| Most common failures | No# failures |
|---|
| Brake pipe excessively corroded | 27 |
| Parking brake: efficiency below requirements |3.7.B.7| | 21 |
| Headlamp aim out of alignment | 15 |
| Windscreen wiper does not clear the windscreen effectively | 15 |
| Exhaust emissions carbon monoxide content after 2nd fast idle excessive |7.3.D.3| | 14 |
| Registration plate lamp issues | 12 |
| Exhaust emissions Lambda reading after 2nd fast idle outside specified limits |7.3.D.3| | 9 |
| Rear parking brake recording little or no effort | 7 |
| Parking brake lever has no reserve travel |3.1.6b| | 7 |
| Rear brake binding | 6 |
| Exhaust has a major leak of exhaust gases |7.1.2| | 6 |
| Anti-lock braking system warning lamp indicates an ABS fault | 5 |
| Registration plate issues | 5 |
| Rear Exhaust has a major leak of exhaust gases |7.1.2| | 5 |
| Offside Front Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 5 |
| Rear brake disc in such a condition that it is seriously weakened | 5 |
| Nearside Rear Service brake excessively binding (1.2.1 (f)) | 4 |
| Nearside Front Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 4 |
| Service brake: efficiency below requirements |3.7.B.7| | 4 |
| Centre Exhaust has a major leak of exhaust gases |7.1.2| | 4 |
| Offside Rear Service brake excessively binding (1.2.1 (f)) | 3 |
| Centre Exhaust mounting missing |7.1.1b| | 3 |
| Offside Rear fog lamp not working |1.3.2b| | 3 |
| Exhaust mounting missing |7.1.1b| | 3 |
| Offside Rear coil spring fractured |2.4.C.1a| | 3 |
| Rear fog lamp not working (4.5.1 (a) (ii)) | 2 |
| Offside Side repeater not working |1.4.A.2c| | 2 |
| Windscreen has damage | 2 |
| Nearside Rear Sub-frame rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 2 |
| Offside Rear Sub-frame rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 2 |
| Nearside Stop lamp not working |1.2.1b| | 2 |
| Nearside Headlamp insecure |1.7.3| | 2 |
| Nearside Front Steering pivot point has excessive play |2.2.B.1g| | 2 |
| Nearside Rear coil spring incomplete |2.4.C.1a| | 2 |
| Emissions not tested |7.0| | 2 |
| Horn not working |1.6.2a| | 2 |
| Rear Mechanical brake component has restricted free movement | 2 |
| Nearside Front Front position lamp|s| not working |1.1.A.3b| | 2 |
| Battery insecure |1.9.1| | 2 |
| Exhaust emissions hydrocarbon content after 2nd fast idle excessive |7.3.D.3| | 2 |
| Offside Headlamp insecure |1.7.3| | 2 |
| Offside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
| Direction indicators not working |1.4.A.2c| | 2 |
| Front brake disc in such a condition that it is seriously weakened | 2 |
| Nearside Intermediate drop arm deformed and unserviceable |2.2.C.1d| | 1 |
| Offside Front Suspension arm ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Offside Rear Coil spring fractured or broken (5.3.1 (b) (i)) | 1 |
| Offside Rear Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting poor repair (6.2.2 (d) (i)) | 1 |
| Parking brake efficiency less than 50% of the required value (1.4.2 (a) (ii)) | 1 |
| Nearside Front Front wheel bearing rough when rotated |2.5.A.2| | 1 |
| Offside Front Front wheel bearing rough when rotated |2.5.A.2| | 1 |
| Nearside Front Shock absorber insecure bolts to hub |2.7.2b| | 1 |
| Offside Front Shock absorber insecure bolts to hub |2.7.2b| | 1 |
| Nearside Side repeater not working |1.4.A.2c| | 1 |
| Front Front position lamp|s| incorrect colour |1.1.A.3e| | 1 |
| Rear Rear fog lamp not working |1.3.2b| | 1 |
| Front Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Front coil spring incomplete |2.4.C.1a| | 1 |
| Offside Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Rear Exhaust emits visible black smoke at idle |7.3.A.2b| | 1 |
| Nearside Front Steering system fouling |2.2.D.2a| | 1 |
| Nearside Rear Seat belt stitching badly frayed |5.2.2b| | 1 |
| Steering wheel in a condition that hampers proper control |2.1.1| | 1 |
| Exhaust tailpipe not capable of allowing the emission probe to be inserted |7.3.D.1| | 1 |
| Nearside Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Offside Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Exhaust engine idle speed too high |7.3.D.1| | 1 |
| Nearside Rear Bonded suspension unit bonding failed and part of unit is likely to become displaced |2.4.F.2| | 1 |
| Offside Rear Bonded suspension unit bonding failed and part of unit is likely to become displaced |2.4.F.2| | 1 |
| Nearside Rear Brake linkage has abnormal movement of levers indicating maladjustment |3.5.1f| | 1 |
| Driver`s door cannot be opened from outside the vehicle |6.2.B.1b| | 1 |
| Centre Exhaust system not adequately supported |7.1.1| | 1 |
| Nearside Inner Drag link end ball joint has excessive play |2.2.B.1f| | 1 |
| Offside Inner Drag link end ball joint has excessive play |2.2.B.1f| | 1 |
| Offside Front Subframe mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Fuel cap/sealing device does not fasten securely maintaining the sealing arrangement |7.2.4b| | 1 |
| Nearside Front Windscreen wiper blade deteriorated |8.2.2| | 1 |
| Nearside Front Headlamp not working on dipped beam |1.7.5a| | 1 |
| Nearside Front Side repeater incorrect colour |1.4.A.2f| | 1 |
| Offside Rear Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Steering arm damaged and unserviceable |2.2.C.1d| | 1 |
| Nearside Front Direction indicator not working |1.4.A.2c| | 1 |
| Nearside Front passenger door cannot be opened from outside the vehicle |6.2.B.1b| | 1 |
| Nearside Front Lower Anti-roll bar linkage has excessive play in a ball joint |2.4.G.2| | 1 |
| Front Exhaust mounting missing |7.1.1b| | 1 |
| Nearside Rear brake disc excessively pitted |3.5.1h| | 1 |
| Offside Rear brake disc excessively pitted |3.5.1h| | 1 |
| Offside Driver`s seat insecure |6.2.A.1| | 1 |
| Nearside Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Rear fog lamp tell tale not working |1.3.1b| | 1 |
| Horn not a continuous or uniform sound |1.6.2e| | 1 |
| Nearside Lower Suspension arm ball joint dust cover missing |2.4.G.2| | 1 |
| Offside Rear Rear fog lamp not working |1.3.2b| | 1 |
| Offside Front Hazard warning lamps inoperative side & rear (4.4.1 (e)) | 1 |
| Rear Exhaust mounting missing |7.1.1b| | 1 |
| Rear Exhaust system not adequately supported |7.1.1| | 1 |
| Nearside Rear Shock absorber has a serious fluid leak |2.7.3| | 1 |
| Nearside Front Lower Ball joint has excessive play |2.2.B.1f| | 1 |
| Nearside Steering pivot point has excessive play |2.2.B.1g| | 1 |
| Exhaust emits excessive dense blue smoke during acceleration |7.3.A.2c| | 1 |
| Brake pedal spongy |3.3.B.1b| | 1 |
| Fuel cap/sealing device sealing washer missing |7.2.4c| | 1 |
| Nearside Front brake caliper leaking |3.6.A.1| | 1 |
| Offside Rear fog lamp excessively damaged so that it is not visible from a reasonable distance |1.3.2d| | 1 |
| Nearside Inner Front Subframe mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Windscreen washer not working | 1 |
| Offside Front Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Offside Rear Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Emissions unable to be completed engine cuts out when warm (8.2.1.2 (d)) | 1 |
| Brakes imbalanced across an axle | 1 |
| Offside Front Position lamp not working |4.2.1 |a|| | 1 |
| Offside Side repeater not working |4.4.1 |a| |ii|| | 1 |
| Offside Front Inner Track rod end ball joint has excessive play |2.1.3 |b| |i|| | 1 |
| Offside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength |5.3.6 |a| |i|| | 1 |
| Nearside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength |5.3.6 |a| |i|| | 1 |
| Nearside Rear Outer Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt |6.1.7 |g| |ii|| | 1 |
| Direction indicator incorrect colour (4.4.3 (a)) | 1 |
| Nearside Front brake disc excessively pitted |3.5.1h| | 1 |
| Offside Front brake disc excessively pitted |3.5.1h| | 1 |
| Nearside Rear position lamp|s| excessively damaged so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Nearside Rear Direction indicator not working |1.4.A.2c| | 1 |
| Nearside Rear Stop lamp not working |1.2.1b| | 1 |
| Rear Parking brake: efficiency below requirements |3.7.B.7| | 1 |
| Nearside Headlamp not working on dipped beam |1.7.5a| | 1 |
| Offside Headlamp not working on dipped beam |1.7.5a| | 1 |
| Rear fog lamp not working |1.3.2b| | 1 |
| Offside Rear coil spring broken |2.4.C.1a| | 1 |
| Nearside Rear Subframe mounting prescribed area is excessively corroded inner and outer sills |2.4.A.3| | 1 |
| Offside Rear Subframe mounting prescribed area is excessively corroded inner and outer sills |2.4.A.3| | 1 |
| Rear fog lamp switch inoperative (4.5.3 (a)) | 1 |
| Offside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength Inner wheel arch to sill closing panel (5.3.6 (a) (i)) | 1 |
| Nearside Rear Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Exhaust emissions carbon monoxide content excessive |7.3.B.1a| | 1 |
| Nearside Headlamp levelling device inoperative |4.1.5 |a|| | 1 |
| Exhaust has a major leak of exhaust gases |6.1.2 |a|| | 1 |
| Parking brake efficiency below requirements |1.4.2 |a| |i|| | 1 |
| Offside Front Steering component mounting prescribed area is excessively corroded |2.2.C.1h| | 1 |
| Rear brake application uneven | 1 |
| Fuel tank leaking |7.2.3| | 1 |
| Offside Front Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Offside Rear Fuel tank leaking |7.2.3| | 1 |
| Nearside Rear Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Rear Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Front Anti-roll bar linkage has excessive play in a ball joint |2.4.G.2| | 1 |
| Offside Front Direction indicator not working |1.4.A.2c| | 1 |
| Fuel pipe leaking |7.2.3| | 1 |
| Rear passenger seat cannot be secured in the upright position. |6.2.3| | 1 |
| Nearside Rear Road wheel cracked |4.2.A.1a| | 1 |
| Hazard warning switch faulty |1.4.B.1d| | 1 |
| Offside Rear coil spring incomplete |2.4.C.1a| | 1 |
| Nearside Front Subframe mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Headlamp not working on main beam |4.1.1 |a| |ii|| | 1 |
| Front Stop lamp not working |1.2.1b| | 1 |
| Rear fog lamp switch faulty |1.3.1a| | 1 |
| Nearside Rear position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
| Offside Rear position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
| Centre Rear Exhaust has a major leak of exhaust gases |7.1.2| | 1 |