| Most common failures | No# failures |
|---|
| Service brake: efficiency below requirements |3.7.B.7| | 14 |
| Brake pipe excessively corroded | 14 |
| Parking brake: efficiency below requirements |3.7.B.7| | 10 |
| Brake hose excessively deteriorated | 8 |
| Windscreen wiper does not clear the windscreen effectively | 4 |
| Headlamp aim out of alignment | 4 |
| Registration plate lamp issues | 4 |
| Brakes imbalanced across an axle | 3 |
| Rear brake binding | 2 |
| Exhaust emissions carbon monoxide content at idle excessive |7.3.D.4| | 2 |
| Nearside Obligatory mirror seriously damaged, affecting the rear view |8.1.2a| | 2 |
| Hazard warning lamps not flashing in phase, with ignition on |1.4.B.1f| | 2 |
| Rear parking brake recording little or no effort | 2 |
| Rear brake application uneven | 2 |
| Rear fog lamp not working |1.3.2b| | 2 |
| Brake load sensing valve seized |3.6.E.3| | 2 |
| Nearside Headlamp not working on dipped beam |1.7.5a| | 2 |
| Nearside Rear position lamp|s| not working |1.1.A.3b| | 2 |
| Offside Rear fog lamp not working |1.3.2b| | 2 |
| Nearside Front Upper Suspension arm has excessive play in a pin/bush |2.4.G.3| | 2 |
| Windscreen has damage | 2 |
| Offside Statutory seat belt missing |5.1.1| | 2 |
| Exhaust system not adequately supported |7.1.1| | 2 |
| Nearside Rear Service brake excessively binding (1.2.1 (f)) | 1 |
| Driver`s seat fore and aft adjustment mechanism not functioning as intended. |6.2.A.3| | 1 |
| Offside front brake binding |3.7.B.1| | 1 |
| Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Nearside Front Upper Suspension arm rubber mounting bonding deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Nearside Front Shock absorber has a serious fluid leak |2.7.3| | 1 |
| Hazard warning lamps not flashing in phase, with ignition off |1.4.B.1f| | 1 |
| Brake pedal creeps down while the pedal is held under pressure |3.3.B.1a| | 1 |
| Nearside wheel cylinder leaking |3.6.A.1| | 1 |
| Brake load sensing valve linkage seized |3.6.E.3| | 1 |
| Nearside Rear Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Nearside Rear Rear wheel bearing rough when rotated |2.6.1| | 1 |
| Offside Rear fog lamp not working |4.5.1 |a| |ii|| | 1 |
| Rear Brake valve leaking |3.6.A.1| | 1 |
| Hazard warning switch inoperative (4.4.2 (a) (ii)) | 1 |
| Exhaust carbon monoxide content after 2nd fast idle exceeds manufacturers specified limits (8.2.1.2 (a)) | 1 |
| Nearside Front Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
| Parking brake lever has no reserve travel |3.1.6b| | 1 |
| Horn not a continuous or uniform sound |1.6.2e| | 1 |
| Centre Front Brake pipe inadequately supported |3.6.B.1| | 1 |
| Centre Front Brake pipe fouled by moving parts |3.6.B.2a| | 1 |
| Nearside rear brake recording little or no effort |3.7.B.5a| | 1 |
| Offside rear brake recording little or no effort |3.7.B.5a| | 1 |
| Offside Outer Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Offside Front Vehicle structure is damaged, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Windscreen wiper blade deteriorated |8.2.2| | 1 |
| Nearside Body has a sharp edge caused by corrosion |6.1.C.1| | 1 |
| Fuel system component leaking |7.2.3| | 1 |
| Nearside Front Lower Shock absorber insecure |2.7.2b| | 1 |
| Rear Drag link end ball joint has excessive play |2.2.B.1f| | 1 |
| Offside Front Brake back plate|s| securing device excessively deteriorated |3.5.1j| | 1 |
| Nearside Front coil spring incomplete |2.4.C.1a| | 1 |
| Offside Front coil spring incomplete |2.4.C.1a| | 1 |
| Nearside Steering arm has relative movement at its fixings |2.2.B.1h| | 1 |
| Offside Front suspension has excessive play in a upper suspension ball joint |2.5.B.1a| | 1 |
| Fuel tank leaking |7.2.3| | 1 |
| Nearside Front Upper Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Nearside Front suspension has excessive play in a upper suspension ball joint |2.5.B.1a| | 1 |
| Offside Front Upper Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Inner Parking brake mechanism/associated mounting prescribed area is excessively corroded |3.1.9| | 1 |
| Offside Outer Parking brake mechanism/associated mounting prescribed area is excessively corroded |3.1.9| | 1 |
| Brake pedal spongy |3.3.B.1b| | 1 |
| Nearside Front Shock absorber detached |2.7.2b| | 1 |
| Nearside Front Front wheel bearing rough when rotated |2.5.A.2| | 1 |
| Offside Rear Front wheel bearing rough when rotated |2.5.A.2| | 1 |
| Body has a sharp edge caused by corrosion |6.1.C.1| | 1 |
| Nearside Front coil spring fractured |2.4.C.1a| | 1 |
| Offside Side repeater not working |1.4.A.2c| | 1 |
| Nearside Stop lamp not working |1.2.1b| | 1 |
| Nearside Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Parking brake mechanism/associated mounting prescribed area is excessively corroded |3.1.9| | 1 |
| Nearside Headlamp not in good working order affecting light output |1.2.4a| | 1 |
| Nearside Front Brake hose excessively damaged |3.6.B.4d| | 1 |
| Offside Front Brake hose excessively damaged |3.6.B.4d| | 1 |
| Offside Front Upper Suspension arm has excessive play in a pin/bush |2.4.G.3| | 1 |
| Transmission brake efficiency below requirements |3.8.A.9/10| | 1 |
| Exhaust emissions carbon monoxide content excessive |7.3.B.1a| | 1 |
| Statutory seat belt missing |5.1.1| | 1 |
| Offside Rear position lamp|s| incorrect colour |1.1.A.3e| | 1 |
| Nearside Rear fog lamp emits a light other than red |1.3.2e| | 1 |
| Nearside Front Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 1 |
| Parking brake lever ratchet mechanism is broken |3.1.5| | 1 |
| Brake pedal anti-slip provision incomplete |3.3.A.1b| | 1 |
| Rear fog lamp tell tale not working |1.3.1b| | 1 |
| Centre Statutory seat belt missing |5.1.1| | 1 |
| Nearside Rear Anti-roll bar linkage has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Rear Anti-roll bar linkage has excessive play in a pin/bush |2.4.G.2| | 1 |
| Nearside Headlamp aim projected beam image is obviously incorrect |4.1.2 |c|| | 1 |
| Emissions not tested vehicle got hot during emissions test |aborted test| |8.2.1.2 |d|| | 1 |
| Offside Side repeater not working |4.4.1 |a| |ii|| | 1 |
| Nearside Track rod end ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Nearside Front Anti-roll bar linkage has excessive play in a pin/bush droplink |2.4.G.2| | 1 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 1 |
| Hazard warning switch missing |1.4.B.1d| | 1 |
| Stop lamp(s) all not working (4.3.1 (a) (iii)) | 1 |
| Nearside Side repeater not working (4.4.1 (a) (ii)) | 1 |
| Nearside Front Side repeater has less than 50% of the light sources illuminating |1.4.A.2c| | 1 |
| Nearside front brake binding |3.7.B.1| | 1 |
| Nearside Side repeater not working |1.4.A.2c| | 1 |