| Most common failures | No# failures |
|---|
| Service brake: efficiency below requirements |3.7.B.7| | 25 |
| Parking brake: efficiency below requirements |3.7.B.7| | 23 |
| Windscreen wiper does not clear the windscreen effectively | 22 |
| Headlamp aim out of alignment | 20 |
| Registration plate lamp issues | 17 |
| Rear parking brake recording little or no effort | 13 |
| Brake hose excessively deteriorated | 11 |
| Offside Rear fog lamp not working |1.3.2b| | 11 |
| Brakes imbalanced across an axle | 10 |
| Exhaust emissions carbon monoxide content excessive |7.3.B.1a| | 8 |
| Offside rear brake recording little or no effort |3.7.B.5a| | 6 |
| Windscreen washer not working | 6 |
| Service brake efficiency below requirements (1.2.2 (a) (i)) | 5 |
| Rear fog lamp not working |1.3.2b| | 5 |
| Nearside rear brake recording little or no effort |3.7.B.5a| | 4 |
| Stop lamp remains on when the brakes are released | 4 |
| Nearside Side repeater not working |1.4.A.2c| | 4 |
| Offside Rear position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 3 |
| Horn not working |1.6.2a| | 3 |
| Rear brake binding | 3 |
| Exhaust has a major leak of exhaust gases |7.1.2| | 3 |
| Brake pipe excessively corroded | 3 |
| Exhaust emissions hydrocarbon content excessive |7.3.B.1b| | 3 |
| Exhaust emissions carbon monoxide content excessive (8.2.1.2 (b)) | 3 |
| Parking brake efficiency below requirements (1.4.2 (a) (i)) | 3 |
| Drivers seat fore and aft adjustment mechanism not functioning as intended. (6.2.5 (b) (i)) | 3 |
| Nearside Front Tie bar/rod rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 3 |
| Offside Front Tie bar/rod rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 3 |
| Windscreen has damage | 3 |
| Parking brake lever has no reserve travel |3.1.6b| | 3 |
| Nearside Stop lamp not working |1.2.1b| | 2 |
| Rear Brake valve leaking |3.6.A.1| | 2 |
| Offside front brake binding |3.7.B.1| | 2 |
| Rear brake application uneven | 2 |
| Offside Steering pivot point has excessive play |2.2.B.1g| | 2 |
| Offside Front Steering pivot point has excessive play |2.2.B.1g| | 2 |
| Offside Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 2 |
| Nearside Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 2 |
| Rear Exhaust system not adequately supported |7.1.1| | 2 |
| Offside Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
| Nearside Side repeater not working (4.4.1 (a) (ii)) | 2 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 2 |
| Rear Exhaust has part of the system excessively deteriorated |7.1.1a| | 2 |
| Exhaust system not adequately supported |7.1.1| | 2 |
| Registration plate issues | 2 |
| Nearside Front Side repeater not working |1.4.A.2c| | 2 |
| Offside Rear fog lamp not working (4.5.1 (a) (ii)) | 2 |
| Nearside Front Upper Suspension arm has excessive play in a ball joint |2.4.G.2| | 2 |
| Service brake efficiency below requirements |1.2.2 |a| |i|| | 2 |
| Nearside Obligatory mirror seriously damaged, affecting the rear view |8.1.2a| | 2 |
| Steering system has excessive free play detected at the steering wheel |steering box fitted| |2.2.A.1a| | 2 |
| Offside Front Upper Suspension arm ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 2 |
| Rear Exhaust system insecure (6.1.2 (a)) | 2 |
| Oil leaking excessively from engine (8.4.1 (a) (i)) | 2 |
| Main beam `tell-tale` not working |1.7.4c| | 2 |
| Nearside Front Lower Suspension arm ball joint dust cover no longer prevents the ingress of dirt |5.3.4 |b| |ii|| | 2 |
