| Most common failures | No# failures |
|---|
| Windscreen wiper does not clear the windscreen effectively | 28 |
| Parking brake efficiency below requirements (1.4.2 (a) (i)) | 14 |
| Windscreen washer not working | 12 |
| Rear fog lamp not working (4.5.1 (a) (ii)) | 12 |
| Headlamp aim out of alignment | 10 |
| Brakes imbalanced across an axle | 9 |
| Horn not working (7.7 (a)) | 5 |
| Parking brake efficiency less than 50% of the required value (1.4.2 (a) (ii)) | 5 |
| Offside Front Position lamp not working (4.2.1 (a) (ii)) | 4 |
| Rear fog lamp not working |1.3.2b| | 4 |
| Registration plate issues | 4 |
| Exhaust Lambda reading after 2nd fast idle outside specified limits (8.2.1.2 (c)) | 4 |
| Service brake efficiency below requirements (1.2.2 (a) (i)) | 4 |
| Registration plate lamp issues | 4 |
| Exhaust emissions Lambda reading after 2nd fast idle outside specified limits |7.3.D.3| | 4 |
| Nearside Front Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 3 |
| Offside Front Upper Suspension arm ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 3 |
| Parking brake: efficiency below requirements |3.7.B.7| | 3 |
| Nearside Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 3 |
| Offside Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 3 |
| Offside Rear Position lamp not working (4.2.1 (a) (ii)) | 3 |
| Offside Headlamp not working on main beam (4.1.1 (a) (ii)) | 3 |
| Exhaust carbon monoxide content after 2nd fast idle exceeds default limits (8.2.1.2 (b)) | 3 |
| Offside Stop lamp(s) not working (4.3.1 (a) (ii)) | 3 |
| Exhaust Lambda reading after 2nd fast idle outside specified limits |8.2.1.2 |c|| | 3 |
| Engine MIL inoperative or indicates a malfunction (8.2.1.2 (h)) | 3 |
| Nearside Rear Exhaust has a major leak of exhaust gases |7.1.2| | 3 |
| Offside Rear Rear fog lamp not working (4.5.1 (a) (ii)) | 3 |
| Exhaust emits dense blue smoke at idle (8.2.1.2 (f)) | 2 |
| Offside Front Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 2 |
| Offside Rear Rear fog lamp not working |1.3.2b| | 2 |
| Rear Rear fog lamp not working |1.3.2b| | 2 |
| Rear fog lamp switch inoperative (4.5.3 (a)) | 2 |
| Offside Front Lower Suspension arm ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 2 |
| Offside Parking brake inoperative on one side (1.4.1 (a)) | 2 |
| Horn not working |1.6.2a| | 2 |
| Rear Exhaust has a major leak of exhaust gases |6.1.2 |a|| | 2 |
| Nearside Stop lamp(s) not working (4.3.1 (a) (ii)) | 2 |
| Nearside Rear Stop lamp(s) not working (4.3.1 (a) (ii)) | 2 |
| Nearside Parking brake inoperative on one side (1.4.1 (a)) | 2 |
| Rear Rear fog lamp not working (4.5.1 (a) (ii)) | 2 |
| Offside Rear fog lamp not working (4.5.1 (a) (ii)) | 2 |
| Horn not working (7.7 (a) (ii)) | 2 |
| Offside Rear Exhaust has a major leak of exhaust gases |7.1.2| | 2 |
| Exhaust emissions carbon monoxide content after 2nd fast idle excessive |7.3.D.3| | 2 |
| Steering box has excessive free play detected at the steering wheel to the extent that safe steering is affected (steering box fitted) (2.3 (a) (ii)) | 2 |
| Parking brake efficiency below requirements |1.4.2 |a| |i|| | 2 |
| Emissions not tested |7.3.A.1| | 2 |
| Exhaust carbon monoxide content at idle exceeds manufacturers specified limits (8.2.1.2 (b)) | 2 |
| Brake master cylinder leaking (1.1.10 (b) (ii)) | 1 |
| Nearside Front Outer Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced (6.1.1 (c) (i)) | 1 |
| Offside Front Outer Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced (6.1.1 (c) (i)) | 1 |
| All direction indicators not working (4.4.1 (a) (ii)) | 1 |
| Rear Exhaust has a major leak of exhaust gases LEFT @ RIGHT |7.1.2| | 1 |
| Rear Emissions not tested |7.4.B.1| | 1 |
| Exhaust carbon monoxide content after 2nd fast idle exceeds manufacturers specified limits (8.2.1.2 (a)) | 1 |
| Steering box sector shaft has excessive movement (2.1.1 (d) (i)) | 1 |
| Rear Direction indicator incorrect colour both sides |1.4.A.2f| | 1 |
| Offside Front Steering box has relative movement between sector shaft and the drop arm |2.2.B.1b| | 1 |
| Parking brake lever has excessive movement indicating incorrect adjustment (1.1.6 (c)) | 1 |
| Upper Stop lamp(s) light intensity significantly reduced (4.3.3 (a) (ii)) | 1 |
| Nearside Side repeater incorrect colour white colour, lens missing (4.4.3 (a)) | 1 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 1 |
| Driver`s view of the road through the swept area of the windscreen materially affected by an obstruction |3.1 |a| |ii|| | 1 |
| rear parking |secondary| brakes imbalanced | 1 |
| Front Steering linkage ball joint ball joint dust cover excessively damaged or deteriorated so that it no longer prevents the ingress of dirt |2.1.3 |g| |ii|| | 1 |
| Front Brake pipe at imminent risk of failure or fracture (1.1.11 (a)) | 1 |
| Offside Front Suspension rod pin or bush likely to become detached (5.3.4 (a) (ii)) | 1 |
| Brake performance unable to be tested Brakes failed on test (1.2.1 (g)) | 1 |
| Nearside Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
| Nearside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength In sill (5.3.6 (a) (i)) | 1 |
| Rear fog lamp tell-tale not working (4.9.1 (a) (ii)) | 1 |
| Nearside Rear Direction indicator not working (4.4.1 (a) (ii)) | 1 |
| Nearside Front Upper Suspension arm ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Offside Rear Upper Suspension arm ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Nearside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength outer sill (5.3.6 (a) (i)) | 1 |
| Offside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength outer sill (5.3.6 (a) (i)) | 1 |
| Nearside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength inner wheel arch forward of wheel (5.3.6 (a) (i)) | 1 |
| Offside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength inner wheel arch forward of wheel (5.3.6 (a) (i)) | 1 |
| Offside Front Suspension component mounting prescribed area excessively corroded significantly reducing structural strength inner wheel arch behind wheel (5.3.6 (a) (i)) | 1 |
| Offside Rear Service brake effort inadequate at a wheel (1.2.1 (a) (i)) | 1 |
| Front Direction indicator incorrect colour both sides (4.4.3 (a)) | 1 |
| Exhaust emissions - engine idle speed too high (8.2.1.2 (e)) | 1 |
| Offside Stop lamp(s) light intensity significantly reduced (4.3.3 (a) (ii)) | 1 |
| Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 1 |
| Steering box has excessive free play detected at the steering wheel to the extent that safe steering is affected |steering box fitted| |2.3 |a| |ii|| | 1 |
| Offside Rear Service brake excessively fluctuating (1.2.1 (e)) | 1 |
| Nearside Headlamp light intensity severely reduced (4.1.4 (a)) | 1 |
| Nearside Rear Outer Drive shaft joint excessively worn (6.1.7 (c) (i)) | 1 |
| Nearside Rear Parking brake inoperative on one side (1.4.1 (a)) | 1 |
| Offside Seat belt anchorage prescribed area strength or continuity significantly reduced (7.1.1 (a) (i)) | 1 |
| Offside Inner Track rod end ball joint has excessive play (2.1.3 (b) (i)) | 1 |
| Nearside Outer Track rod end ball joint has excessive play (2.1.3 (b) (i)) | 1 |
| Nearside Front Body panel corroded and likely to cause injury (6.2.1 (a) (i)) | 1 |
| Offside Parking (secondary brake) on a single line braking system has no recorded effort at a wheel (1.3.1 (a) (ii)) | 1 |
| Nearside Parking (secondary brake) on a single line braking system has inadequate effort at a wheel (1.3.1 (a) (i)) | 1 |
| Stop lamp(s) all not working (4.3.1 (a) (iii)) | 1 |
| Offside Front Steering linkage ball joint has excessive play close to steering box / in under tray (2.1.3 (b) (i)) | 1 |
| Nearside Steering linkage ball joint modified such that the steering is adversely affected (2.1.3 (f) (ii)) | 1 |
| Offside Steering linkage ball joint modified such that the steering is adversely affected (2.1.3 (f) (ii)) | 1 |
| Nearside Front Direction indicator incorrect colour (4.4.3 (a)) | 1 |
| Offside Front Direction indicator incorrect colour (4.4.3 (a)) | 1 |
| Nearside Rear Fuel system component leaking pump (6.1.3 (b) (i)) | 1 |
| Offside Rear Service brake lagging in operation (1.2.1 (d)) | 1 |
| Steering box has excessive free play detected at the steering wheel (steering box fitted) play in centre steering idler arm pin / bush (2.3 (a) (i)) | 1 |
| Nearside Front Service brake excessively binding (1.2.1 (f)) | 1 |
| Offside Front Wheel bearing rough when rotated (5.1.3 (b) (i)) | 1 |
| Nearside Windscreen wiper not working wiper loose (3.4 (a)) | 1 |
| Horn not working terminal loose (7.7 (a)) | 1 |
| Hazard warning lamps inoperative (4.4.1 (e)) | 1 |
| Nearside Rear Inner Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 1 |
| Offside Front Brake disc significantly and obviously worn (1.1.14 (a) (i)) | 1 |
| Offside Front Headlamp aim projected beam image is obviously incorrect no paten lens poor (4.1.2 (c)) | 1 |
| Offside Rear Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
| Nearside Front Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Nearside Inner Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 1 |
| Offside Rear Wheel bearing has excessive play (5.1.3 (a) (i)) | 1 |
| Nearside Rear Direction indicator incorrect colour (4.4.3 (a)) | 1 |
| Offside Rear Direction indicator incorrect colour (4.4.3 (a)) | 1 |
| Nearside Front Suspension arm pin or bush excessively worn king pin (5.3.4 (a) (i)) | 1 |
| Nearside Front Upper Suspension arm pin or bush excessively worn bush (5.3.4 (a) (i)) | 1 |
| Offside Rear Shock absorbers has an excessively worn bush (5.3.2 (c)) | 1 |
| Nearside Front Shock absorbers has an excessively worn bush (5.3.2 (c)) | 1 |
| Offside Front Shock absorbers has an excessively worn bush (5.3.2 (c)) | 1 |
| Nearside Exhaust system insecure (6.1.2 (a)) | 1 |
| Offside Front Service brake excessively binding (1.2.1 (f)) | 1 |
| Rear Drag link end ball joint has excessive play (2.1.3 (b) (i)) | 1 |
| Steering box has excessive free play detected at the steering wheel (steering box fitted) play in centre steering idler arm pin /bush (2.3 (a) (i)) | 1 |
| Brake lever has insufficient reserve travel hand (1.1.2 (a)) | 1 |
| Rear Service brake effort inadequate at a wheel loss of footbrake pressure,rear brake effort poor when pressure goes (1.2.1 (a) (i)) | 1 |
| Central Front Steering linkage ball joint ball joint dust cover excessively damaged or deteriorated so that it no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |
| Exhaust has a major leak of exhaust gases centre silencer (6.1.2 (a)) | 1 |
| Exhaust has a major leak of exhaust gases tail box |7.1.2| | 1 |
| Parking brake lever has no reserve travel |3.1.6b| | 1 |
| Offside Front Windscreen wiper blade missing (3.4 (b) (ii)) | 1 |
| Power steering inoperative (2.1.5 (c) (i)) | 1 |
| Offside Rear Lower Rear fog lamp not working |4.5.1 |a| |ii|| | 1 |
| Exhaust emissions likely to be affected by an exhaust leak (8.2.1.1 (b)) | 1 |
| Exhaust has a major leak of exhaust gases Rear silencer big hole (corroded) (6.1.2 (a)) | 1 |
| Emissions unable to be completed leak affecting results (8.2.1.2 (d)) | 1 |
| Offside Rear Rear fog lamp not working |4.5.1 |a| |ii|| | 1 |
| Engine MIL inoperative or indicates a malfunction |8.2.1.2 |h|| | 1 |
| Nearside Rear Seat belt retracting mechanism defective (7.1.2 (e)) | 1 |
| Front Steering rack gaiter missing or no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |
| Engine MIL inoperative or indicates a malfunction |8.2.2.2 |g|| | 1 |
| Brake performance not tested (1.2.1 (g)) | 1 |
| Nearside Front Seat belt missing (7.1.2 (a)) | 1 |
| Steering pivot point has excessive play |2.2.B.1g| | 1 |
| Steering system has excessive free play detected at the steering wheel |steering box fitted| |2.2.A.1a| | 1 |
| Trailer electrical socket |13 pin| not operating the trailer lamps as intended |1.9.4| | 1 |
| Emissions unable to be completed (8.2.1.2 (d)) | 1 |
| Battery insecure and likely to fall from carrier (4.13 (a) (ii)) | 1 |
| Front Steering rack gaiter missing or no longer prevents the ingress of dirt Steering arm gaiter - not rack (2.1.3 (g) (ii)) | 1 |
| Rear Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 1 |
| Emissions not tested (8.2.1.2 (d)) | 1 |
| Steering column top bearing excessively worn (2.2.2 (b)) | 1 |
| Steering box insecure to the extent there is excessive movement at the mountings (2.1.3 (a) (ii)) | 1 |
| Offside Front Upper Axle swivel joint so worn or insecure in a stub axle that directional stability is impaired (5.1.2 (b) (ii)) | 1 |
| Nearside Front Service brake excessively fluctuating (1.2.1 (e)) | 1 |
| Offside Front Service brake excessively fluctuating (1.2.1 (e)) | 1 |
| Windscreen wiper not working (3.4 (a)) | 1 |
| Offside Obligatory mirror missing (3.3 (a)) | 1 |
| Steering linkage ball joint has excessive play steering arm tie rod |2.1.3 |b| |i|| | 1 |
| Rear fog lamp not working |4.5.1 |a| |ii|| | 1 |
| Emissions unable to be completed misfire (8.2.1.2 (d)) | 1 |
| Offside Rear Exhaust emissions likely to be affected by an exhaust leak |8.2.1.1 |b|| | 1 |
| Exhaust hydrocarbon content after 2nd fast idle exceeds default limits |8.2.1.2 |b|| | 1 |
| Offside Rear fog lamp not working |4.5.1 |a| |ii|| | 1 |
| Exhaust carbon monoxide content after 2nd fast idle exceeds default limits |8.2.1.2 |b|| | 1 |
| Offside Rear Fuel cap/sealing device ineffective (6.1.3 (b) (i)) | 1 |
| Windscreen has a sticker or other obstruction encroaching into the swept area by more than 40mm outside zone `A` |8.3.1e| | 1 |
| Steering lock fails to engage |2.1.4b| | 1 |
| Windscreen has damage | 1 |
| Nearside Rear Suspension has inadequate clearance with the bump stop |2.4.A.1a| | 1 |
| Offside Rear Suspension has inadequate clearance with the bump stop |2.4.A.1a| | 1 |
| Rear Statutory seat belt missing |5.1.1| | 1 |
| Front Windscreen has a sticker or other obstruction encroaching into the swept area by more than 40mm outside zone `A` |8.3.1e| | 1 |
| Steering box has excessive free play detected at the steering wheel |steering box fitted| |2.3 |a| |i|| | 1 |
| Hazard warning switch inoperative (4.4.2 (a) (ii)) | 1 |
| Nearside Front Headlamp aim not tested (4.1.2 (b)) | 1 |
| Offside Front Headlamp aim not tested (4.1.2 (b)) | 1 |
| Nearside Front Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 1 |
| Offside Front Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 1 |
| Offside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength outer sill (5.3.6 (a) (i)) | 1 |
| Offside Rear Stop lamp not working |1.2.1b| | 1 |
| Nearside Stop lamp not working |1.2.1b| | 1 |
| Exhaust emissions carbon monoxide content excessive (8.2.1.2 (b)) | 1 |
| Offside Rear Lower Shock absorbers insecurely attached (5.3.2 (a) (i)) | 1 |
| Nearside Rear Hydraulic brake cylinder leaking and braking performance affected (1.1.16 (b) (ii)) | 1 |
| Nearside Rear Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Brake pedal has insufficient reserve travel (1.1.2 (a)) | 1 |