| Most common failures | No# failures |
|---|
| Brake pipe excessively corroded | 39 |
| Registration plate lamp issues | 35 |
| Brake hose excessively deteriorated | 34 |
| Parking brake: efficiency below requirements |3.7.B.7| | 23 |
| Headlamp aim out of alignment | 18 |
| Brakes imbalanced across an axle | 12 |
| Rear parking brake recording little or no effort | 12 |
| Windscreen wiper does not clear the windscreen effectively | 10 |
| Rear Exhaust has a major leak of exhaust gases |7.1.2| | 8 |
| Exhaust emits an excessive level of metered smoke for a turbo charged engine |7.4.B.3b| | 8 |
| Registration plate issues | 8 |
| Nearside rear brake recording little or no effort |3.7.B.5a| | 6 |
| Offside rear brake recording little or no effort |3.7.B.5a| | 6 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 5 |
| Offside Stop lamp not working |1.2.1b| | 5 |
| Offside Front constant velocity joint gaiter split |2.5.C.1a| | 5 |
| Offside Front coil spring incomplete |2.4.C.1a| | 5 |
| Service brake: efficiency below requirements |3.7.B.7| | 5 |
| Nearside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 5 |
| Front brake disc in such a condition that it is seriously weakened | 4 |
| Parking brake lever has no reserve travel |3.1.6b| | 4 |
| Nearside Side repeater not working |1.4.A.2c| | 4 |
| Offside Front Front constant velocity joint gaiter split |2.5.C.1a| | 4 |
| Offside Steering rack gaiter split |2.2.D.2d| | 4 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 3 |
| Offside Rear wheel bearing has excessive play |2.6.2| | 3 |
| Nearside Rear rear brake recording little or no effort |3.7.B.5a| | 3 |
| Nearside Rear Stop lamp not working |1.2.1b| | 3 |
| Fuel pipe leaking |7.2.3| | 3 |
| Offside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 3 |
| Brake load sensing valve seized |3.6.E.3| | 3 |
| Nearside Front constant velocity joint gaiter split |2.5.C.1a| | 3 |
| Offside Side repeater not working |1.4.A.2c| | 3 |
| Brake pedal spongy |3.3.B.1b| | 3 |
| Offside Front Suspension arm has excessive play in a pin/bush |2.4.G.2| | 3 |
| Brake load sensing valve linkage seized |3.6.E.3| | 3 |
| Front brake application uneven | 3 |
| Offside Front coil spring fractured |2.4.C.1a| | 3 |
| Nearside Front Shock absorber has a serious fluid leak |2.7.3| | 3 |
| Nearside Front Track rod end ball joint has excessive play |2.2.B.1f| | 3 |
| Offside Rear Shock absorber has a serious fluid leak |2.7.3| | 3 |
| Exhaust has a major leak of exhaust gases |7.1.2| | 3 |
| Nearside Front Windscreen wiper blade deteriorated |8.2.2| | 2 |
| Offside Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 2 |
| Offside Rear Stop lamp not working |1.2.1b| | 2 |
| Offside Front Suspension arm has excessive play in a ball joint |2.4.G.2| | 2 |
| Nearside Front Suspension arm has excessive play in a ball joint |2.4.G.2| | 2 |
| Front Exhaust has a major leak of exhaust gases |7.1.2| | 2 |
| Windscreen has damage | 2 |
| Rear brake binding | 2 |
| Battery insecure |1.9.1| | 2 |
| Horn not working |1.6.2a| | 2 |
| Driver`s door cannot be opened from outside the vehicle |6.2.B.1b| | 2 |
| Offside Rear passenger door cannot be opened from outside the vehicle |6.2.B.1c| | 2 |
| Nearside Front Side repeater not working |1.4.A.2c| | 2 |
| Nearside Front Direction indicator not working |1.4.A.2c| | 2 |
| Nearside Stop lamp not working |1.2.1b| | 2 |
| Offside Rear rear brake recording little or no effort |3.7.B.5a| | 2 |
| Nearside Rear Shock absorber has a serious fluid leak |2.7.3| | 2 |
| Nearside Front coil spring cracked |2.4.C.1a| | 2 |
| Nearside Rear Shock absorber has negligible damping effect |2.7.5| | 2 |
| Nearside Rear Rear wheel bearing rough when rotated |2.6.1| | 2 |
| Fuel system component leaking |7.2.3| | 2 |