| Offside Front wheel bearing has excessive play |2.5.A.3c| | 2 |
| Offside Headlamp aim beam image kick up to the offside |1.8| | 2 |
| Brake hose damaged | 2 |
| Offside Front Front wheel bearing has excessive play |2.5.A.3c| | 2 |
| Front brake application uneven | 2 |
| Offside Front Anti-roll bar linkage rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 2 |
| Offside Side repeater not working |1.4.A.2c| | 2 |
| Nearside Rear Body has a sharp edge caused by corrosion |6.1.C.1| | 2 |
| brake disc excessively pitted |3.5.1h| | 1 |
| Exhaust emissions carbon monoxide content after 2nd fast idle excessive |7.3.D.3| | 1 |
| Exhaust emissions hydrocarbon content after 2nd fast idle excessive |7.3.D.3| | 1 |
| Exhaust emissions Lambda reading after 2nd fast idle outside specified limits |7.3.D.3| | 1 |
| Nearside Rear position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
| Nearside front brake binding |3.7.B.1| | 1 |
| Offside Front Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Exhaust emissions hydrocarbon content excessive (8.2.1.2 (b)) | 1 |
| Offside Front Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Rear fog lamp missing (4.5.1 (a) (ii)) | 1 |
| Parking brake lever inoperative (1.1.6 (d)) | 1 |
| Parking brake lever pivot worn to the extent that the brake may inadvertently release (1.1.6 (b) (ii)) | 1 |
| Fuel cap/sealing device component leaking (6.1.3 (b) (i)) | 1 |
| Parking brake efficiency less than 50% of the required value (1.4.2 (a) (ii)) | 1 |
| Horn not working (7.7 (a)) | 1 |
| Steering column top bearing excessively worn |2.1.2c| | 1 |
| Nearside Front Body has a sharp edge caused by corrosion body marked yellow |6.1.C.1| | 1 |
| Nearside Body has a sharp edge caused by corrosion under door marked yellow |6.1.C.1| | 1 |
| Offside Front Seat belt anchorage prescribed area is excessively corroded inner arch marked yellow |5.2.6| | 1 |
| Hazard warning tell tale not working correctly |1.4.B.1e| | 1 |
| Hazard warning lamps not flashing in phase, with ignition on |1.4.B.1f| | 1 |
| Hazard warning lamps not flashing in phase, with ignition off |1.4.B.1f| | 1 |
| Front Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Rear Direction indicator incomplete |1.5.A1b| | 1 |
| Rear Brake cable knotted |3.5.1b| | 1 |
| Nearside Rear Seat belt fluffed or frayed which has clearly weakened the webbing |5.1.B.3b| | 1 |
| Nearside Front Lower Seat belt anchorage prescribed area is fractured |5.2.6| | 1 |
| Brake valve leaking |3.6.A.1| | 1 |
| Offside Rear Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Offside Front Driver`s door cannot be opened from inside the vehicle |6.2.B.1b| | 1 |
| Nearside Outer Track rod end ball joint dust cover insecure so that it no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |
| Steering linkage ball joint has excessive play Various ball joints causing excess play (2.1.3 (b) (i)) | 1 |
| Offside Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
| Offside Seat belt buckle damaged (7.1.2 (d)) | 1 |
| Passengers seat insecure mounting bolts not secure (6.2.6 (a) (ii)) | 1 |
| Offside Outer Track rod end ball joint dust cover insecure so that it no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |
| Front Brake disc significantly and obviously worn (1.1.14 (a) (i)) | 1 |
| Nearside Seat belt not functioning as intended (7.1.2 (c)) | 1 |
| Brake load sensing valve seized and ABS not fitted or inoperative valve seized (1.1.17 (c) (ii)) | 1 |
