Most common failures | No# failures |
---|
Headlamp aim out of alignment | 37 |
Parking brake: efficiency below requirements |3.7.B.7| | 22 |
Registration plate lamp issues | 21 |
Windscreen wiper does not clear the windscreen effectively | 20 |
Rear parking brake recording little or no effort | 19 |
Brake pipe excessively corroded | 17 |
Exhaust emissions Lambda reading after 2nd fast idle outside specified limits |7.3.D.3| | 16 |
Exhaust emissions carbon monoxide content after 2nd fast idle excessive |7.3.D.3| | 15 |
Nearside Rear Direction indicator incorrect colour |1.4.A.2f| | 13 |
Offside Front position lamp|s| not working |1.1.A.3b| | 12 |
Offside Rear Direction indicator incorrect colour |1.4.A.2f| | 12 |
Nearside Rear Shock absorber has a serious fluid leak |2.7.3| | 11 |
Offside Track rod end ball joint has excessive play |2.2.B.1f| | 11 |
Rear Exhaust has a major leak of exhaust gases |7.1.2| | 10 |
Front brake disc in such a condition that it is seriously weakened | 10 |
Registration plate issues | 9 |
Brakes imbalanced across an axle | 8 |
Offside Rear coil spring incomplete |2.4.C.1a| | 8 |
Offside Rear Shock absorber has a serious fluid leak |2.7.3| | 8 |
Nearside Track rod end ball joint has excessive play |2.2.B.1f| | 8 |
Nearside Front position lamp|s| not working |1.1.A.3b| | 8 |
Exhaust emissions carbon monoxide content at idle excessive |7.3.D.4| | 8 |
Battery insecure |1.9.1| | 7 |
Rear brake binding | 7 |
Nearside Front Track rod end ball joint has excessive play |2.2.B.1f| | 6 |
Offside Rear coil spring fractured |2.4.C.1a| | 6 |
Nearside Steering pivot point has excessive play |2.2.B.1g| | 6 |
Front brake application uneven | 5 |
Service brake: efficiency below requirements |3.7.B.7| | 5 |
Offside Front Track rod end ball joint has excessive play |2.2.B.1f| | 5 |
Nearside Rear coil spring broken |2.4.C.1a| | 5 |
Exhaust emissions hydrocarbon content after 2nd fast idle excessive |7.3.D.3| | 5 |
Offside Rear coil spring broken |2.4.C.1a| | 5 |
Nearside Rear Direction indicators incorrect colour |1.4.A.2f| | 5 |
Offside Rear Direction indicators incorrect colour |1.4.A.2f| | 5 |
Nearside Outer Track rod end ball joint has excessive play |2.2.B.1f| | 5 |
Nearside Headlamp not working on dipped beam |1.7.5a| | 4 |
Exhaust system not adequately supported |7.1.1| | 4 |
Nearside Rear coil spring incomplete |2.4.C.1a| | 4 |
Nearside Front Front position lamp|s| not working |1.1.A.3b| | 4 |
Nearside Front Anti-roll bar linkage has excessive play in a ball joint |2.4.G.2| | 4 |
Offside Headlamp not working on dipped beam |1.7.5a| | 4 |
Nearside Rear coil spring fractured |2.4.C.1a| | 4 |
Offside Headlamp excessively damaged so that the light output is severely reduced |1.7.5a| | 4 |
Nearside Front Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 4 |
Parking brake lever has no reserve travel |3.1.6b| | 4 |
Offside Headlamp not in good working order adversely affecting beam image |1.2.4a| | 3 |
Offside Rear Rear fog lamp not working |1.3.2b| | 3 |
Offside Rear fog lamp not working |1.3.2b| | 3 |
Rear brake disc in such a condition that it is seriously weakened | 3 |
Nearside Front Steering pivot point has excessive play |2.2.B.1g| | 3 |
Nearside Stop lamp not working |1.2.1b| | 3 |
Exhaust has a major leak of exhaust gases |7.1.2| | 3 |
Offside Front coil spring broken |2.4.C.1a| | 3 |
Windscreen has a sticker or other obstruction encroaching into the swept area by more than 40mm outside zone `A` |8.3.1e| | 3 |
Nearside Headlamp excessively damaged so that the light output is severely reduced |1.7.5a| | 3 |
Offside Front Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 3 |
Emissions not tested |7.0| | 3 |
Nearside Front Suspension arm has excessive play in a pin/bush |2.4.G.2| | 3 |
Centre Exhaust has a major leak of exhaust gases |7.1.2| | 3 |
Windscreen has damage | 3 |
Rear Direction indicators incorrect colour |1.4.A.2f| | 2 |
Exhaust emissions carbon monoxide content excessive |7.3.B.1a| | 2 |
Anti-lock braking system warning lamp indicates an ABS fault | 2 |
Nearside Side repeater not working |1.4.A.2c| | 2 |
Nearside Front Anti-roll bar linkage ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 2 |
Offside Front Anti-roll bar linkage ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 2 |
Offside Front Brake hose twisted |found during steering lock to lock check| |2.2.D.2b| | 2 |
Supplementary Restraint System warning lamp indicates a fault |5.4.2| | 2 |
Nearside Indicator tell tale inoperative |1.4.A.2a| | 2 |
Exhaust noise is clearly in excess of that emitted by a similar vehicle fitted with a standard silencer in average condition |7.1.4| | 2 |
Offside Headlamp not working on main beam |1.7.5a| | 2 |
Offside Front Inner Track rod end ball joint dust cover excessively damaged or deteriorated so that it no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 2 |
Nearside Macpherson strut upper support bearing is rough in operation |2.5.B.1b| | 2 |
Nearside Front Seat belt locking mechanism does not secure or release |5.2.5a| | 2 |
Brake performance not tested |3.7.A.1| | 2 |
Nearside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 2 |
Offside Stop lamp not working |1.2.1b| | 2 |
Oil leaking excessively from engine |8.4.1 |a| |i|| | 2 |
Rear Direction indicator incorrect colour |1.4.A.2f| | 2 |
Nearside Outer Front Track rod end ball joint has excessive play |2.2.B.1f| | 2 |
Front position lamp|s| incorrect colour |1.1.A.3e| | 2 |
Rear Exhaust system not adequately supported |7.1.1| | 2 |
Centre Exhaust system not adequately supported |7.1.1| | 2 |
Fuel cap/sealing device sealing washer missing |7.2.4c| | 2 |
Offside Front Suspension arm has excessive play in a pin/bush |2.4.G.2| | 2 |
Offside Rear Shock absorber detached |2.7.2b| | 2 |
Nearside Steering arm has relative movement at its fixings |2.2.B.1h| | 2 |
Nearside Front Steering arm has relative movement at its fixings |2.2.B.1h| | 2 |
Nearside Front Battery insecure |1.9.1| | 2 |
Rear coil spring incomplete |2.4.C.1a| | 2 |
Offside Rear coil spring cracked |2.4.C.1a| | 2 |
Nearside Rear Seat belt anchorage prescribed area strength or continuity significantly reduced Lower outer sill |7.1.1 |a| |i|| | 2 |
Offside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 2 |
Offside Front Ball joint has excessive play |2.2.B.1f| | 1 |
Offside Front Suspension arm rubber mounting deteriorated resulting in excessive movement |2.4.G.2| | 1 |
Offside Front Obligatory mirror seriously damaged, affecting the rear view |8.1.2a| | 1 |
Nearside Headlamp aim aimed so that it dazzles other road users |1.8.A.1a| | 1 |
Steering system has excessive free play detected at the steering wheel |steering box fitted| |2.2.A.1a| | 1 |
Nearside Rear Seat belt anchorage prescribed area is excessively corroded outer sill |5.2.6| | 1 |
Offside Rear Seat belt anchorage prescribed area is excessively corroded outer sill |5.2.6| | 1 |
Offside Front Front position lamp|s| not working |1.1.A.3b| | 1 |
Offside Rear Front position lamp|s| not working |1.1.A.3b| | 1 |
Offside Front Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
Nearside Rear Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
Offside Front Headlamp not working on dipped beam |1.7.5a| | 1 |
Body has a sharp edge caused by damage |6.1.C.1| | 1 |
Nearside Front Front passenger door cannot be opened from inside the vehicle |6.2.B.1b| | 1 |
Nearside Rear Rear position lamp|s| not working |1.1.A.3b| | 1 |
Offside Rear Stop lamp not working |1.2.1b| | 1 |
Front brake excessively fluctuating | 1 |
Rear Brake pipe leaking |3.6.A.1| | 1 |
Nearside Front Anti-roll bar linkage has excessive play in a pin/bush |2.4.G.2| | 1 |
Nearside Front Headlamp aim aimed so that it dazzles other road users |1.8.A.1a| | 1 |
Nearside Front Headlamp insecure |1.7.3| | 1 |
Offside Rear Statutory seat belt missing |5.1.1| | 1 |
Brake pedal creeps down when held under pressure |3.3.B.1a| | 1 |
Nearside Front Front position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
Nearside Front Tie bar/rod has excessive play in a pin/bush Track rod end excessively play |2.4.G.2| | 1 |
Offside Front Tie bar/rod has excessive play in a pin/bush Track rod end excessively play |2.4.G.2| | 1 |
Nearside Front suspension has excessive movement at a wishbone pin or bush |2.5.A.1c| | 1 |
Offside Front suspension has excessive movement at a wishbone pin or bush |2.5.A.1c| | 1 |
Rear Statutory seat belt missing |5.1.1| | 1 |
Nearside Front Front suspension has excessive play in a track control arm inner bush |2.5.B.2b| | 1 |
Offside Front Front suspension has excessive play in a track control arm inner bush |2.5.B.2b| | 1 |
Offside Rear Sub-frame has excessive play in a pin/bush |2.4.G.2| | 1 |
Nearside Front Ball joint inappropriately modified IDLE ARM |2.2.C.1e| | 1 |
Nearside Front Lower Front suspension has excessive movement at a wishbone pin or bush FRONT BUSH |2.5.A.1c| | 1 |
Offside Front Lower Front suspension has excessive movement at a wishbone pin or bush FRONT BUSH |2.5.A.1c| | 1 |
Steering column movement between the shaft and steering wheel |2.1.2b| | 1 |
Nearside Rear Wheel stud|s| missing |4.2.A.1e| | 1 |
Offside Front Brake hose twisted |3.6.B.4c| | 1 |
Offside Front Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 1 |
Horn not working |1.6.2a| | 1 |
Service brake effort inadequate at a wheel BRAKE PEDAL SINKING TO THE FLOOR |1.2.1 |a| |i|| | 1 |
Window damaged and affecting the driver`s view of an obligatory external mirror |3.2 |a| |ii|| | 1 |
Rear Seat belt buckle not functioning as intended CENTRE BELT STUCK |7.1.2 |d|| | 1 |
Nearside Rear Direction indicator incorrect colour |4.4.3 |a|| | 1 |
Battery insecure and likely to cause a short circuit |4.13 |a| |ii|| | 1 |
Exhaust system insecure ALL RUBBERS BROKEN OR BADLY PERISHED |6.1.2 |a|| | 1 |
Suspension arm pin or bush excessively worn ALL LOWER WISHBONE BUSHES LEFT AND RIGHT WORN SOFT AND SPLIT |5.3.4 |a| |i|| | 1 |
Offside Rear Vehicle structure is fractured and structural rigidity is significantly reduced NEAR SPRING |6.1.1 |a| |i|| | 1 |
Front Headlamp incorrect colour LENSES FADED |4.1.4 |a|| | 1 |
Service brake efficiency less than 50% of the required value |1.2.2 |a| |ii|| | 1 |
Parking brake efficiency below requirements |1.4.2 |a| |i|| | 1 |
Headlamp lens seriously defective Faded lens (4.1.1 (b) (ii)) | 1 |
Indicator switch inoperative (4.4.2 (a) (ii)) | 1 |
Hazard warning switch inoperative (4.4.2 (a) (ii)) | 1 |
Nearside Rear Outer Track rod end ball joint dust cover excessively damaged or deteriorated so that it no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |
Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting Nearside inner sill (6.2.2 (d) (i)) | 1 |
Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting Offside inner sill (6.2.2 (d) (i)) | 1 |
Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting Nearside rear inside wheel arch (6.2.2 (d) (i)) | 1 |
Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting Offside rear inside wheel arch (6.2.2 (d) (i)) | 1 |
Exhaust system insecure Rear box rubber mounting missing (6.1.2 (a)) | 1 |
Parking brake efficiency below requirements (1.4.2 (a) (i)) | 1 |
Exhaust carbon monoxide content after 2nd fast idle exceeds default limits (8.2.1.2 (b)) | 1 |
Exhaust Lambda reading after 2nd fast idle outside specified limits (8.2.1.2 (c)) | 1 |
Central Emissions oxygen sensor obviously defective Both sides damaged wires (8.2.1.1 (a)) | 1 |
Offside Front Position lamp not working (4.2.1 (a) (ii)) | 1 |
Offside Outer Front Lower Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
Offside Macpherson strut upper support bearing is rough in operation |2.5.B.1b| | 1 |
Offside Rear Brake cable has restricted free movement |3.5.1k| | 1 |
Exhaust has a major leak of exhaust gases blowing at center joint and rear joint |7.1.2| | 1 |
Nearside Rear Suspension spring mounting prescribed area is excessively corroded inner wheel arch |2.4.A.3| | 1 |
Nearside Front Headlamp not working on dipped beam |1.7.5a| | 1 |
Centre Front Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
Nearside Front Exhaust has a major leak of exhaust gases manifold has major crack |7.1.2| | 1 |
Nearside Rear Exhaust system not adequately supported rubber mounting is broken no support |7.1.1| | 1 |
Offside Front Macpherson strut cracked |2.4.G.1| | 1 |
Nearside Rear Radius arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
Offside Rear Braking system leaking |3.6.A.1| | 1 |
Nearside Front Obligatory mirror seriously damaged, affecting the rear view |8.1.2a| | 1 |
Rear Direction indicator incorrect colour both |1.4.A.2f| | 1 |
Offside Drag link end ball joint has excessive play |2.2.B.1f| | 1 |
Power steering fluid level below minimum |2.3.1| | 1 |
Power steering inoperative |2.3.3a| | 1 |
Power steering pipe|s| or hose|s| leaking from a joint |2.3.3b| | 1 |
Offside Front Anti-roll bar linkage ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
Nearside Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
Engine MIL inoperative or indicates a malfunction |8.2.1.2 |h|| | 1 |
Offside Side repeater incorrect colour |4.4.3 |a|| | 1 |
Nearside Rear Seat belt anchorage prescribed area strength or continuity significantly reduced outer sill |7.1.1 |a| |i|| | 1 |
Nearside Front Anti-roll bar linkage ball joint excessively worn |5.3.4 |a| |i|| | 1 |
Offside Front Lower Suspension arm pin or bush excessively worn |5.3.4 |a| |i|| | 1 |
Nearside Headlamp aim not tested |1.8.A.1c| | 1 |
Centre Rear Seat belt locking mechanism does not secure or release |5.2.5a| | 1 |
Nearside Inner Front Track rod end ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
Nearside Front Macpherson strut insecure |2.4.G.1| | 1 |
Nearside Rear Rear position lamp|s| has less than 50% of the light sources illuminating |1.1.A.3b| | 1 |
Rear Stop lamp not working |1.2.1b| | 1 |
Offside Rear Rear fog lamp not working white light showing |1.3.2b| | 1 |
Offside Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
Offside Brake cable has restricted free movement |3.5.1k| | 1 |
Nearside Steering system has excessive free play detected at the steering wheel |steering box fitted| |2.2.A.1a| | 1 |
Headlamp not in a clean condition affecting beam image |1.2.4a| | 1 |
Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
Rear brake application uneven | 1 |
Centre Exhaust has part of the system excessively deteriorated |7.1.1a| | 1 |
Offside Parking brake recording little or no effort |3.7.D.3a| | 1 |
Offside Rear Brake pipe fouled by moving parts |3.6.B.2a| | 1 |
Parking brake is not capable of being maintained in operation by direct mechanical action only |3.1.2| | 1 |
Offside Headlamp insecure |1.7.3| | 1 |
Nearside Rear Wheel bolt|s| loose |4.2.A.1e| | 1 |
Offside Outer Front Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
Brake pedal spongy |3.3.B.1b| | 1 |
Headlamp levelling device obviously defective |1.7.2| | 1 |
Headlamp aim not tested |1.8.A.1c| | 1 |
Nearside Headlamp levelling device obviously defective |1.7.2| | 1 |
Offside Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Offside Lower Front suspension ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
Front passenger door cannot be opened from inside the vehicle |6.2.B.1b| | 1 |
Front passenger door cannot be opened from outside the vehicle |6.2.B.1b| | 1 |
Nearside Front Steering system has excessive free play detected at the steering wheel |steering box fitted| |2.2.A.1a| | 1 |
Nearside Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
Nearside Steering locking device missing |2.2.C.1g| | 1 |
Nearside Drag link end ball joint has excessive play |2.2.B.1f| | 1 |
Rear position lamp|s| incorrect colour |1.1.A.3e| | 1 |
Nearside Front Wheel bolt|s| missing |4.2.A.1e| | 1 |
Drag link end ball pin shank loose |2.2.B.1c| | 1 |
Nearside Front Electrical wiring insecure |1.9.2a| | 1 |
Offside Front front brake binding |3.7.B.1| | 1 |
Offside Front brake disc has restricted free movement |3.5.1j| | 1 |
Rear Exhaust emissions carbon monoxide content after 2nd fast idle excessive |7.3.D.3| | 1 |
Dipswitch operation does not extinguish all main beam headlamps leaving at least one pair of dipped beam headlamps |1.7.4b| | 1 |
Offside Inner Front Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
Electrical wiring damaged and bare wires exposed |1.9.2c| | 1 |
Rear coil spring fractured |2.4.C.1a| | 1 |
Headlamp excessively deteriorated so that the light output is severely reduced Both |1.7.5a| | 1 |
Nearside Front Subframe mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Supplementary restraint system warning lamp indicates a fault |7.1.6 |a|| | 1 |
Exhaust has a major leak of exhaust gases Centre and rear |6.1.2 |a|| | 1 |
Emissions not tested Excessive leak from exhaust |8.2.1.2 |d|| | 1 |
Nearside Inner Steering linkage insecure to the extent there is excessive movement at the mountings |2.1.3 |a| |ii|| | 1 |
Offside Front Lower Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
Nearside Front Lower Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
Fuel system component leaking |7.2.3| | 1 |
Nearside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
Nearside Front Track rod end ball pin shank loose |2.2.B.1c| | 1 |
Offside Front Track rod end ball pin shank loose |2.2.B.1c| | 1 |
Nearside Front Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
Offside Side repeater not working |1.4.A.2c| | 1 |
Nearside Headlamp aim beam image too far to the left |1.6.B4| | 1 |
Rear Fuel system component insecure |7.2.1| | 1 |
Offside Front Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
Rear Exhaust has part of the system excessively deteriorated |7.1.1a| | 1 |
Centre Rear Seat belt retracting mechanism defective |5.2.5b| | 1 |
Offside Outer Rear Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
Nearside Outer Rear Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
Nearside Front Intermediate drop arm deformed and unserviceable |2.2.C.1d| | 1 |
Nearside Front Front suspension has excessive movement at a wishbone pin or bush |2.5.A.1c| | 1 |
Nearside Front Headlamp has a product on the lens so that the light output is severely reduced |1.7.5a| | 1 |
Offside Front Headlamp has a product on the lens so that the light output is severely reduced |1.7.5a| | 1 |
Offside Front Seat belt stitching badly frayed |5.2.2b| | 1 |
Windscreen has a sticker or other obstruction encroaching by more than 10mm within zone `A` |8.3.1b| | 1 |
Nearside Headlamp excessively deteriorated so that the light output is severely reduced |1.7.5a| | 1 |
Offside Headlamp excessively deteriorated so that the light output is severely reduced |1.7.5a| | 1 |
Nearside Rear Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
Brake hose excessively deteriorated | 1 |
Rear fog lamp adversely affected by the operation of another lamp |1.3.2f| | 1 |
Offside Outer Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
Offside Inner Front Lower Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
Nearside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
Nearside Front brake disc excessively pitted |3.5.1h| | 1 |
Offside Front brake disc excessively pitted |3.5.1h| | 1 |
Offside Outer Front Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
Nearside Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
Offside Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
Offside Inner Front Track rod end ball pin shank loose |2.2.B.1c| | 1 |
Nearside Front Brake hose twisted |3.6.B.4c| | 1 |