| Most common failures | No# failures |
|---|
| Parking brake: efficiency below requirements |3.7.B.7| | 10 |
| Rear parking brake recording little or no effort | 10 |
| Headlamp aim out of alignment | 8 |
| Windscreen wiper does not clear the windscreen effectively | 7 |
| Parking brake efficiency below requirements (1.4.2 (a) (i)) | 6 |
| Exhaust emissions Lambda reading after 2nd fast idle outside specified limits |7.3.D.3| | 6 |
| Exhaust emissions carbon monoxide content after 2nd fast idle excessive |7.3.D.3| | 6 |
| Registration plate lamp issues | 5 |
| Horn not working |1.6.2a| | 5 |
| Offside Rear fog lamp not working |1.3.2b| | 4 |
| Steering system has excessive free play detected at the steering wheel |steering box fitted| |2.2.A.1a| | 4 |
| Rear brake binding | 4 |
| Rear fog lamp not working (4.5.1 (a) (ii)) | 3 |
| Registration plate issues | 3 |
| Battery insecure |1.9.1| | 3 |
| Exhaust emissions hydrocarbon content after 2nd fast idle excessive |7.3.D.3| | 3 |
| Rear brake application uneven | 3 |
| Offside Rear fog lamp insecure |1.3.2a| | 2 |
| Nearside Hazard warning lamps inoperative |1.4.B.1b| | 2 |
| Driver`s seat fore and aft adjustment mechanism not functioning as intended. |6.2.A.3| | 2 |
| Exhaust emissions carbon monoxide content at idle excessive |7.3.D.4| | 2 |
| Rear fog lamp not working |1.3.2b| | 2 |
| Nearside Headlamp aim beam image kick up to the offside |1.8| | 2 |
| Windscreen has damage | 2 |
| Brake master cylinder leaking (1.1.10 (b) (ii)) | 1 |
| Brake performance not tested (1.2.1 (g)) | 1 |
| Hazard warning lamps inoperative (4.4.1 (e)) | 1 |
| Dipswitch does not operate immediately when selected on main beam (4.1.3 (b)) | 1 |
| Offside Rear Road wheel fixing missing (5.2.1 (a) (i)) | 1 |
| Windscreen wiper not working Unable to turn off once on (3.4 (a)) | 1 |
| Nearside Rear Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Offside Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 1 |
| Offside Headlamp aim unable to be tested (4.1.2 (b)) | 1 |
| Vehicle Identification Number not displayed (0.2 (a)) | 1 |
| Horn sound not in accordance with requirements (7.7 (c)) | 1 |
| Rear Bumper damaged and likely to cause injury when grazed or contacted Both end caps missing (6.1.4 (a) (i)) | 1 |
| Electrical wiring likely to touch hot or rotating parts fog lamp wiring touching drive shaft (4.11 (a) (iii)) | 1 |
| Electrical wiring insecure and in contact with sharp edges fog lamp wiring (4.11 (a) (ii)) | 1 |
| Offside Rear Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Offside Steering rack gaiter missing or no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |
| Lower Steering column flexible coupling is excessively deteriorated (2.2.2 (c)) | 1 |
| Offside Rear Parking brake inoperative on one side (1.4.1 (a)) | 1 |
| Service brake efficiency below requirements (1.2.2 (a) (i)) | 1 |
| Offside Rear Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
| Nearside Rear Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
| Offside Obligatory mirror insecure |8.1.1| | 1 |
| Nearside Hazard warning lamps not flashing in phase, with ignition on |1.4.B.1f| | 1 |
| Nearside Hazard warning lamps not flashing in phase, with ignition off |1.4.B.1f| | 1 |
| Rear Rear fog lamp not working |1.3.2b| | 1 |
| Offside Front Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 1 |
| Central Steering pivot point has excessive play |2.2.B.1g| | 1 |
| Offside Side repeater missing |1.4.A.2b| | 1 |
| Nearside Side repeater missing |1.4.A.2b| | 1 |
| Outer Rear Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Nearside Rear Hazard warning lamps inoperative |1.4.B.1b| | 1 |
| Offside Inner Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Outer Drive shaft which forms part of the suspension coupling gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.4.G.4e| | 1 |
| Nearside Front Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced jacking point holed (6.1.1 (c) (i)) | 1 |
| Offside Rear Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced battery carrier floor holed (6.1.1 (c) (i)) | 1 |
| Offside Front Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced jacking point holed (6.1.1 (c) (i)) | 1 |
| Rear Stop lamp not working |1.2.1b| | 1 |
| Nearside Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Centre Steering pivot point has excessive play |2.2.B.1g| | 1 |
| Offside Hazard warning lamps inoperative |1.4.B.1b| | 1 |
| Nearside Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Inner Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Drive shaft which forms part of the suspension coupling gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.4.G.4e| | 1 |
| Offside Rear Exhaust system insecure (6.1.2 (a)) | 1 |
| Brake pedal not releasing correctly and functionality of brakes affected (1.1.2 (b) (ii)) | 1 |
| Exhaust carbon monoxide content after 2nd fast idle exceeds default limits (8.2.1.2 (b)) | 1 |
| Offside Rear Inner Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 1 |
| Offside Rear Outer Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 1 |
| Nearside Rear Outer Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 1 |
| Offside Front Inner Steering linkage ball joint has excessive play (2.1.3 (b) (i)) | 1 |
| Nearside Rear Integral body structure corroded to the extent that the rigidity of the assembly is significantly reduced Front of inner arch (6.1.1 (c) (i)) | 1 |
| Offside Front Integral body structure corroded to the extent that the rigidity of the assembly is significantly reduced Rear of inner arch (6.1.1 (c) (i)) | 1 |
| Nearside Front Axle swivel pins and bushes swivel pin and/or bush excessively worn Lower (5.1.2 (b) (i)) | 1 |
| Nearside Front Axle swivel pins and bushes swivel pin and/or bush excessively worn Center (5.1.2 (b) (i)) | 1 |
| Offside Front Lower Axle swivel pins and bushes swivel pin and/or bush excessively worn (5.1.2 (b) (i)) | 1 |
| Parking brake efficiency below requirements Both sides low on performance (1.4.2 (a) (i)) | 1 |
| Nearside Stop lamp adversely affected by the operation of another lamp |1.2.1f| | 1 |
| Parking brake lever ratchet mechanism is broken |3.1.5| | 1 |
| Parking brake lever has no reserve travel |3.1.6b| | 1 |
| Parking brake: efficiency below requirements |3.7.C.1b| | 1 |
| Steering column top bearing excessively worn |2.1.2c| | 1 |
| Offside Front Lower Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Headlamp switch faulty |1.7.1| | 1 |
| Offside Rear rear brake excessively fluctuating |3.7.B.3| | 1 |
| Offside Front rear brake excessively fluctuating |3.7.B.3| | 1 |
| Nearside Front rear brake excessively fluctuating |3.7.B.3| | 1 |
| Service brake: efficiency below requirements |3.7.B.7| | 1 |
| Nearside Rear Rear position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
| Electrical wiring insecure rear fog lamp front to rear |1.9.2a| | 1 |
| Electrical wiring insecure horn wiring |1.9.2a| | 1 |
| Offside Front Valve stem seriously damaged |4.1.D.1e| | 1 |
| Horn not working |7.7 |a| |ii|| | 1 |
| Headlamp not working on main beam Both |4.1.1 |a| |ii|| | 1 |
| Nearside Rear Inner Prop shaft joint constant velocity boot no longer prevents the ingress of dirt |6.1.7 |g| |ii|| | 1 |
| Nearside Rear Outer Prop shaft joint constant velocity boot no longer prevents the ingress of dirt |6.1.7 |g| |ii|| | 1 |
| Parking brake efficiency below requirements |1.4.2 |a| |i|| | 1 |
| Front passenger door cannot be opened from outside the vehicle |6.2.B.1b| | 1 |
| Nearside front brake binding |3.7.B.1| | 1 |
| Offside Headlamp aim beam image kick up to the offside |1.8| | 1 |
| Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Exhaust tailpipe not capable of allowing the emission probe to be inserted |7.3.D.1| | 1 |
| Nearside Front front brake binding |3.7.B.1| | 1 |
| Offside Front front brake binding |3.7.B.1| | 1 |
| Nearside Rear front brake binding |3.7.B.1| | 1 |
| Brake pedal has insufficient reserve movement |3.3.A.5| | 1 |
| rear brake excessively fluctuating |3.7.B.3| | 1 |
| Offside Headlamp not working on main beam (4.1.1 (a) (ii)) | 1 |
| Nearside Hazard warning lamps not fitted |1.4.B.1a| | 1 |
| Offside Front Front wheel bearing rough when rotated |2.5.A.2| | 1 |
| Nearside Front Valve stem seriously damaged (5.2.3 (j)) | 1 |
| Offside Rear fog lamp not working (4.5.1 (a) (ii)) | 1 |
| Battery insecure and likely to fall from carrier both batteries (4.13 (a) (ii)) | 1 |
| Nearside Front Upper Axle king pin is loose in the axle beam (5.1.2 (d) (i)) | 1 |
| Offside Front Lower Axle king pin is loose in the axle beam (5.1.2 (d) (i)) | 1 |
| Offside Front wheel bearing rough when rotated |2.5.A.2| | 1 |
| Nearside Front suspension has excessive play in a upper suspension ball joint |2.5.B.1a| | 1 |
| Nearside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
| Nearside Stub axle has excessive vertical movement between stub axle and axle beam |2.5.A.1a| | 1 |
| Nearside Upper Axle swivel joint has excessive play |2.5.A.3b| | 1 |
| Offside Rear Rear fog lamp tell-tale missing WARNING LIGHT NOT WORKING (4.9.1 (a) (ii)) | 1 |
| Rear fog lamp missing |1.3.2a| | 1 |
| Offside Front Direction indicator incorrect colour |1.4.A.2f| | 1 |
| Nearside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Nearside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Steering pivot point has excessive play |2.2.B.1g| | 1 |
| Nearside Front Ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Brake hose damaged | 1 |
| Stop lamp not working |1.2.1b| | 1 |
| Centre Front Steering system has excessive free play detected at the steering wheel |steering box fitted| |2.2.A.1a| | 1 |