| Most common failures | No# failures |
|---|
| Headlamp aim out of alignment | 11 |
| Exhaust emissions carbon monoxide content after 2nd fast idle excessive |7.3.D.3| | 11 |
| Exhaust emissions Lambda reading after 2nd fast idle outside specified limits |7.3.D.3| | 9 |
| Registration plate issues | 7 |
| Exhaust emissions carbon monoxide content at idle excessive |7.3.D.4| | 7 |
| Exhaust has a major leak of exhaust gases |7.1.2| | 7 |
| Windscreen wiper does not clear the windscreen effectively | 7 |
| Registration plate lamp issues | 6 |
| Windscreen washer not working | 5 |
| Exhaust emissions hydrocarbon content after 2nd fast idle excessive |7.3.D.3| | 5 |
| Emissions not tested |7.0| | 4 |
| Horn not working |1.6.2a| | 4 |
| Nearside Rear Position lamp not working (4.2.1 (a) (ii)) | 3 |
| Exhaust carbon monoxide content after 2nd fast idle exceeds default limits (8.2.1.2 (b)) | 3 |
| Rear fog lamp not working (4.5.1 (a) (ii)) | 3 |
| Brakes imbalanced across an axle | 3 |
| Steering system has excessive free play detected at the steering wheel |steering box fitted| |2.2.A.1a| | 3 |
| Nearside Side repeater missing |1.4.A.2b| | 3 |
| Offside Rear fog lamp not working |1.3.2b| | 3 |
| Rear Rear fog lamp not working |1.3.2b| | 3 |
| Offside Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 2 |
| Brake hose excessively deteriorated | 2 |
| Horn not working (7.7 (a)) | 2 |
| Parking brake efficiency below requirements (1.4.2 (a) (i)) | 2 |
| Stop lamp(s) all not working (4.3.1 (a) (iii)) | 2 |
| Offside Front Position lamp not working (4.2.1 (a) (ii)) | 2 |
| Rear fog lamp tell-tale not working (4.9.1 (a) (ii)) | 2 |
| Nearside Front Side repeater not working (4.4.1 (a) (ii)) | 2 |
| Exhaust emissions carbon monoxide content excessive (8.2.1.2 (b)) | 2 |
| Exhaust Lambda reading after 2nd fast idle outside specified limits (8.2.1.2 (c)) | 2 |
| Parking brake: efficiency below requirements |3.7.B.7| | 2 |
| Exhaust emissions carbon monoxide content excessive |7.3.B.1a| | 2 |
| Exhaust emissions hydrocarbon content excessive |7.3.B.1b| | 2 |
| Offside Rear fog lamp insecure |1.3.2a| | 2 |
| Offside Side repeater missing |1.4.A.2b| | 2 |
| Rear fog lamp tell tale not working |1.3.1b| | 2 |
| Brake pipe excessively corroded | 2 |
| Offside Rear fog lamp not working (4.5.1 (a) (ii)) | 2 |
| Offside Windscreen washer jets misaligned and not providing sufficient fluid to the windscreen (3.5 (a)) | 1 |
| Nearside Headlamp not working on main beam (4.1.1 (a) (ii)) | 1 |
| Nearside Headlamp aim not tested (4.1.2 (b)) | 1 |
| Nearside Position lamp lens seriously defective (4.2.1 (b)) | 1 |
| Offside Rear Position lamp lens seriously defective (4.2.1 (b)) | 1 |
| Nearside Headlamp aim projected beam image is obviously incorrect dipping wrong way (4.1.2 (c)) | 1 |
| Rear Fuel hose leaking (6.1.3 (b) (i)) | 1 |
| Central Steering rack gaiter missing or no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |
| Offside Front Upper Suspension arm ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Nearside Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
| Nearside Stop lamp(s) light intensity significantly reduced when position lights on (4.3.3 (a) (ii)) | 1 |
| Offside Rear Stop lamp(s) light intensity significantly reduced when position lights on (4.3.3 (a) (ii)) | 1 |
| Seat belt missing all rear apart from o/s buckle fitted at rear (7.1.2 (a)) | 1 |
| Nearside Integral body structure corroded to the extent that the rigidity of the assembly is significantly reduced outer sill (6.1.1 (c) (i)) | 1 |
| Nearside Inner Integral body structure corroded to the extent that the rigidity of the assembly is significantly reduced inner sill (6.1.1 (c) (i)) | 1 |
| Offside Integral body structure corroded to the extent that the rigidity of the assembly is significantly reduced outer sill (6.1.1 (c) (i)) | 1 |
| Offside Integral body structure corroded to the extent that the rigidity of the assembly is significantly reduced inner sill (6.1.1 (c) (i)) | 1 |
| Nearside Front Suspension component mounting prescribed area excessively corroded significantly reducing structural strength inner wheel arch (5.3.6 (a) (i)) | 1 |
| Offside Front Suspension component mounting prescribed area excessively corroded significantly reducing structural strength inner wheel arch (5.3.6 (a) (i)) | 1 |
| Speedometer cannot be illuminated (7.8 (c) (ii)) | 1 |
| Nearside Headlamp insecure (4.1.1 (c)) | 1 |
| Offside Headlamp insecure (4.1.1 (c)) | 1 |
| Seat belt missing all rear apart from o/s buckle (7.1.2 (a)) | 1 |
| Exhaust carbon monoxide content after 2nd fast idle exceeds manufacturers specified limits (8.2.1.2 (a)) | 1 |
| Nearside Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
| Offside Rear Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Offside Rear Rear fog lamp not working (4.5.1 (a) (ii)) | 1 |
| Centre Windscreen has a sticker or other obstruction encroaching into the swept area by more than 40mm outside zone `A` |8.3.1e| | 1 |
| Nearside Stop lamp not working |1.2.1b| | 1 |
| Nearside Rear Integral body structure corroded to the extent that the rigidity of the assembly is significantly reduced outrigger and inner/outer sill area holed and corroded (6.1.1 (c) (i)) | 1 |
| Offside Rear Integral body structure corroded to the extent that the rigidity of the assembly is significantly reduced outrigger corroded and holed (6.1.1 (c) (i)) | 1 |
| Rear Direction indicator incorrect colour both rear (4.4.3 (a)) | 1 |
| Brake valve leaking (1.1.7 (d) (i)) | 1 |
| Offside Rear Wheel bearing has excessive play (5.1.3 (a) (i)) | 1 |
| Nearside Front Steering locking device missing (2.1.3 (d)) | 1 |
| Front Windscreen wiper not working (3.4 (a)) | 1 |
| Nearside Front Hazard warning lamps inoperative (4.4.1 (e)) | 1 |
| Rear Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 1 |
| Rear Exhaust system insecure (6.1.2 (a)) | 1 |
| Exhaust carbon monoxide content at idle exceeds manufacturers specified limits (8.2.1.2 (b)) | 1 |
| Centre Steering pivot point has excessive play |2.2.B.1g| | 1 |
| Nearside Front Axle king pin has excessive play in pin and/or bush adversely affecting the steering |2.5.A.3a| | 1 |
| Offside Front Axle king pin has excessive play in pin and/or bush adversely affecting the steering |2.5.A.3a| | 1 |
| Exhaust has a part missing |7.1.1a| | 1 |
| Offside Front Headlamp aim beam image too far to the left |1.6.B4| | 1 |
| Nearside Front Side repeater missing |1.4.A.2b| | 1 |
| Offside Front Side repeater missing |1.4.A.2b| | 1 |
| Brake relay lever has restricted free movement |3.5.1k| | 1 |
| Steering system fouling |2.2.D.2a| | 1 |
| Offside Rear Seat belt retracting mechanism defective |5.2.5b| | 1 |
| Exhaust catalytic converter missing where one was fitted as standard |7.1.3| | 1 |
| Rear parking brake recording little or no effort | 1 |
| Rear Exhaust mounting missing |7.1.1b| | 1 |
| Nearside Rear rear brake recording little or no effort |3.7.B.5a| | 1 |
| Front Anti-roll bar attachment bracket/mounting insecure |2.4.G.1| | 1 |
| Exhaust system not adequately supported |7.1.1| | 1 |
| Nearside Front wheel bearing has excessive play |2.5.A.3c| | 1 |
| Exhaust emits visible black smoke at idle |7.3.A.2b| | 1 |
| Service brake: efficiency below requirements |3.7.B.7| | 1 |
| Offside Rear fog lamp tell tale not working |1.3.1b| | 1 |
| Parking brake lever has no reserve travel |3.1.6b| | 1 |
| Nearside Rear Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Nearside Front wheel bearing rough when rotated |2.5.A.2| | 1 |
| Offside Front passenger door cannot be opened from outside the vehicle |6.2.B.1b| | 1 |
| Offside Rear Seat belt cut sufficient to obstruct correct operation of the belt |5.2.2a| | 1 |
| Nearside Battery insecure |1.9.1| | 1 |
| Offside Battery leaking electrolyte |1.9.1| | 1 |
| Passenger`s seat insecure |6.2.A.1| | 1 |
| Passenger`s seat cannot be secured in the upright position. |6.2.A.2| | 1 |
| Nearside Outer Track rod end ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Offside Outer Track rod end ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Exhaust hydrocarbon content after 2nd fast idle exceeds default limits (8.2.1.2 (b)) | 1 |
| Offside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength (5.3.6 (a) (i)) | 1 |
| Exhaust has part of the system excessively deteriorated |7.1.1a| | 1 |
| Brake pedal actuating linkage functionally incomplete |3.3.A.1a| | 1 |
| Nearside Front suspension has excessive play in a lower wishbone bearing |2.5.B.1a| | 1 |
| Offside Front suspension has excessive play in a lower wishbone bearing |2.5.B.1a| | 1 |
| Nearside Front suspension has excessive play in a upper wishbone bearing |2.5.B.1a| | 1 |
| Offside Front suspension has excessive play in a upper wishbone bearing |2.5.B.1a| | 1 |
| Offside Rear fog lamp missing |1.3.2a| | 1 |
| Nearside Rear Direction indicator adversely affected by the operation of another lamp (4.4.3 (b)) | 1 |
| Nearside Rear Position lamp adversely affected by the operation of another lamp (4.2.3 (c)) | 1 |
| Nearside Rear Stop lamp(s) adversely affected by the operation of another lamp (4.3.3 (b)) | 1 |
| Rear Rear fog lamp missing |1.3.2a| | 1 |
| Rear Rear fog lamp not working (4.5.1 (a) (ii)) | 1 |
| Nearside Side repeater incomplete |1.5.A1b| | 1 |
| Offside Anti-roll bar linkage insecure |2.4.G.1| | 1 |
| Nearside Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
| Offside Front Suspension has inadequate clearance with the bump stop |2.4.A.1a| | 1 |
| Rear brake application uneven | 1 |
| Rear fog lamp obviously incorrectly positioned |1.3.2a| | 1 |
| Nearside Front Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Fuel cap/sealing device ineffective Sealing ring split (6.1.3 (b) (i)) | 1 |
| Nearside Headlamp aim projected beam image is obviously incorrect LHD Headlamp unit fitted ! (4.1.2 (c)) | 1 |
| Offside Headlamp aim projected beam image is obviously incorrect LHD Headlamp unit fitted ! (4.1.2 (c)) | 1 |
| Nearside Rear Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 1 |
| Emissions not tested Exhaust blowing ! (8.2.1.2 (d)) | 1 |
| Rear Seat belt insecurely fixed to the vehicles structure |5.2.1a| | 1 |
| Offside Windscreen wiper blade deteriorated |8.2.2| | 1 |
| Nearside Outer Front Anti-roll bar attachment bracket/mounting insecure |2.4.G.1| | 1 |
| Rear fog lamp not working |1.3.2b| | 1 |
| Rear brake binding | 1 |
| Nearside Headlamp not working on dipped beam |1.7.5a| | 1 |
| Nearside Headlamp not working on main beam |1.7.5a| | 1 |
| Offside Headlamp not working on main beam |1.7.5a| | 1 |
| Offside Rear fog lamp does not face the rear |1.3.2a| | 1 |
| Hazard warning switch faulty |1.4.B.1d| | 1 |
| Rear fog lamp insecure |1.3.2a| | 1 |
| Centre Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Offside Front Upper Suspension arm locating pin locking device missing |2.4.G.3b| | 1 |
| Offside Front Lower Suspension arm locating pin locking device missing |2.4.G.3b| | 1 |