| Most common failures | No# failures |
|---|
| Headlamp aim out of alignment | 55 |
| Registration plate lamp issues | 46 |
| Brake pipe excessively corroded | 32 |
| Windscreen wiper does not clear the windscreen effectively | 23 |
| Nearside Rear coil spring incomplete |2.4.C.1a| | 13 |
| Exhaust emissions Lambda reading after 2nd fast idle outside specified limits |7.3.D.3| | 11 |
| Exhaust has a major leak of exhaust gases |7.1.2| | 11 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 10 |
| Nearside Rear Direction indicator incorrect colour |1.4.A.2f| | 10 |
| Front brake disc in such a condition that it is seriously weakened | 10 |
| Rear Exhaust has a major leak of exhaust gases |7.1.2| | 9 |
| Offside Rear coil spring incomplete |2.4.C.1a| | 9 |
| Offside Rear Direction indicator incorrect colour |1.4.A.2f| | 9 |
| Nearside Front Track rod end ball joint has excessive play |2.2.B.1f| | 7 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 7 |
| Brakes imbalanced across an axle | 6 |
| Parking brake lever has no reserve travel |3.1.6b| | 6 |
| Offside Track rod end ball joint has excessive play |2.2.B.1f| | 6 |
| Rear Exhaust has part of the system excessively deteriorated |7.1.1a| | 5 |
| Offside Front Track rod end ball joint has excessive play |2.2.B.1f| | 5 |
| Parking brake: efficiency below requirements |3.7.B.7| | 5 |
| Windscreen has damage | 5 |
| Centre Exhaust has a major leak of exhaust gases |7.1.2| | 5 |
| Offside Front Anti-roll bar linkage has excessive play in a ball joint |2.4.G.2| | 5 |
| Rear Exhaust system not adequately supported |7.1.1| | 5 |
| Offside Rear Shock absorber has a serious fluid leak |2.7.3| | 4 |
| Exhaust emissions carbon monoxide content after 2nd fast idle excessive |7.3.D.3| | 4 |
| Exhaust emissions hydrocarbon content after 2nd fast idle excessive |7.3.D.3| | 4 |
| Nearside Rear Shock absorber has a serious fluid leak |2.7.3| | 4 |
| Nearside Front Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 4 |
| Rear parking brake recording little or no effort | 4 |
| Nearside Track rod end ball joint has excessive play |2.2.B.1f| | 4 |
| Nearside Stop lamp not working |1.2.1b| | 4 |
| Offside Rear coil spring broken |2.4.C.1a| | 4 |
| Offside Headlamp not working on dipped beam |1.7.5a| | 4 |
| Rear fog lamp not working |1.3.2b| | 4 |
| Anti-lock braking system warning lamp indicates an ABS fault | 4 |
| Nearside Front Lower Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 4 |
| Offside Outer Track rod end ball joint has excessive play |2.2.B.1f| | 3 |
| Front Exhaust has a major leak of exhaust gases |7.1.2| | 3 |
| Nearside Rear coil spring broken |2.4.C.1a| | 3 |
| Emissions not tested |7.0| | 3 |
| Nearside Steering pivot point has excessive play |2.2.B.1g| | 3 |
| Nearside Headlamp excessively damaged so that the light output is severely reduced |1.7.5a| | 3 |
| Brake pedal anti-slip provision incomplete |3.3.A.1b| | 3 |
| Offside Rear coil spring fractured |2.4.C.1a| | 3 |
| Offside Rear fog lamp not working |1.3.2b| | 3 |
| Registration plate issues | 3 |
| Offside Exhaust has a major leak of exhaust gases |7.1.2| | 2 |
| Nearside Front Steering arm has relative movement at its fixings |2.2.B.1h| | 2 |
| Exhaust tailpipe not capable of allowing the emission probe to be inserted |7.3.D.1| | 2 |
| Windscreen has a sticker or other obstruction encroaching by more than 10mm within zone `A` |8.3.1b| | 2 |
| Nearside Front Anti-roll bar linkage has excessive play in a ball joint |2.4.G.2| | 2 |
| Offside Front Seat belt retracting mechanism defective |5.2.5b| | 2 |
| Battery insecure |1.9.1| | 2 |
| Offside Obligatory mirror insecure |8.1.1| | 2 |
| Nearside Headlamp not in good working order adversely affecting beam image |1.2.4a| | 2 |
| Offside Front Lower Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 2 |
| Nearside Rear coil spring fractured |2.4.C.1a| | 2 |
| Offside Front Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 2 |
| Nearside Front brake disc excessively pitted |3.5.1h| | 2 |
| Nearside Headlamp not working on dipped beam |1.7.5a| | 2 |
| Nearside Front Headlamp not working on dipped beam |1.7.5a| | 2 |
| Exhaust emissions carbon monoxide content at idle excessive |7.3.D.4| | 2 |
| Front Exhaust system not adequately supported |7.1.1| | 2 |
| Offside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 2 |
| Rear Shock absorber has a serious fluid leak |2.7.3| | 2 |
| Exhaust emissions carbon monoxide content excessive |7.3.B.1a| | 2 |
| Nearside Front Suspension arm has excessive play in a pin/bush |2.4.G.2| | 2 |
| Offside Headlamp excessively damaged so that the light output is severely reduced |1.7.5a| | 2 |
| Nearside Steering arm has relative movement at its fixings |2.2.B.1h| | 2 |
| Exhaust has part of the system excessively deteriorated |7.1.1a| | 2 |
| Rear Direction indicator incorrect colour |1.4.A.2f| | 2 |
| Centre Rear Seat belt retracting mechanism defective |5.2.5b| | 2 |
| Rear brake application uneven | 2 |
| Rear Direction indicators incorrect colour |1.4.A.2f| | 1 |
| Front Power steering component|s| leaking |2.3.3b| | 1 |
| Headlamp switch faulty |1.7.1| | 1 |
| Centre Upper Stop lamp adversely affected by the operation of another lamp flickers on and off |1.2.1f| | 1 |
| Exhaust has a major leak of exhaust gases middle box |7.1.2| | 1 |
| Offside Front Road wheel fixing missing wheel bolt (5.2.1 (a) (i)) | 1 |
| Trailer electrical socket (13 pin) not operating the trailer lamps as intended fog light function not working and cuts off all other lights (4.10 (c) (i)) | 1 |
| Nearside Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Nearside Front Headlamp light intensity severely reduced |4.1.4 |a|| | 1 |
| Offside Front Headlamp light intensity severely reduced |4.1.4 |a|| | 1 |
| Nearside Rear Service brake lagging in operation |1.2.1 |d|| | 1 |
| Service brake efficiency below requirements |1.2.2 |a| |i|| | 1 |
| Offside Rear Seat belt damaged sufficient to significantly weakened the webbing |5.2.2a| | 1 |
| Nearside Front Tie bar/rod has excessive play in a ball joint |2.4.G.2| | 1 |
| Offside Rear rear brake recording little or no effort |3.7.B.5a| | 1 |
| Service brake: efficiency below requirements |3.7.B.7| | 1 |
| Offside Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
| Offside Front Brake hose twisted |3.6.B.4c| | 1 |
| Nearside Front Steering column flexible coupling has excessive play |2.1.5| | 1 |
| Offside Front Steering column flexible coupling has excessive play |2.1.5| | 1 |
| Nearside Rear Rear position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
| Offside Front Track rod end loose |2.2.B.1d| | 1 |
| Nearside Drag link end ball joint has excessive play |2.2.B.1f| | 1 |
| Nearside Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Nearside Rear Stop lamp excessively damaged so that it is not visible from a reasonable distance |1.2.1d| | 1 |
| Nearside Rear Front suspension has excessive movement at a wishbone pin or bush |2.5.A.1c| | 1 |
| Offside Front Front suspension has excessive movement at a wishbone pin or bush |2.5.A.1c| | 1 |
| Nearside Rear Direction indicators incorrect colour |1.4.A.2f| | 1 |
| Offside Rear Direction indicators incorrect colour |1.4.A.2f| | 1 |
| Front Exhaust has part of the system excessively deteriorated |7.1.1a| | 1 |
| Rear Fuel system component leaking |7.2.3| | 1 |
| Front brake disc excessively pitted |3.5.1h| | 1 |
| Nearside Front Ball joint has excessive play |2.2.B.1f| | 1 |
| Nearside Front Brake hose twisted |found during steering lock to lock check| |2.2.D.2b| | 1 |
| Offside Front brake disc excessively scored |3.5.1h| | 1 |
| Nearside Rear Passenger`s seat cannot be secured in the upright position. |6.2.A.2| | 1 |
| Offside Front brake disc excessively pitted |3.5.1h| | 1 |
| Offside Rear Rear fog lamp not working |1.3.2b| | 1 |
| Centre Seat belt attachment fitting badly deteriorated |5.2.3| | 1 |
| Headlamp not working on dipped beam |1.7.5a| | 1 |
| Headlamp aim not tested |1.8.A.1c| | 1 |
| Nearside Inner Front Lower Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Inner Front Lower Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Nearside Front Brake hose twisted |3.6.B.4c| | 1 |
| Nearside Rear Stop lamp not working |1.2.1b| | 1 |
| Power steering malfunctioning |2.3.3a| | 1 |