| Front Windscreen wiper blade deteriorated |8.2.2| | 1 |
| Offside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Horn sounds harsh or grating |1.6.2e| | 1 |
| Rear Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Parking brake mechanism/associated mounting prescribed area is excessively corroded |3.1.9| | 1 |
| Offside Front Rear wheel bearing rough when rotated |2.6.1| | 1 |
| Rear rear brake recording little or no effort |3.7.B.5a| | 1 |
| Nearside Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Offside Stop lamp not working |1.2.1b| | 1 |
| Offside Rear Brake valve leaking |3.6.A.1| | 1 |
| Nearside Front Brake pipe inadequately supported |3.6.B.1| | 1 |
| Nearside Front coil spring fractured |2.4.C.1a| | 1 |
| Offside Front coil spring fractured |2.4.C.1a| | 1 |
| Offside Front Lower Ball joint has excessive play |2.2.B.1f| | 1 |
| Nearside Front Anti-roll bar rubber bush bonding deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Brake pedal has insufficient reserve travel |1.1.2 |a|| | 1 |
| Exhaust emissions hydrocarbon content excessive |8.2.1.2 |b|| | 1 |
| Offside Rear Rear fog lamp not working |1.3.2b| | 1 |
| Offside Front Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Nearside Front brake caliper has restricted free movement |3.5.1k| | 1 |
| Offside Front Brake hose connection leaking on a hydraulic braking system |1.1.12 |c| |ii|| | 1 |
| Nearside Side repeater not working |4.4.1 |a| |ii|| | 1 |
| Offside Side repeater not working |4.4.1 |a| |ii|| | 1 |
| Nearside Front Lower Anti-roll bar linkage pin or bush excessively worn |5.3.4 |a| |i|| | 1 |
| Parking brake efficiency less than 50% of the required value |1.4.2 |a| |ii|| | 1 |
| Offside Rear Seat belt anchorage prescribed area is excessively corroded |5.1.B.7| | 1 |
| Nearside Rear Suspension spring mounting prescribed area is excessively corroded crossmember |2.4.A.3| | 1 |
| Nearside Rear Suspension spring mounting prescribed area is excessively corroded dropsill |2.4.A.3| | 1 |
| Offside Rear Suspension spring mounting prescribed area is excessively corroded dropsill |2.4.A.3| | 1 |
| Offside Rear Suspension spring mounting prescribed area is excessively corroded crossmember |2.4.A.3| | 1 |
| Centre Front Seat belt locking mechanism does not secure or release |5.2.5a| | 1 |
| Nearside Front wheel bearing rough when rotated |2.5.A.2| | 1 |
| Nearside Rear Body has a sharp edge caused by damage |6.1.C.1| | 1 |
| Offside Front Upper Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Nearside Front Upper Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Front Brake rod excessively worn and seriously weakened |3.5.1e| | 1 |
| Nearside Front Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Rear Seat belt insecurely fixed to the vehicles structure |5.2.1a| | 1 |
| Parking brake lever defective so that it cannot be satisfactorily operated |1.1.6 |d|| | 1 |
| Exhaust carbon monoxide content after 2nd fast idle exceeds manufacturer`s specified limits |8.2.1.2 |a|| | 1 |
| Exhaust hydrocarbon content after 2nd fast idle exceeds manufacturer`s specified limits |8.2.1.2 |a|| | 1 |
| Parking brake efficiency below requirements |1.4.2 |a| |i|| | 1 |
| Hazard warning switch faulty |1.4.B.1d| | 1 |
| Windscreen wiper not operating automatically when switched on |8.2.1b| | 1 |
| Brake load sensing valve seized and ABS not fitted or inoperative (1.1.17 (c) (ii)) | 1 |
| Offside Front Service brake excessively binding (1.2.1 (f)) | 1 |
