| Most common failures | No# failures |
|---|
| Headlamp aim out of alignment | 20 |
| Registration plate lamp issues | 16 |
| Windscreen wiper does not clear the windscreen effectively | 9 |
| Engine MIL inoperative or indicates a malfunction (8.2.1.2 (h)) | 8 |
| Registration plate issues | 6 |
| Brake pipe excessively corroded | 6 |
| Engine MIL inoperative or indicates a malfunction |8.2.1.2 |h|| | 4 |
| Anti-lock braking system warning lamp indicates an ABS fault | 3 |
| Windscreen washer not working | 3 |
| Rear fog lamp not working (4.5.1 (a) (ii)) | 3 |
| Rear parking brake recording little or no effort | 3 |
| Parking brake: efficiency below requirements |3.7.B.7| | 3 |
| Offside Stop lamp(s) not working (4.3.1 (a) (ii)) | 3 |
| Offside Rear Shock absorbers has a serious fluid leak | 3 |
| Windscreen has damage | 2 |
| Nearside Rear Shock absorbers has a serious fluid leak | 2 |
| Offside Headlamp not working on dipped beam |4.1.1 |a| |ii|| | 2 |
| Exhaust emissions carbon monoxide content at idle excessive |7.3.D.4| | 2 |
| Offside Rear Rear fog lamp not working |4.5.1 |a| |ii|| | 2 |
| Nearside Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 2 |
| Brake pedal spongy |3.3.B.1b| | 2 |
| Brake hose has insufficient room to move | 2 |
| Exhaust carbon monoxide content after 2nd fast idle exceeds default limits |8.2.1.2 |b|| | 2 |
| Parking brake efficiency less than 50% of the required value |1.4.2 |a| |ii|| | 2 |
| Nearside Stop lamp not working |1.2.1b| | 2 |
| Nearside Front Upper Anti-roll bar linkage ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 2 |
| Nearside Side repeater not working |1.4.A.2c| | 2 |
| Driver`s door cannot be opened from inside the vehicle |6.2.3 |a|| | 2 |
| Windscreen has a sticker or other obstruction encroaching into the swept area by more than 40mm outside zone `A` |8.3.1e| | 2 |
| Exhaust emissions Lambda reading after 2nd fast idle outside specified limits |7.3.D.3| | 2 |
| Offside Rear Stop lamp not working |1.2.1b| | 1 |
| Front passenger door cannot be opened from inside the vehicle |6.2.B.1b| | 1 |
| Front passenger door cannot be opened from outside the vehicle |6.2.B.1b| | 1 |
| Offside Obligatory mirror missing glass |8.1.1| | 1 |
| Offside Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Front Anti-roll bar has excessive play in a ball joint |2.4.G.2| | 1 |
| Nearside Front Lower Suspension arm rubber bush deteriorated resulting in excessive movement rear |2.4.G.2| | 1 |
| Offside Front Lower Suspension arm rubber bush deteriorated resulting in excessive movement rear |2.4.G.2| | 1 |
| Nearside Stop lamp|s| not working |4.3.1 |a| |ii|| | 1 |
| Offside Front Upper Anti-roll bar linkage ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Nearside Rear Stop lamp not working |1.2.1b| | 1 |
| Service brake: efficiency below requirements |3.7.B.7| | 1 |
| Front Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 1 |
| Nearside Front Lower Suspension arm ball joint dust cover no longer prevents the ingress of dirt |5.3.4 |b| |ii|| | 1 |
| Nearside Front Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Nearside Headlamp aim unable to be tested (4.1.2 (b)) | 1 |
| Nearside Headlamp not working on main beam (4.1.1 (a) (ii)) | 1 |
| Nearside Front Direction indicator not working (4.4.1 (a) (ii)) | 1 |
| Battery insecure and likely to fall from carrier (4.13 (a) (ii)) | 1 |
| Nearside Front Anti-roll bar linkage pin or bush excessively worn d bush (5.3.4 (a) (i)) | 1 |
| Offside Front Anti-roll bar linkage pin or bush excessively worn d bush (5.3.4 (a) (i)) | 1 |
| Offside Front Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Front passenger door cannot be opened from outside the vehicle (6.2.3 (a)) | 1 |
| Front passenger door cannot be opened from inside the vehicle (6.2.3 (a)) | 1 |
| Nearside Front Anti-roll bar linkage ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Rear Seat belt locking mechanism does not secure or release |5.2.5a| | 1 |
| Offside Front Front constant velocity joint gaiter split |2.5.C.1a| | 1 |
| Offside Front Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Nearside Front Anti-roll bar linkage has excessive play in a ball joint |2.4.G.2| | 1 |
| Offside Front Anti-roll bar linkage has excessive play in a ball joint |2.4.G.2| | 1 |
| Nearside Front Inner Front constant velocity joint gaiter insecure to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Main beam `tell-tale` not working |1.7.4c| | 1 |
| Main beam tell-tale not working |4.9.1 |a| |ii|| | 1 |
| Rear fog lamp tell-tale missing |4.9.1 |a| |ii|| | 1 |
| Rear fog lamp missing |4.5.1 |a| |ii|| | 1 |
| Rear fog lamp switch missing |4.5.3 |a| |ii|| | 1 |
| Trailer electrical socket |13 pin| not operating the trailer lamps as intended |4.10 |c| |i|| | 1 |
| Exhaust Lambda reading after 2nd fast idle outside specified limits |8.2.1.2 |c|| | 1 |
| Offside Parking brake inoperative on one side |1.4.1 |a|| | 1 |
| Steering box has excessive free play detected at the steering wheel |steering box fitted| |2.3 |a| |i|| | 1 |
| Steering lock stop incorrectly adjusted |2.1.4 |b|| | 1 |
| Central Upper Stop lamp(s) with a multiple light source more than 1/2 not functioning (4.3.1 (a) (ii)) | 1 |
| Nearside Front Lower Suspension arm ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Offside Front Lower Suspension arm ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Nearside Front Anti-roll bar linkage ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 1 |
| Nearside Rear coil spring broken |2.4.C.1a| | 1 |
| Nearside Rear reflector missing (4.8.2 (a) (ii)) | 1 |
| Nearside Front Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 1 |
| Offside Driver`s door cannot be opened from inside the vehicle |6.2.B.1b| | 1 |
| Brake hose damaged | 1 |
| Exhaust carbon monoxide content after 2nd fast idle exceeds manufacturers specified limits (8.2.1.2 (a)) | 1 |
| Exhaust Lambda reading after 2nd fast idle outside specified limits (8.2.1.2 (c)) | 1 |
| Nearside Rear Vehicle structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting (6.2.2 (d) (i)) | 1 |
| Rear fog lamp not working |1.3.2b| | 1 |
| Offside Front Front wheel bearing rough when rotated |2.5.A.2| | 1 |
| Battery insecure and likely to fall from carrier |4.13 |a| |ii|| | 1 |
| Nearside Rear passenger door does not latch securely closed |6.2.B.1a| | 1 |
| Nearside Front Wheel bolt|s| missing |4.2.A.1e| | 1 |
| Nearside Rear Wheel bolt|s| missing |4.2.A.1e| | 1 |
| Offside Front Wheel bolt|s| missing |4.2.A.1e| | 1 |
| Offside Rear Wheel bolt|s| missing |4.2.A.1e| | 1 |
| Nearside Rear Stop lamp|s| not working |4.3.1 |a| |ii|| | 1 |
| Offside Stop lamp|s| not working |4.3.1 |a| |ii|| | 1 |
| Nearside Front Road wheel fixing loose |5.2.1 |a| |i|| | 1 |
| Anti-roll bar linkage ball joint dust cover no longer prevents the ingress of dirt nearside and offside front (5.3.4 (b) (ii)) | 1 |
| Suspension component ball joint dust cover no longer prevents the ingress of dirt nearside and offside front (5.3.4 (b) (ii)) | 1 |
| Centre Stop lamp not working |1.2.1b| | 1 |
| Offside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
| Nearside Rear Entrance/exit door door open warning device inoperative (9.1.1 (d)) | 1 |
| Nearside Front Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
| Nearside Front Suspension arm ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Offside Front Suspension arm ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Nearside Front Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Exhaust system not adequately supported |7.1.1| | 1 |
| Nearside Front Brake hose excessively damaged (1.1.12 (b) (ii)) | 1 |
| Brake performance not tested (1.2.1 (g)) | 1 |
| Nearside Front Anti-roll bar ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Front Anti-roll bar ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Front Lower Suspension arm pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Brake servo vacuum pipe split |3.6.C.1b| | 1 |
| Offside Rear coil spring incomplete |2.4.C.1a| | 1 |
| Nearside Front Position lamp not working |4.2.1 |a|| | 1 |
| rear parking |secondary| brakes imbalanced | 1 |
| Nearside Rear Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
| Exhaust emits an excessive level of metered smoke for a turbo charged engine |7.4.B.3b| | 1 |
| Exhaust emissions exceed manufacturers specified limit (8.2.2.2 (a)) | 1 |
| Offside Front Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 1 |
| Offside Rear Other passenger door cannot be opened from outside the vehicle (6.2.3 (a)) | 1 |
| Nearside Front Suspension arm rubber bush bonding deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Headlamp not working on dipped beam |1.7.5a| | 1 |
| Offside Headlamp not working on main beam |1.7.5a| | 1 |
| Offside Front Direction indicator not working |1.4.A.2c| | 1 |
| Nearside Front Road wheel fixing missing (5.2.1 (a) (i)) | 1 |
| Nearside Rear Road wheel fixing missing (5.2.1 (a) (i)) | 1 |
| Offside Rear Outer Drive shaft which forms part of the suspension coupling gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.4.G.4e| | 1 |
| Brake pedal has insufficient reserve travel |1.1.2 |a|| | 1 |
| Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 1 |
| Emissions unable to be completed due to exhaust (8.2.1.2 (d)) | 1 |
| Nearside Front Drag link end ball joint has excessive play |2.2.B.1f| | 1 |
| Nearside Front Anti-roll bar linkage ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Centre Rear Seat belt locking mechanism does not secure or release |5.2.5a| | 1 |
| Offside Rear Parking brake inoperative on one side |1.4.1 |a|| | 1 |
| Exhaust emissions carbon monoxide content after 2nd fast idle excessive |7.3.D.3| | 1 |
| Offside Rear fog lamp not working |1.3.2b| | 1 |
| Nearside Side repeater missing |1.4.A.2b| | 1 |
| Horn not working |1.6.2a| | 1 |
| Offside Rear Rear fog lamp excessively deteriorated so that it is not visible from a reasonable distance |1.3.2d| | 1 |
| Offside Rear Service brake grabbing severely (1.2.1 (c)) | 1 |
| Exhaust has a major leak of exhaust gases rear box (6.1.2 (a)) | 1 |
| Offside Front Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 1 |