Most common failures | No# failures |
---|
Parking brake: efficiency below requirements |3.7.B.7| | 517 |
Service brake: efficiency below requirements |3.7.B.7| | 377 |
Headlamp aim out of alignment | 317 |
Registration plate lamp issues | 282 |
Windscreen wiper does not clear the windscreen effectively | 277 |
Brakes imbalanced across an axle | 235 |
Brake hose excessively deteriorated | 194 |
Brake pipe excessively corroded | 178 |
Rear parking brake recording little or no effort | 164 |
Offside Rear fog lamp not working |1.3.2b| | 126 |
Horn not working |1.6.2a| | 124 |
Exhaust emits an excessive level of metered smoke for a non-turbo charged engine |7.4.B.3b| | 71 |
Rear brake binding | 62 |
Exhaust has a major leak of exhaust gases |7.1.2| | 61 |
Rear brake application uneven | 60 |
Registration plate issues | 59 |
Brake load sensing valve linkage seized |3.6.E.3| | 58 |
Nearside front brake binding |3.7.B.1| | 56 |
Offside front brake binding |3.7.B.1| | 51 |
Nearside Stop lamp not working |1.2.1b| | 49 |
Fuel system component leaking |7.2.3| | 49 |
Nearside Headlamp not working on dipped beam |1.7.5a| | 48 |
Parking brake lever has no reserve travel |3.1.6b| | 47 |
Nearside Side repeater not working |1.4.A.2c| | 45 |
Offside Rear Rear fog lamp not working |1.3.2b| | 44 |
Offside Side repeater not working |1.4.A.2c| | 43 |
Offside Stop lamp not working |1.2.1b| | 42 |
Front brake application uneven | 42 |
Offside Front Parking brake mechanism/associated mounting prescribed area is excessively corroded |3.1.9| | 38 |
Hazard warning switch faulty |1.4.B.1d| | 35 |
Rear fog lamp not working |1.3.2b| | 34 |
Offside Front coil spring fractured |2.4.C.1a| | 33 |
Offside Front Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 33 |
Hazard warning lamps not flashing in phase, with ignition on |1.4.B.1f| | 33 |
Offside Headlamp not working on dipped beam |1.7.5a| | 33 |
Offside rear brake recording little or no effort |3.7.B.5a| | 32 |
Nearside rear brake recording little or no effort |3.7.B.5a| | 32 |
Emissions not tested |7.0| | 29 |
Parking brake efficiency below requirements (1.4.2 (a) (i)) | 29 |
Offside Headlamp not working on main beam |1.7.5a| | 29 |
Parking brake mechanism/associated mounting prescribed area is excessively corroded |3.1.9| | 29 |
Nearside Front position lamp|s| not working |1.1.A.3b| | 29 |
Battery insecure |1.9.1| | 29 |
Offside Front position lamp|s| not working |1.1.A.3b| | 29 |
Nearside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 28 |
Hazard warning lamps not flashing in phase, with ignition off |1.4.B.1f| | 28 |
Windscreen has damage | 27 |
Offside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 27 |
Brake load sensing valve seized |3.6.E.3| | 26 |
Nearside Front Upper Suspension arm has excessive play in a ball joint |2.4.G.2| | 26 |
Brake hose damaged | 26 |
Nearside Headlamp not working on main beam |1.7.5a| | 25 |
Service brake efficiency below requirements (1.2.2 (a) (i)) | 25 |
Offside Front Upper Suspension arm has excessive play in a ball joint |2.4.G.2| | 24 |
Nearside Front Upper Suspension arm has excessive play in a pin/bush |2.4.G.2| | 24 |
Nearside Front suspension has excessive play in a upper suspension ball joint |2.5.B.1a| | 24 |
Nearside Front Side repeater not working |1.4.A.2c| | 23 |
Rear fog lamp tell tale not working |1.3.1b| | 23 |
Exhaust emits an excessive level of metered smoke for a turbo charged engine |7.4.B.3b| | 23 |
Nearside Front wheel bearing has excessive play |2.5.A.3c| | 22 |
Driver`s seat fore and aft adjustment mechanism not functioning as intended. |6.2.A.3| | 22 |
Nearside Front Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 22 |
