| Most common failures | No# failures |
|---|
| Parking brake: efficiency below requirements |3.7.B.7| | 11 |
| Brake hose excessively deteriorated | 7 |
| Brake pipe excessively corroded | 6 |
| Horn not working |1.6.2a| | 5 |
| Windscreen wiper does not clear the windscreen effectively | 4 |
| Headlamp aim out of alignment | 4 |
| Service brake: efficiency below requirements |3.7.B.7| | 3 |
| Brakes imbalanced across an axle | 3 |
| Rear parking brake recording little or no effort | 3 |
| Offside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
| Front passenger seat insecure |6.2.3| | 2 |
| Offside Front Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 2 |
| Offside Rear Direction indicator not working |1.4.A.2c| | 2 |
| Offside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 2 |
| Steering column top bearing excessively worn |2.1.2c| | 2 |
| Offside front brake binding |3.7.B.1| | 2 |
| Nearside Front Front wheel bearing rough when rotated |2.5.A.2| | 2 |
| Parking brake lever has no reserve travel |3.1.6b| | 2 |
| Nearside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Nearside Stop lamp not working |1.2.1b| | 1 |
| Offside Stop lamp not working |1.2.1b| | 1 |
| Centre Stop lamp not working |1.2.1b| | 1 |
| Main beam `tell-tale` not working |1.7.4c| | 1 |
| Offside Front suspension has excessive play in a upper suspension ball joint |2.5.B.1a| | 1 |
| Headlamp not working on dipped beam |1.7.5a| | 1 |
| Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Indicator tell tale inoperative |1.4.A.2a| | 1 |
| Offside Driver`s seat cannot be secured in the upright position. |6.2.A.2| | 1 |
| Anti-roll bar rubber mounting deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Anti-roll bar linkage has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Rear coil spring incomplete |2.4.C.1a| | 1 |
| Nearside Rear Lower Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Rear Exhaust has a part missing |7.1.1a| | 1 |
| Emissions not tested |7.0| | 1 |
| Offside Windscreen has a sticker or other obstruction encroaching into the swept area by more than 40mm outside zone `A` |8.3.1e| | 1 |
| Nearside Front Lower Suspension arm ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Horn not working (7.7 (a)) | 1 |
| Emissions not tested coolant leak and Oil leak (8.2.1.2 (d)) | 1 |
| Offside Front Headlamp not working on main beam (4.1.1 (a) (ii)) | 1 |
| Nearside Rear Service brake excessively binding (1.2.1 (f)) | 1 |
| Service brake is causing the vehicle to swerve to the offside |3.7.C.2| | 1 |
| Nearside Front Anti-roll bar linkage fractured |2.4.G.1| | 1 |
| Offside Front Lower Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Rear Service brake excessively fluctuating (1.2.1 (e)) | 1 |
| Nearside Headlamp not working on main beam |1.7.5a| | 1 |
| Offside Headlamp not working on main beam |1.7.5a| | 1 |
| Exhaust emits an excessive level of metered smoke for a non-turbo charged engine |7.4.B.3b| | 1 |
| Offside Rear Suspension component mounting prescribed area is excessively corroded Outer sill |2.4.A.3| | 1 |
| Offside Front Seat belt anchorage prescribed area is excessively corroded outer body |5.2.6| | 1 |
| Offside Rear Seat belt anchorage prescribed area is inadequately repaired outer body |5.2.6| | 1 |
| Offside Rear Suspension arm corroded and seriously weakened holed |2.4.G.1| | 1 |
| Nearside front brake binding |3.7.B.1| | 1 |
| Exhaust emissions exceed level of metered smoke for a turbo charged engine |8.2.2.2 |b|| | 1 |
| Nearside Rear Suspension arm corroded and seriously weakened |5.3.3 |b| |i|| | 1 |
| Offside Headlamp aim so that beam "kick up" is not visible on the screen |4.1.2 |a|| | 1 |
| Exhaust emits an excessive level of metered smoke for a turbo charged engine |7.4.B.3b| | 1 |
| Nearside Rear Lower Suspension spring mounting prescribed area is excessively corroded spring seat / spring locator |2.4.A.3| | 1 |
| Offside Rear Lower Suspension spring mounting prescribed area is excessively corroded spring seat / spring locator |2.4.A.3| | 1 |
| Nearside Front Anti-roll bar pin or bush excessively worn |5.3.4 |a| |i|| | 1 |
| Offside Front Wheel bearing has excessive play (5.1.3 (a) (i)) | 1 |
| Nearside Front Service brake excessively binding |1.2.1 |f|| | 1 |
| Nearside Rear coil spring incomplete |2.4.C.1a| | 1 |
| Nearside Front Anti-roll bar linkage has excessive play in a pin/bush |2.4.G.2| | 1 |
| Parking brake mechanism/associated mounting prescribed area is excessively corroded |3.1.9| | 1 |
| Fuel system component leaking |7.2.3| | 1 |
| Nearside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Nearside Front Direction indicator not working |1.4.A.2c| | 1 |
| Offside Front Direction indicator not working |1.4.A.2c| | 1 |
| Nearside Front Headlamp aim aimed so that it dazzles other road users |1.8.A.1a| | 1 |
| Offside Rear Seat belt has a cut which has significantly weakened the webbing |5.2.2a| | 1 |
| Nearside Front Lower Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Offside Rear Lower Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Hazard warning lamps inoperative |1.4.B.1b| | 1 |
| Front passenger door cannot be opened from outside the vehicle |6.2.B.1b| | 1 |
| Offside Rear fog lamp not working |1.3.2b| | 1 |
| Fuel tank leaking |7.2.3| | 1 |
| Offside Front Shock absorber has a serious fluid leak |2.7.3| | 1 |
| Rear Exhaust system not adequately supported |7.1.1| | 1 |
| Nearside Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Nearside Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Front Brake hose bulging under pressure |3.6.B.3| | 1 |
| Nearside Rear Brake hose bulging under pressure |3.6.B.3| | 1 |
| Driver`s seat insecure |6.2.A.1| | 1 |
| Registration plate lamp issues | 1 |
| Hazard warning tell tale not working correctly |1.4.B.1e| | 1 |
| Steering component cracked and unserviceable |2.2.C.1d| | 1 |
| Nearside Rear Suspension arm corroded and seriously weakened |2.4.G.1| | 1 |
| Offside Rear Suspension arm corroded and seriously weakened |2.4.G.1| | 1 |
| Offside Rear Braking system leaking |3.6.A.1| | 1 |
| Offside Rear rear brake recording little or no effort |3.7.B.5a| | 1 |
| Nearside Front Front suspension ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Nearside Steering rack gaiter split |2.2.D.2d| | 1 |
| Offside Steering rack gaiter split |2.2.D.2d| | 1 |
| Lower Steering column flexible coupling is excessively deteriorated |2.1.5| | 1 |
| Offside Rear Suspension component mounting prescribed area is excessively corroded marked yellow, hole in wishbone dangerous |2.4.A.3| | 1 |
| Nearside Rear Suspension component mounting prescribed area is excessively corroded marked yellow, hole in wishbone dangerous |2.4.A.3| | 1 |
| Nearside Rear Suspension arm corroded and seriously weakened marked yellow, hole in wishbone dangerous |2.4.G.1| | 1 |
| Offside Rear Suspension arm corroded and seriously weakened marked yellow, hole in wishbone dangerous |2.4.G.1| | 1 |
| Nearside Rear Body has a sharp edge caused by damage missing bumper cap |6.1.C.1| | 1 |
| Steering component damaged and unserviceable secondary rubber coupling. marked yellow. excessive movement. |2.2.C.1d| | 1 |
| Stop lamp not working NEITHER NS OR OS |1.2.1b| | 1 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Inner Front Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Brake pedal creeps down when held under pressure |3.3.B.1a| | 1 |
| Exhaust emissions hydrocarbon content excessive |7.3.B.1b| | 1 |
| Offside Front Upper Front suspension has excessive play in a upper suspension ball joint |2.5.B.1a| | 1 |
| Nearside Front Steering rack gaiter insecure |2.2.D.2d| | 1 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 1 |
| Horn control missing |1.6.1| | 1 |
| Position lamp switch faulty |1.1.A.1| | 1 |
| Position lamp switch insecure |1.1.A.1| | 1 |
| Brake pedal has insufficient reserve movement |3.3.A.5| | 1 |
| Offside Front Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Nearside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
| Nearside Rear passenger door cannot be opened from outside the vehicle |6.2.B.1c| | 1 |
| Offside Front Steering rack gaiter split |2.2.D.2d| | 1 |
| Speedometer cannot be illuminated. |6.7.3| | 1 |
| Offside Front Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Stop lamp adversely affected by the operation of another lamp |1.2.1f| | 1 |
| Offside Rear position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
| Parking brake lever ratchet mechanism is broken |3.1.5| | 1 |
| Nearside Rear Drive shaft uj which forms part of the suspension has a loose flange bolt |2.4.G.4c| | 1 |