| Nearside Rear passenger door cannot be opened from outside the vehicle |6.2.B.1c| | 2 |
| Offside Macpherson strut has excessive movement at the upper attachment |2.5.A.1c| | 2 |
| Centre Exhaust has a major leak of exhaust gases |7.1.2| | 2 |
| Nearside Front constant velocity joint gaiter insecure to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 2 |
| Offside Headlamp insecure |1.7.3| | 2 |
| Rear Brake load sensing valve seized |3.6.E.3| | 2 |
| Rear brake application uneven | 2 |
| Offside Track rod end ball joint has excessive play |2.2.B.1f| | 2 |
| Offside Front Suspension arm corroded and seriously weakened |2.4.G.1| | 2 |
| Offside Rear Road wheel bead rim badly distorted |4.2.A.1a| | 2 |
| Nearside Headlamp not working on dipped beam |1.7.5a| | 2 |
| Rear fog lamp tell tale not working |1.3.1b| | 2 |
| Offside Rear Rear fog lamp not working |1.3.2b| | 2 |
| Offside Front Steering rack gaiter split |2.2.D.2d| | 2 |
| Power steering pump insecure |2.3.6| | 2 |
| Brake hose has insufficient room to move | 2 |
| Nearside Front Lower Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 1 |
| Nearside Front Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Steering system excessively rough |2.2.D.1| | 1 |
| Nearside Front All position lamps not working |1.1.A.3b| | 1 |
| Nearside Rear Wheel bolt|s| missing |4.2.A.1e| | 1 |
| Offside Front Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Nearside Rear wheel bearing has excessive play |2.6.2| | 1 |
| Rear fog lamp switch missing |1.3.1a| | 1 |
| Hazard warning lamps not flashing in phase, with ignition on |1.4.B.1f| | 1 |
| Hazard warning lamps not flashing in phase, with ignition off |1.4.B.1f| | 1 |
| Front Direction indicators not working |1.4.A.2c| | 1 |
| Rear Direction indicators not working |1.4.A.2c| | 1 |
| Rear Rear fog lamp not working |1.3.2b| | 1 |
| Rear Mechanical brake component has restricted free movement | 1 |
| Front position lamp|s| incorrect colour |1.1.A.3e| | 1 |
| Nearside Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Emissions not tested |7.0| | 1 |
| Offside Outer Front constant velocity joint gaiter deteriorated to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Offside Front Seat belt stitching badly frayed |5.2.2b| | 1 |
| Emissions not tested |7.3.A.1| | 1 |
| Offside Front Suspension arm attachment bracket/mounting insecure |2.4.G.1| | 1 |
| Nearside Rear Body has a sharp edge caused by corrosion |6.1.C.1| | 1 |
| Nearside Front constant velocity joint gaiter insecurely mounted to its housing |2.5.C.1a| | 1 |
| Steering column top bearing excessively worn |2.1.2c| | 1 |
| Offside Rear Rear wheel bearing rough when rotated |2.6.1| | 1 |
| Offside Rear Rear wheel bearing has excessive play |2.6.2| | 1 |
| Nearside Rear Outer Other passenger door cannot be opened from outside the vehicle (6.2.3 (a)) | 1 |
| Nearside Front Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
| Offside Front Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
| Nearside Front Headlamp has a product on the light source so that the light output is severely reduced (4.1.4 (b)) | 1 |
| Offside Front Headlamp has a product on the light source so that the light output is severely reduced (4.1.4 (b)) | 1 |
| Offside Front Service brake excessively binding (1.2.1 (f)) | 1 |
| Nearside Front Power steering component insecure (2.1.5 (d) (i)) | 1 |
| Nearside Rear Exhaust fumes causing a danger to health of persons on board silencer missing (6.1.2 (b) (ii)) | 1 |
| Exhaust emissions carbon monoxide content excessive |7.3.B.1a| | 1 |
| Nearside Front Steering rack gaiter insecure |2.2.D.2d| | 1 |
| Offside Front Front wheel bearing has excessive play |2.5.A.3c| | 1 |
| Exhaust tailpipe not capable of allowing the emission probe to be inserted |7.3.B.1| | 1 |