Offside Front wheel bearing has excessive play |2.5.A.3c| | 21 |
Nearside Front coil spring fractured |2.4.C.1a| | 21 |
Offside Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 21 |
Rear Exhaust has a major leak of exhaust gases |7.1.2| | 21 |
Exhaust emits excessive smoke or vapour of any colour |7.4.B.4| | 21 |
Offside Front Upper Suspension arm has excessive play in a pin/bush |2.4.G.2| | 21 |
Nearside Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 21 |
Offside Front Side repeater not working |1.4.A.2c| | 21 |
Offside Front suspension has excessive play in a upper suspension ball joint |2.5.B.1a| | 21 |
Nearside Rear position lamp|s| not working |1.1.A.3b| | 20 |
Exhaust system not adequately supported |7.1.1| | 20 |
Offside Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 20 |
Offside Front front brake binding |3.7.B.1| | 20 |
Rear Brake load sensing valve linkage seized |3.6.E.3| | 19 |
Offside Track rod end ball joint has excessive play |2.2.B.1f| | 19 |
Centre Statutory seat belt missing |5.1.1| | 18 |
Nearside Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 18 |
Brake hose has insufficient room to move | 18 |
Offside Front Direction indicator not working |1.4.A.2c| | 18 |
Brake pedal spongy |3.3.B.1b| | 18 |
Parking brake lever ratchet mechanism is broken |3.1.5| | 17 |
Steering system has excessive free play detected at the steering wheel |steering box fitted| |2.2.A.1a| | 17 |
Offside Obligatory mirror seriously damaged, affecting the rear view |8.1.2a| | 17 |
Nearside Front Direction indicator not working |1.4.A.2c| | 17 |
Rear Exhaust system not adequately supported |7.1.1| | 17 |
Exhaust has part of the system excessively deteriorated |7.1.1a| | 17 |
Nearside Front front brake binding |3.7.B.1| | 17 |
Nearside Front Track rod end ball joint has excessive play |2.2.B.1f| | 16 |
Offside Rear rear brake recording little or no effort |3.7.B.5a| | 16 |
Nearside Rear Direction indicator not working |1.4.A.2c| | 16 |
Nearside Headlamp insecure |1.7.3| | 16 |
Rear Rear fog lamp not working |1.3.2b| | 16 |
Hazard warning lamps inoperative |1.4.B.1b| | 16 |
Offside Front Track rod end ball joint has excessive play |2.2.B.1f| | 15 |
Nearside Obligatory mirror seriously damaged, affecting the rear view |8.1.2a| | 15 |
Parking brake lever defective so that it cannot be satisfactorily operated |3.1.3c| | 15 |
Nearside Windscreen wiper blade deteriorated |8.2.2| | 14 |
Nearside Rear rear brake recording little or no effort |3.7.B.5a| | 14 |
Offside Rear position lamp|s| not working |1.1.A.3b| | 14 |
Offside Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 14 |
Service brake efficiency below requirements |1.2.2 |a| |i|| | 14 |
Parking brake efficiency below requirements |1.4.2 |a| |i|| | 14 |
Nearside Front Headlamp not working on dipped beam |1.7.5a| | 14 |
Windscreen wiper blade insecure | 13 |
Offside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 13 |
Offside Rear Direction indicator not working |1.4.A.2c| | 13 |
Offside Front Shock absorber has a serious fluid leak |2.7.3| | 13 |
Hazard warning tell tale not working correctly |1.4.B.1e| | 13 |
Windscreen washer not working | 12 |
Direction indicators not working |1.4.A.2c| | 12 |
Nearside Track rod end ball joint has excessive play |2.2.B.1f| | 12 |
Offside Front Headlamp not working on main beam |1.7.5a| | 12 |
Parking brake lever has excessive side play in the pivot and may disengage |3.1.4a| | 12 |
Nearside Front Tie bar/rod rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 12 |
Offside Rear Stop lamp not working |1.2.1b| | 12 |
Offside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 12 |
Nearside Rear Stop lamp not working |1.2.1b| | 12 |
