| Most common failures | No# failures |
|---|
| Brake pipe excessively corroded | 23 |
| Windscreen wiper does not clear the windscreen effectively | 10 |
| Registration plate lamp issues | 10 |
| Offside Rear Stop lamp not working |1.2.1b| | 6 |
| Nearside Stop lamp not working |1.2.1b| | 5 |
| Parking brake: efficiency below requirements |3.7.B.7| | 5 |
| Exhaust has a major leak of exhaust gases |7.1.2| | 5 |
| Rear brake binding | 4 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 4 |
| Brakes imbalanced across an axle | 4 |
| Nearside Front constant velocity joint gaiter split |2.5.C.1a| | 3 |
| Offside Front constant velocity joint gaiter split |2.5.C.1a| | 3 |
| Front Exhaust has a major leak of exhaust gases |7.1.2| | 3 |
| Rear parking brake recording little or no effort | 3 |
| Nearside Front Lower Shock absorber has an excessively worn bush |2.7.4| | 3 |
| Offside Front Lower Shock absorber has an excessively worn bush |2.7.4| | 3 |
| Exhaust emissions carbon monoxide content at idle excessive |7.3.D.4| | 3 |
| Offside front brake binding |3.7.B.1| | 3 |
| Nearside Front Front wheel bearing has excessive play |2.5.A.3c| | 2 |
| Anti-lock braking system warning lamp indicates an ABS fault | 2 |
| Offside Front Shock absorber has a serious fluid leak |2.7.3| | 2 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 2 |
| Service brake: efficiency below requirements |3.7.B.7| | 2 |
| Exhaust emissions hydrocarbon content after 2nd fast idle excessive |7.3.D.3| | 2 |
| Rear Exhaust has a major leak of exhaust gases |7.1.2| | 2 |
| Nearside front brake binding |3.7.B.1| | 2 |
| Front brake application uneven | 2 |
| Offside Rear fog lamp not working |1.3.2b| | 2 |
| Battery insecure |1.9.1| | 2 |
| Nearside Front Front position lamp|s| not working |1.1.A.3b| | 2 |
| Nearside Front Front constant velocity joint gaiter split |2.5.C.1a| | 2 |
| Offside Front Front constant velocity joint gaiter split |2.5.C.1a| | 2 |
| Exhaust emissions Lambda reading after 2nd fast idle outside specified limits |7.3.D.3| | 2 |
| Horn not working |1.6.2a| | 2 |
| Exhaust carbon monoxide content after 2nd fast idle exceeds manufacturers specified limits (8.2.1.2 (a)) | 2 |
| Windscreen washer not working | 2 |
| Nearside Stop lamp|s| not working |4.3.1 |a| |ii|| | 1 |
| Nearside Rear Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Brake hydraulic reservoir fluid level below minimum level |3.6.G.1b| | 1 |
| Offside Front Power steering component|s| leaking |2.3.3b| | 1 |
| Exhaust has a major leak of exhaust gases center box |7.1.2| | 1 |
| Offside Rear Seat belt anchorage prescribed area is excessively corroded inner sill |5.2.6| | 1 |
| Emissions not tested due to exhaust leak |7.4.B.1| | 1 |
| Nearside Front constant velocity joint gaiter deteriorated to the extent that it no longer prevents the ingress of dirt etc leaking |2.5.C.1a| | 1 |
| Central Upper Windscreen has a sticker or other obstruction encroaching into the swept area by more than 40mm outside zone `A` |8.3.1e| | 1 |
| Statutory seat belt missing All rears unavailable for inspection |5.1.1| | 1 |
| Nearside Front constant velocity joint gaiter deteriorated to the extent that it no longer prevents the ingress of dirt etc split |2.5.C.1a| | 1 |
| Nearside Front Front constant velocity joint gaiter deteriorated to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Exhaust catalytic converter missing where one was fitted as standard |7.1.3| | 1 |
| Nearside Rear Stop lamp not working |1.2.1b| | 1 |
| Nearside Front Headlamp incorrect colour |1.7.5b| | 1 |
| Steering column top mounting bracket insecure |2.1.2d| | 1 |
| Rear Brake load sensing valve linkage seized |3.6.E.3| | 1 |
| rear parking |secondary| brakes imbalanced | 1 |
| Headlamp aim out of alignment | 1 |
| Offside Rear Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Rear Body has a projection caused by corrosion |6.1.C.1| | 1 |
| Offside Front Front position lamp|s| not working |1.1.A.3b| | 1 |
| Rear Exhaust has part of the system excessively deteriorated |7.1.1a| | 1 |
| Parking brake: efficiency below requirements |3.7.C.1b| | 1 |
| Nearside Rear position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
| Offside Headlamp excessively damaged so that the light output is severely reduced |1.7.5a| | 1 |
| Fuel system component insecure |7.2.1| | 1 |
| Nearside Rear rear brake excessively fluctuating |3.7.B.3| | 1 |
| Offside Headlamp insecure |1.7.3| | 1 |
| Rear Rear fog lamp not working |1.3.2b| | 1 |
| Offside Stop lamp not working |1.2.1b| | 1 |
| Nearside Lower Shock absorber has an excessively worn bush |2.7.4| | 1 |
| Battery insecure and likely to fall from carrier |4.13 |a| |ii|| | 1 |
| Nearside Front Position lamp not working |4.2.1 |a|| | 1 |
| Fuel system component leaking excessively or a risk of fire |6.1.3 |b| |ii|| | 1 |
| Offside Front Suspension arm ball joint excessively worn |5.3.4 |a| |i|| | 1 |
| Nearside Front Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt |6.1.7 |g| |ii|| | 1 |
| Offside Front Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt |6.1.7 |g| |ii|| | 1 |
| Offside Front Braking system leaking caliper |3.6.A.1| | 1 |
| Brake pedal anti-slip provision missing |3.3.A.1b| | 1 |
| Offside Front constant velocity joint gaiter deteriorated to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Fuel pipe leaking Rear |7.2.3| | 1 |
| Exhaust system not adequately supported |7.1.1| | 1 |
| Central Rear Stop lamp not working |1.2.1b| | 1 |
| Central Rear Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Offside Rear position lamp|s| incorrect colour |1.1.A.3e| | 1 |
| Offside Rear Stop lamp emits other than a steady red light |1.2.1e| | 1 |
| Offside Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Front Lower Front suspension ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Offside Front Upper Front suspension ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Centre Rear Fuel hose leaking |7.2.3| | 1 |
| Offside Front Upper Suspension arm ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Offside Front Upper Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Exhaust has part of the system excessively deteriorated |7.1.1a| | 1 |
| Offside front brake grabbing severely |3.7.A.2b| | 1 |
| Emissions not tested |7.0| | 1 |
| Nearside Front Front passenger door cannot be opened from inside the vehicle |6.2.B.1b| | 1 |
| Nearside Rear Seat belt locking mechanism does not secure or release |5.2.5a| | 1 |
| Nearside Front Brake hose leaking |3.6.A.1| | 1 |
| Parking brake lever has no reserve travel |3.1.6b| | 1 |
| Exhaust emissions carbon monoxide content after 2nd fast idle excessive |7.3.D.3| | 1 |
| Nearside Ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Hazard warning switch faulty |1.4.B.1d| | 1 |
| Nearside Front wheel bearing has excessive play |2.5.A.3c| | 1 |
| Nearside Front Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 1 |
| Brake pipe leaking on a hydraulic braking system front to rear x2 (1.1.11 (b) (ii)) | 1 |
| Exhaust Lambda reading after 2nd fast idle outside specified limits (8.2.1.2 (c)) | 1 |
| Offside Front Wheel bearing has excessive play (5.1.3 (a) (i)) | 1 |
| Power steering component leaking Steering box (2.1.5 (a)) | 1 |
| Exhaust hydrocarbon content after 2nd fast idle exceeds default limits (8.2.1.2 (b)) | 1 |
| Front Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 1 |
| Emissions unable to be completed (8.2.1.2 (d)) | 1 |
| Offside Rear Parking brake inoperative on one side (1.4.1 (a)) | 1 |