| Most common failures | No# failures |
|---|
| Brake pipe excessively corroded | 162 |
| Headlamp aim out of alignment | 91 |
| Offside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 69 |
| Windscreen wiper does not clear the windscreen effectively | 61 |
| Nearside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 56 |
| Registration plate lamp issues | 52 |
| Parking brake: efficiency below requirements |3.7.B.7| | 52 |
| Offside Rear Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 47 |
| Exhaust emissions carbon monoxide content after 2nd fast idle excessive |7.3.D.3| | 36 |
| Nearside Rear Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 32 |
| Offside Rear Subframe mounting prescribed area is excessively corroded |2.4.A.3| | 30 |
| Nearside Rear Subframe mounting prescribed area is excessively corroded |2.4.A.3| | 27 |
| Parking brake lever has no reserve travel |3.1.6b| | 25 |
| Rear parking brake recording little or no effort | 25 |
| Centre Exhaust has a major leak of exhaust gases |7.1.2| | 23 |
| Offside Rear Body has a sharp edge caused by corrosion |6.1.C.1| | 22 |
| Exhaust has a major leak of exhaust gases |7.1.2| | 22 |
| Brakes imbalanced across an axle | 21 |
| Offside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 21 |
| Rear Exhaust has a major leak of exhaust gases |7.1.2| | 20 |
| Exhaust emissions Lambda reading after 2nd fast idle outside specified limits |7.3.D.3| | 20 |
| Registration plate issues | 19 |
| Anti-lock braking system warning lamp indicates an ABS fault | 19 |
| Nearside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 18 |
| Front brake disc in such a condition that it is seriously weakened | 17 |
| Offside Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 17 |
| Windscreen has damage | 15 |
| Offside Rear coil spring incomplete |2.4.C.1a| | 14 |
| Nearside Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 13 |
| Offside Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 13 |
| Nearside Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 13 |
| Nearside Rear coil spring incomplete |2.4.C.1a| | 12 |
| Nearside Front Track rod end ball joint has excessive play |2.2.B.1f| | 11 |
| Exhaust emissions carbon monoxide content at idle excessive |7.3.D.4| | 11 |
| Nearside Stop lamp not working |1.2.1b| | 10 |
| Rear Exhaust has part of the system excessively deteriorated |7.1.1a| | 10 |
| Nearside Front Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 10 |
| Nearside Rear Body has a sharp edge caused by corrosion |6.1.C.1| | 9 |
| Exhaust emissions carbon monoxide content excessive |7.3.B.1a| | 9 |
| Emissions not tested |7.0| | 9 |
| Brake hose excessively deteriorated | 9 |
| Offside Front Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 9 |
| Rear brake binding | 9 |
| Offside Front brake disc excessively pitted |3.5.1h| | 9 |
| Offside Front Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 9 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 8 |
| Nearside Headlamp insecure |1.7.3| | 8 |
| Offside Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 8 |
| Exhaust mounting missing |7.1.1b| | 8 |
| Nearside Front brake disc excessively pitted |3.5.1h| | 8 |
| Fuel tank leaking |7.2.3| | 8 |
| Offside Stop lamp not working |1.2.1b| | 7 |
| Offside Front Suspension arm has excessive play in a ball joint |2.4.G.2| | 7 |
| Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 7 |
| Offside Rear fog lamp not working |1.3.2b| | 7 |
| Nearside Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 7 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 7 |
| Exhaust emissions hydrocarbon content after 2nd fast idle excessive |7.3.D.3| | 7 |
| Rear Exhaust system not adequately supported |7.1.1| | 6 |
| Nearside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 6 |
| Offside Front Windscreen wiper blade deteriorated |8.2.2| | 6 |
| Service brake: efficiency below requirements |3.7.B.7| | 6 |
| Nearside Rear Lower Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 6 |
| Offside Side repeater not working |1.4.A.2c| | 6 |
| Nearside Front Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 6 |
| Offside Outer Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 6 |
| Centre Exhaust mounting missing |7.1.1b| | 6 |
| Nearside Rear Sub-frame rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 6 |
| Offside Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 6 |
| Offside Rear Sub-frame rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 6 |
| Offside Track rod end ball joint has excessive play |2.2.B.1f| | 6 |
| Offside Front Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 5 |
| Offside Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 5 |
| Offside Front Track rod end ball joint has excessive play |2.2.B.1f| | 5 |
| Centre Exhaust has part of the system excessively deteriorated |7.1.1a| | 5 |
| Nearside Front Lower Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 5 |
| Rear fog lamp tell tale not working |1.3.1b| | 5 |
| Nearside Rear coil spring fractured |2.4.C.1a| | 5 |
| Nearside Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 5 |
| Nearside Outer Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 5 |
| Nearside Front Anti-roll bar linkage has excessive play in a ball joint |2.4.G.2| | 5 |
| Nearside Front Steering pivot point has excessive play |2.2.B.1g| | 5 |
| Nearside Rear Stop lamp not working |1.2.1b| | 5 |
| Offside Front Upper Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 5 |
| Nearside Front Vehicle structure has excessive corrosion which adversely affects braking or steering |6.1.A.1| | 5 |
| Exhaust tailpipe not capable of allowing the emission probe to be inserted |7.3.D.1| | 5 |
| Nearside Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 4 |
| Offside Inner Track rod end ball joint has excessive play |2.2.B.1f| | 4 |
| Front brake application uneven | 4 |
| Offside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 4 |
| Front passenger door cannot be opened from outside the vehicle |6.2.B.1b| | 4 |
| Offside Headlamp insecure |1.7.3| | 4 |
| Windscreen wiper blade insecure | 4 |
| Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 4 |
| Front Exhaust has a major leak of exhaust gases |7.1.2| | 4 |
| Nearside Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 4 |
| Fuel system component leaking |7.2.3| | 4 |
| Offside Windscreen wiper blade deteriorated |8.2.2| | 4 |
| Offside Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 4 |
| Rear Exhaust mounting missing |7.1.1b| | 4 |
| Horn not working |1.6.2a| | 4 |
| Offside Rear Lower Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 4 |
| Body has a sharp edge caused by corrosion |6.1.C.1| | 4 |
| Hazard warning switch faulty |1.4.B.1d| | 4 |
| Rear brake application uneven | 4 |
| Offside Rear position lamp|s| not working |1.1.A.3b| | 3 |
| Offside Rear coil spring fractured |2.4.C.1a| | 3 |
| Rear Fuel pipe leaking |7.2.3| | 3 |
| Nearside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 3 |
| Offside Front Macpherson strut has excessive movement at the upper attachment |2.5.A.1c| | 3 |
| Offside Rear coil spring broken |2.4.C.1a| | 3 |
| Offside Rear Vehicle structure has excessive corrosion which adversely affects braking or steering |6.1.A.1| | 3 |
| Offside Rear coil spring cracked |2.4.C.1a| | 3 |
| Offside Front Suspension arm rubber bush bonding deteriorated resulting in excessive movement |2.4.G.2| | 3 |
| Offside Front Shock absorber has a serious fluid leak |2.7.3| | 3 |
| Brake performance not tested |3.7.A.1| | 3 |
| Offside Front Lower Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 3 |
| Offside Front Steering component mounting prescribed area is excessively corroded |2.2.C.1h| | 3 |
| Nearside Front Shock absorber has a serious fluid leak |2.7.3| | 3 |
| Offside Front Bonded suspension unit bonding failed and part of unit is likely to become displaced |2.4.F.2| | 3 |
| Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 3 |
| Nearside Front Upper Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 3 |
| Nearside Subframe mounting prescribed area is excessively corroded |2.4.A.3| | 3 |
| Offside Subframe mounting prescribed area is excessively corroded |2.4.A.3| | 3 |
| Nearside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 3 |
| Centre Exhaust system not adequately supported |7.1.1| | 3 |
| Windscreen has a sticker or other obstruction encroaching into the swept area by more than 40mm outside zone `A` |8.3.1e| | 3 |
| Battery insecure |1.9.1| | 3 |
| Offside Headlamp not working on main beam |1.7.5a| | 3 |
| Offside Front brake disc excessively scored |3.5.1h| | 3 |
| Driver`s door cannot be opened from outside the vehicle |6.2.B.1b| | 3 |
| Offside Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 3 |
| Nearside Outer Rear Subframe mounting prescribed area is excessively corroded |2.4.A.3| | 3 |
| Nearside Rear Exhaust has a major leak of exhaust gases |7.1.2| | 3 |
| Offside Outer Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 3 |
| Offside Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 3 |
| Offside Front Front position lamp|s| not working |1.1.A.3b| | 3 |
| Nearside Steering pivot point has excessive play |2.2.B.1g| | 3 |
| Offside Front Vehicle structure has excessive corrosion which adversely affects braking or steering |6.1.A.1| | 3 |
| Nearside Rear Lower Subframe mounting prescribed area is excessively corroded |2.4.A.3| | 3 |
| Offside Rear Lower Subframe mounting prescribed area is excessively corroded |2.4.A.3| | 3 |
| Rear Rear fog lamp not working |1.3.2b| | 3 |
| Front brake disc excessively pitted |3.5.1h| | 3 |
| Front Fuel pipe leaking |7.2.3| | 3 |
| Nearside Windscreen wiper blade deteriorated |8.2.2| | 3 |
| Rear brake disc in such a condition that it is seriously weakened | 3 |
| Nearside Side repeater incomplete |1.5.A1b| | 3 |
| Nearside Headlamp not in good working order adversely affecting beam image |1.2.4a| | 3 |
| Nearside Track rod end ball joint has excessive play |2.2.B.1f| | 3 |
| Anti-lock braking system warning lamp does not illuminate |3.4.1b| | 3 |
| Nearside Front Front position lamp|s| not working |1.1.A.3b| | 3 |
| Offside Rear brake disc excessively scored |3.5.1h| | 2 |
| Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 2 |
| Nearside Rear position lamp|s| not working |1.1.A.3b| | 2 |
| Bootlid cannot be secured in the closed position |6.4.1| | 2 |
| Offside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 2 |
| Exhaust carbon monoxide content after 2nd fast idle exceeds manufacturers specified limits (8.2.1.2 (a)) | 2 |
| Offside Rear Rear fog lamp not working |1.3.2b| | 2 |
| Nearside Front Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 2 |
| Nearside Outer Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
| Offside Outer Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
| Centre Rear Exhaust has a major leak of exhaust gases |7.1.2| | 2 |
| Nearside Front Upper Vehicle structure has excessive corrosion which adversely affects braking or steering |6.1.A.1| | 2 |
| Nearside Front Lower Vehicle structure has excessive corrosion which adversely affects braking or steering |6.1.A.1| | 2 |
| front brakes release unevenly |3.7.B.4| | 2 |
| Nearside Front Steering component mounting prescribed area is excessively corroded |2.2.C.1h| | 2 |
| Front Fuel hose leaking |7.2.3| | 2 |
| Offside Front Direction indicators incorrect colour |1.4.A.2f| | 2 |
| Fuel hose leaking |7.2.3| | 2 |
| Nearside Front Suspension arm rubber bush bonding deteriorated resulting in excessive movement |2.4.G.2| | 2 |
| Rear Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 2 |
| Offside Rear Brake lever has restricted free movement |3.5.1k| | 2 |
| Nearside Brake cable locking device missing |3.5.1l| | 2 |
| Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 2 |
| Offside Front Subframe mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
| Offside Rear Sub-frame has excessive play in a pin/bush |2.4.G.2| | 2 |
| Nearside Front front brake binding |3.7.B.1| | 2 |
| Offside Front front brake binding |3.7.B.1| | 2 |
| Offside Front Direction indicator incomplete |1.5.A1b| | 2 |
| Nearside Front Front suspension has excessive movement at a wishbone pin or bush |2.5.A.1c| | 2 |
| brake disc excessively pitted |3.5.1h| | 2 |
| Nearside Front Bonded suspension unit bonding failed and part of unit is likely to become displaced |2.4.F.2| | 2 |
| Offside Outer Track rod end ball joint has excessive play |2.2.B.1f| | 2 |
| Rear Mechanical brake component has restricted free movement | 2 |
| Offside Side repeater incomplete |1.5.A1b| | 2 |
| Front passenger door cannot be opened from inside the vehicle |6.2.B.1b| | 2 |
| Body has a sharp edge caused by damage |6.1.C.1| | 2 |
| Nearside Side repeater incorrect colour |1.4.A.2f| | 2 |
| Nearside Inner Track rod end ball joint has excessive play |2.2.B.1f| | 2 |
| Nearside Rear Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 2 |
| Nearside Front brake disc excessively scored |3.5.1h| | 2 |
| Nearside Front Subframe mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
| Nearside Front Side repeater not working |1.4.A.2c| | 2 |
| Nearside Front Suspension arm has excessive play in a ball joint |2.4.G.2| | 2 |
| Nearside Front Steering arm has relative movement at its fixings |2.2.B.1h| | 2 |
| Rear brake disc excessively pitted |3.5.1h| | 2 |
| Offside Front Direction indicator not working |1.4.A.2c| | 2 |
| Offside Headlamp not working on dipped beam |1.7.5a| | 2 |
| Exhaust system not adequately supported |7.1.1| | 2 |
| Nearside Front Road wheel badly damaged |4.2.A.1a| | 2 |
| Rear Stop lamp(s) all not working (4.3.1 (a) (iii)) | 2 |
| Offside front brake binding |3.7.B.1| | 2 |
| Exhaust emissions hydrocarbon content excessive |7.3.B.1b| | 2 |
| Nearside Outer Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 2 |
| Nearside Front Suspension arm has excessive play in a pin/bush |2.4.G.2| | 2 |
| Nearside Front passenger door cannot be opened from inside the vehicle |6.2.B.1b| | 2 |
| Nearside Exhaust has a major leak of exhaust gases |7.1.2| | 2 |
| Battery insecure and likely to cause a short circuit (4.13 (a) (ii)) | 2 |
| Offside Front Upper Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
| Parking brake: efficiency below requirements |3.7.D.4| | 2 |
| Offside Front Anti-roll bar has excessive play in a ball joint |2.4.G.2| | 2 |
| Parking brake efficiency below requirements (1.4.2 (a) (i)) | 2 |
| Centre Rear Exhaust mounting missing |7.1.1b| | 2 |
| Offside Outer Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 2 |
| Nearside Outer Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 2 |
| Nearside Rear Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 2 |
| Offside Rear Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 2 |
| Offside Rear Direction indicator incorrect colour |1.4.A.2f| | 2 |
| Brake pedal spongy |3.3.B.1b| | 2 |
| Offside Rear Brake cable has wires broken and is significantly weakened |3.5.1b| | 2 |
| Nearside Exhaust mounting missing |7.1.1b| | 2 |
| Driver`s door cannot be opened from inside the vehicle |6.2.B.1b| | 2 |
| Rear coil spring incomplete |2.4.C.1a| | 2 |
| Offside Rear Shock absorber has a serious fluid leak |2.7.3| | 2 |
| Hazard warning lamps not flashing in phase, with ignition on |1.4.B.1f| | 2 |
| Offside Rear fog lamp obscured more than 50% |1.3.2c| | 2 |
| Offside Rear Lower Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
| Horn not working (7.7 (a) (ii)) | 2 |
| Nearside Stop lamp adversely affected by the operation of another lamp |1.2.1f| | 2 |
| Nearside Rear Shock absorber has a serious fluid leak |2.7.3| | 2 |
| Nearside Rear Outer Drive shaft which forms part of the suspension coupling gaiter insecure to the extent that it no longer prevents the ingress of dirt etc |2.4.G.4e| | 2 |
| Offside Outer Rear Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 2 |
| Offside Front Braking system leaking |3.6.A.1| | 2 |
| Nearside Headlamp aim not tested |1.8.A.1c| | 2 |
| Nearside Rear Lower Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
| Nearside Front Lower Ball joint has excessive play |2.2.B.1f| | 2 |
| Nearside Rear Exhaust has part of the system excessively deteriorated |7.1.1a| | 2 |
| Fuel pipe leaking |7.2.3| | 2 |
| Offside Rear Bonded suspension unit bonding failed and part of unit is likely to become displaced |2.4.F.2| | 2 |
| Nearside Inner Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
| Offside Obligatory mirror seriously damaged, affecting the rear view |8.1.2a| | 2 |
| Exhaust has a part missing |7.1.1a| | 2 |
| Offside Front Side repeater not working |1.4.A.2c| | 2 |
| Nearside Front Lower Suspension arm rubber bush bonding deteriorated resulting in excessive movement |2.4.G.2| | 2 |
| Nearside Rear Vehicle structure is damaged, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 2 |
| Offside Obligatory mirror missing |8.1.1| | 2 |
| Nearside Rear brake disc excessively pitted |3.5.1h| | 2 |
| Nearside Outer Track rod end ball joint has excessive play |2.2.B.1f| | 2 |
| Offside Outer Rear Subframe mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
| Nearside Front coil spring incomplete |2.4.C.1a| | 2 |