Most common failures | No# failures |
---|
Brake pipe excessively corroded | 78 |
Headlamp aim out of alignment | 30 |
Offside Rear fog lamp not working |1.3.2b| | 28 |
Parking brake: efficiency below requirements |3.7.B.7| | 22 |
Windscreen wiper does not clear the windscreen effectively | 21 |
Registration plate lamp issues | 17 |
Offside Front Shock absorber has a serious fluid leak |2.7.3| | 15 |
Exhaust has a major leak of exhaust gases |7.1.2| | 10 |
Front Exhaust has a major leak of exhaust gases |7.1.2| | 10 |
Offside Rear Rear fog lamp not working |1.3.2b| | 9 |
Offside Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 9 |
Windscreen has damage | 9 |
Centre Exhaust has a major leak of exhaust gases |7.1.2| | 9 |
Registration plate issues | 8 |
Nearside Stop lamp not working |1.2.1b| | 8 |
Nearside Front Shock absorber has a serious fluid leak |2.7.3| | 8 |
Brakes imbalanced across an axle | 8 |
Offside Front Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 7 |
Nearside Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 7 |
Exhaust emissions carbon monoxide content excessive |7.3.B.1a| | 7 |
Rear Exhaust has a major leak of exhaust gases |7.1.2| | 7 |
Emissions not tested |7.0| | 7 |
Rear fog lamp not working |1.3.2b| | 7 |
Nearside Front Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 6 |
Nearside Front position lamp|s| not working |1.1.A.3b| | 6 |
Offside Front Steering component mounting prescribed area is excessively corroded |2.2.C.1h| | 6 |
Rear parking brake recording little or no effort | 6 |
Rear Rear fog lamp not working |1.3.2b| | 5 |
Body has a sharp edge caused by corrosion |6.1.C.1| | 5 |
Rear brake application uneven | 5 |
Nearside Front Front position lamp|s| not working |1.1.A.3b| | 5 |
Exhaust emissions carbon monoxide content after 2nd fast idle excessive |7.3.D.3| | 5 |
Exhaust emissions Lambda reading after 2nd fast idle outside specified limits |7.3.D.3| | 5 |
Offside Stop lamp not working |1.2.1b| | 5 |
Nearside Body has a sharp edge caused by corrosion |6.1.C.1| | 4 |
Nearside Rear Body has a sharp edge caused by corrosion |6.1.C.1| | 4 |
Offside Rear rear brake recording little or no effort |3.7.B.5a| | 4 |
Exhaust system not adequately supported |7.1.1| | 4 |
Exhaust emissions hydrocarbon content after 2nd fast idle excessive |7.3.D.3| | 4 |
Service brake: efficiency below requirements |3.7.B.7| | 4 |
Steering system has excessive free play detected at the steering wheel |steering box fitted| |2.2.A.1a| | 4 |
Exhaust emissions hydrocarbon content excessive |7.3.B.1b| | 4 |
Offside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 3 |
Offside Steering pivot point has excessive play |2.2.B.1g| | 3 |
Nearside Front Body has a sharp edge caused by corrosion |6.1.C.1| | 3 |
Offside Rear Body has a sharp edge caused by corrosion |6.1.C.1| | 3 |
Offside Front position lamp|s| not working |1.1.A.3b| | 3 |
Centre Exhaust system not adequately supported |7.1.1| | 3 |
Offside Windscreen wiper blade deteriorated |8.2.2| | 3 |
Offside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 3 |
Offside Inner Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 3 |
Power steering pipe|s| or hose|s| leaking |2.3.3b| | 3 |
Nearside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 3 |
Offside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 3 |
Nearside Front Steering component mounting prescribed area is excessively corroded |2.2.C.1h| | 3 |
Rear brake binding | 3 |
Rear fog lamp tell tale not working |1.3.1b| | 2 |
Offside Front Obligatory mirror missing |8.1.1| | 2 |
Horn not working |1.6.2a| | 2 |
Offside Rear Leaf spring fractured |2.4.B.1a| | 2 |
Nearside Front Lower Ball joint has excessive play |2.2.B.1f| | 2 |
Fuel cap/sealing device does not fasten securely by positive means |7.2.4b| | 2 |
Nearside Rear rear brake recording little or no effort |3.7.B.5a| | 2 |
Offside Front Windscreen wiper blade deteriorated |8.2.2| | 2 |
Offside Rear wheel bearing rough when rotated |2.6.1| | 2 |
Ball joint has excessive play |2.2.B.1f| | 2 |
Nearside Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 2 |
Nearside Rear Leaf spring has excessive wear in a shackle pin and/or bush |2.4.B.2| | 2 |
Brake load sensing valve linkage seized |3.6.E.3| | 2 |
Rear Brake cable has wires broken and is significantly weakened |3.5.1b| | 2 |
Offside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 2 |
Nearside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 2 |
Rear Exhaust system not adequately supported |7.1.1| | 2 |
Power steering malfunctioning |2.3.3a| | 2 |
Offside Front Front position lamp|s| not working |1.1.A.3b| | 2 |
Rear Exhaust has part of the system excessively deteriorated |7.1.1a| | 2 |
Nearside Rear Brake pipe leaking |3.6.A.1| | 2 |
Offside Rear fog lamp missing |1.3.2a| | 2 |
Nearside Inner Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
Emissions not tested |7.3.A.1| | 2 |
Nearside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 2 |
Nearside Front brake disc excessively scored |3.5.1h| | 2 |
Brake hose excessively deteriorated | 2 |
Nearside Front Lower Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 2 |
Offside Front Power steering pipe|s| or hose|s| leaking from a joint |2.3.3b| | 1 |
Tailgate cannot be secured in the closed position |6.4.1| | 1 |
Nearside Headlamp not working on dipped beam |1.7.5a| | 1 |
Centre Braking system leaking |3.6.A.1| | 1 |
Brake pedal creeps down when held under pressure |3.3.B.1a| | 1 |
Spare wheel insecure |6.4.2| | 1 |
Offside Obligatory mirror insecure |8.1.1| | 1 |
Offside Headlamp not working on dipped beam |1.7.5a| | 1 |
Offside Headlamp aim not tested |1.8.A.1c| | 1 |
Offside Rear Rear fog lamp tell tale not working |1.3.1b| | 1 |
Offside Front Obligatory mirror seriously deteriorated, affecting the rear view |8.1.2a| | 1 |
Nearside Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Nearside Lower Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Offside Front Vehicle structure has excessive corrosion which adversely affects braking or steering |6.1.A.1| | 1 |
Offside Front Drag link end ball joint has excessive play |2.2.B.1f| | 1 |
Nearside Front Steering arm has relative movement at its fixings |2.2.B.1h| | 1 |
Nearside Front Anti-roll bar fractured |2.4.G.1| | 1 |
Offside Front Body has a sharp edge caused by corrosion |6.1.C.1| | 1 |
Nearside Outer Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Nearside Rear Direction indicator not working |1.4.A.2c| | 1 |
Nearside Front Steering pivot point has excessive play |2.2.B.1g| | 1 |
Nearside Front Shock absorber has negligible damping effect |2.7.5| | 1 |
Nearside Rear wheel bearing rough when rotated |2.6.1| | 1 |
Offside Front Brake actuating linkage mounting prescribed area is excessively corroded |3.3.A.2| | 1 |
Lower Rear fog lamp not working |1.3.2b| | 1 |
Rear Lower Leaf spring has excessive wear in a shackle pin and/or bush |2.4.B.2| | 1 |
Nearside Rear Lower Leaf spring has excessive wear in a shackle pin and/or bush |2.4.B.2| | 1 |
Offside Front Brake hose twisted |found during steering lock to lock check| |2.2.D.2b| | 1 |
Nearside Front Suspension arm worn and seriously weakened |2.4.G.1| | 1 |
Offside Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Offside Rear Rear position lamp|s| incomplete |1.1.4a| | 1 |
Rear An item not tested |Manual| | 1 |
Offside Rear Leaf spring has excessive wear in a shackle pin and/or bush |2.4.B.2| | 1 |
Nearside Stop lamp emits other than a steady red light |1.2.1e| | 1 |
Nearside Rear Statutory seat belt missing |5.1.1| | 1 |
Offside Rear Statutory seat belt missing |5.1.1| | 1 |
Nearside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
Brake master cylinder leaking hydraulic fluid |3.6.G.1f| | 1 |
Nearside Inner Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Rear fog lamp insecure |1.3.2a| | 1 |
Offside Rear Direction indicator not working |1.4.A.2c| | 1 |
Offside Headlamp insecure |1.7.3| | 1 |
Offside Front Tie bar/rod fractured |2.4.G.1| | 1 |
Front brake disc excessively pitted |3.5.1h| | 1 |
Shock absorber has a serious fluid leak |2.7.3| | 1 |
Nearside Rear fog lamp not working |1.3.2b| | 1 |
Brake pipe leaking |3.6.A.1| | 1 |
Rear Exhaust has a part missing |7.1.1a| | 1 |
Hazard warning switch missing |1.4.B.1d| | 1 |
Hazard warning lamps not flashing in phase, with ignition on |1.4.B.1f| | 1 |
Nearside Windscreen wiper blade deteriorated |8.2.2| | 1 |
Nearside Front Subframe mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Centre Exhaust has part of the system excessively deteriorated |7.1.1a| | 1 |
Nearside Front Direction indicator incomplete |1.5.A1b| | 1 |
Offside Outer Body has a sharp edge caused by damage |6.1.C.1| | 1 |
Offside Front Anti-roll bar linkage fractured |2.4.G.1| | 1 |
Power steering inoperative |2.3.3a| | 1 |
Offside Front Lower Shock absorber has an excessively worn bush |2.7.4| | 1 |
Steering system excessively tight |2.2.D.1| | 1 |
Steering system excessively rough |2.2.D.1| | 1 |
Nearside Windscreen wiper not operating automatically when switched on |8.2.1b| | 1 |
Offside Windscreen wiper not operating automatically when switched on |8.2.1b| | 1 |
An item not tested |Manual| | 1 |
Nearside Inner Front Lower Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Offside Front Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 1 |
Nearside Inner Lower Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
Exhaust emissions carbon monoxide content at idle excessive |7.3.D.4| | 1 |
Hazard warning lamps not flashing in phase, with ignition on |1.5.4b| | 1 |
Hazard warning lamps not flashing in phase, with ignition off |1.5.4b| | 1 |
Hazard warning tell tale not working correctly |1.5.4c| | 1 |
Rear Emergency exit door cannot be opened from inside the vehicle |6.2.D.1a| | 1 |
Nearside Front Brake pipe leaking |3.6.A.1| | 1 |
Nearside Front front brake recording little or no effort |3.7.B.5a| | 1 |
Nearside Rear front brake recording little or no effort |3.7.B.5a| | 1 |
Mechanical brake component has restricted free movement | 1 |
Offside Rear position lamp|s| incomplete |1.1.4a| | 1 |
Loading door cannot be secured in the closed position |6.4.1| | 1 |
Offside Obligatory mirror seriously damaged, affecting the rear view |8.1.2a| | 1 |
Nearside Front Windscreen wiper blade deteriorated |8.2.2| | 1 |
Nearside Headlamp insecure |1.7.3| | 1 |
Nearside Steering component mounting prescribed area is excessively corroded |2.2.C.1h| | 1 |
Offside Outer Rear Suspension spring mounting prescribed area is inadequately repaired |2.4.A.3| | 1 |
Nearside Drag link end ball joint has excessive play |2.2.B.1f| | 1 |
Exhaust engine idle speed too high |7.3.A.2a| | 1 |
Rear Fuel system component leaking |7.2.3| | 1 |
Front Fuel pipe leaking AND REAR |7.2.3| | 1 |
Front Parking brake lever ratchet mechanism is excessively worn |3.1.5| | 1 |
Anti-roll bar insecure broken |2.4.G.1| | 1 |
Nearside Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Nearside Rear Rear reflector excessively damaged so that its function is impaired |1.5.1c| | 1 |
Nearside Front Drag link end ball joint has excessive play |2.2.B.1f| | 1 |
Nearside Rear Leaf spring cracked |2.4.B.1a| | 1 |
Front Exhaust has part of the system excessively deteriorated |7.1.1a| | 1 |
Nearside Inner Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Offside Inner Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Nearside Rear All position lamps not working |1.1.A.3b| | 1 |
Rear Stop lamp emits other than a steady red light |1.2.1e| | 1 |
Offside Steering component mounting prescribed area is excessively corroded |2.2.C.1h| | 1 |
Nearside Rear Suspension spring mounting prescribed area is deliberately modified which significantly reduces the original strength |2.4.A.3| | 1 |
Offside Rear Service brake indicates brake bind |3.7.D.2a| | 1 |
Nearside rear brake grabbing severely |3.7.A.5b| | 1 |
Offside rear brake grabbing severely |3.7.A.5b| | 1 |
Vehicle structure excessively corroded within 30cm of towbar mounting |6.6.6| | 1 |
