| Most common failures | No# failures |
|---|
| Windscreen wiper does not clear the windscreen effectively | 47 |
| Headlamp aim out of alignment | 24 |
| Registration plate lamp issues | 12 |
| Offside Front Coil spring fractured or broken (5.3.1 (b) (i)) | 9 |
| Nearside Front Position lamp not working (4.2.1 (a) (ii)) | 8 |
| Nearside Stop lamp(s) not working (4.3.1 (a) (ii)) | 7 |
| Nearside Rear Shock absorbers has a serious fluid leak | 6 |
| Windscreen washer not working | 6 |
| Exhaust Lambda reading after 2nd fast idle outside specified limits (8.2.1.2 (c)) | 6 |
| Front brake disc in such a condition that it is seriously weakened | 5 |
| Offside Front Position lamp not working (4.2.1 (a) (ii)) | 5 |
| Nearside Stop lamp not working |1.2.1b| | 5 |
| Nearside Rear Stop lamp not working |1.2.1b| | 5 |
| Brakes imbalanced across an axle | 4 |
| Offside Rear Service brake excessively binding (1.2.1 (f)) | 4 |
| Offside Rear Stop lamp(s) not working (4.3.1 (a) (ii)) | 3 |
| Nearside Front coil spring broken |2.4.C.1a| | 3 |
| Front Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 3 |
| Brake servo vacuum pipe split |3.6.C.1b| | 3 |
| Offside Front coil spring broken |2.4.C.1a| | 3 |
| Offside Rear Shock absorbers has a serious fluid leak | 2 |
| Nearside Front Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 2 |
| Anti-lock braking system warning lamp indicates an ABS fault | 2 |
| Electronic stability control warning lamp indicates a fault (7.12 (e)) | 2 |
| Offside Front Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 2 |
| Service brake efficiency below requirements (1.2.2 (a) (i)) | 2 |
| Offside Front Anti-roll bar linkage ball joint excessively worn (5.3.4 (a) (i)) | 2 |
| Registration plate issues | 2 |
| Nearside Front Position lamp not working |4.2.1 |a|| | 2 |
| Offside Front Front position lamp|s| not working |1.1.A.3b| | 2 |
| Nearside Front Anti-roll bar linkage ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 2 |
| Offside Front Anti-roll bar linkage ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 2 |
| Offside Headlamp not working on dipped beam |1.7.5a| | 2 |
| Position lamp switch does not illuminate the front and rear position lamps with a single operation |1.1.A.2| | 2 |
| Nearside Front Road wheel badly distorted (5.2.2 (c) (i)) | 2 |
| Offside Front Coil spring fractured or broken |5.3.1 |b| |i|| | 2 |
| Offside Rear Shock absorber has a serious fluid leak |2.7.3| | 2 |
| Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 2 |
| Nearside Front Anti-roll bar linkage ball joint excessively worn (5.3.4 (a) (i)) | 2 |
| Nearside Front Shock absorbers has a serious fluid leak | 2 |
| Nearside Front Coil spring fractured or broken (5.3.1 (b) (i)) | 2 |
| Brake hose excessively deteriorated | 2 |
| Nearside Front Headlamp aim not tested (4.1.2 (b)) | 1 |
| Headlamp switch faulty switch for side lights inop |1.7.1| | 1 |
| Offside Front Driver`s seat fore and aft adjustment mechanism not functioning as intended. |6.2.5 |b| |i|| | 1 |
| Exhaust has a major leak of exhaust gases front flexible section (6.1.2 (a)) | 1 |
| Exhaust Lambda reading after 2nd fast idle outside specified limits |8.2.1.2 |c|| | 1 |
| Offside Rear Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Nearside Front Upper Anti-roll bar linkage ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Offside Front Lower Anti-roll bar linkage ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Nearside Front Road wheel badly distorted |5.2.2 |c| |i|| | 1 |
| Nearside Headlamp aim so that beam "kick up" is not visible on the screen |4.1.2 |a|| | 1 |
| Offside Headlamp aim so that beam "kick up" is not visible on the screen |4.1.2 |a|| | 1 |
| Nearside Rear Road wheel distorted |4.2.A.1a| | 1 |
| Electrical wiring insecure and connectors likely to become disconnected on top of battery (4.11 (a) (ii)) | 1 |
| Emissions not tested exhaust blowing (8.2.1.2 (d)) | 1 |
| Nearside Rear Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
| Offside Front Steering arm has relative movement at its fixings EXCESS MOVEMENTSTEERING INNER TIE ROD |2.2.B.1h| | 1 |
| Offside Stop lamp|s| not working |4.3.1 |a| |ii|| | 1 |
| Nearside Front Anti-roll bar linkage ball joint dust cover no longer prevents the ingress of dirt |5.3.4 |b| |ii|| | 1 |
| Offside Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
| Exhaust emissions Lambda reading after 2nd fast idle outside specified limits |7.3.D.3| | 1 |
| Front Windscreen wiper not operating automatically when switched on |8.2.1b| | 1 |
| Nearside Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 1 |
| Fuel tank leaking (6.1.3 (b) (i)) | 1 |
| Exhaust has a major leak of exhaust gases front section |7.1.2| | 1 |
| Offside Front Lower Suspension component ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Front Exhaust has a major leak of exhaust gases flange (6.1.2 (a)) | 1 |
| Electronic power steering warning lamp indicates a system malfunction (2.6 (a)) | 1 |
| Nearside Front Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
| Nearside Front Valve stem seriously damaged (5.2.3 (j)) | 1 |
| Nearside Rear Body has a sharp edge caused by damage |6.1.C.1| | 1 |
| Nearside Front Front position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Rear Coil spring fractured or broken |5.3.1 |b| |i|| | 1 |
| Offside Rear Seat belt has a cut which has significantly weakened the webbing |5.2.2a| | 1 |
| Nearside Rear Seat belt has a cut which has significantly weakened the webbing |5.2.2a| | 1 |
| Offside Rear Seat belt damaged sufficient to significantly weakened the webbing |5.2.2a| | 1 |
| Nearside Headlamp light intensity severely reduced (4.1.4 (a)) | 1 |
| Nearside Rear Stop lamp|s| not working |4.3.1 |a| |ii|| | 1 |
| Windscreen washer jets misaligned and not providing sufficient fluid to the windscreen (3.5 (a)) | 1 |
| Exhaust emissions likely to be affected by an exhaust leak (8.2.2.1 (b)) | 1 |
| Emissions not tested (8.2.1.2 (d)) | 1 |
| Nearside Headlamp not working on dipped beam |4.1.1 |a| |ii|| | 1 |
| Nearside Side repeater not working |1.4.A.2c| | 1 |
| Offside Rear Stop lamp not working |1.2.1b| | 1 |
| Offside Rear fog lamp not working (4.5.1 (a) (ii)) | 1 |
| Offside Front Seat belt has a cut which has significantly weakened the webbing |5.2.2a| | 1 |
| Nearside Rear Rear position lamp|s| incorrect colour |1.1.A.3e| | 1 |
| Nearside Front Headlamp excessively deteriorated so that the light output is severely reduced reduced light output. |1.7.5a| | 1 |
| Nearside Front Headlamp not working on main beam |1.7.5a| | 1 |
| Horn not working |7.7 |a| |ii|| | 1 |
| Nearside Stop lamp|s| not working |4.3.1 |a| |ii|| | 1 |
| Oil leaking excessively from engine |8.4.1 |a| |i|| | 1 |
| Offside Front Macpherson strut pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Reversing lamp inoperative (4.6.1 (a)) | 1 |
| Rear Exhaust system insecure (6.1.2 (a)) | 1 |
| Nearside Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Side repeater not working (4.4.1 (a) (ii)) | 1 |
| Offside Front Side repeater not working (4.4.1 (a) (ii)) | 1 |
| Parking brake efficiency below requirements |1.4.2 |a| |i|| | 1 |
| Parking brake lever has excessive movement indicating incorrect adjustment |1.1.6 |c|| | 1 |
| Offside Stop lamp not working |1.2.1b| | 1 |
| Front Exhaust has a major leak of exhaust gases flexi area (6.1.2 (a)) | 1 |
| Rear Exhaust has a major leak of exhaust gases silencer (6.1.2 (a)) | 1 |
| Offside Rear Fuel system component leaking fuel filter area (6.1.3 (b) (i)) | 1 |
| Nearside Front Power steering pipe|s| or hose|s| excessively corroded |2.3.2| | 1 |
| Front Exhaust has a major leak of exhaust gases Flexi-pipe broken |6.1.2 |a|| | 1 |
| Engine MIL inoperative or indicates a malfunction (8.2.1.2 (h)) | 1 |
| Nearside Headlamp not working on dipped beam |1.7.5a| | 1 |
| Offside Front Upper Anti-roll bar linkage ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Nearside Front Road wheel badly damaged |4.2.A.1a| | 1 |
| Offside Rear Direction indicator incorrect colour faded to white |4.4.3 |a|| | 1 |
| Front brake excessively fluctuating | 1 |
| Offside Front Anti-roll bar linkage worn and seriously weakened |2.4.G.1| | 1 |
| Offside Front Lower Suspension rod ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Offside Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 1 |
| Nearside Obligatory mirror missing |8.1.1| | 1 |
| Offside Front Road wheel bead rim badly distorted |4.2.A.1a| | 1 |
| Offside Front Track rod end ball joint has excessive play (2.1.3 (b) (i)) | 1 |
| Nearside Rear Service brake excessively binding (1.2.1 (f)) | 1 |
| Parking brake efficiency below requirements (1.4.2 (a) (i)) | 1 |
| Nearside Front Shock absorber has a serious fluid leak |2.7.3| | 1 |
| Nearside Headlamp aim projected beam image is obviously incorrect LHD headlight fitted (4.1.2 (c)) | 1 |
| Front Exhaust has a major leak of exhaust gases Flex broken (6.1.2 (a)) | 1 |
| Rear fog lamp not working |1.3.2b| | 1 |
| Front Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Offside Front Anti-roll bar has excessive play in a ball joint |2.4.G.2| | 1 |
| Offside Front Upper Macpherson strut attachment bracket/mounting insecure and impairing directional stability (5.3.3 (a) (ii)) | 1 |
| Nearside Front Headlamp insecure (4.1.1 (c)) | 1 |
| Front Bumper insecure (6.1.4 (a) (i)) | 1 |
| Offside Rear Anti-roll bar linkage ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Offside Front Upper Coil spring fractured or broken (5.3.1 (b) (i)) | 1 |
| Offside Front Wheel bearing rough when rotated (5.1.3 (b) (i)) | 1 |
| Offside Headlamp insecure (4.1.1 (c)) | 1 |
| Offside Front Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 1 |
| Offside Front Headlamp aim not tested (4.1.2 (b)) | 1 |
| Rear fog lamp not working (4.5.1 (a) (ii)) | 1 |
| Power steering pipe/hose excessively corroded from steering rack to pump resovoir (2.1.5 (g) (i)) | 1 |
| Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Central Front Emissions not tested exhaust blow at flex (8.2.1.2 (d)) | 1 |
| Offside Rear Shock absorbers has negligible damping effect (5.3.2 (d)) | 1 |
| Nearside Rear Road wheel badly distorted (5.2.2 (c) (i)) | 1 |
| Offside Front Service brake excessively binding (1.2.1 (f)) | 1 |
| Rear Mechanical brake component has restricted free movement | 1 |
| Service brake excessively fluctuating both front discs corroded (1.2.1 (e)) | 1 |
| Exhaust system insecure (6.1.2 (a)) | 1 |
| Offside Windscreen washer jets misaligned and not providing sufficient fluid to the windscreen (3.5 (a)) | 1 |
| Front Exhaust has a major leak of exhaust gases |6.1.2 |a|| | 1 |
| Offside Headlamp not working on main beam |4.1.1 |a| |ii|| | 1 |
| Exhaust emissions likely to be affected by an exhaust leak |8.2.1.1 |b|| | 1 |
| Nearside Reversing lamp does not emit a steady white light |4.6.2 |a|| | 1 |
| Front Exhaust has a major leak of exhaust gases exhaust flex pipe |6.1.2 |a|| | 1 |
| Driver`s door cannot be opened from inside the vehicle |6.2.B.1b| | 1 |
| Central Exhaust system insecure (6.1.2 (a)) | 1 |
| Exhaust Lambda reading after 2nd fast idle outside specified limits reading 1.10 (8.2.1.2 (c)) | 1 |
| Nearside Front Upper Anti-roll bar linkage ball joint dust cover no longer prevents the ingress of dirt droplink (5.3.4 (b) (ii)) | 1 |
| Offside Front Lower Anti-roll bar linkage ball joint dust cover no longer prevents the ingress of dirt droplink (5.3.4 (b) (ii)) | 1 |
| Exhaust emissions likely to be affected by an exhaust leak front pipe silencer (8.2.2.1 (b)) | 1 |
| Brake lever has insufficient reserve travel (1.1.2 (a)) | 1 |
| Exhaust Lambda reading after 2nd fast idle outside specified limits due to exhaust leak (8.2.1.2 (c)) | 1 |