| Nearside Front Headlamp aim aimed so that it dazzles other road users |1.8.A.1a| | 1 |
| Nearside Front Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 1 |
| Offside Front Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 1 |
| Indicator switch faulty |1.4.A.1| | 1 |
| Brake pipe leaking on a hydraulic braking system front to rear (1.1.11 (b) (ii)) | 1 |
| Nearside Front Suspension arm pin or bush excessively worn rearmost bush (5.3.4 (a) (i)) | 1 |
| Rear Braking system leaking |3.6.A.1| | 1 |
| Nearside Front Windscreen wiper blade missing |8.2.2| | 1 |
| Offside Front Windscreen wiper blade missing |8.2.2| | 1 |
| Nearside Front Front suspension has excessive movement at a wishbone pin or bush |2.5.A.1c| | 1 |
| Offside Front Front suspension has excessive movement at a wishbone pin or bush |2.5.A.1c| | 1 |
| Offside Rear Braking system leaking |3.6.A.1| | 1 |
| Offside Rear Shock absorber has negligible damping effect |2.7.5| | 1 |
| Offside Rear Direction indicator excessively damaged so that it is not visible from a reasonable distance |1.4.A.2e| | 1 |
| Offside Steering rack gaiter insecure |2.2.D.2d| | 1 |
| Brake cable has wires broken and is significantly weakened |3.5.1b| | 1 |
| Shock absorber has a serious fluid leak |2.7.3| | 1 |
| Nearside Rear Brake load sensing valve linkage seized |3.6.E.3| | 1 |
| Nearside Front Lower Bonded suspension unit bonding failed and part of unit is likely to become displaced |2.4.F.2| | 1 |
| Offside Front Shock absorber has a serious fluid leak |2.7.3| | 1 |
| Nearside Rear Braking system leaking |3.6.A.1| | 1 |
| Rear Exhaust system not adequately supported |7.1.1| | 1 |
| Steering column shaft has excessive end float |2.1.3| | 1 |
| Nearside Front Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Nearside front brake recording little or no effort |3.7.B.5a| | 1 |
| Offside front brake recording little or no effort |3.7.B.5a| | 1 |
| Brake performance not tested |3.7.A.1| | 1 |
| Exhaust emits an excessive level of metered smoke for a non-turbo charged engine |7.4.B.3b| | 1 |
| Front passenger door cannot be opened from outside the vehicle |6.2.B.1b| | 1 |
| Brake pedal creeps down while the pedal is held under pressure |3.3.B.1a| | 1 |
| Nearside Front Tie bar/rod rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Front Tie bar/rod rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Nearside Front passenger door cannot be opened from outside the vehicle |6.2.B.1b| | 1 |
| Nearside Outer Front Front constant velocity joint gaiter deteriorated to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Offside Front Front position lamp|s| not working |1.1.A.3b| | 1 |
| Fuel hose leaking |7.2.3| | 1 |
| Braking system leaking Offside rear brake cylinder |3.6.A.1| | 1 |
| Horn not working |7.7 |a| |ii|| | 1 |
| Brake master cylinder defective but brake still operating |1.1.10 |b| |i|| | 1 |
| Offside Front Anti-roll bar linkage fractured |2.4.G.1| | 1 |
| Offside Rear Brake pipe leaking |3.6.A.1| | 1 |
| Nearside front brake binding |3.7.B.1| | 1 |
| Nearside Front Anti-roll bar rubber mounting deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Front Anti-roll bar rubber mounting deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Nearside Outer Front Anti-roll bar linkage has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Outer Front Anti-roll bar linkage has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Suspension component mounting prescribed area is excessively corroded chassis |2.4.A.3| | 1 |
| Offside Seat belt anchorage prescribed area is excessively corroded floor |5.2.6| | 1 |
| Nearside Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Rear Rear fog lamp does not emit a steady red light |4.5.4 |a|| | 1 |
| Nearside Inner Front Front constant velocity joint gaiter split |2.5.C.1a| | 1 |
| Nearside Front Lower Sub-frame corroded and seriously weakened |2.4.G.1| | 1 |
| Offside Front Lower Sub-frame corroded and seriously weakened |2.4.G.1| | 1 |
| Rear Brake valve leaking |3.6.A.1| | 1 |
| Nearside Rear wheel bearing rough when rotated |2.6.1| | 1 |
| Offside Front Lower Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Nearside Front Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
| Nearside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Offside Front Brake hose bulging under pressure |3.6.B.3| | 1 |
| Rear Brake valve has an excessive discharge of oil |3.6.E.1| | 1 |
| Nearside Rear Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Fuel cap/sealing device does not fasten securely maintaining the sealing arrangement |7.2.4b| | 1 |
| Nearside Front suspension has excessive play in a track control arm inner bush |2.5.B.2b| | 1 |
| Offside Rear fog lamp excessively damaged so that it is not visible from a reasonable distance |1.3.2d| | 1 |
| Centre Rear Braking system leaking |3.6.A.1| | 1 |
| Nearside Front Suspension arm has excessive play in a track control arm inner bush |2.5.B.2b| | 1 |
| Offside Windscreen wiper not operating automatically when switched on |8.2.1b| | 1 |
| Nearside Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Nearside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Nearside Outer Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Nearside Rear Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Nearside Front brake disc contaminated by grease |3.5.1h| | 1 |
| Offside Front Direction indicator has a product on the light source so it is not visible from a reasonable distance |1.4.A.2e| | 1 |
| Offside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings drivers floor well and jacking point |6.1.B.2| | 1 |
| Nearside Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings chassis member |6.1.B.2| | 1 |
| Nearside Front Lower Bonded suspension unit deteriorated and cannot function as intended wishbone rear rubber bush |2.4.F.3| | 1 |
| Nearside Rear Brake valve leaking service brake valve |3.6.A.1| | 1 |
| Centre Statutory seat belt missing |5.1.1| | 1 |
| Nearside Front Body insecure and dangerous to other road users |6.1.B.1b| | 1 |
| Offside Front Body insecure and dangerous to other road users |6.1.B.1b| | 1 |
| Fuel system component insecure |7.2.1| | 1 |
| Offside Rear Direction indicators not working |1.4.A.2c| | 1 |
| Nearside Rear Sub-frame rubber bush bonding deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Rear Sub-frame rubber bush bonding deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Rear Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Nearside Front Brake pipe inadequately clipped to flexible hose |3.6.B.1| | 1 |
| Offside Front Brake pipe inadequately clipped to flexible hose |3.6.B.1| | 1 |
| Offside Front Lower Suspension arm has excessive play in a pin/bush rear bush |2.4.G.2| | 1 |
| Offside Front Lower Suspension component mounting prescribed area is excessively corroded suspension arm front mounting |2.4.A.3| | 1 |
| Rear Exhaust has a part missing |7.1.1a| | 1 |
| Offside front brake binding |3.7.B.1| | 1 |
| Offside Front Body has a projection caused by damage |6.1.C.1| | 1 |
| Nearside Rear Subframe mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Rear fog lamp switch inoperative (4.5.3 (a) (ii)) | 1 |
| Nearside Front Suspension arm ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Offside Front Suspension arm ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Nearside Windscreen wiper blade deteriorated |8.2.2| | 1 |
| Offside Windscreen wiper blade deteriorated |8.2.2| | 1 |
| Offside Rear Driver`s door cannot be opened from inside the vehicle |6.2.B.1b| | 1 |
