not working |4.2.1 |a|| | 1 |
Offside Front Position lamp not working |4.2.1 |a|| | 1 |
Nearside Front Brake hose excessively damaged |1.1.12 |b| |ii|| | 1 |
Offside Front Brake hose excessively damaged |1.1.12 |b| |ii|| | 1 |
Nearside Front Anti-roll bar pin or bush excessively worn |5.3.4 |a| |i|| | 1 |
Offside Front Anti-roll bar pin or bush excessively worn |5.3.4 |a| |i|| | 1 |
Nearside Rear Anti-roll bar pin or bush excessively worn |5.3.4 |a| |i|| | 1 |
Offside Rear Anti-roll bar pin or bush excessively worn |5.3.4 |a| |i|| | 1 |
Nearside Front Shock absorbers has a serious fluid leak | 1 |
Offside Rear Headlamp not working on dipped beam |1.7.5a| | 1 |
Nearside Front Headlamp not working on main beam |1.7.5a| | 1 |
Main beam `tell-tale` not working |1.7.4c| | 1 |
Rear fog lamp tell tale not working |1.3.1b| | 1 |
Brake load sensing valve linkage defective and function impaired |3.6.E.3| | 1 |
Nearside Front wheel bearing has excessive play |2.5.A.3c| | 1 |
Offside Front wheel bearing has excessive play |2.5.A.3c| | 1 |
Nearside Front Anti-roll bar attachment bracket/mounting fractured |2.4.G.1| | 1 |
Offside Front Suspension has inadequate clearance with the bump stop |2.4.A.1a| | 1 |
Offside Driver`s door cannot be opened from inside the vehicle |6.2.B.1b| | 1 |
Nearside Inner Rear Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
Offside Inner Rear Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
Brake cable has wires broken and is significantly weakened |3.5.1b| | 1 |
Horn not working |1.6.2a| | 1 |
Nearside Inner Front Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
Offside Inner Front Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
Windscreen wiper blade insecure | 1 |
Nearside Rear Anti-roll bar linkage worn and seriously weakened |2.4.G.1| | 1 |
Offside Rear brake caliper securing device missing |3.5.1j| | 1 |
Offside Front Suspension arm ball joint dust cover missing |2.4.G.2| | 1 |
Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 1 |
Rear Anti-roll bar missing |2.4.G.1| | 1 |
Centre Stop lamp not working |1.2.1b| | 1 |
Nearside Rear Body has a sharp edge caused by damage |6.1.C.1| | 1 |
Brake load sensing valve linkage seized |3.6.F.4| | 1 |
Nearside Front Anti-roll bar has excessive play in a pin/bush D bush |2.4.G.2| | 1 |
Offside Front Anti-roll bar has excessive play in a pin/bush D bush |2.4.G.2| | 1 |
Exhaust has a major leak of exhaust gases centre pipe |7.1.2| | 1 |
Exhaust emits an excessive level of metered smoke for a turbo charged engine unable to check emissions due to exhaust |7.4.B.3b| | 1 |
Offside Side repeater not working |1.4.A.2c| | 1 |
Nearside All position lamps not working |1.1.A.3b| | 1 |
Offside Stop lamp excessively damaged so that it is not visible from a reasonable distance |1.2.1d| | 1 |
Front wheel bearing has excessive play |2.5.A.3c| | 1 |
Offside Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
Offside Rear position lamp|s| incorrect colour lens holed |1.1.A.3e| | 1 |
Offside Stop lamp excessively damaged so that it is not visible from a reasonable distance lens holed |1.2.1d| | 1 |
Offside Rear fog lamp emits a light other than red lens holed |1.3.2e| | 1 |
Rear Brake cable has wires broken and is significantly weakened |3.5.1b| | 1 |
Nearside Stop lamp adversely affected by the operation of another lamp |1.2.1f| | 1 |
Offside Steering rack gaiter split |2.2.D.2d| | 1 |
Offside Rear Rear position lamp|s| incorrect colour |1.1.A.3e| | 1 |
Offside Stop lamp emits other than a steady red light |1.2.1e| | 1 |
Offside Rear fog lamp emits a light other than red |1.3.2e| | 1 |
Emissions not tested |7.4.B.1| | 1 |
Offside Front Steering rack gaiter split |2.2.D.2d| | 1 |
Nearside Rear Rear reflector excessively damaged so that its function is impaired |1.5.1c| | 1 |
Windscreen washer not working | 1 |
Nearside Front Steering rack gaiter missing or no longer prevents the ingress of dirt |2.1.3 |g| |ii|| | 1 |
Rear Exhaust has a major leak of exhaust gases |6.1.2 |a|| | 1 |
Parking brake efficiency less than 50% of the required value |1.4.2 |a| |ii|| | 1 |
Nearside Front Headlamp not working on main beam (4.1.1 (a) (ii)) | 1 |
Nearside Front Steering rack gaiter missing or no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |
Nearside Front Steering rack gaiter split |2.2.D.2d| | 1 |
rear parking |secondary| brakes imbalanced | 1 |
Nearside Rear rear brake recording little or no effort |3.7.B.5a| | 1 |
Offside Rear rear brake recording little or no effort |3.7.B.5a| | 1 |
Rear Brake valve damaged |3.6.A.2c| | 1 |
Offside Front Direction indicator not working |1.4.A.2c| | 1 |
Rear Brake load sensing valve linkage seized |3.6.E.3| | 1 |
Nearside Braking system leaking |3.6.A.1| | 1 |
Offside Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
Front Fuel system component leaking |7.2.3| | 1 |
Nearside Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 1 |
Headlamp aim not tested (4.1.2 (b)) | 1 |
Nearside Rear Service brake excessively binding (1.2.1 (f)) | 1 |
Offside Rear Service brake excessively binding (1.2.1 (f)) | 1 |
Brake performance not tested (1.2.1 (g)) | 1 |
Upper Stop lamp not working |1.2.1b| | 1 |
Brake load sensing valve seized but ABS functioning |1.1.17 |c| |i|| | 1 |
Nearside Rear Service brake excessively binding |1.2.1 |f|| | 1 |
Offside Rear Service brake excessively binding |1.2.1 |f|| | 1 |
Nearside Rear Direction indicator not working |1.4.A.2c| | 1 |
Offside Front Seat belt damaged sufficient to obstruct correct operation of the belt |5.2.2a| | 1 |
Nearside Front Inner Anti-roll bar rubber mounting deteriorated resulting in excessive movement |2.4.G.2| | 1 |
Exhaust noise is clearly in excess of that emitted by a similar vehicle fitted with a standard silencer in average condition exhaust box missing |7.1.4| | 1 |
Offside Front Headlamp excessively damaged so that the light output is severely reduced |1.7.5a| | 1 |
Offside Front Brake pipe leaking |3.6.A.1| | 1 |
Hazard warning tell tale not working correctly |1.4.B.1e| | 1 |
Nearside Front Front suspension has excessive play in a lower suspension ball joint and offside front |2.5.B.1a| | 1 |
Rear Stop lamp not working |1.2.1b| | 1 |
Front Anti-roll bar linkage has excessive play in a pin/bush |2.4.G.2| | 1 |
Rear Shock absorber has negligible damping effect |2.7.5| | 1 |
Power steering inoperative |2.3.3a| | 1 |
Offside Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |