| Most common failures | No# failures |
|---|
| Headlamp aim out of alignment | 34 |
| Registration plate issues | 33 |
| Registration plate lamp issues | 18 |
| Anti-lock braking system warning lamp indicates an ABS fault | 13 |
| Exhaust emissions carbon monoxide content after 2nd fast idle excessive |7.3.D.3| | 9 |
| Exhaust emissions Lambda reading after 2nd fast idle outside specified limits |7.3.D.3| | 8 |
| Rear parking brake recording little or no effort | 7 |
| Horn not working |1.6.2a| | 7 |
| Parking brake: efficiency below requirements |3.7.B.7| | 6 |
| Windscreen wiper does not clear the windscreen effectively | 6 |
| Nearside Headlamp not working on dipped beam |1.7.5a| | 6 |
| Rear fog lamp not working |1.3.2b| | 5 |
| Exhaust emissions carbon monoxide content at idle excessive |7.3.D.4| | 4 |
| Offside Headlamp not working on dipped beam |1.7.5a| | 4 |
| Rear brake binding | 3 |
| Nearside Track rod end ball joint has excessive play |2.2.B.1f| | 3 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 3 |
| Offside Front Headlamp not working on dipped beam |1.7.5a| | 3 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 2 |
| Nearside Front Track rod end ball joint has excessive play |2.2.B.1f| | 2 |
| Parking brake lever has no reserve travel |3.1.6b| | 2 |
| Brakes imbalanced across an axle | 2 |
| Offside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 2 |
| Exhaust catalytic converter missing where one was fitted as standard |7.1.3| | 2 |
| Nearside Front Headlamp not working on dipped beam |1.7.5a| | 2 |
| Nearside Rear Shock absorber has a serious fluid leak |2.7.3| | 2 |
| Nearside Front Direction indicator not working |1.4.A.2c| | 2 |
| Offside Front Direction indicator not working |1.4.A.2c| | 2 |
| Nearside Passenger`s seat insecure |6.2.A.1| | 2 |
| Offside Rear fog lamp not working |1.3.2b| | 2 |
| Rear fog lamp tell tale not working |1.3.1b| | 2 |
| Windscreen washer not working | 2 |
| Nearside Rear Brake cable has restricted free movement |3.5.1k| | 2 |
| Offside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Nearside Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Position lamp switch faulty |1.1.A.1| | 1 |
| Position lamp switch does not illuminate the front and rear position lamps with a single operation |1.1.A.2| | 1 |
| Windscreen has a sticker or other obstruction encroaching into the swept area by more than 40mm outside zone `A` |8.3.1e| | 1 |
| Nearside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
| Offside Front Shock absorber has a serious fluid leak |2.7.3| | 1 |
| Offside Rear Shock absorber has a serious fluid leak |2.7.3| | 1 |
| Offside Rear Shock absorbers has a serious fluid leak | 1 |
| Nearside Rear Stop lamp not working |1.2.1b| | 1 |
| Service brake: efficiency below requirements |3.7.B.7| | 1 |
| Nearside Outer Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Nearside Front wheel bearing has excessive play |2.5.A.3c| | 1 |
| Hazard warning lamps inoperative |1.4.B.1b| | 1 |
| Offside Rear Rear reflector missing |1.5.1a| | 1 |
| Anti-lock braking system warning lamp does not illuminate |3.4.1b| | 1 |
| Exhaust emissions hydrocarbon content after 2nd fast idle excessive |7.3.D.3| | 1 |
| Nearside Stop lamp not working |1.2.1b| | 1 |
| Nearside Front Upper Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Nearside Rear Tie bar/rod has excessive play in a ball joint |2.4.G.2| | 1 |
| Offside Front Electrical wiring inadequately supported |1.9.2a| | 1 |
| Steering system has excessive free play detected at the steering wheel |steering rack fitted| |2.2.A.1b| | 1 |
| Nearside Inner Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Offside Inner Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Nearside Steering rack gaiter split |2.2.D.2d| | 1 |
| Offside Steering rack gaiter split |2.2.D.2d| | 1 |
| Nearside Front Lower Ball joint has excessive play |2.2.B.1f| | 1 |
| Offside Front Lower Ball joint has excessive play |2.2.B.1f| | 1 |
| All position lamps not working |1.1.A.3b| | 1 |
| Headlamp switch faulty |1.7.1| | 1 |
| Nearside Front Steering lock stop loose |2.2.D.2c| | 1 |
| Offside Rear Panhard rod has excessive play in a ball joint |2.4.G.2| | 1 |
| Offside Rear Rear fog lamp not working |1.3.2b| | 1 |
| Nearside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Driver`s door cannot be opened from outside the vehicle |6.2.B.1b| | 1 |
| Nearside Stop lamp|s| not working |4.3.1 |a| |ii|| | 1 |
| Offside Stop lamp|s| not working |4.3.1 |a| |ii|| | 1 |
| Offside Front Direction indicator not working |4.4.1 |a| |ii|| | 1 |
| Offside Rear Direction indicator not working |4.4.1 |a| |ii|| | 1 |
| Parking brake inoperative on one side low braking effort both sides |1.4.1 |a|| | 1 |
| Parking brake lever has excessive movement indicating incorrect adjustment no reserve travel on lever |1.1.6 |c|| | 1 |
| Parking brake efficiency less than 50% of the required value |1.4.2 |a| |ii|| | 1 |
| Offside Front Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
| Nearside Headlamp not working on main beam |1.7.5a| | 1 |
| Nearside Front position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
| Nearside Rear Tie bar/rod insecure |2.4.G.1| | 1 |
| Offside Front Coil spring mounting corroded and seriously weakened |2.4.C.3c| | 1 |
| Windscreen has damage | 1 |
| Front Hazard warning lamps not flashing in phase, with ignition on |1.4.B.1f| | 1 |
| Front Hazard warning lamps not flashing in phase, with ignition off |1.4.B.1f| | 1 |
| Exhaust noise is clearly in excess of that emitted by a similar vehicle fitted with a standard silencer in average condition |7.1.4| | 1 |
| Nearside Rear Shock absorber has negligible damping effect |2.7.5| | 1 |
| Nearside Front Shock absorber has negligible damping effect |2.7.5| | 1 |
| Driver`s seat insecure |6.2.A.1| | 1 |
| Offside Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 1 |
| Nearside Front Track rod end ball joint dust cover excessively damaged or deteriorated so that it no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |
| Brake lever has insufficient reserve travel (1.1.2 (a)) | 1 |
| Stop lamp(s) all not working (4.3.1 (a) (iii)) | 1 |
| Nearside Rear brake disc excessively pitted |3.5.1h| | 1 |
| Front Windscreen wiper blade deteriorated |8.2.2| | 1 |
| Offside Track rod end ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Hazard warning lamps not flashing in phase, with ignition on |1.4.B.1f| | 1 |
| Offside Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Rear Rear fog lamp not working |1.3.2b| | 1 |
| Front brake disc in such a condition that it is seriously weakened | 1 |
| Nearside Outer Rear brake disc excessively pitted |3.5.1h| | 1 |
| Offside Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Nearside Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Rear Tailgate cannot be secured in the closed position |6.4.1| | 1 |
| Offside Rear Brake cable has restricted free movement |3.5.1k| | 1 |
| Nearside Rear brake caliper has restricted free movement |3.5.1k| | 1 |
| Front passenger door cannot be opened from outside the vehicle |6.2.B.1b| | 1 |
| Nearside Inner Rear Tie bar/rod has excessive play in a ball joint |2.4.G.2| | 1 |
| Nearside Front Shock absorber has a serious fluid leak |2.7.3| | 1 |
| Nearside Headlamp not working on dipped beam |4.1.1 |a| |ii|| | 1 |
| Fuel cap/sealing device does not fasten securely maintaining the sealing arrangement |7.2.4b| | 1 |
| Windscreen wiper control missing |8.2.1a| | 1 |
| Windscreen wiper control is inaccessible to the driver |8.2.1a| | 1 |
| Nearside Rear Brake cable locking device insecure |3.5.1l| | 1 |
| Rear brake application uneven | 1 |
| Emissions not tested |7.0| | 1 |
| Braking system leaking |3.6.A.1| | 1 |