Most common failures | No# failures |
---|
Windscreen wiper does not clear the windscreen effectively | 19 |
Headlamp aim out of alignment | 19 |
Horn not working |1.6.2a| | 17 |
Registration plate lamp issues | 14 |
Brake pipe excessively corroded | 13 |
Offside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 12 |
Exhaust emissions carbon monoxide content excessive |7.3.B.1a| | 12 |
Brake hose excessively deteriorated | 12 |
Nearside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 9 |
Rear brake binding | 8 |
Parking brake: efficiency below requirements |3.7.B.7| | 8 |
Nearside Front Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 7 |
Rear parking brake recording little or no effort | 7 |
Exhaust emissions hydrocarbon content excessive |7.3.B.1b| | 6 |
Offside Front Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 6 |
Brakes imbalanced across an axle | 5 |
Offside front brake binding |3.7.B.1| | 5 |
Exhaust has a major leak of exhaust gases |7.1.2| | 4 |
Rear Exhaust has a major leak of exhaust gases |7.1.2| | 4 |
Offside Stop lamp not working |1.2.1b| | 4 |
Offside Headlamp not working on dipped beam |1.7.5a| | 4 |
Nearside Stop lamp not working |1.2.1b| | 4 |
Offside Steering rack gaiter insecure |2.2.D.2d| | 4 |
Offside Rear Position lamp not working |4.2.1 |a|| | 3 |
Nearside Rear Stop lamp not working |1.2.1b| | 3 |
Offside Front Headlamp not working on dipped beam |1.7.5a| | 3 |
Nearside Headlamp not working on dipped beam |1.7.5a| | 3 |
Nearside front brake binding |3.7.B.1| | 3 |
Stop lamp not working |1.2.1b| | 3 |
Offside Steering rack gaiter split |2.2.D.2d| | 3 |
Rear brake application uneven | 3 |
Windscreen washer not working | 2 |
Offside Rear position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 2 |
Offside Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 2 |
Offside Rear Stop lamp not working |1.2.1b| | 2 |
Nearside Rear position lamp|s| not working |1.1.A.3b| | 2 |
Nearside Front Subframe mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
Offside Front Subframe mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
Nearside Front Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 2 |
Offside Front Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 2 |
Nearside Front Anti-roll bar linkage rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 2 |
Offside Front Anti-roll bar linkage rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 2 |
Offside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
Nearside Front Seat belt anchorage prescribed area is inadequately repaired |5.2.6| | 2 |
Nearside Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 2 |
Offside Front position lamp|s| not working |1.1.A.3b| | 2 |
Offside Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 2 |
Nearside Front position lamp|s| not working |1.1.A.3b| | 2 |
Nearside Front Front wheel bearing rough when rotated |2.5.A.2| | 2 |
Body has a sharp edge caused by corrosion |6.1.C.1| | 2 |
Nearside Front wheel bearing has excessive play |2.5.A.3c| | 2 |
Nearside Front wheel bearing rough when rotated |2.5.A.2| | 2 |
Offside Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 2 |
Offside Rear Brake hose bulging under pressure |3.6.B.3| | 2 |
Service brake efficiency below requirements (1.2.2 (a) (i)) | 2 |
Offside Front Brake actuating linkage mounting prescribed area is excessively corroded |3.3.A.2| | 2 |
Nearside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
Horn not working |7.7 |a| |ii|| | 2 |
Nearside Front Steering rack gaiter split |2.2.D.2d| | 2 |
Nearside Front Upper Suspension component ball joint dust cover no longer prevents the ingress of dirt |5.3.4 |b| |ii|| | 2 |
Offside Front Upper Suspension component ball joint dust cover no longer prevents the ingress of dirt |5.3.4 |b| |ii|| | 2 |
Windscreen wiper not working |3.4 |a|| | 1 |
Stop lamp|s| all not working |4.3.1 |a| |iii|| | 1 |
Rear fog lamp not working |4.5.1 |a| |ii|| | 1 |
Brake pedal has insufficient reserve travel |1.1.2 |a|| | 1 |
Offside Front Lower Suspension arm ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
Offside Front Upper Indicator tell tale inoperative |1.4.A.2a| | 1 |
Offside Rear Lower Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
Nearside Front Brake hose bulging under pressure |3.6.B.3| | 1 |
Nearside Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
Parking brake lever defective so that it cannot be satisfactorily operated |3.1.3c| | 1 |
Fuel cap/sealing device does not fasten securely by positive means |7.2.4b| | 1 |
Nearside Rear Wheel nut|s| missing |4.2.A.1e| | 1 |
Offside Rear Wheel nut|s| missing |4.2.A.1e| | 1 |
Front Anti-roll bar missing |2.4.G.1| | 1 |
Nearside Front Lower Suspension arm ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
Offside Front Lower Suspension arm ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
Offside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
Offside Rear Towbar retaining device missing |6.6.3a| | 1 |
Nearside Front All position lamps not working |1.1.A.3b| | 1 |
Nearside Front Direction indicators not working |1.4.A.2c| | 1 |
Offside Rear Direction indicator not working |1.4.A.2c| | 1 |
All position lamps not working |1.1.A.3b| | 1 |
Nearside Front Anti-roll bar attachment bracket/mounting fractured |2.4.G.1| | 1 |
Windscreen has damage | 1 |
Offside Hazard warning lamps not flashing in phase, with ignition off |1.4.B.1f| | 1 |
Offside Hazard warning lamps not flashing in phase, with ignition on |1.4.B.1f| | 1 |
Nearside Front Front position lamp|s| not working |1.1.A.3b| | 1 |
Nearside Rear Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
Nearside Headlamp insecure |1.7.3| | 1 |
Parking brake is not capable of being maintained in operation by direct mechanical action only |3.1.2| | 1 |
Rear fog lamp not working |1.3.2b| | 1 |
Nearside Front Shock absorber has negligible damping effect |2.7.5| | 1 |
Offside Front Shock absorber has negligible damping effect |2.7.5| | 1 |
Offside Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
Offside Rear Subframe mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Nearside Rear Subframe mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Nearside Headlamp does not operate immediately when selected on main beam |1.7.4a| | 1 |
Offside Headlamp does not operate immediately when selected on main beam |1.7.4a| | 1 |
Hazard warning lamps not flashing in phase, with ignition off |1.4.B.1f| | 1 |
Centre Steering pivot point has excessive play |2.2.B.1g| | 1 |
Offside Rear Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced |6.1.1 |c| |i|| | 1 |
Nearside Rear Vehicle structure excessively corroded within 30cm of towbar mounting |6.6.6| | 1 |
Offside Rear Vehicle structure excessively corroded within 30cm of towbar mounting |6.6.6| | 1 |
Indicator tell tale inoperative |1.4.A.2a| | 1 |
Nearside Direction indicator not working |1.4.A.2c| | 1 |
Offside Front Seat belt anchorage prescribed area is inadequately repaired |5.2.6| | 1 |
Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Battery insecure |1.9.1| | 1 |
Offside Front Suspension component mounting prescribed area is excessively corroded cross tube |2.4.A.3| | 1 |
Nearside Rear Suspension component mounting prescribed area is excessively corroded cross tube |2.4.A.3| | 1 |
Offside Rear Suspension component mounting prescribed area is excessively corroded cross tube |2.4.A.3| | 1 |
Nearside Front Headlamp not working on dipped beam |1.7.5a| | 1 |
Offside Front Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
Centre Front Brake pipe leaking |3.6.A.1| | 1 |
Nearside Front Direction indicator not working |1.4.A.2c| | 1 |
Nearside Rear Suspension component mounting prescribed area is inadequately repaired |2.4.A.3| | 1 |
Offside Front Front position lamp|s| not working |1.1.A.3b| | 1 |
Offside Rear Front position lamp|s| not working |1.1.A.3b| | 1 |
Nearside Windscreen wiper blade deteriorated |8.2.2| | 1 |
Nearside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
Nearside Rear Rear wheel bearing rough when rotated |2.6.1| | 1 |
Offside Rear Rear fog lamp not working |1.3.2b| | 1 |
Offside Rear Body has a sharp edge caused by corrosion |6.1.C.1| | 1 |
Nearside Suspension component mounting prescribed area is excessively corroded outer seal |2.4.A.3| | 1 |
Nearside Headlamp excessively deteriorated so that the light output is severely reduced |1.7.5a| | 1 |
Offside Headlamp excessively deteriorated so that the light output is severely reduced |1.7.5a| | 1 |
Front passenger door cannot be opened from inside the vehicle |6.2.B.1b| | 1 |
Front passenger door cannot be opened from outside the vehicle |6.2.B.1b| | 1 |
Front Steering component mounting prescribed area is excessively corroded front panel/crossmember at lower column mount |2.2.C.1h| | 1 |
Nearside Rear Suspension component mounting prescribed area is excessively corroded sill |2.4.A.3| | 1 |
Offside Rear Suspension component mounting prescribed area is excessively corroded sill
|2.4.A.3| | 1 |
Nearside Rear Parking brake mechanism/associated mounting prescribed area is excessively corroded backplate |3.1.9| | 1 |
Offside Rear Parking brake mechanism/associated mounting prescribed area is excessively corroded backplate |3.1.9| | 1 |
Nearside Rear Suspension component mounting prescribed area is excessively corroded wheelarch |2.4.A.3| | 1 |
Offside Rear Suspension component mounting prescribed area is excessively corroded wheelarch |2.4.A.3| | 1 |
Nearside Steering rack gaiter split |2.2.D.2d| | 1 |
Nearside Front Anti-roll bar linkage rubber mounting deteriorated resulting in excessive movement |2.4.G.2| | 1 |
Offside Front Anti-roll bar linkage rubber mounting deteriorated resulting in excessive movement |2.4.G.2| | 1 |
Nearside Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Offside Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Offside Rear wheel bearing has excessive play |2.6.2| | 1 |
Offside Suspension component mounting prescribed area is excessively corroded outer sill |2.4.A.3| | 1 |
Registration plate issues | 1 |
Nearside Rear Suspension component mounting prescribed area is excessively corroded outer sill |2.4.A.3| | 1 |
Nearside Body has a sharp edge caused by corrosion outer sill |6.1.C.1| | 1 |
Offside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings jacking point |6.1.B.2| | 1 |
Nearside Front Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
Offside Rear Suspension component mounting prescribed area is excessively corroded inner arch |2.4.A.3| | 1 |
Nearside Rear Suspension component mounting prescribed area is excessively corroded inner arch |2.4.A.3| | 1 |
Offside Rear Brake back plate|s| securing device excessively deteriorated plate excessively corroded |3.5.1j| | 1 |
Nearside Rear Brake back plate|s| securing device excessively deteriorated plate excessively corroded |3.5.1j| | 1 |
Offside Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings chassis and rear panel |6.1.B.2| | 1 |
Nearside Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings chassis and rear panel |6.1.B.2| | 1 |
Dipswitch operation does not extinguish all main beam headlamps leaving at least one pair of dipped beam headlamps |1.7.4b| | 1 |
Offside Obligatory mirror insecure |8.1.1| | 1 |
Offside Obligatory mirror does not provide a view to the rear |8.1.2b| | 1 |
Nearside Front Headlamp not working on dipped beam |4.1.1 |a| |ii|| | 1 |
Offside Front Headlamp not working on dipped beam |4.1.1 |a| |ii|| | 1 |
Offside Front Headlamp not working on main beam |4.1.1 |a| |ii|| | 1 |
Nearside Rear Position lamp not working |4.2.1 |a|| | 1 |
Nearside Rear Stop lamp|s| not working |4.3.1 |a| |ii|| | 1 |
Parking brake efficiency below requirements |1.4.2 |a| |i|| | 1 |
Offside Rear Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 1 |
Nearside Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 1 |
Offside Rear Direction indicator not working (4.4.1 (a) (ii)) | 1 |
Suspension component mounting prescribed area is inadequately repaired Inner sills (5.3.6 (a) (i)) | 1 |
Nearside Front Anti-roll bar linkage fractured |2.4.G.1| | 1 |
Rear Rear fog lamp not working |1.3.2b| | 1 |
Offside Front Front suspension has excessive play in a upper suspension ball joint |2.5.B.1a| | 1 |
Fuel hose leaking |7.2.3| | 1 |
Position lamp switch faulty |1.1.A.1| | 1 |
Nearside Front Upper Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
Offside Front Suspension arm ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
Rear Stop lamp not working |1.2.1b| | 1 |
Offside Front Lower Front suspension ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
Offside Rear Rear fog lamp insecure |1.3.2a| | 1 |
Offside Front Upper Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
Offside Front Anti-roll bar linkage fractured |2.4.G.1| | 1 |
Rear Fuel system component leaking |7.2.3| | 1 |
Parking brake efficiency below requirements (1.4.2 (a) (i)) | 1 |
Nearside Front Vehicle structure has excessive corrosion which adversely affects braking or steering |6.1.A.1| | 1 |
Offside Front Vehicle structure has excessive corrosion which adversely affects braking or steering |6.1.A.1| | 1 |
Offside Front Tie bar/rod rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
Nearside Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Nearside Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Nearside Rear Coil spring mounting corroded and seriously weakened |2.4.C.3c| | 1 |
Offside Rear Coil spring mounting corroded and seriously weakened |2.4.C.3c| | 1 |
Offside Outer Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Offside Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
Brake hose damaged | 1 |
Offside Stop lamp|s| not working |4.3.1 |a| |ii|| | 1 |
Steering component is not secure to the vehicle structure |2.2.B.1a| | 1 |
Offside Front Headlamp not working on main beam |1.7.5a| | 1 |
Offside Rear brake drum contaminated by brake fluid |3.5.1h| | 1 |
Offside rear brake recording little or no effort |3.7.B.5a| | 1 |
Subframe mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Windscreen wiper not working (3.4 (a)) | 1 |
Nearside Rear position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
Nearside Steering arm has relative movement at its fixings |2.2.B.1h| | 1 |
Offside Steering arm has relative movement at its fixings |2.2.B.1h| | 1 |
Steering system has excessive free play detected at the steering wheel |steering box fitted| |2.2.A.1a| | 1 |
Offside Steering system fouling |2.2.D.2a| | 1 |
Offside Battery insecure |1.9.1| | 1 |
rear brakes release unevenly |3.7.B.4| | 1 |
Front Driver`s view of the road through the swept area of the windscreen materially affected by an obstruction wiper park |3.1 |a| |ii|| | 1 |
Offside Front Upper Suspension arm ball joint excessively worn |5.3.4 |a| |i|| | 1 |
Oil leaking continuously from engine posing a serious risk to road safety |8.4.1 |a| |ii|| | 1 |
Offside Suspension arm ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
Nearside Track rod end ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
Offside Track rod end ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
Brake pedal anti-slip provision incomplete |3.3.A.1b| | 1 |
Offside Windscreen wiper not operating over a large enough area to give an adequate view |8.2.1c| | 1 |
Hazard warning tell tale not working correctly |1.4.B.1e| | 1 |
Offside Rear position lamp|s| not working |1.1.A.3b| | 1 |
Offside Rear fog lamp not working |1.3.2b| | 1 |
Parking brake: efficiency below requirements |3.7.C.1b| | 1 |
Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Centre Fuel system component insecure |7.2.1| | 1 |
Nearside Front Anti-roll bar linkage insecure |2.4.G.1| | 1 |
Front brake application uneven | 1 |
Fuel cap/sealing device does not fasten securely maintaining the sealing arrangement |7.2.4b| | 1 |
Nearside Rear Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
Exhaust noise is clearly in excess of that emitted by a similar vehicle fitted with a standard silencer in average condition |7.1.4| | 1 |
Nearside Rear Lower Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Offside Rear Lower Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Braking system leaking |3.6.A.1| | 1 |
Offside Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Offside Vehicle structure has excessive corrosion which adversely affects braking or steering |6.1.A.1| | 1 |
Offside Suspension component mounting prescribed area is inadequately repaired |2.4.A.3| | 1 |
Offside Front Body has a projection caused by corrosion |6.1.C.1| | 1 |
Nearside Rear Hydraulic brake cylinder leaking hydraulic fluid |3.6.A.1| | 1 |
Nearside Front Position lamp not working (4.2.1 (a) (ii)) | 1 |
Offside Front Lower Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 1 |
Offside Rear Brake pipe leaking on a hydraulic braking system (1.1.11 (b) (ii)) | 1 |
Steering wheel has movement relative to the column indicating looseness |2.2.1 |a| |i|| | 1 |
Offside Front Headlamp aim so that beam "kick up" is not visible on the screen |4.1.2 |a|| | 1 |
Nearside Front Position lamp not working |4.2.1 |a|| | 1 |
Offside Front Position lamp not working |4.2.1 |a|| | 1 |
Nearside Front Lower Suspension component ball joint dust cover no longer prevents the ingress of dirt |5.3.4 |b| |ii|| | 1 |
Offside Front Lower Suspension component ball joint dust cover no longer prevents the ingress of dirt |5.3.4 |b| |ii|| | 1 |
Offside Front Headlamp adversely affected by the operation of another lamp main beam flashing/flickering on operation |1.7.5c| | 1 |
Nearside Front Headlamp not working on main beam |1.7.5a| | 1 |
Steering column top bearing excessively worn |2.1.2c| | 1 |
Offside Front position lamp|s| missing |1.1.A.3a| | 1 |
Nearside Front Suspension arm ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
Rear fog lamp tell tale not working |1.3.1b| | 1 |
Nearside Rear Brake hose bulging under pressure |3.6.B.3| | 1 |
front brake binding |3.7.B.1| | 1 |
Rear Exhaust system not adequately supported |7.1.1| | 1 |
Nearside Front Upper Ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
Front Headlamp not working on main beam |1.7.5a| | 1 |
Front Suspension arm ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
Offside Front Track rod end ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
Front Drag link end ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
Front Front wheel bearing has excessive play |2.5.A.3c| | 1 |
Nearside Rear Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
Offside Rear Braking system leaking |3.6.A.1| | 1 |
Front Torsion bar attachment bracket fractured |2.4.E.4b| | 1 |
Service brake: efficiency below requirements |3.7.B.7| | 1 |
Offside Rear Shock absorber has a serious fluid leak |2.7.3| | 1 |
Nearside Rear Service brake excessively fluctuating |1.2.1 |e|| | 1 |