| Offside Rear Driver`s door cannot be opened from outside the vehicle |6.2.B.1b| | 1 |
| Nearside Front Macpherson strut has excessive movement at the upper attachment |2.5.A.1c| | 1 |
| Nearside Headlamp aim beam image too far to the right |1.6.B4| | 1 |
| Steering system has excessive free play detected at the steering wheel |steering rack fitted| |2.2.A.1b| | 1 |
| Nearside Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Mechanical brake component has restricted free movement | 1 |
| Offside Front Windscreen wiper blade deteriorated |8.2.2| | 1 |
| Offside Front Shock absorber casing corroded externally so the unit does not function |2.7.2a| | 1 |
| Nearside Front Shock absorber casing corroded externally so the unit does not function |2.7.2a| | 1 |
| Nearside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
| Nearside Rear Rear position lamp|s| excessively damaged so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Steering rack insecure |2.2.B.1a| | 1 |
| Offside Front Direction indicator has less than 50% of the light sources illuminating |1.4.A.2c| | 1 |
| Nearside Front Front constant velocity joint gaiter split |2.5.C.1a| | 1 |
| Nearside Rear Sub-frame attachment rubber mounting deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Rear Sub-frame attachment rubber mounting deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Nearside Front Suspension arm rubber mounting deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Front Suspension arm rubber mounting deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Nearside Front Suspension arm worn and seriously weakened |2.4.G.1| | 1 |
| Nearside Headlamp insecure |1.7.3| | 1 |
| Nearside Front coil spring broken |2.4.C.1a| | 1 |
| Nearside Rear Shock absorber insecure |2.7.2b| | 1 |
| Offside Rear Brake hose twisted |3.6.B.4c| | 1 |
| Nearside Front Outer Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings sill |6.1.B.2| | 1 |
| Nearside Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Nearside Rear Direction indicators not working |1.4.A.2c| | 1 |
| Stop lamp not working |1.2.1b| | 1 |
| Ball joint has excessive play |2.2.B.1f| | 1 |
| Front Front position lamp|s| incorrect colour |1.1.A.3e| | 1 |
| Nearside Rear Front wheel bearing has excessive play |2.5.A.3c| | 1 |
| Nearside Front Front wheel bearing has excessive play |2.5.A.3c| | 1 |
| Offside Front Headlamp not working on dipped beam |1.7.5a| | 1 |
| Nearside Steering rack gaiter split |2.2.D.2d| | 1 |
| Offside Front Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Nearside Rear Rear fog lamp not working |1.3.2b| | 1 |
| Centre Rear Stop lamp not working |1.2.1b| | 1 |
| Nearside Rear Rear wheel bearing has excessive play |2.6.2| | 1 |
| Exhaust emits excessive smoke or vapour of any colour |7.4.B.4| | 1 |
| Nearside Front Suspension arm ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Offside Front Suspension arm ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Front brake disc excessively pitted |3.5.1h| | 1 |
| Offside Rear Brake hose bulging under pressure |3.6.B.3| | 1 |
| front brake binding |3.7.B.1| | 1 |
| Nearside Rear front brake binding |3.7.B.1| | 1 |
| Nearside Rear Wheel stud|s| missing |4.2.A.1e| | 1 |
| Nearside Rear Brake pipe inappropriately repaired |3.6.A.3| | 1 |
| Offside Front Side repeater not working |1.4.A.2c| | 1 |
| Nearside Front brake disc excessively pitted |3.5.1h| | 1 |
| Offside Front brake disc excessively pitted |3.5.1h| | 1 |
| Rear Exhaust mounting missing |7.1.1b| | 1 |
| Offside Front Brake hose excessively damaged |3.6.B.4d| | 1 |
| Front Bootlid cannot be secured in the closed position |6.4.1| | 1 |
| Offside Front Shock absorber has an excessively worn shock absorber pivot |2.7.4| | 1 |
| Offside Front Anti-roll bar synthetic bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |