| Most common failures | No# failures |
|---|
| Headlamp aim out of alignment | 18 |
| Windscreen wiper does not clear the windscreen effectively | 17 |
| Registration plate lamp issues | 10 |
| Brake pipe excessively corroded | 10 |
| Brakes imbalanced across an axle | 7 |
| Exhaust Lambda reading after 2nd fast idle outside specified limits (8.2.1.2 (c)) | 4 |
| Horn not working |1.6.2a| | 4 |
| Exhaust emissions carbon monoxide content after 2nd fast idle excessive |7.3.D.3| | 3 |
| Centre Exhaust system not adequately supported |7.1.1| | 3 |
| Horn not working (7.7 (a)) | 3 |
| Exhaust emissions Lambda reading after 2nd fast idle outside specified limits |7.3.D.3| | 3 |
| Exhaust carbon monoxide content after 2nd fast idle exceeds default limits (8.2.1.2 (b)) | 3 |
| Brake hose excessively deteriorated | 3 |
| Rear brake binding | 3 |
| Offside Front Service brake excessively binding (1.2.1 (f)) | 2 |
| Windscreen washer not working | 2 |
| Exhaust emissions carbon monoxide content excessive (8.2.1.2 (b)) | 2 |
| Windscreen has a sticker or other obstruction encroaching into the swept area by more than 40mm outside zone `A` |8.3.1e| | 2 |
| Exhaust emissions carbon monoxide content at idle excessive |7.3.D.4| | 2 |
| Rear brake application uneven | 2 |
| Offside Rear Rear position lamp|s| not working |1.1.A.3b| | 2 |
| Exhaust carbon monoxide content at idle exceeds default limits |8.2.1.2 |b|| | 2 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 2 |
| Exhaust emissions hydrocarbon content after 2nd fast idle excessive |7.3.D.3| | 2 |
| Rear fog lamp switch faulty |1.3.1a| | 2 |
| Nearside Steering rack gaiter split |2.2.D.2d| | 2 |
| Offside Steering rack gaiter split |2.2.D.2d| | 2 |
| Rear parking brake recording little or no effort | 2 |
| Exhaust emissions carbon monoxide content excessive |7.3.B.1a| | 2 |
| Hazard warning lamps inoperative (4.4.1 (e)) | 1 |
| Rear fog lamp tell-tale not working (4.9.1 (a) (ii)) | 1 |
| Offside Rear Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
| Offside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength chassis (5.3.6 (a) (i)) | 1 |
| Exhaust emissions hydrocarbon content excessive (8.2.1.2 (b)) | 1 |
| Registration plate issues | 1 |
| Centre Braking system leaking |3.6.A.1| | 1 |
| Centre Brake pipe leaking |3.6.A.1| | 1 |
| Centre Rear Brake load sensing valve linkage seized |3.6.E.3| | 1 |
| Offside Rear fog lamp not working |1.3.2b| | 1 |
| Headlamp aim beam image kick up to the offside |1.8| | 1 |
| Nearside Front Shock absorber has a serious fluid leak |2.7.3| | 1 |
| Nearside Front Suspension has inadequate clearance with the bump stop |2.4.A.1a| | 1 |
| Front brake application uneven | 1 |
| Nearside Upper Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Rear Brake pipe leaking |3.6.A.1| | 1 |
| Service brake: efficiency below requirements |3.7.B.7| | 1 |
| Nearside Front constant velocity joint gaiter deteriorated to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Exhaust system not adequately supported |7.1.1| | 1 |
| Front Exhaust has a major leak of exhaust gases at various joins and also leaking around repair (cat) (6.1.2 (a)) | 1 |
| Horn sound not in accordance with requirements hardly working (7.7 (c)) | 1 |
| Exhaust emissions likely to be affected by an exhaust leak emissions not tested (8.2.1.1 (b)) | 1 |
| Nearside Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Nearside Front Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt |6.1.7 |g| |ii|| | 1 |
| Nearside Front Lower Suspension arm ball joint dust cover no longer prevents the ingress of dirt |5.3.4 |b| |ii|| | 1 |
| Front Exhaust has a major leak of exhaust gases at joins (6.1.2 (a)) | 1 |
| Nearside Front Shock absorbers has an excessively worn bush lower bush (5.3.2 (c)) | 1 |
| Offside Front Shock absorbers has an excessively worn bush lower bush (5.3.2 (c)) | 1 |
| Windscreen wiper not operating automatically when switched on |8.2.1b| | 1 |
| Front position lamp|s| missing |1.1.A.3a| | 1 |
| Offside Side repeater not working |1.4.A.2c| | 1 |
| Nearside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Rear fog lamp switch insecure Loose in dash (4.5.3 (a)) | 1 |
| Offside Front Front constant velocity joint gaiter deteriorated to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Nearside Outer Front Upper Suspension arm ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Nearside Front Front position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Front Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Battery insecure |1.9.1| | 1 |
| Front Exhaust has a major leak of exhaust gases |6.1.2 |a|| | 1 |
| Parking brake efficiency less than 50% of the required value |1.4.2 |a| |ii|| | 1 |
| Windscreen damaged and affecting the drivers view of the road (3.2 (a) (ii)) | 1 |
| Centre Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Nearside Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
| Central Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 1 |
| Nearside Outer Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 1 |
| Emissions not tested (8.2.1.2 (d)) | 1 |
| Offside Front Outer Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 1 |
| Central Exhaust system insecure (6.1.2 (a)) | 1 |
| Horn sound not in accordance with requirements (7.7 (c)) | 1 |
| Brake fluid contaminated |1.8 |a|| | 1 |
| Horn not working |7.7 |a| |ii|| | 1 |
| Trailer electrical socket insecure |1.9.3a| | 1 |
| Offside Rear coil spring broken |2.4.C.1a| | 1 |
| Rear Exhaust has a major leak of exhaust gases box |7.1.2| | 1 |
| Nearside Ball joint has excessive play steering rack inner ball joint |2.2.B.1f| | 1 |
| Offside Ball joint has excessive play steering rack inner ball joint |2.2.B.1f| | 1 |
| Nearside Front Brake hose bulging under pressure |3.6.B.3| | 1 |
| Bonnet cannot be secured in the closed position (3.1 (b) (i)) | 1 |
| Nearside front brake binding |3.7.B.1| | 1 |
| Offside Front Brake hose bulging under pressure |3.6.B.3| | 1 |
| Parking brake: efficiency below requirements |3.7.B.7| | 1 |
| Exhaust carbon monoxide content at idle exceeds manufacturers specified limits (8.2.1.2 (b)) | 1 |
| Exhaust emits dense blue smoke at idle (8.2.1.2 (f)) | 1 |
| Nearside Rear Inner Suspension component mounting prescribed area excessively corroded significantly reducing structural strength sill (5.3.6 (a) (i)) | 1 |
| Front Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Exhaust hydrocarbon content after 2nd fast idle exceeds default limits (8.2.1.2 (b)) | 1 |
| Offside Front Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 1 |
| Shock absorbers damaged to the extent that it does not function both rears (5.3.2 (b)) | 1 |
| Shock absorbers has a serious fluid leak steering damper (5.3.2 (b)) | 1 |
| Oil leaking excessively from engine (8.4.1 (a) (i)) | 1 |
| Nearside Front Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 1 |
| Nearside Front Lower Suspension arm ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Offside Front Lower Suspension arm ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Offside Front Upper Suspension arm ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Exhaust has a major leak of exhaust gases blowing at front pipe (6.1.2 (a)) | 1 |
| Nearside Parking brake inoperative on one side (1.4.1 (a)) | 1 |
| Parking brake efficiency below requirements (1.4.2 (a) (i)) | 1 |
| Offside Front Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Offside Rear Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Nearside Front Steering rack gaiter missing or no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |
| Offside Steering locking device missing |2.2.C.1g| | 1 |
| Offside Rear Upper Vehicle structure excessively corroded within 30cm of towbar mounting |6.6.6| | 1 |
| Nearside Rear Wheel bearing has excessive play (5.1.3 (a) (i)) | 1 |
| Offside Front Brake hose bulging under pressure (1.1.12 (d)) | 1 |
| Steering rack gaiter missing or no longer prevents the ingress of dirt n/s and o/s |2.1.3 |g| |ii|| | 1 |
| Nearside Rear Braking system leaking |3.6.A.1| | 1 |
| Offside Rear Braking system leaking |3.6.A.1| | 1 |
| Nearside Rear Coil spring fractured or broken (5.3.1 (b) (i)) | 1 |
| Nearside Front Direction indicator not working (4.4.1 (a) (ii)) | 1 |
| Offside Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Nearside Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Nearside Front constant velocity joint is excessively worn |2.5.C.1b| | 1 |
| Offside Outer Front constant velocity joint is excessively worn |2.5.C.1b| | 1 |
| Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Nearside Front Headlamp aim beam image kick up to the offside |1.8| | 1 |
| Offside Front Headlamp aim beam image kick up to the offside |1.8| | 1 |
| Nearside Front Front constant velocity joint gaiter split |2.5.C.1a| | 1 |
| Offside Rear Rear fog lamp not working |1.3.2b| | 1 |
| Offside Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Front Fuel system component leaking |7.2.3| | 1 |
| Brake load sensing valve seized |3.6.E.3| | 1 |
| Nearside Front Suspension component mounting prescribed area is excessively corroded chassis |2.4.A.3| | 1 |
| Offside Front Suspension component mounting prescribed area is excessively corroded chassis |2.4.A.3| | 1 |
| Nearside Front Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced innersill |6.1.1 |c| |i|| | 1 |
| Offside Front Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced innersill |6.1.1 |c| |i|| | 1 |
| Offside Front Front constant velocity joint gaiter split |2.5.C.1a| | 1 |
| Nearside Front Position lamp not working |4.2.1 |a|| | 1 |
| Offside Front Front position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Battery insecure |1.9.1| | 1 |
| Offside Rear Exhaust system not adequately supported |7.1.1| | 1 |
| Direction indicators flashing more than 120 times a minute |1.4.A.2g| | 1 |
| Nearside Front Lower Shock absorber has an excessively worn bush |2.7.4| | 1 |