| Offside Headlamp not working on main beam |1.7.5a| | 1 |
| Offside Rear Exhaust mounting missing |7.1.1b| | 1 |
| Offside Exhaust has part of the system excessively deteriorated |7.1.1a| | 1 |
| Front Windscreen wiper blade deteriorated |8.2.2| | 1 |
| Nearside Front Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
| Offside Front Front position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Front wheel bearing rough when rotated |2.5.A.2| | 1 |
| Nearside Outer Front Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Steering column top bearing excessively worn |2.1.2c| | 1 |
| Nearside Front Anti-roll bar has excessive play in a ball joint |2.4.G.2| | 1 |
| Nearside Front Suspension component mounting prescribed area is excessively corroded inner wheel arch
|2.4.A.3| | 1 |
| Nearside Front Suspension component mounting prescribed area excessively corroded significantly reducing structural strength (5.3.6 (a) (i)) | 1 |
| Offside Front Suspension component mounting prescribed area excessively corroded significantly reducing structural strength (5.3.6 (a) (i)) | 1 |
| Central Rear Seat belt locking mechanism does not secure or release |5.2.5a| | 1 |
| Nearside Headlamp has a product on the light source so that the light output is severely reduced |1.7.5a| | 1 |
| Offside Headlamp has a product on the lens so that the light output is severely reduced |1.7.5a| | 1 |
| Nearside Rear Passenger`s seat insecure cant clip in up right |6.2.6 |a| |ii|| | 1 |
| Central Rear Seat belt buckle not functioning as intended |7.1.2 |d|| | 1 |
| Oil leaking continuously from engine posing a serious risk to road safety |8.4.1 |a| |ii|| | 1 |
| Nearside Rear Suspension component mounting prescribed area is corroded to the extent that control of the vehicle is likely to be adversely affected outer sill |5.3.6 |a| |ii|| | 1 |
| Offside Rear Suspension component mounting prescribed area is corroded to the extent that control of the vehicle is likely to be adversely affected outer sill |5.3.6 |a| |ii|| | 1 |
| Nearside Front Front wheel bearing has excessive play |2.5.A.3c| | 1 |
| Nearside Outer Track rod end ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Offside Inner Track rod end ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Offside Outer Track rod end ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Nearside Inner Track rod end ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Emissions not tested |7.3.A.1| | 1 |
| Nearside Inner Front Drag link end ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Nearside Outer Front Drag link end ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Offside Inner Front Drag link end ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Offside Outer Drag link end ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Nearside Front Direction indicator incorrect colour |1.4.A.2f| | 1 |
| Offside Front Direction indicator incorrect colour |1.4.A.2f| | 1 |
| Nearside Outer Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Centre Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Nearside Side repeater not working |1.4.A.2c| | 1 |
| Nearside Front Steering pivot point has excessive play |2.2.B.1g| | 1 |
| Anti-lock braking system warning lamp does not illuminate |3.4.1b| | 1 |
| Offside Front Headlamp not working on dipped beam |1.7.5a| | 1 |
| Offside front brake binding |3.7.B.1| | 1 |
| Offside Stop lamp emits other than a steady red light |1.2.1e| | 1 |
| Offside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Offside Front Lower Suspension arm synthetic bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Nearside Front Subframe mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Rear rear parking |secondary| brake grabbing severely |3.7.B.6b| | 1 |
| Exhaust emissions hydrocarbon content excessive |7.3.B.1b| | 1 |
| Nearside Front Outer Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Nearside Front Inner Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Nearside Front Lower Suspension arm has excessive play in a pin/bush front |2.4.G.2| | 1 |
| Direction indicator incorrect colour |1.4.A.2f| | 1 |
| Offside Stop lamp not working |1.2.1b| | 1 |
| Offside Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Front Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Horn not loud enough to be heard by another road user |1.6.2b| | 1 |
| Nearside Rear position lamp|s| incorrect colour |1.1.A.3e| | 1 |
| Offside Front Macpherson strut has excessive movement at the upper attachment |2.5.A.1c| | 1 |
| Nearside Front Track rod end ball joint has excessive play and o/s/f |2.2.B.1f| | 1 |
| Nearside Front Shock absorber has a serious fluid leak |2.7.3| | 1 |
| Nearside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
| Stop lamp remains on when the brakes are released | 1 |
| Centre Rear Seat belt locking mechanism does not secure or release |5.2.5a| | 1 |
| Nearside Rear Sub-frame rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Rear Sub-frame rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Nearside Rear Suspension spring mounting prescribed area is excessively corroded inner arch |2.4.A.3| | 1 |
| Offside Rear Suspension spring mounting prescribed area is excessively corroded inner arch |2.4.A.3| | 1 |
| Rear Seat belt retracting mechanism defective center seat belt |5.2.5b| | 1 |
| Brake hose excessively deteriorated | 1 |
| Nearside Front Subframe mounting prescribed area is excessively corroded under wing inner wing |2.4.A.3| | 1 |
| Nearside Front Seat belt anchorage prescribed area is excessively corroded outrigger |5.2.6| | 1 |
| Offside Rear Seat belt has a cut which has significantly weakened the webbing |5.2.2a| | 1 |
| Centre Rear Seat belt has a cut which has significantly weakened the webbing |5.2.2a| | 1 |
| Nearside front brake binding |3.7.B.1| | 1 |
| Nearside Front Subframe mounting prescribed area is excessively corroded inner wheel arch |2.4.A.3| | 1 |
| Nearside Front Lower Anti-roll bar ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Offside Front Lower Anti-roll bar ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Rear Exhaust system not adequately supported box |7.1.1| | 1 |
| Exhaust has a major leak of exhaust gases tail box missing |7.1.2| | 1 |
| Wheel bolt|s| missing 1 from every wheel |4.2.A.1e| | 1 |
| Windscreen has a sticker or other obstruction encroaching into the swept area by more than 40mm outside zone `A` |8.3.1e| | 1 |
| Nearside Headlamp insecure |1.7.3| | 1 |
| Nearside Front Front position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Rear Rear fog lamp not working |4.5.1 |a| |ii|| | 1 |
| Offside Front Anti-roll bar has excessive play in a ball joint |2.4.G.2| | 1 |
| Offside Rear Road wheel fixing missing (5.2.1 (a) (i)) | 1 |
| Engine MIL inoperative or indicates a malfunction (8.2.1.2 (h)) | 1 |
| Nearside rear brake juddering severely |3.7.A.5b| | 1 |
| Offside rear brake juddering severely |3.7.A.5b| | 1 |
| Windscreen wiper blade insecure | 1 |
| Nearside Outer Seat belt anchorage prescribed area is excessively corroded sill |5.2.6| | 1 |
| Offside Outer Seat belt anchorage prescribed area is excessively corroded sill |5.2.6| | 1 |
| Nearside Front Wheel bolt|s| missing |4.2.A.1e| | 1 |
| Nearside Direction indicator incorrect colour |1.4.A.2f| | 1 |
| Offside Front Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Stop lamp not working |1.2.1b| | 1 |
| Hazard warning lamps not flashing in phase, with ignition on |1.4.B.1f| | 1 |
| Hazard warning lamps not flashing in phase, with ignition off |1.4.B.1f| | 1 |
| Direction indicators not working |1.4.A.2c| | 1 |
| Nearside Front Lower Suspension arm rubber mounting bonding deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Front Lower Suspension arm rubber mounting bonding deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Centre Exhaust system not adequately supported |7.1.1| | 1 |
| Offside Front Suspension arm rubber mounting deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Nearside Rear wheel bearing has excessive play |2.6.2| | 1 |
| Nearside Front Anti-roll bar linkage ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Offside Front Anti-roll bar linkage ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Nearside Rear Rear wheel bearing has excessive play |2.6.2| | 1 |