Offside Front front brake juddering severely |3.7.A.2b| | 1 |
Nearside Front Windscreen wiper blade deteriorated |6.1.2| | 1 |
Offside Front Windscreen wiper blade deteriorated |6.1.2| | 1 |
Offside Rear fog lamp not in good working order |not working| |1.1.6b| | 1 |
Nearside Body has sharp edges or projections caused by corrosion or damage making the vehicle dangerous to other road users |6.5.10| | 1 |
Offside Front Body has sharp edges or projections caused by corrosion or damage making the vehicle dangerous to other road users |6.5.10| | 1 |
Offside Front brake disc excessively scored |3.5.1h| | 1 |
Centre Front Seat belt locking mechanism does not secure or release |5.2.5a| | 1 |
Brake pedal spongy |3.3.B.1b| | 1 |
Brake pedal has insufficient reserve movement |3.3.A.5| | 1 |
Rear rear brake excessively fluctuating |3.7.B.3| | 1 |
Nearside Rear Passenger`s seat insecure bolt not secure |6.2.A.1| | 1 |
Offside Front Inner Steering component mounting prescribed area is excessively corroded floor |2.2.C.1h| | 1 |
Nearside Rear wheel bearing has excessive play |2.6.2| | 1 |
Offside Front Power steering pipe|s| or hose|s| leaking from a joint inner arch area |2.3.3b| | 1 |
Offside Front Subframe mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Offside Front Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Hazard warning switch faulty |1.4.B.1d| | 1 |
Offside Lower Ball joint has excessive play |2.2.B.1f| | 1 |
Rear Brake clevis joint has restricted free movement |3.5.1k| | 1 |
Offside Front Seat belt insecurely fixed to the vehicles structure |5.2.1a| | 1 |
Centre Front Seat belt insecurely fixed to the vehicles structure |5.2.1a| | 1 |
Nearside Front Anti-roll bar linkage fractured |2.4.G.1| | 1 |
Leaf spring has excessive wear in a shackle pin and/or bush |2.4.B.2| | 1 |
Offside Rear fog lamp insecure |1.3.2a| | 1 |
Offside Rear Hydraulic brake cylinder leaking hydraulic fluid |1.1.16 |b| |i|| | 1 |
Nearside Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting sill inner |6.2.2 |d| |i|| | 1 |
Offside Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting sill inner |6.2.2 |d| |i|| | 1 |
Centre Front Brake pipe leaking |3.6.A.1| | 1 |
Nearside Rear Direction indicator excessively deteriorated so that it is not visible from a reasonable distance |1.4.A.2e| | 1 |
Offside Front Seat belt retracting mechanism defective |5.2.5b| | 1 |
Nearside Rear Leaf spring anchor bracket corroded and seriously weakened |2.4.B.6d| | 1 |
Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Centre Front Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
Offside Front Seat belt damaged sufficient to obstruct correct operation of the belt |5.2.2a| | 1 |
Offside Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Nearside Outer Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Offside Outer Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Nearside Rear Leaf spring fractured |2.4.B.1a| | 1 |
Parking brake lever has no reserve travel |3.1.6b| | 1 |
Offside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Offside Inner Rear Brake cable has a seized clevis joint pivot |3.5.1c| | 1 |
Offside Power steering pipe|s| or hose|s| leaking |2.3.3b| | 1 |
Offside front brake binding |3.7.B.1| | 1 |
Offside Front Upper Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
Offside Rear fog lamp excessively damaged so that it is not visible from a reasonable distance |1.3.2d| | 1 |
Front Power steering component|s| leaking |2.3.3b| | 1 |
Parking brake efficiency less than 50% of the required value (1.4.2 (a) (ii)) | 1 |
Rear Rear fog lamp not working (4.5.1 (a) (ii)) | 1 |
Rear Service brake has no recorded effort at a wheel both sides (1.2.1 (a) (ii)) | 1 |
Brake load sensing valve seized and ABS not fitted or inoperative (1.1.17 (c) (ii)) | 1 |
Emissions not tested (8.2.1.2 (d)) | 1 |
Exhaust has a major leak of exhaust gases front flexi area (6.1.2 (a)) | 1 |
Rear fog lamp not working (4.5.1 (a) (ii)) | 1 |
Parking brake efficiency below requirements (1.4.2 (a) (i)) | 1 |