| Most common failures | No# failures |
|---|
| Brake pipe excessively corroded | 6 |
| Registration plate lamp issues | 6 |
| Nearside Front front brake binding |3.7.B.1| | 4 |
| Parking brake mechanism/associated mounting prescribed area is excessively corroded |3.1.9| | 3 |
| Battery insecure |1.9.1| | 3 |
| Offside Front front brake binding |3.7.B.1| | 3 |
| Rear brake binding | 3 |
| Rear fog lamp tell tale not working |1.3.1b| | 3 |
| Offside Rear Rear position lamp|s| incorrect colour |1.1.A.3e| | 2 |
| Centre Exhaust has a major leak of exhaust gases |7.1.2| | 2 |
| Registration plate issues | 2 |
| Nearside Rear Rear reflector missing |1.5.1a| | 2 |
| Windscreen wiper does not clear the windscreen effectively | 2 |
| Service brake: efficiency below requirements |3.7.B.7| | 2 |
| Parking brake: efficiency below requirements |3.7.B.7| | 2 |
| Brake load sensing valve seized |3.6.E.3| | 2 |
| Exhaust emissions carbon monoxide content excessive |7.3.B.1a| | 2 |
| Brakes imbalanced across an axle | 2 |
| Offside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 2 |
| Offside Front Electrical wiring insecure |1.9.2a| | 1 |
| Parking brake lever has no reserve travel |3.1.6b| | 1 |
| Nearside Front Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
| Offside Front Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
| Nearside Front Headlamp excessively deteriorated so that the light output is severely reduced |1.7.5a| | 1 |
| Steering box has relative movement between sector shaft and the drop arm |2.2.B.1b| | 1 |
| Offside Front Steering pivot point has excessive play |2.2.B.1g| | 1 |
| Nearside Front Lower Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Offside Front Lower Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Offside Front Headlamp aim aimed so that it dazzles other road users |1.8.A.1a| | 1 |
| Rear Exhaust system not adequately supported |7.1.1| | 1 |
| Offside Front Steering locking device missing |2.2.C.1g| | 1 |
| Nearside Front An item not tested |Manual| | 1 |
| Offside Front An item not tested |Manual| | 1 |
| Driver`s seat fore and aft adjustment mechanism not functioning as intended. |6.2.A.3| | 1 |
| Nearside Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Nearside Front Body has a sharp edge caused by corrosion |6.1.C.1| | 1 |
| Nearside Body has a sharp edge caused by damage |6.1.C.1| | 1 |
| Nearside Seat belt anchorage prescribed area is excessively corroded rear panel seatbelt clasp |5.2.6| | 1 |
| Headlamp aim out of alignment | 1 |
| Nearside Suspension component mounting prescribed area is excessively corroded crossmember |2.4.A.3| | 1 |
| Rear brake application uneven | 1 |
| rear brakes release unevenly |3.7.B.4| | 1 |
| Exhaust system not adequately supported |7.1.1| | 1 |
| Offside Front Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Nearside Front Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Nearside Headlamp not working on dipped beam |1.7.5a| | 1 |
| Offside Headlamp not working on dipped beam |1.7.5a| | 1 |
| Nearside Headlamp not working on main beam |1.7.5a| | 1 |
| Offside Headlamp not working on main beam |1.7.5a| | 1 |
| Headlamp aim not tested |1.8.A.1c| | 1 |
| Emissions not tested |7.0| | 1 |
| Offside Front wheel bearing has excessive play |2.5.A.3c| | 1 |
| Brake master cylinder/servo mounting prescribed area is excessively corroded |3.6.C.3| | 1 |
| Offside Rear Stop lamp emits other than a steady red light |1.2.1e| | 1 |
| Offside Rear Direction indicator incorrect colour |1.4.A.2f| | 1 |
| Front Anti-roll bar has excessive play in a pin/bush d bushes |ns and os| |2.4.G.2| | 1 |
| Brake hose excessively deteriorated | 1 |
| Hazard warning switch faulty |1.4.B.1d| | 1 |
| Offside Rear Rear reflector more than 50% obscured |1.5.1b| | 1 |
| Offside Front Front wheel bearing rough when rotated |2.5.A.2| | 1 |
| Nearside Front Suspension component mounting prescribed area is excessively corroded at anti role bar D area |2.4.A.3| | 1 |
| Offside Front Suspension component mounting prescribed area is excessively corroded at anti roll bar D area |2.4.A.3| | 1 |
| Nearside Front Suspension component mounting prescribed area is excessively corroded out rigger |2.4.A.3| | 1 |
| Offside Front Suspension component mounting prescribed area is excessively corroded out rigger |2.4.A.3| | 1 |
| Offside Front Steering system has excessive free play detected at the steering wheel |steering box fitted| steering idler |2.2.A.1a| | 1 |
| Brake performance not tested |3.7.A.1| | 1 |
| Nearside Front Anti-roll bar has excessive play in a pin/bush D bush |2.4.G.2| | 1 |
| Offside Front Anti-roll bar has excessive play in a pin/bush D bush |2.4.G.2| | 1 |
| Offside Rear brake drum in such a condition that it is seriously weakened back plate corroded |3.5.1i| | 1 |
| Brake pipe inadequately supported front to rear |3.6.B.1| | 1 |
| Offside Rear fog lamp not working |1.3.2b| | 1 |
| Offside Headlamp aim aimed so that it dazzles other road users |1.8.A.1a| | 1 |
| Offside Front Front position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Front Vehicle structure has a modification which adversely affects braking or steering |6.1.A.1| | 1 |
| Nearside Front Windscreen wiper blade deteriorated |8.2.2| | 1 |
| Offside Front Windscreen wiper blade deteriorated |8.2.2| | 1 |
| Nearside Front Axle has inadequate clearance with the bump stop |2.4.A.1a| | 1 |
| Offside Front Axle has inadequate clearance with the bump stop |2.4.A.1a| | 1 |
| Nearside Rear Axle has inadequate clearance with the bump stop |2.4.A.1a| | 1 |
| Offside Rear Axle has inadequate clearance with the bump stop |2.4.A.1a| | 1 |
| Nearside Front Shock absorber has negligible damping effect |2.7.5| | 1 |
| Offside Front Shock absorber has negligible damping effect |2.7.5| | 1 |
| Steering system excessively rough |2.2.D.1| | 1 |
| Brake load sensing valve linkage defective and function impaired |3.6.E.3| | 1 |
| Exhaust emissions hydrocarbon content excessive |7.3.B.1b| | 1 |
| Fuel hose leaking |7.2.3| | 1 |
| Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Rear Fuel pipe leaking |7.2.3| | 1 |
| Fuel system component leaking |7.2.3| | 1 |