Most common failures | No# failures |
---|
Parking brake: efficiency below requirements |3.7.B.7| | 30 |
Service brake: efficiency below requirements |3.7.B.7| | 23 |
Windscreen wiper does not clear the windscreen effectively | 17 |
Brake hose excessively deteriorated | 15 |
Headlamp aim out of alignment | 14 |
Registration plate lamp issues | 13 |
Brakes imbalanced across an axle | 13 |
Brake pipe excessively corroded | 11 |
Rear parking brake recording little or no effort | 10 |
Offside Rear fog lamp not working |1.3.2b| | 7 |
Horn not working |1.6.2a| | 5 |
Nearside Front Upper Suspension arm has excessive play in a pin/bush |2.4.G.2| | 5 |
Registration plate issues | 5 |
Steering system has excessive free play detected at the steering wheel |steering box fitted| |2.2.A.1a| | 4 |
Steering box has relative movement between sector shaft and the drop arm |2.2.B.1b| | 4 |
Nearside Front Upper Suspension arm has excessive play in a ball joint |2.4.G.2| | 4 |
Nearside Headlamp not working on dipped beam |1.7.5a| | 4 |
Offside Rear Rear fog lamp not working |1.3.2b| | 3 |
Battery insecure |1.9.1| | 3 |
Nearside Stop lamp not working |1.2.1b| | 3 |
Rear brake binding | 3 |
Exhaust emits an excessive level of metered smoke for a non-turbo charged engine |7.4.B.3b| | 3 |
Offside front brake binding |3.7.B.1| | 3 |
Offside Headlamp not working on main beam |1.7.5a| | 3 |
Exhaust system not adequately supported |7.1.1| | 3 |
Driver`s seat insecure |6.2.A.1| | 3 |
Offside Front Tie bar/rod rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 3 |
Exhaust emits excessive smoke or vapour of any colour |7.4.B.4| | 2 |
Fuel system component leaking |7.2.3| | 2 |
Brake hose damaged | 2 |
Parking brake lever defective so that it cannot be satisfactorily operated |3.1.3c| | 2 |
Nearside Headlamp not working on main beam |1.7.5a| | 2 |
Windscreen wiper blade insecure | 2 |
Parking brake lever ratchet mechanism is excessively worn |3.1.5| | 2 |
Nearside front brake binding |3.7.B.1| | 2 |
Offside Front Upper Suspension arm has excessive play in a ball joint |2.4.G.2| | 2 |
Front brake application uneven | 2 |
Nearside rear brake recording little or no effort |3.7.B.5a| | 2 |
Offside rear brake recording little or no effort |3.7.B.5a| | 2 |
Offside Stop lamp not working |1.2.1b| | 2 |
Nearside Front Body has a sharp edge caused by corrosion |6.1.C.1| | 2 |
Offside Front Body has a sharp edge caused by corrosion |6.1.C.1| | 2 |
Offside Front Upper Suspension arm has excessive play in a pin/bush |2.4.G.2| | 2 |
Brake load sensing valve linkage seized |3.6.E.3| | 2 |
Nearside Front wheel bearing has excessive play |2.5.A.3c| | 2 |
Offside Front wheel bearing has excessive play |2.5.A.3c| | 2 |
Parking brake is not capable of being maintained in operation by direct mechanical action only |3.1.2| | 2 |
Nearside Obligatory mirror seriously damaged, affecting the rear view |8.1.2a| | 2 |
Nearside Side repeater not working |1.4.A.2c| | 2 |
Parking brake mechanism/associated mounting prescribed area is excessively corroded |3.1.9| | 2 |
Windscreen has damage | 2 |
Centre Exhaust has a major leak of exhaust gases |7.1.2| | 2 |
Nearside Front Front wheel bearing has excessive play |2.5.A.3c| | 2 |
Centre Statutory seat belt missing |5.1.1| | 2 |
Rear Brake load sensing valve linkage seized |3.6.E.3| | 2 |
Offside Front position lamp|s| not working |1.1.A.3b| | 2 |
Front brake disc in such a condition that it is seriously weakened | 2 |
Nearside Front Front position lamp|s| not working |1.1.A.3b| | 2 |
Nearside Front Headlamp not working on dipped beam |1.7.5a| | 2 |
Nearside Headlamp insecure |1.7.3| | 2 |
Driver`s seat fore and aft adjustment mechanism not functioning as intended. |6.2.A.3| | 2 |
Fuel cap/sealing device does not fasten securely maintaining the sealing arrangement |7.2.4b| | 1 |
Main beam `tell-tale` not working |1.7.4c| | 1 |
Rear brake application uneven | 1 |
Nearside Rear rear brake recording little or no effort |3.7.B.5a| | 1 |
Nearside Rear Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
Nearside Rear Stop lamp not working |1.2.1b| | 1 |
Offside Front Front wheel bearing rough when rotated |2.5.A.2| | 1 |
Offside Rear Brake load sensing valve linkage seized |3.6.E.3| | 1 |
Nearside Rear Rear position lamp|s| not working |1.1.A.3b| | 1 |
Offside Headlamp insecure |1.7.3| | 1 |
Offside Front Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
Nearside Windscreen wiper not operating automatically when switched on |8.2.1b| | 1 |
Offside Windscreen wiper not operating automatically when switched on |8.2.1b| | 1 |
Rear fog lamp not working |1.3.2b| | 1 |
Nearside Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
Nearside Rear Stop lamp adversely affected by the operation of another lamp |1.2.1f| | 1 |
Nearside Rear Direction indicator adversely affected by the operation of another lamp |1.4.A.2h| | 1 |
Nearside Obligatory mirror insecure |8.1.1| | 1 |
Offside Front Obligatory mirror insecure |8.1.1| | 1 |
Steering system excessively tight |2.2.D.1| | 1 |
Brake rod reduced in thickness more than 1/3rd by chaffing |3.5.1a| | 1 |
Brake pivot excessively worn and seriously weakened |3.5.1e| | 1 |
Brake relay lever excessively worn and seriously weakened |3.5.1e| | 1 |
Offside Parking brake mechanism/associated mounting prescribed area is excessively corroded |3.1.9| | 1 |
Front Steering locking device missing |2.2.C.1g| | 1 |
Front Exhaust system not adequately supported |7.1.1| | 1 |
Front Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
Brake load sensing valve seized |3.6.E.3| | 1 |
Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
Offside Front Anti-roll bar linkage rubber mounting deteriorated resulting in excessive movement |2.4.G.2| | 1 |
Nearside Front Brake hose twisted |found during steering lock to lock check| |2.2.D.2b| | 1 |
Nearside Steering arm has relative movement at its fixings drop arm |2.2.B.1h| | 1 |
Offside Rear Brake load sensing valve seized |3.6.E.3| | 1 |
Emissions not tested oil leak |7.4.B.1| | 1 |
Offside Rear Position lamp not working |4.2.1 |a|| | 1 |
Offside Stop lamp|s| not working |4.3.1 |a| |ii|| | 1 |
Offside Rear fog lamp not working |4.5.1 |a| |ii|| | 1 |
Horn not working |7.7 |a| |ii|| | 1 |
Offside Front Anti-roll bar linkage likely to fail |5.3.3 |b| |ii|| | 1 |
Nearside Rear Service brake excessively binding |1.2.1 |f|| | 1 |
Nearside Parking brake inoperative on one side |1.4.1 |a|| | 1 |
Offside Parking brake inoperative on one side |1.4.1 |a|| | 1 |
Parking brake efficiency less than 50% of the required value |1.4.2 |a| |ii|| | 1 |
Brake pedal anti-slip provision incomplete |3.3.A.1b| | 1 |
Offside Rear Body has a sharp edge caused by corrosion |6.1.C.1| | 1 |
Brake pedal creeps down under servo assistance and touches the floor |3.3.C.3| | 1 |
Nearside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
Brake load sensing valve linkage obviously incorrectly adjusted |3.6.E.3| | 1 |
Offside Rear Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
Offside Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Nearside Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Offside Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Steering box damaged and unserviceable |2.2.C.1d| | 1 |
Centre Brake linkage excessively corroded and seriously weakened |3.5.1e| | 1 |
Nearside Rear Position lamp not working (4.2.1 (a) (ii)) | 1 |
Offside Front Position lamp not working (4.2.1 (a) (ii)) | 1 |
Windscreen washer not working | 1 |
Offside Headlamp insecure (4.1.1 (c)) | 1 |
Nearside Rear Bumper insecure (6.1.4 (a) (i)) | 1 |
Offside Rear Body component corroded and likely to cause injury bumper (6.2.1 (a) (i)) | 1 |
Offside Rear fog lamp not working (4.5.1 (a) (ii)) | 1 |
Offside Rear Rear reflector defective or damaged by more than 50% of the reflecting surface (4.8.1 (a) (ii)) | 1 |
Nearside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength cross member (5.3.6 (a) (i)) | 1 |
Offside Front Service brake excessively binding (1.2.1 (f)) | 1 |
Offside Upper Body has a sharp edge caused by corrosion |6.1.C.1| | 1 |
Nearside Rear Exhaust mounting missing |7.1.1b| | 1 |
Nearside Headlamp aim not tested |1.8.A.1c| | 1 |
Offside Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
Nearside Front Anti-roll bar linkage rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
Brake performance not tested |1.2.1 |g|| | 1 |
Offside Front Hydraulic brake calliper leaking and braking performance affected |1.1.16 |b| |ii|| | 1 |
Offside Front Upper Suspension arm has excessive play in a pin/bush forward bush |2.4.G.2| | 1 |
Offside Front Upper Suspension arm has excessive play in a pin/bush back bush |2.4.G.2| | 1 |
Fuel system component leaking fuel pump /injector area |7.2.3| | 1 |
Nearside rear brake excessively fluctuating |3.7.B.3| | 1 |
Nearside Inner Front Upper Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
Offside Rear Shock absorber has a serious fluid leak |2.7.3| | 1 |
Front Brake pipe leaking |3.6.A.1| | 1 |
Centre Front Statutory seat belt missing |5.1.1| | 1 |
Offside Brake cable has restricted free movement |3.5.1k| | 1 |
Steering column top bearing excessively worn |2.1.2c| | 1 |
Body insecure and dangerous to other road users |6.1.B.1b| | 1 |
Front Fuel system component leaking |7.2.3| | 1 |
Nearside Front Lower Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
Brake linkage excessively corroded and seriously weakened |3.5.1e| | 1 |
Rear Stop lamp not working |1.2.1b| | 1 |
Parking brake lever, pawl mechanism pivots or their associated mountings are insecure |3.1.4b| | 1 |
Offside Front Lower Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
Offside Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Offside Front coil spring fractured |2.4.C.1a| | 1 |
Nearside Front Shock absorber has negligible damping effect |2.7.5| | 1 |
Offside Front Shock absorber has negligible damping effect |2.7.5| | 1 |
Nearside Front Shock absorber has a serious fluid leak |2.7.3| | 1 |
Offside Front Shock absorber has a serious fluid leak |2.7.3| | 1 |
Nearside Front Obligatory mirror seriously damaged, affecting the rear view |8.1.2a| | 1 |
Driver`s door cannot be opened from inside the vehicle |6.2.B.1b| | 1 |
Offside Steering arm has relative movement at its fixings |2.2.B.1h| | 1 |
Offside Front Parking brake lever, pawl mechanism pivot|s| or their associated mountings locking device insecure |3.1.4b| | 1 |
Nearside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Exhaust emits an excessive level of metered smoke for a turbo charged engine |7.4.B.3b| | 1 |
Nearside Rear Shock absorber has a serious fluid leak |2.7.3| | 1 |
Nearside Front coil spring cracked |2.4.C.1a| | 1 |
Offside Front Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
Offside Rear Body insecure and dangerous to other road users |6.1.B.1b| | 1 |
Centre Rear Brake lever has restricted free movement |3.5.1k| | 1 |
Nearside Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Offside Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Inner Front Drag link end ball joint has excessive play |2.2.B.1f| | 1 |
Nearside Front Windscreen wiper blade deteriorated |8.2.2| | 1 |
Offside Front Windscreen wiper blade deteriorated |8.2.2| | 1 |
Offside Front Front wheel bearing has excessive play |2.5.A.3c| | 1 |
Hazard warning switch faulty |1.4.B.1d| | 1 |
Nearside Rear passenger door does not latch securely closed |6.2.B.1a| | 1 |
Rear Brake valve leaking |3.6.A.1| | 1 |
Offside Headlamp not working on dipped beam |1.7.5a| | 1 |
Nearside Front brake disc excessively scored |3.5.1h| | 1 |
Emissions not tested |7.0| | 1 |
Offside Rear fog lamp obscured more than 50% |1.3.2c| | 1 |
Rear Rear fog lamp not working |1.3.2b| | 1 |
Offside Rear Stop lamp not working |1.2.1b| | 1 |
Nearside Front Steering box has relative movement between sector shaft and the drop arm |2.2.B.1b| | 1 |
Hazard warning switch inoperative |4.4.2 |a| |ii|| | 1 |
Prop shaft bearing excessively worn prop shaft centre bearing has excessive play |6.1.7 |b| |i|| | 1 |
Nearside Front Headlamp not working on dipped beam |4.1.1 |a| |ii|| | 1 |
Horn not working (7.7 (a) (ii)) | 1 |
Brake rod locking device insecure |3.5.1l| | 1 |
Nearside Exhaust system not adequately supported |7.1.1| | 1 |
Offside Front Brake pipe inadequately clipped |3.6.B.1| | 1 |
Windscreen has a sticker or other obstruction encroaching by more than 10mm within zone `A` |8.3.1b| | 1 |
Offside Headlamp excessively damaged so that the light output is severely reduced |1.7.5a| | 1 |
Upper Fuel system component leaking |7.2.3| | 1 |
Nearside Rear position lamp|s| incorrect colour |1.1.A.3e| | 1 |
Nearside Rear Direction indicator incorrect colour |1.4.A.2f| | 1 |
Hazard warning lamps not flashing in phase, with ignition on |1.4.B.1f| | 1 |
Hazard warning lamps not flashing in phase, with ignition off |1.4.B.1f| | 1 |
Offside Side repeater not working |1.4.A.2c| | 1 |
Nearside Steering pivot point has excessive play |2.2.B.1g| | 1 |
Nearside Front Upper Ball joint has excessive play |2.2.B.1f| | 1 |
Offside Front front brake binding |3.7.B.1| | 1 |
Nearside Front Wheel bearing has excessive play (5.1.3 (a) (i)) | 1 |
Nearside Front Seat belt retracting mechanism defective |5.2.5b| | 1 |
Nearside Front Vehicle structure is cracked, seriously affecting its strength within 30cm of the body mountings seat |6.1.B.2| | 1 |
Offside Front Shock absorber insecure |2.7.2b| | 1 |
Parking brake lever has no reserve travel |3.1.6b| | 1 |
Nearside Front Side repeater not working |1.4.A.2c| | 1 |
Offside Front Driver`s seat fore and aft adjustment mechanism not functioning as intended. |6.2.A.3| | 1 |
Nearside Front front brake binding |3.7.B.1| | 1 |
Fuel tank leaking |7.2.3| | 1 |
Front passenger seat insecure |6.2.3| | 1 |
Parking brake lever releases when knocked |3.1.6a| | 1 |
Headlamp switch faulty |1.7.1| | 1 |
Nearside Side repeater insecure |1.4.A.2b| | 1 |
Nearside Body has a sharp edge caused by corrosion |6.1.C.1| | 1 |
An item not tested |Manual| | 1 |
Nearside coil spring fractured |2.4.C.1a| | 1 |
Offside Front Tie bar/rod has excessive play in a pin/bush |2.4.G.2| | 1 |
Braking system leaking |3.6.A.1| | 1 |
Front position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
Nearside Windscreen wiper blade deteriorated |8.2.2| | 1 |
Rear Exhaust has a part missing |7.1.1a| | 1 |
Offside Outer Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
Parking brake lever ratchet mechanism is broken |3.1.5| | 1 |
Service brake: efficiency below requirements |3.7.D.4| | 1 |
Parking brake: efficiency below requirements |3.7.D.4| | 1 |
Offside Front Side repeater missing |1.4.A.2b| | 1 |
Nearside Rear Upper Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |