| Most common failures | No# failures |
|---|
| Registration plate lamp issues | 20 |
| Headlamp aim out of alignment | 19 |
| Brake pipe excessively corroded | 17 |
| Parking brake: efficiency below requirements |3.7.B.7| | 15 |
| Windscreen wiper does not clear the windscreen effectively | 11 |
| Horn not working |1.6.2a| | 10 |
| Brake hose excessively deteriorated | 10 |
| Brakes imbalanced across an axle | 9 |
| Offside Rear fog lamp not working |1.3.2b| | 7 |
| Registration plate issues | 7 |
| Offside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 6 |
| Nearside Stop lamp not working |1.2.1b| | 5 |
| Offside Stop lamp not working |1.2.1b| | 5 |
| Rear fog lamp tell tale not working |1.3.1b| | 5 |
| Rear brake binding | 5 |
| Nearside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 4 |
| Rear fog lamp not working |1.3.2b| | 4 |
| Parking brake efficiency below requirements (1.4.2 (a) (i)) | 4 |
| Windscreen has a sticker or other obstruction encroaching into the swept area by more than 40mm outside zone `A` |8.3.1e| | 4 |
| Front brake disc in such a condition that it is seriously weakened | 4 |
| Rear parking brake recording little or no effort | 4 |
| Windscreen washer not working | 4 |
| Offside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 3 |
| Nearside Rear Suspension arm corroded and seriously weakened |2.4.G.1| | 3 |
| Nearside Front Front wheel bearing has excessive play |2.5.A.3c| | 3 |
| Exhaust system not adequately supported |7.1.1| | 3 |
| Offside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 3 |
| Exhaust emissions carbon monoxide content excessive |7.3.B.1a| | 3 |
| Rear Rear fog lamp not working |1.3.2b| | 3 |
| Nearside Steering rack gaiter split |2.2.D.2d| | 3 |
| Nearside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 2 |
| Offside Front Seat belt anchorage prescribed area strength or continuity significantly reduced (7.1.1 (a) (i)) | 2 |
| Rear Exhaust system not adequately supported |7.1.1| | 2 |
| Nearside Body has a sharp edge caused by corrosion |6.1.C.1| | 2 |
| Exhaust emits an excessive level of metered smoke for a non-turbo charged engine |7.4.B.3b| | 2 |
| Exhaust has a major leak of exhaust gases |7.1.2| | 2 |
| Offside Front Anti-roll bar linkage rubber mounting deteriorated resulting in excessive movement |2.4.G.2| | 2 |
| Offside Front Front wheel bearing has excessive play |2.5.A.3c| | 2 |
| Emissions not tested |7.0| | 2 |
| Offside Rear Rear position lamp|s| not working |1.1.A.3b| | 2 |
| Speedometer cannot be illuminated. |6.7.3| | 2 |
| Fuel system component leaking |7.2.3| | 2 |
| Nearside Rear Body has a sharp edge caused by corrosion |6.1.C.1| | 2 |
| Nearside Front wheel bearing rough when rotated |2.5.A.2| | 2 |
| Offside Front wheel bearing has excessive play |2.5.A.3c| | 2 |
| Parking brake efficiency below requirements |1.4.2 |a| |i|| | 2 |
| Parking brake lever has no reserve travel |3.1.6b| | 2 |
| Offside Front Direction indicator not working |1.4.A.2c| | 2 |
| Nearside Rear position lamp|s| not working |1.1.A.3b| | 2 |
| Steering rack insecure |2.2.B.1a| | 2 |
| Nearside Rear Stop lamp not working |1.2.1b| | 2 |
| Offside Rear Rear fog lamp not working (4.5.1 (a) (ii)) | 2 |
| Offside Front front brake binding |3.7.B.1| | 2 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 2 |
| Nearside Front wheel bearing has excessive play |2.5.A.3c| | 2 |
| Horn not loud enough to be heard by another road user |1.6.2b| | 2 |
| Offside Steering rack gaiter split |2.2.D.2d| | 2 |
| Front Lower Suspension rod attachment bracket/mounting insecure front rubber mounting to chassis perrished,both. |5.3.3 |a| |i|| | 1 |
| Offside Headlamp not working on dipped beam |4.1.1 |a| |ii|| | 1 |
| Nearside Headlamp not working on dipped beam |1.7.5a| | 1 |
| Nearside Rear Subframe mounting prescribed area excessively corroded significantly reducing structural strength Inner sill. (5.3.6 (a) (i)) | 1 |
| Offside Rear Service brake has no recorded effort at a wheel (1.2.1 (a) (ii)) | 1 |
| Offside Parking brake inoperative on one side (1.4.1 (a)) | 1 |
| Parking brake efficiency less than 50% of the required value (1.4.2 (a) (ii)) | 1 |
| Driver`s door cannot be opened from outside the vehicle |6.2.B.1b| | 1 |
| Nearside Front Anti-roll bar attachment bracket/mounting insecure |2.4.G.1| | 1 |
| Nearside Windscreen wiper blade deteriorated |8.2.2| | 1 |
| Offside Windscreen wiper blade deteriorated |8.2.2| | 1 |
| Nearside Headlamp excessively damaged so that the light output is severely reduced |1.7.5a| | 1 |
| Offside Headlamp excessively damaged so that the light output is severely reduced |1.7.5a| | 1 |
| Nearside Rear Vehicle structure excessively corroded within 30cm of towbar mounting |6.6.6| | 1 |
| Offside Rear Vehicle structure excessively corroded within 30cm of towbar mounting |6.6.6| | 1 |
| Offside Rear Suspension arm corroded and seriously weakened |2.4.G.1| | 1 |
| Parking brake: efficiency below requirements |3.7.C.1b| | 1 |
| Indicator switch faulty |1.4.A.1| | 1 |
| Nearside Front Direction indicator insecure |1.4.A.2b| | 1 |
| Nearside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Exhaust has part of the system excessively deteriorated |7.1.1a| | 1 |
| Exhaust tailpipe not capable of allowing the emission probe to be inserted |7.4.B.1| | 1 |
| Direction indicators flashing more than 120 times a minute |1.4.A.2g| | 1 |
| Nearside Front Anti-roll bar linkage fractured |2.4.G.1| | 1 |
| Nearside front brake juddering severely |3.7.A.2b| | 1 |
| Offside Front Steering rack gaiter split |2.2.D.2d| | 1 |
| Nearside Front Tie bar/rod fractured |2.4.G.1| | 1 |
| Offside Rear coil spring fractured |2.4.C.1a| | 1 |
| Rear Exhaust has a part missing |7.1.1a| | 1 |
| Front passenger door cannot be opened from outside the vehicle |6.2.B.1b| | 1 |
| front brake binding both |3.7.B.1| | 1 |
| Direction indicator not working Both O/S |1.4.A.2c| | 1 |
| Brake pedal spongy |3.3.B.1b| | 1 |
| Rear fog lamp missing (4.5.1 (a) (ii)) | 1 |
| Rear fog lamp switch missing (4.5.3 (a)) | 1 |
| Nearside Rear Outer Suspension component mounting prescribed area excessively corroded significantly reducing structural strength Sill (5.3.6 (a) (i)) | 1 |
| Nearside Parking brake inoperative on one side (1.4.1 (a)) | 1 |
| Offside Front Upper Ball joint has excessive play |2.2.B.1f| | 1 |
| Offside Rear Rear fog lamp missing |1.3.2a| | 1 |
| Front Service brake excessively binding BOTH (1.2.1 (f)) | 1 |
| Exhaust emissions - engine idle speed too high (8.2.1.2 (e)) | 1 |
| Nearside Front Tie bar/rod synthetic bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Front Windscreen has a sticker or other obstruction encroaching by more than 10mm within zone `A` |8.3.1b| | 1 |
| Indicator tell tale inoperative |1.4.A.2a| | 1 |
| Offside Rear Lower Suspension arm corroded and seriously weakened |2.4.G.1| | 1 |
| Offside Front Body has a sharp edge caused by corrosion |6.1.C.1| | 1 |
| Offside Front Lower Ball joint has excessive play |2.2.B.1f| | 1 |
| Nearside Front Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Front Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Fuel cap/sealing device does not fasten securely maintaining the sealing arrangement |7.2.4b| | 1 |
| Nearside Brake cable locking device insecure |3.5.1l| | 1 |
| Fuel tank leaking |7.2.3| | 1 |
| Offside Front Upper Suspension arm ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Offside Upper Front suspension ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Nearside Rear Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Offside Rear Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Offside Front Brake pipe kinked |3.6.B.2b| | 1 |
| Offside Front Brake hose inappropriately repaired insecure |3.6.A.3| | 1 |
| Nearside Windscreen wiper not operating automatically when switched on |8.2.1b| | 1 |
| Offside Windscreen wiper not operating automatically when switched on |8.2.1b| | 1 |
| Nearside Headlamp aim aimed so that it dazzles other road users |1.8.A.1a| | 1 |
| Offside Front suspension has excessive play in a upper suspension ball joint |2.5.B.1a| | 1 |
| Service brake: efficiency below requirements |3.7.B.7| | 1 |
| Centre Front Upper Braking system leaking |3.6.A.1| | 1 |
| Front Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Front Anti-roll bar linkage corroded and seriously weakened |2.4.G.1| | 1 |
| Nearside Parking brake inoperative on one side |1.4.1 |a|| | 1 |
| Offside Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Nearside Headlamp aim beam image kick up to the offside |1.8| | 1 |
| Nearside Rear fog lamp not working |1.3.2b| | 1 |
| Offside Front Anti-roll bar linkage fractured |2.4.G.1| | 1 |
| Steering component is not secure to the vehicle structure steering wheel loose |2.2.B.1a| | 1 |
| Headlamp aim beam image kick up to the offside both |1.8| | 1 |
| Windscreen wiper not operating automatically when switched on |8.2.1b| | 1 |
| Offside Front Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Fuel pipe leaking (6.1.3 (b) (i)) | 1 |
| Nearside Outer Drive shaft which forms part of the suspension coupling gaiter insecure to the extent that it no longer prevents the ingress of dirt etc |2.4.G.4e| | 1 |
| Offside Front Front suspension ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt top |2.4.G.2| | 1 |
| Offside Front Front suspension ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt lower |2.4.G.2| | 1 |
| Nearside Front Seat belt has a cut which has significantly weakened the webbing |5.2.2a| | 1 |
| Fuel tank leaking from tank area unsure requires investigation |7.2.3| | 1 |
| Offside Rear fog lamp not working (4.5.1 (a) (ii)) | 1 |
| Nearside Front Seat belt anchorage prescribed area strength or continuity significantly reduced (7.1.1 (a) (i)) | 1 |
| Position lamp switch insecure |4.2.2 |b|| | 1 |
| Offside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength outer sill |5.3.6 |a| |i|| | 1 |
| Offside Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Rear Body has a sharp edge caused by damage |6.1.C.1| | 1 |
| Nearside Inner Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Rear Service brake excessively binding (1.2.1 (f)) | 1 |
| Nearside Rear rear brake excessively fluctuating |3.7.B.3| | 1 |
| Nearside Front Direction indicator not working (4.4.1 (a) (ii)) | 1 |
| Offside Rear Suspension component mounting prescribed area is excessively corroded wheel arch |2.4.A.3| | 1 |
| Nearside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
| Horn not working |7.7 |a| |ii|| | 1 |
| Front passenger door cannot be opened from inside the vehicle |6.2.B.1b| | 1 |
| Nearside Front Statutory seat belt missing |5.1.1| | 1 |
| Nearside Rear Brake pipe inadequately clipped |3.6.B.1| | 1 |
| Brake pedal has insufficient reserve movement |3.3.A.5| | 1 |
| Nearside front brake binding |3.7.B.1| | 1 |
| Offside front brake binding |3.7.B.1| | 1 |
| Nearside Rear front brake binding |3.7.B.1| | 1 |
| Front brake application uneven | 1 |
| Nearside Rear Other passenger door cannot be opened from outside the vehicle (6.2.3 (a)) | 1 |
| Nearside Front Front passenger door cannot be opened from inside the vehicle (6.2.3 (a)) | 1 |
| Nearside Front Front passenger door cannot be opened from outside the vehicle (6.2.3 (a)) | 1 |
| Offside Rear Outer Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 1 |
| Offside Front Lower Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Front Track rod end ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Offside Front Track rod end ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Offside Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Obligatory mirror insecure |8.1.1| | 1 |
| Nearside Rear Upper Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Nearside Front Lower Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Nearside Front Anti-roll bar linkage corroded and seriously weakened |2.4.G.1| | 1 |
| Driver`s seat insecure |6.2.A.1| | 1 |
| Offside Headlamp not working on dipped beam |1.7.5a| | 1 |
| Nearside Headlamp not working on main beam |1.7.5a| | 1 |
| Offside Front wheel bearing rough when rotated |2.5.A.2| | 1 |
| Front position lamp|s| not working |1.1.A.3b| | 1 |
| Headlamp not working on dipped beam |1.7.5a| | 1 |
| Headlamp not working on main beam |1.7.5a| | 1 |
| Nearside Front Direction indicator not working |1.4.A.2c| | 1 |
| Windscreen has a sticker or other obstruction encroaching by more than 10mm within zone `A` |8.3.1b| | 1 |
| Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Nearside Front Seat belt insecurely fixed to the vehicles structure |5.2.1a| | 1 |
| Rear fog lamp obviously incorrectly positioned |1.3.2a| | 1 |
| Horn not a continuous or uniform sound |1.6.2e| | 1 |
| Exhaust emissions hydrocarbon content excessive |7.3.B.1b| | 1 |
| brake disc in such a condition that it is seriously weakened |3.5.1i| | 1 |
| Nearside Rear Vehicle structure is damaged, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Front Front position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Front Front position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
| Offside Front Front position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
| Nearside Front Direction indicator adversely affected by the operation of another lamp |1.4.A.2h| | 1 |
| Offside Front Direction indicator adversely affected by the operation of another lamp |1.4.A.2h| | 1 |
| Nearside Front Bonded suspension unit bonding failed and part of unit is likely to become displaced |2.4.F.2| | 1 |
| Nearside Rear Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Rear Parking brake lever has no reserve travel |3.1.6b| | 1 |
| Nearside Upper Front suspension has excessive movement at a wishbone pin or bush |2.5.A.1c| | 1 |
| Offside Rear wheel bearing has excessive play |2.6.2| | 1 |
| Rear Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Centre Rear Fuel system component leaking |7.2.3| | 1 |
| Nearside Front Headlamp insecure |1.7.3| | 1 |
| Nearside Front Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Brake pipe inadequately supported |3.6.B.1| | 1 |
| Offside Front Front suspension has excessive play in a upper suspension ball joint |2.5.B.1a| | 1 |
| Horn not working (7.7 (a)) | 1 |
| Offside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength (5.3.6 (a) (i)) | 1 |
| Nearside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength (5.3.6 (a) (i)) | 1 |
| Nearside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength chassis crossmember , ahead of suspension arm. (5.3.6 (a) (i)) | 1 |
| Exhaust noise is clearly in excess of that emitted by a similar vehicle fitted with a standard silencer in average condition Back box broken off vehicle |8.1.1 |a|| | 1 |
| Rear reflector missing No reflectors at all on rear of vehicle |4.8.2 |a| |ii|| | 1 |
| Nearside Rear Wheel bearing has excessive play |5.1.3 |a| |i|| | 1 |
| Offside Rear Wheel bearing has excessive play |5.1.3 |a| |i|| | 1 |
| Offside Front Obligatory mirror seriously damaged, affecting the rear view |3.3 |b| |ii|| | 1 |
| Nearside Front Upper Suspension arm ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Offside Front Upper Suspension arm ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Nearside Rear Brake hose bulging under pressure |3.6.B.3| | 1 |
| Nearside Front Anti-roll bar rubber bush deteriorated resulting in excessive movement D-bush |2.4.G.2| | 1 |
| Nearside Steering locking device missing track rod split pin |2.2.C.1g| | 1 |
| Nearside Rear Suspension spring mounting prescribed area excessively corroded significantly reducing structural strength Chassis Leg (5.3.6 (a) (i)) | 1 |
| Offside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Front Wheel bearing has excessive play (5.1.3 (a) (i)) | 1 |
| Offside Front Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Position lamp not working both front (4.2.1 (a) (ii)) | 1 |
| Nearside Towbar is so weakened by corrosion within 30cm of a towbar mounting, the towbar is likely to become detached |6.1.6 |i| |ii|| | 1 |
| Offside Towbar is so weakened by corrosion within 30cm of a towbar mounting, the towbar is likely to become detached |6.1.6 |i| |ii|| | 1 |
| Nearside Front Inner Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting And outer |6.2.2 |d| |i|| | 1 |
| Offside Front Inner Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting |6.2.2 |d| |i|| | 1 |