| Most common failures | No# failures |
|---|
| Windscreen wiper does not clear the windscreen effectively | 60 |
| Headlamp aim out of alignment | 41 |
| Registration plate lamp issues | 30 |
| Brake pipe excessively corroded | 26 |
| Brakes imbalanced across an axle | 15 |
| Brake hose excessively deteriorated | 14 |
| Offside Rear fog lamp not working |1.3.2b| | 13 |
| Offside Headlamp aim beam image kick up to the offside |1.8| | 13 |
| Horn not working |1.6.2a| | 13 |
| Nearside Headlamp aim beam image kick up to the offside |1.8| | 12 |
| Rear brake binding | 12 |
| Rear fog lamp not working |1.3.2b| | 11 |
| Service brake: efficiency below requirements |3.7.B.7| | 11 |
| Nearside Stop lamp not working |1.2.1b| | 8 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 7 |
| Exhaust has a major leak of exhaust gases |7.1.2| | 7 |
| Headlamp aim beam image kick up to the offside |1.8| | 7 |
| Parking brake: efficiency below requirements |3.7.B.7| | 7 |
| Rear parking brake recording little or no effort | 7 |
| Nearside rear brake recording little or no effort |3.7.B.5a| | 6 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 5 |
| Nearside Rear coil spring broken |2.4.C.1a| | 5 |
| Windscreen wiper blade insecure | 4 |
| Exhaust emits an excessive level of metered smoke for a turbo charged engine |7.4.B.3b| | 4 |
| Windscreen washer not working | 4 |
| Offside Rear Rear fog lamp not working (4.5.1 (a) (ii)) | 4 |
| Horn not working (7.7 (a) (ii)) | 4 |
| Offside rear brake recording little or no effort |3.7.B.5a| | 4 |
| Nearside Front constant velocity joint gaiter split |2.5.C.1a| | 4 |
| Nearside front brake binding |3.7.B.1| | 4 |
| Nearside Rear position lamp|s| not working |1.1.A.3b| | 3 |
| Nearside Front Brake hose bulging under pressure |3.6.B.3| | 3 |
| Brake pedal anti-slip provision incomplete |3.3.A.1b| | 3 |
| Power steering pump drive system defective |2.3.6| | 3 |
| Offside Stop lamp not working |1.2.1b| | 3 |
| Offside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 3 |
| Nearside Rear coil spring incomplete |2.4.C.1a| | 3 |
| Front Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 3 |
| Offside Rear coil spring broken |2.4.C.1a| | 3 |
| Main beam `tell-tale` not working |1.7.4c| | 3 |
| Rear Rear fog lamp not working (4.5.1 (a) (ii)) | 3 |
| Exhaust emits an excessive level of metered smoke for a non-turbo charged engine |7.4.B.3b| | 3 |
| Nearside Steering rack gaiter missing or no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 3 |
| Nearside Front Upper Suspension arm ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 3 |
| Brake pedal has insufficient reserve travel (1.1.2 (a)) | 3 |
| Brake load sensing valve seized |3.6.E.3| | 3 |
| Nearside Front Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 3 |
| Offside Rear Rear fog lamp not working |1.3.2b| | 3 |
| Nearside Track rod end ball joint dust cover excessively damaged or deteriorated so that it no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 3 |
| Rear Exhaust has a major leak of exhaust gases |7.1.2| | 3 |
| Offside Front coil spring fractured |2.4.C.1a| | 3 |
| Nearside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
| Offside Rear position lamp|s| not working |1.1.A.3b| | 2 |
| Offside Front Upper Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 2 |
| Nearside Steering rack gaiter split |2.2.D.2d| | 2 |
| Nearside Rear Outer Suspension component mounting prescribed area excessively corroded significantly reducing structural strength sill (5.3.6 (a) (i)) | 2 |
| Nearside Headlamp not working on dipped beam |1.7.5a| | 2 |
| Nearside Front Headlamp aim beam image kick up to the offside |1.8| | 2 |
| Offside Front Headlamp aim beam image kick up to the offside |1.8| | 2 |
| Offside Rear coil spring incomplete |2.4.C.1a| | 2 |
| Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 2 |
| Nearside Rear Wheel bearing has excessive play (5.1.3 (a) (i)) | 2 |
| Exhaust has a part missing |7.1.1a| | 2 |
| Nearside Rear Direction indicator not working (4.4.1 (a) (ii)) | 2 |
| Rear Exhaust system not adequately supported |7.1.1| | 2 |
| Rear fog lamp not working (4.5.1 (a) (ii)) | 2 |
| Offside Front Brake hose bulging under pressure (1.1.12 (d)) | 2 |
| Offside Steering rack gaiter split |2.2.D.2d| | 2 |
| Offside Rear Stop lamp not working |1.2.1b| | 2 |
| Offside Rear Rear position lamp|s| not working |1.1.A.3b| | 2 |
| Offside Front Upper Suspension arm pin or bush excessively worn (5.3.4 (a) (i)) | 2 |
| Power steering pipe/hose modification unsafe |2.1.5 |f| |i|| | 2 |
| Nearside Obligatory mirror missing |8.1.1| | 2 |
| Offside Front Headlamp not working on dipped beam |1.7.5a| | 2 |
| Nearside Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 2 |
| Offside Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 2 |
| Offside Front Outer Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 2 |
| Rear fog lamp tell tale not working |1.3.1b| | 2 |
| Nearside Front Outer Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 2 |
| Exhaust emissions test not completed because smoke levels are significantly in excess of the specified limit values (8.2.2.2 (f)) | 2 |
| Horn not working |7.7 |a| |ii|| | 2 |
| Offside Front constant velocity joint gaiter split |2.5.C.1a| | 2 |
| Nearside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 2 |
| Nearside Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 2 |
| Nearside Front Front constant velocity joint gaiter split |2.5.C.1a| | 2 |
| Front brake application uneven | 2 |
| Rear brake application uneven | 2 |
| Nearside Front Brake pipe leaking |3.6.A.1| | 2 |
| Horn not loud enough to be heard by another road user |1.6.2b| | 2 |
| Rear Stop lamp not working |1.2.1b| | 2 |
| Offside front brake binding |3.7.B.1| | 2 |
| Stop lamp remains on when the brakes are released | 2 |
| Nearside Rear Stop lamp not working |1.2.1b| | 2 |
| Nearside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 2 |
| Offside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 2 |
| Nearside Front Upper Suspension arm ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 2 |
| Service brake efficiency below requirements (1.2.2 (a) (i)) | 2 |
| Offside Rear Service brake excessively binding (1.2.1 (f)) | 2 |
| Nearside Front Position lamp not working (4.2.1 (a) (ii)) | 2 |
| Offside Rear Rear fog lamp missing |1.3.2a| | 2 |
| Parking brake lever has no reserve travel |3.1.6b| | 2 |
| Offside Front Lower Suspension arm ball joint dust cover no longer prevents the ingress of dirt |5.3.4 |b| |ii|| | 2 |
| Nearside Side repeater missing |1.4.A.2b| | 2 |
| Offside Side repeater missing |1.4.A.2b| | 2 |
| Horn not working (7.7 (a)) | 2 |
| Power steering malfunctioning (2.1.5 (a)) | 2 |
| Exhaust system not adequately supported |7.1.1| | 2 |
| Parking brake efficiency below requirements (1.4.2 (a) (i)) | 2 |
| Offside Front Front position lamp|s| not working |1.1.A.3b| | 2 |
| Offside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength (5.3.6 (a) (i)) | 2 |
| Offside Front Lower Ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.2.C.1c| | 2 |
| Offside Rear coil spring fractured |2.4.C.1a| | 2 |
| Exhaust emissions carbon monoxide content excessive |7.3.B.1a| | 2 |
| Exhaust emits excessive smoke or vapour of any colour |7.4.B.4| | 2 |
| Offside Track rod end ball joint dust cover excessively damaged or deteriorated so that it no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 2 |
| Offside Headlamp not working on main beam |1.7.5a| | 2 |
| Offside Rear fog lamp not working (1.3.2b) | 2 |
| Nearside Body has a sharp edge caused by corrosion |6.1.C.1| | 1 |
| Headlamp aim beam image obviously incorrect Both sides - LHD headlamp units |1.8.A.1b| | 1 |
| Nearside Ball joint has excessive play |2.2.B.1f| | 1 |
| Offside Ball joint has excessive play |2.2.B.1f| | 1 |
| Offside Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Offside Front Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 1 |
| Nearside Coil spring fractured or broken (5.3.1 (b) (i)) | 1 |
| Offside Coil spring fractured or broken (5.3.1 (b) (i)) | 1 |
| Offside Rear Inner Suspension component mounting prescribed area excessively corroded significantly reducing structural strength wheel arch (5.3.6 (a) (i)) | 1 |
| Offside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength inner wheel arch (5.3.6 (a) (i)) | 1 |
| Nearside Rear Inner Suspension component mounting prescribed area excessively corroded significantly reducing structural strength wheel arch (5.3.6 (a) (i)) | 1 |
| Offside Rear Outer Suspension component mounting prescribed area excessively corroded significantly reducing structural strength sill (5.3.6 (a) (i)) | 1 |
| Nearside Front Inner Suspension component mounting prescribed area excessively corroded significantly reducing structural strength wheel arch (5.3.6 (a) (i)) | 1 |
| Offside Headlamp not working on dipped beam |1.7.5a| | 1 |
| Nearside Rear Inner Suspension component mounting prescribed area excessively corroded significantly reducing structural strength sill (5.3.6 (a) (i)) | 1 |
| Brake load sensing valve linkage seized lever/plate securing nut missing |3.6.E.3| | 1 |
| Offside Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Nearside Headlamp insecure (4.1.1 (c)) | 1 |
| Offside Rear fog lamp missing |1.3.2a| | 1 |
| Nearside Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
| Nearside Rear Shock absorbers has an excessively worn bush (5.3.2 (c)) | 1 |
| Offside Front Windscreen wiper not operating over a large enough area to give an adequate view |8.2.1c| | 1 |
| Headlamp switch insecure |1.7.1| | 1 |
| Offside Outer Rear Seat belt locking mechanism does not secure or release |5.2.5a| | 1 |
| Offside Seat belt buckle not functioning as intended (7.1.2 (d)) | 1 |
| Offside Front Upper Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Nearside Rear Lower Shock absorbers has an excessively worn bush (5.3.2 (c)) | 1 |
| Offside Rear Lower Shock absorbers has an excessively worn bush (5.3.2 (c)) | 1 |
| Nearside Rear Seat belt not functioning as intended (7.1.2 (c)) | 1 |
| Offside Rear Seat belt not functioning as intended (7.1.2 (c)) | 1 |
| Offside Front Upper Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Nearside Front Wheel bearing rough when rotated (5.1.3 (b) (i)) | 1 |
| Headlamp aim projected beam image is obviously incorrect EU stickers fitted (4.1.2 (c)) | 1 |
| Front Anti-roll bar pin or bush excessively worn D bushes (5.3.4 (a) (i)) | 1 |
| Offside Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
| Nearside Rear Brake hose leaking on a hydraulic braking system (1.1.12 (c) (ii)) | 1 |
| Offside Rear Brake hose leaking on a hydraulic braking system (1.1.12 (c) (ii)) | 1 |
| Nearside Front Brake hose bulging under pressure (1.1.12 (d)) | 1 |
| Nearside Rear Wheel bearing has excessive play |5.1.3 |a| |i|| | 1 |
| Offside Rear Outer Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt |6.1.7 |g| |ii|| | 1 |
| Front Windscreen washer jets misaligned and not providing sufficient fluid to the windscreen Both OS and NS (3.5 (a)) | 1 |
| Offside Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings sill/chassis step |6.1.B.2| | 1 |
| Offside Front Steering component mounting prescribed area is excessively corroded floor near jacking point (2.1.2 (e) (i)) | 1 |
| Offside Rear Cab or chassis has excessive corrosion, seriously affecting its strength within 30cm of a cab mounting O/S WHEEL ARCH HOLED ABOVE ARM MOUNTING AREA AND TO THE REAR OF THE WHEEL ARCH BOTH MARKED (6.2.2 (d) (i)) | 1 |
| Offside Rear Cab or chassis has excessive corrosion, seriously affecting its strength within 30cm of a cab mounting O/.S REAR WING BADLY CORRODED AND HOLED AREA MARKED (6.2.2 (d) (i)) | 1 |
| Nearside Rear Cab or chassis has excessive corrosion, seriously affecting its strength within 30cm of a cab mounting ABOVE REAR ARM MOUNTING AREA MARKED (6.2.2 (d) (i)) | 1 |
| Nearside Front Obligatory mirror seriously damaged, affecting the rear view Door mirror. (3.3 (b) (ii)) | 1 |
| Braking system leaking brake pipe at master cylinder corroded |3.6.A.1| | 1 |
| Rear fog lamp switch missing |1.3.1a| | 1 |
| Nearside Inner Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
| Nearside Inner Ball joint has excessive play |2.2.B.1f| | 1 |
| Braking system leaking |3.6.A.1| | 1 |
| Battery insecure and likely to fall from carrier |4.13 |a| |ii|| | 1 |
| Nearside Headlamp not working on dipped beam |4.1.1 |a| |ii|| | 1 |
| Nearside Front Direction indicator not working |4.4.1 |a| |ii|| | 1 |
| Rear fog lamp not working |4.5.1 |a| |ii|| | 1 |
| Fuel pipe insecure |6.1.3 |a| |i|| | 1 |
| Offside Drive shaft securing bolt loose |6.1.7 |a| |i|| | 1 |
| Nearside Steering rack gaiter missing or no longer prevents the ingress of dirt |2.1.3 |g| |ii|| | 1 |
| Offside Steering rack gaiter missing or no longer prevents the ingress of dirt |2.1.3 |g| |ii|| | 1 |
| Offside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength upper shocker mount |5.3.6 |a| |i|| | 1 |
| Fuel cap/sealing device missing |7.2.4a| | 1 |
| Hazard warning lamps inoperative |1.4.B.1b| | 1 |
| Rear Direction indicators not working |1.4.A.2c| | 1 |
| Offside Front Direction indicator not working |1.4.A.2c| | 1 |
| Nearside Front Headlamp not working on dipped beam |1.7.5a| | 1 |
| Bonnet cannot be secured in the closed position |8.4.1| | 1 |
| Nearside Front Anti-roll bar linkage rubber mounting deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Nearside Front Steering rack gaiter split |2.2.D.2d| | 1 |
| Nearside Front Suspension component mounting prescribed area excessively corroded significantly reducing structural strength inside the wheel arch (5.3.6 (a) (i)) | 1 |
| Steering wheel likely to become detached (2.2.1 (b) (ii)) | 1 |
| Brake load sensing valve seized and ABS not fitted or inoperative Cable tie holding valve open/closed. (1.1.17 (c) (ii)) | 1 |
| Speedometer cannot be illuminated (7.8 (c) (ii)) | 1 |
| Nearside Front Steering rack gaiter missing or no longer prevents the ingress of dirt Clip missing. (2.1.3 (g) (ii)) | 1 |
| Headlamp aim unable to be tested Dip beam not working. (4.1.2 (b)) | 1 |
| Nearside Front Anti-roll bar pin or bush excessively worn D bush (5.3.4 (a) (i)) | 1 |
| Nearside Rear Service brake excessively binding |1.2.1 |f|| | 1 |
| Brake fluid contaminated |1.8 |a|| | 1 |
| Parking brake lever has excessive movement indicating incorrect adjustment |1.1.6 |c|| | 1 |
| Brake pedal has insufficient reserve travel |1.1.2 |a|| | 1 |
| Nearside Front Direction indicator incorrect colour |4.4.3 |a|| | 1 |
| Offside Front Direction indicator incorrect colour |4.4.3 |a|| | 1 |
| Front Anti-roll bar pin or bush excessively worn |5.3.4 |a| |i|| | 1 |
| Battery insecure |1.9.1| | 1 |
| Offside Seat belt retracting mechanism defective |5.2.5b| | 1 |
| Offside Lower Front suspension ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Offside Front Lower Front suspension ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Offside Front Seat belt retracting mechanism defective |5.2.5b| | 1 |
| Nearside Front Direction indicator incorrect colour (4.4.3 (a)) | 1 |
| Offside Front Direction indicator incorrect colour (4.4.3 (a)) | 1 |
| Offside Front Steering rack gaiter missing or no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |
| Central Brake pipe leaking on a hydraulic braking system (1.1.11 (b) (ii)) | 1 |
| Nearside Front Lower Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Rear fog lamp switch inoperative (4.5.3 (a) (ii)) | 1 |
| Drivers seat fore and aft adjustment mechanism not functioning as intended. (6.2.5 (b) (i)) | 1 |
| Headlamps matched pair are not the same colour (4.1.4 (d)) | 1 |
| Offside Front Anti-roll bar linkage pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Nearside Front Steering rack gaiter missing or no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |
| Central Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 1 |
| Brake fluid contaminated (1.8 (a)) | 1 |
| Offside Steering rack gaiter missing or no longer prevents the ingress of dirt split (2.1.3 (g) (ii)) | 1 |
| Central Exhaust system insecure (6.1.2 (a)) | 1 |
| Nearside Rear Service brake effort inadequate at a wheel (1.2.1 (a) (i)) | 1 |
| Offside Rear Service brake effort inadequate at a wheel (1.2.1 (a) (i)) | 1 |
| Nearside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength outer sill (5.3.6 (a) (i)) | 1 |
| Front position lamp|s| incorrect colour both sides |1.1.A.3e| | 1 |
| Offside Front Headlamp not working on dipped beam |4.1.1 |a| |ii|| | 1 |
| Nearside Rear Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced |6.1.1 |c| |i|| | 1 |
| Offside Front Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced |6.1.1 |c| |i|| | 1 |
| Nearside Front Lower Suspension component ball joint excessively worn |5.3.4 |a| |i|| | 1 |
| Offside Front Lower Suspension component ball joint excessively worn |5.3.4 |a| |i|| | 1 |
| Offside Front Upper Suspension component ball joint excessively worn |5.3.4 |a| |i|| | 1 |
| Nearside Rear Seat belt stitching badly frayed |5.2.2b| | 1 |
| Brake load sensing valve seized and ABS not fitted or inoperative (1.1.17 (c) (ii)) | 1 |
| Nearside Front Upper Obligatory mirror missing (3.3 (a)) | 1 |
| Nearside Front Lower Obligatory mirror seriously damaged, affecting the rear view (3.3 (b) (ii)) | 1 |
| Offside Front Upper Position lamp missing (4.2.1 (a) (ii)) | 1 |
| Rear Prop shaft bearing housing fractured (6.1.7 (f) (i)) | 1 |
| Nearside Seat belt locking mechanism does not secure or release |5.2.5a| | 1 |
| Brake has no servo assistance |3.3.B.2| | 1 |
| Offside Front All position lamps not working |1.1.A.3b| | 1 |
| Fuel cap/sealing device does not fasten securely maintaining the sealing arrangement |7.2.4b| | 1 |
| Nearside Headlamp aim beam image kick up to the offside |1.6.B1| | 1 |
| Offside Headlamp aim beam image kick up to the offside |1.6.B1| | 1 |
| Rear position lamp|s| incorrect colour |1.1.A.3e| | 1 |
| Stop lamp emits other than a steady red light |1.2.1e| | 1 |
| Offside Rear fog lamp emits a light other than red |1.3.2e| | 1 |
| Offside Rear brake drum contaminated by oil |3.5.1h| | 1 |
| Nearside Headlamp not working on main beam |1.7.5a| | 1 |
| Nearside Front Anti-roll bar linkage rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Front Anti-roll bar linkage rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Centre Obligatory mirror missing |8.1.1| | 1 |
| Offside Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Centre Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Offside Front Body has a sharp edge caused by corrosion |6.1.C.1| | 1 |
| Nearside Rear coil spring fractured |2.4.C.1a| | 1 |
| Nearside Lower Front suspension ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Offside Rear Shock absorber has an excessively worn linkage |2.7.4| | 1 |
| Nearside Rear Shock absorber has an excessively worn bush |2.7.4| | 1 |
| Offside Front Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Nearside Front Seat belt locking mechanism does not secure or release |5.2.5a| | 1 |
| Nearside Front Seat belt anchorage prescribed area is excessively corroded outer sill |5.2.6| | 1 |
| Offside Front Brake pipe leaking |3.6.A.1| | 1 |
| Offside Front Windscreen has a sticker or other obstruction encroaching by more than 10mm within zone `A` |8.3.1b| | 1 |
| Power steering inoperative |2.3.3a| | 1 |
| Vehicle structure has excessive corrosion which adversely affects braking or steering Nearside inner sill (6.1.1 (c) (ii)) | 1 |
| Vehicle structure has excessive corrosion which adversely affects braking or steering Offside and nearside front inner wheel arches (6.1.1 (c) (ii)) | 1 |
| Vehicle structure has excessive corrosion which adversely affects braking or steering Offside front wheel arche rear (6.1.1 (c) (ii)) | 1 |
| Nearside Front Shock absorber insecure |2.7.2b| | 1 |
| Nearside Front Shock absorber has an excessively worn bush |2.7.4| | 1 |
| Nearside Front Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 1 |
| Nearside Front constant velocity joint gaiter insecurely mounted to its housing |2.5.C.1a| | 1 |
| Power steering pump drive system defective Belt slipping |2.3.6| | 1 |
| Nearside Rear Subframe mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Rear Subframe mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Nearside Front brake disc excessively scored |3.5.1h| | 1 |
| Offside Headlamp excessively deteriorated so that the light output is severely reduced |1.7.5a| | 1 |
| Offside Front Braking system leaking |3.6.A.1| | 1 |
| Nearside Rear Brake cable has wires broken and is significantly weakened |3.5.1b| | 1 |
| Front brake disc in such a condition that it is seriously weakened | 1 |
| Exhaust has part of the system excessively deteriorated |7.1.1a| | 1 |
| Nearside Front An item not tested |Manual| | 1 |
| Offside Front An item not tested |Manual| | 1 |
| Nearside Front Brake hose twisted |found during steering lock to lock check| |2.2.D.2b| | 1 |
| Front brake disc has restricted free movement |3.5.1j| | 1 |
| Nearside Rear Rear position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
| Nearside Front Inner Suspension component mounting prescribed area is excessively corroded sill |2.4.A.3| | 1 |
| Nearside Front Outer Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Track rod end ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Steering column top bearing excessively worn |2.1.2c| | 1 |
| Offside Front Steering rack gaiter split |2.2.D.2d| | 1 |
| Offside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength Hole to outer sill (5.3.6 (a) (i)) | 1 |
| Offside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength Hole to inner sill (5.3.6 (a) (i)) | 1 |
| Nearside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength Hole to outer sill (5.3.6 (a) (i)) | 1 |
| Headlamp levelling device inoperative (4.1.5 (a)) | 1 |
| Nearside Front Headlamp insecure |1.7.3| | 1 |
| Braking system leaking front to rear metal brake pipes above fuel tank |3.6.A.1| | 1 |
| Brake pedal spongy |3.3.B.1b| | 1 |
| Brake pedal creeps down while the pedal is held under pressure |3.3.B.1a| | 1 |
| Offside Front Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Offside Front Lower Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Nearside Front Valve stem seriously misaligned (5.2.3 (j)) | 1 |
| Offside Front Valve stem seriously misaligned (5.2.3 (j)) | 1 |
| Nearside Rear Valve stem seriously misaligned (5.2.3 (j)) | 1 |
| Offside Rear Valve stem seriously misaligned (5.2.3 (j)) | 1 |
| Nearside Front Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced out riggers behind bumper/chassis (6.1.1 (c) (i)) | 1 |
| Offside Front Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced out riggers behind bumper/chassis (6.1.1 (c) (i)) | 1 |
| Nearside Headlamp levelling device inoperative |4.1.5 |a|| | 1 |
| Offside Headlamp levelling device inoperative |4.1.5 |a|| | 1 |
| Trailer electrical socket likely to become detached |4.10 |a| |ii|| | 1 |
| Offside Rear Towbar excessively corroded within 30cm of towbar mounting rear panel |6.1.6 |i| |i|| | 1 |
| Nearside Rear Seat belt not functioning as intended |7.1.2 |c|| | 1 |
| Exhaust emissions exceed manufacturer`s specified limit |8.2.2.2 |a|| | 1 |
| Nearside Rear Service brake has no recorded effort at a wheel |1.2.1 |a| |ii|| | 1 |
| Nearside Front Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt |6.1.7 |g| |ii|| | 1 |
| Offside Front Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt |6.1.7 |g| |ii|| | 1 |
| Offside Front Seat belt retracting mechanism defective |7.1.2 |e|| | 1 |
| Offside Front Shock absorbers has a serious fluid leak | 1 |
| Offside Rear Towbar is so weakened by corrosion within 30cm of a towbar mounting, the towbar is likely to become detached |6.1.6 |i| |ii|| | 1 |