| Parking brake lever defective so that it cannot be satisfactorily operated (1.1.6 (d)) | 1 |
| Passengers seat with a defective structure mounted on wood (6.2.6 (a) (i)) | 1 |
| Offside Side repeater incorrect colour (4.4.3 (a)) | 1 |
| Nearside Front Direction indicator light intensity significantly reduced (4.4.3 (a)) | 1 |
| Rear Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 1 |
| Offside Obligatory mirror insecure (3.3 (b) (ii)) | 1 |
| Nearside Headlamp insecure (4.1.1 (c)) | 1 |
| Nearside Front Lower Suspension arm ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Nearside Rear Body component corroded and likely to cause injury valence (6.2.1 (a) (i)) | 1 |
| Offside Rear Body component corroded and likely to cause injury valence (6.2.1 (a) (i)) | 1 |
| Offside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength body panel (5.3.6 (a) (i)) | 1 |
| Nearside Front Direction indicator not working (4.4.1 (a) (ii)) | 1 |
| Battery insecure and likely to cause a short circuit behind passenger seat (4.13 (a) (ii)) | 1 |
| Rear Brake load sensing valve seized |3.6.E.3| | 1 |
| Exhaust mounting missing |7.1.1b| | 1 |
| Offside Headlamp not working on main beam |1.7.5a| | 1 |
| Passenger`s seat insecure floor corroded |6.2.6 |a| |ii|| | 1 |
| Nearside Obligatory mirror seriously damaged, affecting the rear view |3.3 |b| |ii|| | 1 |
| Offside Obligatory mirror seriously damaged, affecting the rear view |3.3 |b| |ii|| | 1 |
| Nearside Headlamp aim projected beam image is obviously incorrect |4.1.2 |c|| | 1 |
| Nearside Front Wheel bearing has excessive play |5.1.3 |a| |i|| | 1 |
| Offside Front Wheel bearing has excessive play |5.1.3 |a| |i|| | 1 |
| Offside Front Upper Suspension arm ball joint dust cover no longer prevents the ingress of dirt |5.3.4 |b| |ii|| | 1 |
| Nearside Rear Service brake excessively fluctuating |1.2.1 |e|| | 1 |
| Oil leaking excessively from engine a few |8.4.1 |a| |i|| | 1 |
| Brake rod excessively worn and seriously weakened |3.5.1e| | 1 |
| Direction indicators not working |1.4.A.2c| | 1 |
| Driver`s seat insecure |6.2.A.1| | 1 |
| Nearside Front Front wheel bearing rough when rotated |2.5.A.2| | 1 |
| Offside Front Front wheel bearing rough when rotated |2.5.A.2| | 1 |
| Nearside Front wheel bearing has excessive play |2.5.A.3c| | 1 |
| Nearside Front Shock absorber has a serious fluid leak |2.7.3| | 1 |
| Offside Front Shock absorber has a serious fluid leak |2.7.3| | 1 |
| Nearside Front Direction indicator excessively deteriorated so that it is not visible from a reasonable distance |1.4.A.2e| | 1 |
| Nearside Upper Stop lamp not working |1.2.1b| | 1 |
| Nearside Outer Track rod end ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Offside Outer Track rod end ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Rear fog lamp emits a light other than red |1.3.2e| | 1 |
| Offside Front Upper Front suspension has excessive play in a upper suspension ball joint |2.5.B.1a| | 1 |
| Centre Rear Fuel tank leaking |7.2.3| | 1 |
| Nearside Headlamp aim beam image kick up to the offside |1.8| | 1 |
| Offside Front Wheel bolt|s| loose |4.2.A.1e| | 1 |
| Rear fog lamp missing |1.3.2a| | 1 |
| Centre Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Rear Rear fog lamp tell tale not working |1.3.1b| | 1 |
| Rear Rear fog lamp not working |1.3.2b| | 1 |
| Nearside Front Brake hose excessively damaged |3.6.B.4d| | 1 |
| Centre Front Seat belt damaged sufficient to obstruct correct operation of the belt |5.2.2a| | 1 |