Service brake: efficiency below requirements |3.7.D.4| | 12 |
Offside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 12 |
Offside Front Front position lamp|s| not working |1.1.A.3b| | 12 |
Centre Front Statutory seat belt missing |5.1.1| | 11 |
Nearside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 11 |
Nearside Front wheel bearing rough when rotated |2.5.A.2| | 11 |
Offside Parking brake mechanism/associated mounting prescribed area is excessively corroded |3.1.9| | 11 |
Offside Steering pivot point has excessive play |2.2.B.1g| | 11 |
Brake performance not tested |3.7.A.1| | 11 |
Nearside Front Front position lamp|s| not working |1.1.A.3b| | 11 |
Steering column top bearing excessively worn |2.1.2c| | 11 |
Parking brake efficiency less than 50% of the required value (1.4.2 (a) (ii)) | 11 |
Parking brake lever ratchet mechanism is excessively worn |3.1.5| | 11 |
Offside Front Lower Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 11 |
Nearside Front Lower Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 11 |
Offside Front Front wheel bearing has excessive play |2.5.A.3c| | 10 |
Offside Headlamp aim beam image kick up to the offside |1.8| | 10 |
Mechanical brake component has restricted free movement | 10 |
Nearside Front Body has a sharp edge caused by damage |6.1.C.1| | 10 |
Offside Front Headlamp not working on dipped beam |1.7.5a| | 10 |
Exhaust has a part missing |7.1.1a| | 10 |
Windscreen has a sticker or other obstruction encroaching into the swept area by more than 40mm outside zone `A` |8.3.1e| | 10 |
Centre Exhaust has a major leak of exhaust gases |7.1.2| | 10 |
Nearside Front Brake hose bulging under pressure |3.6.B.3| | 10 |
Front passenger seat insecure |6.2.3| | 10 |
Offside Front brake disc excessively pitted |3.5.1h| | 10 |
Nearside Front Upper Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 10 |
Offside Windscreen wiper blade deteriorated |8.2.2| | 10 |
Nearside Front Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 10 |
Nearside Headlamp aim beam image kick up to the offside |1.8| | 9 |
Rear Brake valve leaking |3.6.A.1| | 9 |
Offside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 9 |
Parking brake lever, pawl mechanism pivots or their associated mountings are insecure |3.1.4b| | 9 |
Offside Rear fog lamp missing |1.3.2a| | 9 |
Offside Headlamp insecure |1.7.3| | 9 |
Rear fog lamp not working (4.5.1 (a) (ii)) | 9 |
Main beam `tell-tale` not working |1.7.4c| | 9 |
Brake pedal creeps down when held under pressure |3.3.B.1a| | 9 |
Nearside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 9 |
Nearside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 9 |
Brake pedal anti-slip provision incomplete |3.3.A.1b| | 9 |
Offside Rear Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 9 |
Front Windscreen wiper not operating automatically when switched on |8.2.1b| | 9 |
Rear Exhaust has part of the system excessively deteriorated |7.1.1a| | 9 |
Nearside Front Shock absorber has a serious fluid leak |2.7.3| | 9 |
Parking brake is not capable of being maintained in operation by direct mechanical action only |3.1.2| | 9 |
Offside Front Steering pivot point has excessive play |2.2.B.1g| | 9 |
Nearside Front Headlamp not working on main beam |1.7.5a| | 9 |
Nearside Front coil spring broken |2.4.C.1a| | 9 |
Offside Statutory seat belt missing |5.1.1| | 8 |
Offside Front coil spring incomplete |2.4.C.1a| | 8 |
Fuel tank leaking |7.2.3| | 8 |
Brake pedal has no servo assistance |3.3.B.2| | 8 |
Nearside Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 8 |
Steering box has relative movement between sector shaft and the drop arm |2.2.B.1b| | 8 |
