| Most common failures | No# failures |
|---|
| Headlamp aim out of alignment | 23 |
| Windscreen wiper does not clear the windscreen effectively | 15 |
| Registration plate lamp issues | 12 |
| Registration plate issues | 8 |
| Parking brake efficiency below requirements (1.4.2 (a) (i)) | 5 |
| Windscreen washer not working | 4 |
| Offside Front Service brake excessively binding (1.2.1 (f)) | 3 |
| Nearside Stop lamp(s) not working (4.3.1 (a) (ii)) | 3 |
| Nearside Rear Coil spring fractured or broken (5.3.1 (b) (i)) | 3 |
| Nearside Front Position lamp not working (4.2.1 (a) (ii)) | 2 |
| Brakes imbalanced across an axle | 2 |
| Offside Track rod end ball joint has excessive play (2.1.3 (b) (i)) | 2 |
| Hazard warning switch inoperative (4.4.2 (a) (ii)) | 2 |
| Service brake efficiency below requirements (1.2.2 (a) (i)) | 2 |
| Rear Stop lamp(s) all not working (4.3.1 (a) (iii)) | 2 |
| Supplementary restraint system warning lamp indicates a fault (7.1.6 (a)) | 2 |
| Rear fog lamp not working (4.5.1 (a) (ii)) | 2 |
| Rear fog lamp not working |1.3.2b| | 2 |
| Offside Front Anti-roll bar linkage ball joint excessively worn (5.3.4 (a) (i)) | 2 |
| Rear brake disc in such a condition that it is seriously weakened | 2 |
| Nearside Front Anti-roll bar linkage ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Nearside Front Track rod end ball joint worn to the extent there is a serious risk of detachment (2.1.3 (b) (ii)) | 1 |
| Nearside Rear Parking brake inoperative on one side (1.4.1 (a)) | 1 |
| Nearside Front Body component damaged and likely to cause injury mirror cover missing (6.2.1 (a) (i)) | 1 |
| Nearside Rear Road wheel more than one fixing missing |5.2.1 |a| |ii|| | 1 |
| Nearside Front Road wheel fixing missing |5.2.1 |a| |i|| | 1 |
| Offside Rear Road wheel fixing loose wrong type bolt |5.2.1 |a| |i|| | 1 |
| Offside Front Outer Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt split |6.1.7 |g| |ii|| | 1 |
| Nearside Front Lower Suspension arm ball joint excessively worn |5.3.4 |a| |i|| | 1 |
| Offside Front Upper Anti-roll bar ball joint dust cover no longer prevents the ingress of dirt |5.3.4 |b| |ii|| | 1 |
| Engine MIL inoperative or indicates a malfunction (8.2.2.2 (g)) | 1 |
| Nearside Front Anti-roll bar ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Offside Front Anti-roll bar ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Offside Front Suspension arm ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Offside Front Shock absorber has a serious fluid leak |2.7.3| | 1 |
| Nearside Body panel damaged and likely to cause injury Repeater. (6.2.1 (a) (i)) | 1 |
| Horn not working (7.7 (a) (ii)) | 1 |
| Engine MIL inoperative or indicates a malfunction (8.2.1.2 (h)) | 1 |
| Nearside Rear Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Nearside Front Upper Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Nearside Lower Obligatory mirror missing (3.3 (a)) | 1 |
| Offside Outline marker lamp likely to become detached (4.2.1 (c) (ii)) | 1 |
| Nearside Outline marker lamp not working (4.2.1 (a) (ii)) | 1 |
| Nearside Reversing lamp does not emit a steady white light (4.6.2 (a)) | 1 |
| Exhaust fumes causing a danger to health of persons on board (6.1.2 (b) (ii)) | 1 |
| Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 1 |
| Emissions not tested (8.2.2.2 (e)) | 1 |
| Front Brake disc significantly and obviously worn (1.1.14 (a) (i)) | 1 |
| Fluid leak harmful to the environment or a risk to other road users (8.4.1 (a) (i)) | 1 |
| Nearside Front Shock absorbers has an excessively worn bush (5.3.2 (c)) | 1 |
| Offside Front Shock absorbers has an excessively worn bush (5.3.2 (c)) | 1 |
| Nearside Rear Body component damaged and likely to cause injury WHEEL ARCH MISSING (6.2.1 (a) (i)) | 1 |
| Offside Front Headlamp not working on dipped beam |1.7.5a| | 1 |
| Engine MIL inoperative or indicates a malfunction |8.2.2.2 |g|| | 1 |
| Brake pedal anti-slip provision worn smooth |1.1.2 |c|| | 1 |
| Offside Stop lamp|s| remains on when the brakes are released |4.3.2 |a| |iii|| | 1 |
| Nearside Stop lamp|s| not working |4.3.1 |a| |ii|| | 1 |
| Offside Front Outline marker lamp not working |4.2.1 |a|| | 1 |
| Offside Outline marker lamp likely to become detached |4.2.1 |c| |ii|| | 1 |
| Nearside Outline marker lamp not working |4.2.1 |a|| | 1 |
| Offside Position lamp not working |4.2.1 |a|| | 1 |
| Nearside Front Inner Track rod end ball joint has excessive play |2.1.3 |b| |i|| | 1 |
| Offside Front Inner Track rod end ball joint has excessive play |2.1.3 |b| |i|| | 1 |
| Nearside Front Suspension arm ball joint excessively worn |5.3.4 |a| |i|| | 1 |
| Offside Front Suspension arm ball joint excessively worn |5.3.4 |a| |i|| | 1 |
| Parking brake efficiency below requirements |1.4.2 |a| |i|| | 1 |
| Nearside Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 1 |
| Windscreen wiper blade insecure | 1 |
| Nearside Headlamp aim projected beam image is obviously incorrect Bulb incorrectly fitted (4.1.2 (c)) | 1 |
| Nearside Rear Rear reflector missing |4.8.2 |a| |ii|| | 1 |
| Service brake effort inadequate at a wheel (1.2.1 (a) (i)) | 1 |
| Nearside Rear Service brake excessively fluctuating (1.2.1 (e)) | 1 |
| Offside Rear Service brake excessively fluctuating (1.2.1 (e)) | 1 |
| Central Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 1 |
| Nearside Front Service brake excessively binding (1.2.1 (f)) | 1 |
| Steering box has excessive free play detected at the steering wheel (steering box fitted) (2.3 (a) (i)) | 1 |
| Exhaust emissions test not completed because smoke levels are significantly in excess of the specified limit values (8.2.2.2 (f)) | 1 |
| Rear Brake load sensing valve seized and ABS not fitted or inoperative (1.1.17 (c) (ii)) | 1 |
| Offside Rear fog lamp not working (4.5.1 (a) (ii)) | 1 |
| Steering rack has excessive free play detected at the steering wheel (steering rack fitted) (2.3 (a) (i)) | 1 |
| Nearside Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
| Offside Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
| Nearside Headlamp light source and lamp not compatible (4.1.4 (c)) | 1 |
| Offside Headlamp light source and lamp not compatible (4.1.4 (c)) | 1 |
| Horn not working (7.7 (a)) | 1 |
| Offside Front Braking system leaking caliper (1.1.3 (d)) | 1 |
| Service brake efficiency less than 50% of the required value (1.2.2 (a) (ii)) | 1 |
| Nearside Hazard warning lamps inoperative front, side and rear (4.4.1 (e)) | 1 |
| Nearside Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 1 |
| Fuel system component leaking (6.1.3 (b) (i)) | 1 |
| Rear All direction indicators adversely affected by the operation of another lamp both sides (4.4.3 (b)) | 1 |
| Rear Brake cable insecure | 1 |
| Anti-roll bar pin or bush excessively worn both front d-bushes (5.3.4 (a) (i)) | 1 |
| Nearside Reversing lamp inoperative (4.6.1 (a)) | 1 |
| Rear fog lamp tell tale not working |1.3.1b| | 1 |
| Offside Rear Rear fog lamp not working |4.5.1 |a| |ii|| | 1 |
| Nearside Front Anti-roll bar ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Exhaust has a major leak of exhaust gases centre/rear silencer (6.1.2 (a)) | 1 |
| Front Exhaust has a major leak of exhaust gases |6.1.2 |a|| | 1 |
| Offside Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Offside Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced CENTRE OUTER SILL HOLED (6.1.1 (c) (i)) | 1 |
| Nearside Front Shock absorbers has a serious fluid leak | 1 |
| Front Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Rear Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Offside Front Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 1 |
| Offside Rear Brake pipe excessively damaged (1.1.11 (c)) | 1 |
| Nearside Rear Shock absorber has a serious fluid leak |2.7.3| | 1 |
| Nearside Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Nearside Daytime running lamp not working (4.2.1 (a) (ii)) | 1 |
| Nearside Front Track rod end ball joint has excessive play (2.1.3 (b) (i)) | 1 |
| Braking system leaking n/s/f flexy brake hose leaking |3.6.A.1| | 1 |
| Brake performance not tested all brakes |3.7.A.1| | 1 |
| Offside Front Outer Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 1 |
| Offside Rear Brake disc significantly and obviously worn (1.1.14 (a) (i)) | 1 |
| Offside Rear Parking brake inoperative on one side (1.4.1 (a)) | 1 |
| Nearside Front Anti-roll bar linkage ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Front Track rod end ball joint has excessive play (2.1.3 (b) (i)) | 1 |
| Nearside Front Anti-roll bar pin or bush excessively worn d bush (5.3.4 (a) (i)) | 1 |
| Offside Front Anti-roll bar pin or bush excessively worn d bush (5.3.4 (a) (i)) | 1 |
| Offside Rear Coil spring fractured or broken |5.3.1 |b| |i|| | 1 |
| Nearside Rear position lamp|s| incorrect colour shown white light |1.1.A.3e| | 1 |
| Nearside Rear wheel bearing has excessive play |2.6.2| | 1 |
| Rear Passenger`s seat insecure |6.2.6 |a| |ii|| | 1 |
| Nearside Front Anti-roll bar ball joint dust cover no longer prevents the ingress of dirt |5.3.4 |b| |ii|| | 1 |
| Offside Front Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Nearside Front Coil spring fractured or broken (5.3.1 (b) (i)) | 1 |
| Nearside Rear Service brake excessively binding (1.2.1 (f)) | 1 |
| Parking brake efficiency less than 50% of the required value (1.4.2 (a) (ii)) | 1 |
| Nearside Front Fuel pipe leaking (6.1.3 (b) (i)) | 1 |
| Emissions not tested due to exhaust leak (8.2.2.2 (e)) | 1 |
| Offside Exhaust emissions likely to be affected by an exhaust leak (8.2.2.1 (b)) | 1 |
| Fuel pipe leaking excessively or a risk of fire (6.1.3 (b) (ii)) | 1 |
| Brake pedal has insufficient reserve travel (1.1.2 (a)) | 1 |
| Offside Front Seat belt retracting mechanism defective 1st row (7.1.2 (e)) | 1 |
| Central Front Seat belt retracting mechanism defective 1st row (7.1.2 (e)) | 1 |
| Offside Seat belt retracting mechanism defective 3rd row (7.1.2 (e)) | 1 |
| Central Seat belt retracting mechanism defective 3rd row (7.1.2 (e)) | 1 |
| Nearside Obligatory mirror seriously damaged, affecting the rear view (3.3 (b) (ii)) | 1 |
| Nearside Entrance/exit door defective in operation (9.1.1 (a)) | 1 |
| Nearside Rear Suspension unit damaged or deteriorated and function affected air bag deflated (5.3.5 (b) (i)) | 1 |
| Exhaust has a major leak of exhaust gases flexible section snapped (6.1.2 (a)) | 1 |
| Nearside Front passenger door cannot be opened from inside the vehicle front part (6.2.3 (a)) | 1 |
| Offside Driver`s view to side impaired by crack |6.9.1b| | 1 |
| Nearside Rear Seat belt webbing significantly weakened last row |7.1.2 |b| |ii|| | 1 |