| Nearside Side repeater incomplete |1.5.A1b| | 1 |
| Nearside Front Body has a sharp edge caused by damage |6.1.C.1| | 1 |
| Offside Rear Body has a sharp edge caused by damage |6.1.C.1| | 1 |
| Exhaust emissions carbon monoxide content excessive |6.4.B.2a| | 1 |
| Nearside Rear Body has sharp edges or projections caused by corrosion or damage making the vehicle dangerous to other road users |6.5.10| | 1 |
| Offside Rear Suspension spring mounting prescribed area is excessively corroded which significantly reduces the original strength |2.4.A.2| | 1 |
| Rear Seat belt fluffed or frayed which has clearly weakened the webbing |5.1.B.3b| | 1 |
| Rear Seat belt affected by an insecure seat fixing |5.1.B.2b| | 1 |
| Offside Rear Service brake effort inadequate at a wheel (1.2.1 (a) (i)) | 1 |
| Nearside Front Suspension arm pin or bush excessively worn Track control arm front bush (5.3.4 (a) (i)) | 1 |
| Offside Rear Upper Suspension component mounting prescribed area excessively corroded significantly reducing structural strength Shock absorber mounting (5.3.6 (a) (i)) | 1 |
| Seat belt retracting mechanism defective |5.1.B.6b| | 1 |
| Seat belt locking mechanism does not secure or release |5.1.B.6a| | 1 |
| Nearside Rear Valve stem seriously damaged (5.2.3 (j)) | 1 |
| Offside Rear Valve stem seriously damaged (5.2.3 (j)) | 1 |
| Offside Rear Rear reflector defective or damaged by more than 50% of the reflecting surface (4.8.1 (a) (ii)) | 1 |
| Brake load sensing valve linkage defective and function impaired pivot seized (1.1.17 (a)) | 1 |
| Centre Horn not working |1.6.2a| | 1 |
| Nearside Brake pipe excessively chafed |3.6.B.2c| | 1 |
| Nearside Front front brake binding |3.7.B.1| | 1 |
| Nearside Rear Rear wheel bearing rough when rotated |2.6.1| | 1 |
| Offside Front Anti-roll bar linkage insecure |2.4.G.1| | 1 |
| Exhaust has a part missing |7.1.1a| | 1 |
| Nearside Rear Body has a sharp edge caused by damage 1/4 bumper missing, bracket exposed |6.1.C.1| | 1 |
| Rear fog lamp does not face the rear |1.3.2a| | 1 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Rear Body has a sharp edge caused by corrosion |6.1.C.1| | 1 |
| Nearside Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Front Windscreen wiper blade deteriorated |8.2.2| | 1 |
| Offside Rear Rear fog lamp does not face the rear |1.3.2a| | 1 |
| Centre Exhaust system not adequately supported |7.1.1| | 1 |
| Nearside Front Windscreen wiper blade deteriorated |8.2.2| | 1 |
| Offside Rear Exhaust has part of the system excessively deteriorated |7.1.1a| | 1 |
| Offside Rear Exhaust system not adequately supported |7.1.1| | 1 |
| Nearside Rear Brake cable has wires broken and is significantly weakened |3.5.1b| | 1 |
| Fuel tank leaking |7.2.3| | 1 |
| Brake pedal anti-slip provision incomplete |3.3.A.1b| | 1 |
| Indicator tell tale inoperative |1.4.A.2a| | 1 |
| Nearside Front Seat belt anchorage prescribed area is excessively corroded under wheel arch |5.2.6| | 1 |
| Centre Front Steering locking device missing |2.2.C.1g| | 1 |
| Nearside Windscreen wiper blade deteriorated |8.2.2| | 1 |
| Nearside Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
| Offside Front Statutory seat belt missing |5.1.A.1| | 1 |
| Centre Statutory seat belt missing |5.1.A.1| | 1 |
| Offside Front Parking brake mechanism/associated mounting prescribed area is excessively corroded |3.1.9| | 1 |
| Rear Brake load sensing valve linkage seized |3.6.E.3| | 1 |