| Most common failures | No# failures |
|---|
| Headlamp aim out of alignment | 19 |
| Parking brake: efficiency below requirements |3.7.B.7| | 10 |
| Rear parking brake recording little or no effort | 8 |
| Offside Stop lamp not working |1.2.1b| | 7 |
| Brakes imbalanced across an axle | 7 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 6 |
| Registration plate lamp issues | 6 |
| Service brake: efficiency below requirements |3.7.B.7| | 5 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 4 |
| Nearside Front Position lamp not working (4.2.1 (a) (ii)) | 4 |
| Parking brake efficiency below requirements (1.4.2 (a) (i)) | 4 |
| Nearside Stop lamp not working |1.2.1b| | 3 |
| Brake pipe excessively corroded | 3 |
| Front brake application uneven | 3 |
| Horn not working |1.6.2a| | 3 |
| Nearside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 3 |
| Nearside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 3 |
| Nearside Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 3 |
| Registration plate issues | 3 |
| Nearside rear brake recording little or no effort |3.7.B.5a| | 3 |
| Offside Rear position lamp|s| not working |1.1.A.3b| | 2 |
| Parking brake: efficiency below requirements |3.7.C.1b| | 2 |
| Nearside Front Seat belt insecurely fixed to the vehicles structure |5.2.1a| | 2 |
| Offside Front Seat belt insecurely fixed to the vehicles structure |5.2.1a| | 2 |
| Offside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
| Rear brake application uneven | 2 |
| Offside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 2 |
| Parking brake lever has no reserve travel |3.1.6b| | 2 |
| Windscreen wiper does not clear the windscreen effectively | 2 |
| Nearside Rear Outer Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 2 |
| Offside Rear Outer Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 2 |
| Nearside Front Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 2 |
| Exhaust has a major leak of exhaust gases |7.1.2| | 2 |
| Drag link end ball joint has excessive play |2.2.B.1f| | 2 |
| Fuel cap/sealing device ineffective (6.1.3 (b) (i)) | 2 |
| Offside Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 2 |
| Offside Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 2 |
| Nearside Vehicle structure excessively corroded within 30cm of towbar mounting |6.6.6| | 1 |
| Offside Vehicle structure excessively corroded within 30cm of towbar mounting |6.6.6| | 1 |
| Front Windscreen has a sticker or other obstruction encroaching into the swept area by more than 40mm outside zone `A` |8.3.1e| | 1 |
| Offside Front Upper Suspension arm ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Centre Front Steering component mounting prescribed area is excessively corroded |2.2.C.1h| | 1 |
| Service brake: efficiency below requirements |3.7.C.1a| | 1 |
| Nearside Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance Really poor lighting |1.1.A.3d| | 1 |
| Offside Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance Really poor lighting |1.1.A.3d| | 1 |
| Hazard warning switch faulty |1.4.B.1d| | 1 |
| Nearside Front Seat belt has a cut which has significantly weakened the webbing |5.2.2a| | 1 |
| Nearside Front Sub-frame corroded and seriously weakened |2.4.G.1| | 1 |
| Offside Front Sub-frame corroded and seriously weakened |2.4.G.1| | 1 |
| Nearside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Front Front position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Front Upper Front suspension ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Nearside Rear Battery insecure |1.9.1| | 1 |
| Offside Rear Battery insecure |1.9.1| | 1 |
| Nearside Rear Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Nearside Front Vehicle structure has an inadequate repair, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Battery insecure will require new clamp |1.9.1| | 1 |
| Offside Battery insecure will require new clamp |1.9.1| | 1 |
| Offside Rear Brake hose bulging under pressure |3.6.B.3| | 1 |
| Offside Rear Brake pipe inadequately clipped requires new clip |3.6.B.1| | 1 |
| Nearside Brake cable has wires broken and is significantly weakened |3.5.1b| | 1 |
| Nearside Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
| Offside Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
| Nearside Front front brake binding |3.7.B.1| | 1 |
| Offside Front front brake binding |3.7.B.1| | 1 |
| Offside Rear Direction indicators not in good working order |function impaired| |1.5.A1b| | 1 |
| Offside Front Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Nearside Rear Position lamp adversely affected by the operation of another lamp (4.2.3 (c)) | 1 |
| Offside Rear Position lamp adversely affected by the operation of another lamp (4.2.3 (c)) | 1 |
| Nearside Rear Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
| Offside Rear Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
| Offside Rear Suspension component mounting prescribed area is inadequately repaired |2.4.A.3| | 1 |
| Fuel system component insecure |7.2.1| | 1 |
| Towbar component insecure |6.6.1| | 1 |
| Towbar retaining device insecure |6.6.3a| | 1 |
| Centre Steering component mounting prescribed area is excessively corroded |2.2.C.1h| | 1 |
| Dipswitch operation does not extinguish all main beam headlamps leaving at least one pair of dipped beam headlamps |1.7.4b| | 1 |
| Nearside Track rod end ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Centre Rear Track rod end ball joint dust cover missing |2.2.C.1c| | 1 |
| Offside Front Steering component mounting prescribed area is excessively corroded near steering box |2.2.C.1h| | 1 |
| Brake master cylinder/servo mounting prescribed area is excessively corroded |3.6.C.3| | 1 |
| Offside Vehicle structure is so weakened by corrosion within 30cm of a towbar mounting, the towbar is likely to become detached (6.1.6 (i) (ii)) | 1 |
| Nearside Front Seat belt anchorage prescribed area is inadequately repaired Seat base (7.1.1 (a) (i)) | 1 |
| Offside Front Seat belt anchorage prescribed area is inadequately repaired Seat base (7.1.1 (a) (i)) | 1 |
| Nearside Front Suspension component mounting prescribed area excessively corroded significantly reducing structural strength (5.3.6 (a) (i)) | 1 |
| Offside Front Suspension component mounting prescribed area excessively corroded significantly reducing structural strength (5.3.6 (a) (i)) | 1 |
| Nearside Front Shock absorbers has an excessively worn bush (5.3.2 (c)) | 1 |
| Offside Front Shock absorbers has an excessively worn bush (5.3.2 (c)) | 1 |
| Front Steering linkage ball joint ball joint dust cover missing (2.1.3 (g) (ii)) | 1 |
| Rear Steering linkage ball joint ball joint dust cover excessively damaged or deteriorated so that it no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |
| Front Suspension component corroded and seriously weakened Beam axle holed and corroded (5.3.3 (b) (i)) | 1 |
| Nearside Front Upper Suspension arm ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Offside Front Upper Suspension arm ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength Beam axle (5.3.6 (a) (i)) | 1 |
| Offside Battery insecure and likely to fall from carrier (4.13 (a) (ii)) | 1 |
| Nearside Rear Direction indicator incorrect colour |1.4.A.2f| | 1 |
| Offside Rear Direction indicator incorrect colour |1.4.A.2f| | 1 |
| Offside Front Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Offside Rear wheel cylinder leaking |3.6.A.1| | 1 |
| Nearside Front Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
| Offside Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings Floor pan |6.1.B.2| | 1 |
| Nearside Front Track rod end ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Offside Front Track rod end ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Offside Lower Front suspension ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| All position lamps not working |1.1.A.3b| | 1 |
| Nearside Headlamp not working on main beam |1.7.5a| | 1 |
| Position lamp switch insecure |1.1.A.1| | 1 |
| Windscreen wiper blade deteriorated |8.2.2| | 1 |
| Offside Front Brake pipe inadequately supported |3.6.B.1| | 1 |
| Front passenger door cannot be opened from outside the vehicle |6.2.B.1b| | 1 |
| Nearside Rear Braking system leaking |3.6.A.1| | 1 |
| Nearside Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Rear Direction indicator not working |1.4.A.2c| | 1 |
| Offside Windscreen wiper not operating automatically when switched on |8.2.1b| | 1 |
| Nearside Windscreen wiper not operating automatically when switched on |8.2.1b| | 1 |
| Nearside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Front Lower Seat belt anchorage prescribed area is inadequately repaired |5.2.6| | 1 |
| Offside Front Lower Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Nearside Rear Rear wheel bearing has excessive play |2.6.2| | 1 |
| Nearside Rear Stop lamp(s) all not working (4.3.1 (a) (iii)) | 1 |
| Offside Steering rack gaiter split |2.2.D.2d| | 1 |
| Nearside Steering rack gaiter split |2.2.D.2d| | 1 |
| Nearside Rear Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Stop lamp(s) all not working (4.3.1 (a) (iii)) | 1 |
| Nearside Steering rack gaiter missing or no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |
| Offside Steering rack gaiter missing or no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |
| Parking brake efficiency below requirements |1.4.2 |a| |i|| | 1 |
| Offside Front Windscreen wiper not working |3.4 |a|| | 1 |
| Nearside Front Position lamp not working |4.2.1 |a|| | 1 |
| Nearside Steering rack gaiter insecure |2.2.D.2d| | 1 |
| Offside Rear Subframe mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Rear Fuel system component insecure |7.2.1| | 1 |
| Nearside Front Subframe mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Front Subframe mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Headlamp not working on dipped beam |1.7.5a| | 1 |
| Nearside Rear Brake actuating linkage mounting prescribed area is excessively corroded brake back plate corroded |3.3.A.2| | 1 |
| Offside Rear Brake actuating linkage mounting prescribed area is excessively corroded brake back plate corroded |3.3.A.2| | 1 |
| Drivers seat fore and aft adjustment mechanism not functioning as intended. (6.2.5 (b) (i)) | 1 |
| Nearside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength inner sill (5.3.6 (a) (i)) | 1 |
| Nearside Parking brake inoperative on one side (1.4.1 (a)) | 1 |
| rear brakes release unevenly |3.7.B.4| | 1 |
| Nearside rear brake juddering severely |3.7.A.5b| | 1 |
| Horn not working (7.7 (a)) | 1 |
| Drivers seat insecure (6.2.5 (a) (ii)) | 1 |
| Bumper damaged and likely to cause injury when grazed or contacted (6.1.4 (a) (i)) | 1 |
| Nearside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength (5.3.6 (a) (i)) | 1 |
| Nearside Front Wheel bearing has excessive play (5.1.3 (a) (i)) | 1 |
| Nearside Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Front Headlamp not working on main beam |1.7.5a| | 1 |
| Centre Front Steering component mounting prescribed area is excessively corroded crossmember |2.2.C.1h| | 1 |
| Nearside Inner Rear Lower Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Inner Rear Lower Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Inner Front Lower Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Rear brake binding | 1 |
| Steering system has excessive free play detected at the steering wheel |steering box fitted| |2.2.A.1a| | 1 |
| Offside Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Nearside Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Rear Exhaust has a major leak of exhaust gases box (6.1.2 (a)) | 1 |
| Offside Front Vehicle structure has excessive corrosion which adversely affects braking or steering x3 (6.1.1 (c) (ii)) | 1 |
| Nearside Front Vehicle structure has excessive corrosion which adversely affects braking or steering (6.1.1 (c) (ii)) | 1 |
| Nearside Rear Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced inner sill (6.1.1 (c) (i)) | 1 |
| Offside Front Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced cross member (6.1.1 (c) (i)) | 1 |
| Nearside Front Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced inner step (6.1.1 (c) (i)) | 1 |
| Offside Front Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced inner step (6.1.1 (c) (i)) | 1 |
| Horn not working (7.7 (a) (ii)) | 1 |
| Nearside Front Seat belt anchorage prescribed area is excessively corroded in wheel arch |5.2.6| | 1 |
| Offside Front Seat belt anchorage prescribed area is excessively corroded in wheel arch |5.2.6| | 1 |
| Central Intermediate drop arm insecure top bolt loss |2.2.B.1a| | 1 |
| Nearside Rear Drive shaft which forms part of the suspension coupling gaiter deteriorated to the extent that it no longer prevents the ingress of dirt etc |2.4.G.4e| | 1 |
| Rear Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Nearside Front Shock absorber has a serious fluid leak |2.7.3| | 1 |
| Front Sub-frame corroded and seriously weakened |2.4.G.1| | 1 |