| Nearside Front Seat belt insecurely fixed to the vehicles structure |5.2.1a| | 1 |
| Offside Front Seat belt insecurely fixed to the vehicles structure |5.2.1a| | 1 |
| Nearside Steering linkage ball joint ball joint dust cover excessively damaged or deteriorated so that it no longer prevents the ingress of dirt draglink end front (2.1.3 (g) (ii)) | 1 |
| Nearside Steering linkage ball joint ball joint dust cover excessively damaged or deteriorated so that it no longer prevents the ingress of dirt draglink end rear (2.1.3 (g) (ii)) | 1 |
| Nearside Front Ball joint has excessive play |2.2.B.1f| | 1 |
| Fuel system component leaking |7.2.3| | 1 |
| Nearside Front Front constant velocity joint gaiter insecurely mounted to its housing |2.5.C.1a| | 1 |
| Offside Front Anti-roll bar linkage has excessive play in a pin/bush |2.4.G.2| | 1 |
| Nearside Front Shock absorber has a serious fluid leak |2.7.3| | 1 |
| Offside Front Inner Anti-roll bar pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Oil leaking excessively from engine oil switch (8.4.1 (a) (i)) | 1 |
| Nearside Seat belt anchorage prescribed area strength or continuity significantly reduced b post fractured (7.1.1 (a) (i)) | 1 |
| Nearside Rear Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting inner sill (6.2.2 (d) (i)) | 1 |
| Oil leaking excessively from engine (8.4.1 (a) (i)) | 1 |
| Offside Rear Body component corroded and likely to cause injury (6.2.1 (a) (i)) | 1 |
| Front Fuel hose leaking |7.2.3| | 1 |
| Nearside Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
| Nearside Front Anti-roll bar rubber mounting deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Front Anti-roll bar rubber mounting deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Brake lever has insufficient reserve travel (1.1.2 (a)) | 1 |
| Headlamp aim not tested |1.8.A.1c| | 1 |
| Offside Front constant velocity joint gaiter deteriorated to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Offside Track rod end ball joint has excessive play (2.1.3 (b) (i)) | 1 |
| Central Rear Statutory seat belt missing buckle missing |5.1.1| | 1 |
| Offside Front Direction indicator insecure held on with tape |1.4.A.2b| | 1 |
| Offside Rear Exhaust system not adequately supported rubber split |7.1.1| | 1 |
| Nearside Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Braking system leaking compensator valve leaking |3.6.A.1| | 1 |
| Offside Front Lower Suspension arm ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Rear Brake load sensing valve seized |3.6.E.3| | 1 |
| Nearside Front constant velocity joint gaiter deteriorated to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Offside Front Suspension arm ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Nearside Front Steering rack gaiter missing or no longer prevents the ingress of dirt |2.1.3 |g| |ii|| | 1 |
| Offside Front Steering rack gaiter missing or no longer prevents the ingress of dirt |2.1.3 |g| |ii|| | 1 |
| Fuel system component leaking excessively or a risk of fire |6.1.3 |b| |ii|| | 1 |
| Front Exhaust system not adequately supported |7.1.1| | 1 |
| Nearside Front Upper Anti-roll bar linkage has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Front Shock absorber has negligible damping effect |2.7.5| | 1 |
| Rear Shock absorber has negligible damping effect |2.7.5| | 1 |
| Nearside Indicator tell tale inoperative |1.4.A.2a| | 1 |
| Nearside Front Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 1 |
| All direction indicators not working (4.4.1 (a) (ii)) | 1 |
| Nearside Brake pipe leaking on a hydraulic braking system (1.1.11 (b) (ii)) | 1 |
| Passengers seat insecure (6.2.6 (a) (ii)) | 1 |
| Offside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength inner arch) (rear of arch (5.3.6 (a) (i)) | 1 |
| Offside Rear fog lamp not working (4.5.1 (a) (ii)) | 1 |
| Offside Rear Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting (6.2.2 (d) (i)) | 1 |
| Nearside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength (5.3.6 (a) (i)) | 1 |
| Nearside Front Lower Seat belt anchorage prescribed area strength or continuity significantly reduced |7.1.1 |a| |i|| | 1 |
| Offside Front Lower Seat belt anchorage prescribed area strength or continuity significantly reduced |7.1.1 |a| |i|| | 1 |
| Central Rear Passenger`s seat backrest cannot be secured in the upright position. |6.2.6 |a| |i|| | 1 |
| Battery insecure and likely to cause a short circuit |4.13 |a| |ii|| | 1 |
| Offside Front Brake hose bulging under pressure |3.6.B.3| | 1 |
| Nearside Windscreen has a sticker or other obstruction encroaching into the swept area by more than 40mm outside zone `A` |8.3.1e| | 1 |
| Nearside Front Upper Ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Nearside Front Lower Ball joint has excessive play |2.2.B.1f| | 1 |
| Offside Front Upper Ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Offside Front Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Nearside Front Front constant velocity joint gaiter deteriorated to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Rear fog lamp does not emit a steady red light |4.5.4 |a|| | 1 |
| Road wheel fixing missing all 4 |5.2.1 |a| |i|| | 1 |
| Nearside Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings jacking point |6.1.B.2| | 1 |
| Offside Rear Outer Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings wheel arch to sill |6.1.B.2| | 1 |
| Offside Front Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Nearside Front Inner Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Offside Front Inner Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Offside Front Outer Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Nearside Windscreen wiper not operating over a large enough area to give an adequate view |8.2.1c| | 1 |
| Brake hydraulic reservoir fluid level below minimum level |3.6.G.1b| | 1 |
| Registration plate issues | 1 |
| Power steering malfunctioning |2.3.3a| | 1 |
| Nearside Steering arm has relative movement at its fixings |2.2.B.1h| | 1 |
| Nearside Rear reflector missing |1.5.1a| | 1 |
| Offside Rear reflector missing |1.5.1a| | 1 |
| Rear fog lamp insecure |1.3.2a| | 1 |
| Centre Exhaust system not adequately supported |7.1.1| | 1 |
| Offside Rear Upper Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Front Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
| Nearside Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Front Fuel system component leaking fuel pump |7.2.3| | 1 |
| Front Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Nearside Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings inner sill |6.1.B.2| | 1 |
| Offside Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings inner sill |6.1.B.2| | 1 |
| Offside Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings lower inner wheel arch |6.1.B.2| | 1 |
| Nearside Rear Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Brake pedal anti-slip provision missing |3.3.A.1b| | 1 |
| Nearside Rear Seat belt locking mechanism does not secure or release |5.2.5a| | 1 |
| Nearside Front Fuel hose leaking |7.2.3| | 1 |
| Central Rear Brake cable has wires broken and is significantly weakened |3.5.1b| | 1 |
| Nearside Front Upper Steering system has a road wheel fouling a part of the vehicle arm catching inner rim |2.2.D.2a| | 1 |
| Offside Front Upper Steering system has a road wheel fouling a part of the vehicle arm catching inner rim |2.2.D.2a| | 1 |
| Offside Front wheel bearing has excessive play |2.5.A.3c| | 1 |
| Offside Front Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 1 |
| Nearside Rear Suspension arm corroded and seriously weakened (5.3.3 (b) (i)) | 1 |
| Brake pedal anti-slip provision missing (1.1.2 (c)) | 1 |
| Steering column top bearing excessively worn (2.2.2 (b)) | 1 |
| Nearside Front Headlamp not working on main beam (4.1.1 (a) (ii)) | 1 |
| Nearside Rear Rear wheel bearing has excessive play |2.6.2| | 1 |
| Nearside Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Offside Front constant velocity joint gaiter insecurely mounted to its housing |2.5.C.1a| | 1 |
| Rear Mechanical brake component has restricted free movement | 1 |
| Nearside Rear Service brake: efficiency below requirements |3.7.B.7| | 1 |
| Offside Front Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Brake valve inappropriately repaired |3.6.A.3| | 1 |
| Nearside Front coil spring fractured |2.4.C.1a| | 1 |
| Nearside Inner Front drive shaft coupling is insecure |2.5.C.1c| | 1 |
| Nearside Rear Service brake excessively binding (1.2.1 (f)) | 1 |
| Nearside Brake hose leaking |3.6.A.1| | 1 |
| Brake performance not tested |3.7.A.1| | 1 |
| Fuel pipe leaking diesel injector spill pipes (6.1.3 (b) (i)) | 1 |
| Nearside Rear Position lamp light intensity significantly reduced light lens misted (4.2.3 (a) (ii)) | 1 |
| Offside Inner Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 1 |
| Brake pipe leaking on a hydraulic braking system front to rear (1.1.11 (b) (ii)) | 1 |
| Rear fog lamp does not emit a steady red light is emiting almost white light (4.5.4 (a)) | 1 |
| Nearside Headlamp aim projected beam image is obviously incorrect dip beam ;kick up; is incorrect, has left hand drive lamps fitted. (4.1.2 (c)) | 1 |
| Offside Headlamp aim projected beam image is obviously incorrect dip beam ;kick up; is incorrect,left hand drive headlamp is fitted. (4.1.2 (c)) | 1 |
| Central Exhaust has a major leak of exhaust gases centre silencer is holed (6.1.2 (a)) | 1 |
| Nearside Front Front constant velocity joint is excessively worn |2.5.C.1b| | 1 |
| Hazard warning switch faulty |1.4.B.1d| | 1 |
| Nearside Front Track rod end ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Nearside Front Direction indicator not working |1.4.A.2c| | 1 |
| Offside Front Direction indicator incorrect colour |1.4.A.2f| | 1 |
| Nearside Front Lower Front suspension ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Offside Front Lower Front suspension ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Offside Front Upper Front suspension ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Offside Rear Direction indicator excessively deteriorated so that it is not visible from a reasonable distance |1.4.A.2e| | 1 |
| Nearside Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Fuel hose leaking diesel injector spill pipes (6.1.3 (b) (i)) | 1 |
| Power steering malfunctioning belt slipping (2.1.5 (a)) | 1 |
| Emissions unable to be completed diesel fuel leak (8.2.2.2 (e)) | 1 |
| Hazard warning switch inoperative (4.4.2 (a) (ii)) | 1 |
| Nearside Side repeater incorrect colour (4.4.3 (a)) | 1 |
| Offside Side repeater not working (4.4.1 (a) (ii)) | 1 |
| Offside Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
| Brake load sensing valve linkage defective and function impaired (1.1.17 (a)) | 1 |
| Offside Front Body has a projection caused by corrosion |6.1.C.1| | 1 |
| Rear Brake lever has restricted free movement |3.5.1k| | 1 |
| Parking brake lever is impeded in its travel |3.1.6c| | 1 |
| Nearside Front Parking brake mechanism/associated mounting prescribed area is excessively corroded |3.1.9| | 1 |
| Nearside Front Driver`s seat insecure |6.2.A.1| | 1 |
| Offside Front front brake binding |3.7.B.1| | 1 |
| Rear Rear fog lamp not working |1.3.2b| | 1 |
| Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
| Nearside Front wheel bearing rough when rotated |2.5.A.2| | 1 |
| Fuel system component leaking excessively or a risk of fire (6.1.3 (b) (ii)) | 1 |
| Emissions unable to be completed excessive fuel leak (8.2.2.2 (e)) | 1 |
| Brake performance unable to be tested excessive fuel leak (1.2.1 (g)) | 1 |
| Offside Steering rack gaiter insecure (2.2.D.2d) | 1 |
| Nearside Front Front suspension has a suspension lower ball joint securing nut loose (2.5.B.1a) | 1 |
| Battery insecure (1.9.1) | 1 |
| Front position lamp(s) not working (1.1.A.3b) | 1 |
| Rear Body has a sharp edge caused by damage (6.1.C.1) | 1 |
| Nearside Front Headlamp incorrect colour (4.1.4 (a)) | 1 |
| Offside Stop lamp not working (1.2.1b) | 1 |
| Nearside rear brake grabbing severely (3.7.A.5b) | 1 |
| Exhaust emissions exceed manufacturers specified limit (8.2.2.2 (a)) | 1 |
| Nearside Rear Vehicle structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting outer panel (6.2.2 (d) (i)) | 1 |
| Nearside Rear Body panel corroded and likely to cause injury bumper (6.2.1 (a) (i)) | 1 |
| Offside Front Lower Suspension arm ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Nearside Front Vehicle structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting inner sill (6.2.2 (d) (i)) | 1 |
| Offside Front Vehicle structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting inner sill (6.2.2 (d) (i)) | 1 |
| Front Anti-roll bar pin or bush excessively worn both sides d bushes (5.3.4 (a) (i)) | 1 |
| Centre Statutory seat belt missing |5.1.1| | 1 |
| Offside Front Service brake excessively binding (1.2.1 (f)) | 1 |
| Offside Front Inner Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt |6.1.7 |g| |ii|| | 1 |
| Nearside Rear Direction indicator not working |1.4.A.2c| | 1 |
| Exhaust has a major leak of exhaust gases various leaks |7.1.2| | 1 |
| Offside Steering rack gaiter missing or no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |
| Nearside Front Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 1 |
| Nearside Direction indicator incorrect colour |1.4.A.2f| | 1 |
| Nearside Front Suspension component ball joint dust cover no longer prevents the ingress of dirt TOP JOINT |5.3.4 |b| |ii|| | 1 |
| Nearside Front Suspension component ball joint dust cover no longer prevents the ingress of dirt BOTTOM JOINT |5.3.4 |b| |ii|| | 1 |
| Nearside Headlamp not working on main beam (4.1.1 (a) (ii)) | 1 |
| Offside Headlamp not working on main beam (4.1.1 (a) (ii)) | 1 |
| rear brake recording little or no effort |3.7.B.5a| | 1 |
| Nearside Front Upper Suspension arm ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Driver`s seat fore and aft adjustment mechanism not functioning as intended. |6.2.5 |b| |i|| | 1 |
| Nearside Front Suspension arm ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Nearside Outer Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Offside Outer Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Offside Outer Front constant velocity joint gaiter split |2.5.C.1a| | 1 |