Offside Rear Body has a sharp edge caused by corrosion |6.1.C.1| | 8 |
Nearside Front Axle king pin has excessive play in pin and/or bush adversely affecting the steering |2.5.A.3a| | 8 |
Nearside Rear Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 8 |
Centre Exhaust has part of the system excessively deteriorated |7.1.1a| | 8 |
Offside Front Drag link end ball joint has excessive play |2.2.B.1f| | 8 |
Offside Front Tie bar/rod rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 8 |
Nearside Front Body has a sharp edge caused by corrosion |6.1.C.1| | 8 |
Parking brake: efficiency below requirements |3.7.C.1b| | 8 |
Brake pedal creeps down while the pedal is held under pressure |3.3.B.1a| | 8 |
Offside Rear wheel bearing rough when rotated |2.6.1| | 8 |
Nearside Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 8 |
Front Exhaust has a major leak of exhaust gases |7.1.2| | 8 |
Brake valve leaking |3.6.A.1| | 8 |
Offside Track rod end ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.2.C.1c| | 8 |
Nearside Steering pivot point has excessive play |2.2.B.1g| | 7 |
rear brakes release unevenly |3.7.B.4| | 7 |
Offside Rear fog lamp insecure |1.3.2a| | 7 |
Nearside Front Front wheel bearing has excessive play |2.5.A.3c| | 7 |
Offside Side repeater not working (4.4.1 (a) (ii)) | 7 |
Nearside Rear Position lamp not working (4.2.1 (a) (ii)) | 7 |
Offside Front Brake hose bulging under pressure |3.6.B.3| | 7 |
Nearside Front Headlamp insecure |1.7.3| | 7 |
Nearside Front Steering pivot point has excessive play |2.2.B.1g| | 7 |
Offside Front coil spring cracked |2.4.C.1a| | 7 |
Rear Brake hose bulging under pressure |3.6.B.3| | 7 |
Offside Side repeater not working |4.4.1 |a| |ii|| | 7 |
Hazard warning switch inoperative (4.4.2 (a) (ii)) | 7 |
Rear Exhaust mounting missing |7.1.1b| | 7 |
Offside Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 7 |
Exhaust tailpipe not capable of allowing the emission probe to be inserted |7.4.B.1| | 7 |
Nearside Front Shock absorber insecure |2.7.2b| | 6 |
Nearside Front Suspension arm has excessive play in a pin/bush |2.4.G.2| | 6 |
Parking brake: efficiency below requirements |3.7.D.4| | 6 |
Nearside Front Front suspension has excessive play in a upper suspension ball joint |2.5.B.1a| | 6 |
Nearside Front Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 6 |
Brake pedal anti-slip provision worn smooth |3.3.A.1b| | 6 |
Nearside Statutory seat belt missing |5.1.1| | 6 |
Fuel cap/sealing device does not fasten securely maintaining the sealing arrangement |7.2.4b| | 6 |
Drivers seat fore and aft adjustment mechanism not functioning as intended. (6.2.5 (b) (i)) | 6 |
Rear fog lamp not working |4.5.1 |a| |ii|| | 6 |
Driver`s door cannot be opened from inside the vehicle |6.2.B.1b| | 6 |
Nearside Front brake disc excessively pitted |3.5.1h| | 6 |
Nearside Rear position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 6 |
Nearside front brake recording little or no effort |3.7.B.5a| | 6 |
Offside Front Body has a sharp edge caused by corrosion |6.1.C.1| | 6 |
Nearside Front Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 6 |
Offside Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 6 |
Rear Exhaust has a part missing |7.1.1a| | 6 |
Nearside Rear Shock absorber has a serious fluid leak |2.7.3| | 6 |
Offside Front Axle king pin has excessive play in pin and/or bush adversely affecting the steering |2.5.A.3a| | 6 |
Nearside Side repeater missing |1.4.A.2b| | 6 |
Nearside Front Service brake excessively binding (1.2.1 (f)) | 6 |
Offside Front Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 6 |
Offside Front Braking system leaking |3.6.A.1| | 6 |
Nearside Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 6 |