| Most common failures | No# failures |
|---|
| Headlamp aim out of alignment | 52 |
| Windscreen wiper does not clear the windscreen effectively | 19 |
| Registration plate lamp issues | 15 |
| Offside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 9 |
| Nearside Rear coil spring broken |2.4.C.1a| | 8 |
| Offside Rear Coil spring fractured or broken (5.3.1 (b) (i)) | 8 |
| Offside Rear coil spring broken |2.4.C.1a| | 7 |
| Offside Headlamp aim beam image kick up to the offside |1.8| | 5 |
| Nearside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 5 |
| Front brake excessively fluctuating | 4 |
| Nearside Headlamp aim beam image kick up to the offside |1.8| | 4 |
| Offside Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 4 |
| Brake pipe excessively corroded | 4 |
| Offside Rear fog lamp not working |1.3.2b| | 4 |
| Offside Stop lamp not working |1.2.1b| | 4 |
| Registration plate issues | 3 |
| Exhaust emissions exceed manufacturers specified limit (8.2.2.2 (a)) | 3 |
| Nearside Rear Coil spring fractured or broken (5.3.1 (b) (i)) | 3 |
| Nearside Front Position lamp not working (4.2.1 (a) (ii)) | 3 |
| Rear fog lamp not working |1.3.2b| | 3 |
| Offside Front Position lamp not working (4.2.1 (a) (ii)) | 3 |
| Offside Front Position lamp not working |4.2.1 |a|| | 3 |
| Parking brake: efficiency below requirements |3.7.B.7| | 3 |
| Nearside Rear Stop lamp(s) not working (4.3.1 (a) (ii)) | 3 |
| Supplementary Restraint System warning lamp indicates a fault |5.4.2| | 3 |
| Offside Front Lower Suspension arm ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 2 |
| Offside Rear Coil spring fractured or broken |5.3.1 |b| |i|| | 2 |
| Nearside rear brake excessively fluctuating |3.7.B.3| | 2 |
| Nearside Rear Coil spring fractured or broken |5.3.1 |b| |i|| | 2 |
| Offside Front Macpherson strut top bush or bearing has excessive wear or free play (5.3.4 (a) (i)) | 2 |
| Nearside Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 2 |
| Nearside Side repeater not working (4.4.1 (a) (ii)) | 2 |
| Offside Front Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 2 |
| Nearside Side repeater not working |4.4.1 |a| |ii|| | 2 |
| Offside Rear fog lamp not working |4.5.1 |a| |ii|| | 2 |
| Exhaust emissions exceed manufacturers specified limit 0.6 (8.2.2.2 (a)) | 2 |
| Parking brake efficiency below requirements (1.4.2 (a) (i)) | 2 |
| Nearside Front Anti-roll bar linkage ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 2 |
| Nearside Stop lamp(s) not working (4.3.1 (a) (ii)) | 2 |
| Offside Front Anti-roll bar linkage ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 2 |
| Offside Rear Rear fog lamp not working |1.3.2b| | 2 |
| Nearside Front Suspension arm has excessive play in a pin/bush |2.4.G.2| | 2 |
| Offside Front Coil spring fractured or broken (5.3.1 (b) (i)) | 2 |
| Nearside Front Lower Suspension component ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 2 |
| Nearside Front Coil spring fractured or broken (5.3.1 (b) (i)) | 2 |
| Brake hose has insufficient room to move | 2 |
| Offside Rear Stop lamp(s) not working (4.3.1 (a) (ii)) | 2 |
| Nearside Stop lamp not working |1.2.1b| | 2 |
| Rear brake binding | 2 |
| Driver`s door cannot be opened from inside the vehicle |6.2.B.1b| | 1 |
| Nearside Rear Valve stem seriously damaged |4.1.D.1e| | 1 |
| Offside Rear Valve stem seriously damaged |4.1.D.1e| | 1 |
| Offside rear brake excessively fluctuating |3.7.B.3| | 1 |
| Windscreen washer not working | 1 |
| Offside Headlamp not working on dipped beam |4.1.1 |a| |ii|| | 1 |
| Rear fog lamp missing |1.3.2a| | 1 |
| Nearside Front Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
| Exhaust fumes entering cabin Leak from EGR pipe gasket in engine bay (6.1.2 (b) (i)) | 1 |
| Exhaust fumes causing a danger to health of persons on board Leak from EGR pipe gasket in engine bay (6.1.2 (b) (ii)) | 1 |
| Offside Front Headlamp not working on dipped beam |1.7.5a| | 1 |
| Nearside Front Lower Anti-roll bar linkage ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Nearside Rear Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Offside Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 1 |
| Offside Headlamp aim unable to be tested (4.1.2 (b)) | 1 |
| Nearside Front Suspension arm ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Nearside Front Macpherson strut top bush or bearing has excessive wear or free play (5.3.4 (a) (i)) | 1 |
| Nearside Front Suspension arm pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Front Suspension arm pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Nearside Front Side repeater not working (4.4.1 (a) (ii)) | 1 |
| Nearside Front Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Rear Stop lamp|s| missing |4.3.1 |a| |ii|| | 1 |
| Offside Front Seat belt buckle damaged (7.1.2 (d)) | 1 |
| Offside Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
| Power steering fluid level below minimum |2.3.1| | 1 |
| Nearside Rear Seat belt buckle damaged (7.1.2 (d)) | 1 |
| Offside Rear Seat belt buckle damaged (7.1.2 (d)) | 1 |
| Nearside Stop lamp|s| not working |4.3.1 |a| |ii|| | 1 |
| Offside Front Obligatory mirror missing (3.3 (a)) | 1 |
| Offside Rear Lower Rear fog lamp not working |1.3.2b| | 1 |
| Front passenger door cannot be opened from inside the vehicle (6.2.3 (a)) | 1 |
| Electronic stability control warning lamp indicates a fault (7.12 (e)) | 1 |
| Nearside Front Anti-roll bar ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Offside Front Suspension component ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Exhaust carbon monoxide content at idle exceeds default limits (8.2.1.2 (b)) | 1 |
| Nearside Headlamp levelling device inoperative (4.1.5 (a)) | 1 |
| Offside Headlamp not working on dipped beam |1.7.5a| | 1 |
| Nearside Headlamp not working on dipped beam |1.7.5a| | 1 |
| Exhaust on a vehicle fitted with a diesel particulate filter emits visible smoke of any colour (8.2.2.2 (d)) | 1 |
| Exhaust emissions exceed manufacturers specified limit Plate limit 0.60 (8.2.2.2 (a)) | 1 |
| Offside Rear Seat belt retracting mechanism defective |5.2.5b| | 1 |
| Rear Spare wheel insecure spare wheel missing |6.4.2| | 1 |
| Emissions not tested engine oil below min |7.3.A.1| | 1 |
| Exhaust particulate filter missing where one was fitted as standard |7.1.3| | 1 |
| Offside Rear Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Nearside Front Wheel bearing rough when rotated (5.1.3 (b) (i)) | 1 |
| Offside Rear Rear fog lamp adversely affected by the operation of another lamp (4.5.4 (b)) | 1 |
| Nearside Headlamp aim projected beam image is obviously incorrect |4.1.2 |c|| | 1 |
| Offside Headlamp aim projected beam image is obviously incorrect |4.1.2 |c|| | 1 |
| Nearside Front Suspension arm pin or bush excessively worn Rear bush (5.3.4 (a) (i)) | 1 |
| Nearside Front Lower Suspension arm pin or bush excessively worn front arm rear bush has play (5.3.4 (a) (i)) | 1 |
| Offside Front Lower Suspension arm pin or bush excessively worn front arm rear bush has play (5.3.4 (a) (i)) | 1 |
| Nearside Front Suspension component ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Offside Rear Service brake excessively binding (1.2.1 (f)) | 1 |
| Rear fog lamp not working (4.5.1 (a) (ii)) | 1 |
| Nearside Rear Rear position lamp|s| has a product on the light source so it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Offside Front Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Engine MIL inoperative or indicates a malfunction (8.2.2.2 (g)) | 1 |
| Brake pedal has insufficient reserve travel (1.1.2 (a)) | 1 |
| Suspension arm pin or bush excessively worn both sides at front suspension - lower arm rear bushes worn (5.3.4 (a) (i)) | 1 |
| Nearside Rear Seat belt retracting mechanism defective (7.1.2 (e)) | 1 |
| Rear Coil spring fractured or broken both |5.3.1 |b| |i|| | 1 |
| Nearside Front Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Nearside Rear Stop lamp not working |1.2.1b| | 1 |
| Offside Front Headlamp not working on dipped beam |4.1.1 |a| |ii|| | 1 |
| Parking brake efficiency below requirements |1.4.2 |a| |i|| | 1 |
| Nearside Rear Rear position lamp|s| incorrect colour |1.1.A.3e| | 1 |
| Offside Front Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 1 |
| Tailgate cannot be secured in the closed position |6.4.1| | 1 |
| Offside Rear Rear fog lamp missing |1.3.2a| | 1 |
| Offside Rear brake disc excessively pitted |3.5.1h| | 1 |
| Offside Front Lower Suspension component ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Offside Rear Shock absorbers has a serious fluid leak | 1 |
| Nearside Front Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 1 |
| Offside Rear coil spring incomplete |2.4.C.1a| | 1 |
| Offside Front Anti-roll bar linkage ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Supplementary restraint system warning lamp indicates a fault (7.1.6 (a)) | 1 |
| Offside Front Brake hose twisted |3.6.B.4c| | 1 |
| Offside Front Lower Suspension arm ball joint likely to become detached (5.3.4 (a) (ii)) | 1 |
| Nearside Rear Rear wheel bearing rough when rotated |2.6.1| | 1 |
| Nearside Front Brake hose twisted |found during steering lock to lock check| |2.2.D.2b| | 1 |
| Windscreen has damage | 1 |
| Offside Front Lower Suspension arm ball joint dust cover no longer prevents the ingress of dirt |5.3.4 |b| |ii|| | 1 |
| Driver`s airbag obviously defective |5.4.1| | 1 |
| Nearside Front Suspension arm rubber bush deteriorated resulting in excessive movement Rear bush |2.4.G.2| | 1 |
| Offside Front Suspension arm rubber bush deteriorated resulting in excessive movement Rear bush |2.4.G.2| | 1 |
| Front passenger door cannot be opened from outside the vehicle (6.2.3 (a)) | 1 |
| Brake fluid contaminated |1.8 |a|| | 1 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Front Ball joint has excessive play |2.2.B.1f| | 1 |
| Offside Rear Body has a sharp edge caused by damage |6.1.C.1| | 1 |
| Offside Front Power steering fluid level below minimum |2.3.1| | 1 |
| Nearside Front Lower Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Nearside Rear coil spring incomplete |2.4.C.1a| | 1 |
| Offside Rear coil spring fractured |2.4.C.1a| | 1 |
| Offside Front Lower Suspension arm rubber bush deteriorated resulting in excessive movement Rear |2.4.G.2| | 1 |
| Nearside Front Anti-roll bar linkage ball joint dust cover insecure so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Offside Front Windscreen has a sticker or other obstruction encroaching into the swept area by more than 40mm outside zone `A` |8.3.1e| | 1 |
| Exhaust emissions exceed manufacturer`s specified limit |8.2.2.2 |a|| | 1 |
| Offside Front Coil spring fractured or broken |5.3.1 |b| |i|| | 1 |
| Nearside Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Nearside Parking brake inoperative on one side (1.4.1 (a)) | 1 |
| Offside Parking brake inoperative on one side (1.4.1 (a)) | 1 |
| Parking brake efficiency less than 50% of the required value (1.4.2 (a) (ii)) | 1 |
| Nearside Front Steering rack gaiter missing or no longer prevents the ingress of dirt |2.1.3 |g| |ii|| | 1 |
| Offside Rear rear brake excessively fluctuating |3.7.B.3| | 1 |
| Nearside Front Lower Suspension arm ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Drivers door cannot be opened from inside the vehicle (6.2.3 (a)) | 1 |
| Rear Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 1 |
| Offside Rear Shock absorber has a serious fluid leak |2.7.3| | 1 |
| Nearside Front Suspension arm pin or bush excessively worn |5.3.4 |a| |i|| | 1 |
| Offside Front Suspension arm pin or bush excessively worn |5.3.4 |a| |i|| | 1 |
| Nearside Rear Shock absorbers has a serious fluid leak | 1 |
| Nearside Rear Seat belt retracting mechanism defective |5.2.5b| | 1 |
| Offside Front Driver`s airbag obviously defective WARNING LIGHT STAYING ON |5.4.1| | 1 |
| Offside Front Front suspension has a loose unit in the upper support bearing assembly NOISY AND WORN |2.5.B.3b| | 1 |
| Nearside Front Body component damaged and likely to cause injury door mirror |6.2.1 |a| |i|| | 1 |
| Exhaust emits an excessive level of metered smoke for a turbo charged engine |7.4.B.3b| | 1 |