| Most common failures | No# failures |
|---|
| Brake pipe excessively corroded | 48 |
| Windscreen wiper does not clear the windscreen effectively | 41 |
| Service brake: efficiency below requirements |3.7.B.7| | 15 |
| Headlamp aim out of alignment | 13 |
| Offside Stop lamp not working |1.2.1b| | 9 |
| Anti-lock braking system warning lamp indicates an ABS fault | 9 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 8 |
| Brakes imbalanced across an axle | 8 |
| Registration plate lamp issues | 8 |
| Registration plate issues | 8 |
| Offside Front Track rod end ball joint has excessive play |2.2.B.1f| | 6 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 6 |
| Parking brake lever has no reserve travel |3.1.6b| | 5 |
| Offside Front Anti-roll bar has excessive play in a ball joint |2.4.G.2| | 4 |
| Exhaust has a major leak of exhaust gases |7.1.2| | 4 |
| Nearside Stop lamp not working |1.2.1b| | 4 |
| Parking brake: efficiency below requirements |3.7.B.7| | 4 |
| Nearside Front Track rod end ball joint has excessive play |2.2.B.1f| | 3 |
| Offside Front Anti-roll bar linkage has excessive play in a ball joint |2.4.G.2| | 3 |
| Steering column top bearing excessively worn |2.1.2c| | 3 |
| Offside Rear fog lamp not working |1.3.2b| | 3 |
| Nearside Track rod end ball joint has excessive play |2.2.B.1f| | 3 |
| Offside Rear position lamp|s| not working |1.1.A.3b| | 2 |
| Front Exhaust system not adequately supported |7.1.1| | 2 |
| Nearside Front Front position lamp|s| not working |1.1.A.3b| | 2 |
| Engine MIL inoperative or indicates a malfunction |8.2.1.2 |h|| | 2 |
| Rear brake disc in such a condition that it is seriously weakened | 2 |
| Nearside Front Anti-roll bar has excessive play in a ball joint |2.4.G.2| | 2 |
| Horn not working |1.6.2a| | 2 |
| Nearside Front Anti-roll bar ball joint excessively worn (5.3.4 (a) (i)) | 2 |
| Offside Front Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 2 |
| Steering system has excessive free play detected at the steering wheel |steering rack fitted| |2.2.A.1b| | 2 |
| Offside Track rod end ball joint has excessive play |2.2.B.1f| | 2 |
| Nearside front brake binding |3.7.B.1| | 2 |
| Nearside Front Outer Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 2 |
| Offside Front Outer Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 2 |
| Steering column movement between the shaft and steering wheel |2.1.2b| | 2 |
| Engine MIL inoperative or indicates a malfunction (8.2.1.2 (h)) | 2 |
| Rear brake binding | 2 |
| Front Exhaust has a major leak of exhaust gases flange |7.1.2| | 2 |
| Front brake disc in such a condition that it is seriously weakened | 2 |
| Central Rear Brake pipe leaking on a hydraulic braking system across axle (1.1.11 (b) (ii)) | 1 |
| Offside Front Brake pipe leaking on a hydraulic braking system (1.1.11 (b) (ii)) | 1 |
| Brake performance unable to be tested leaking brake pipes (1.2.1 (g)) | 1 |
| Exhaust carbon monoxide content after 2nd fast idle exceeds manufacturers specified limits (8.2.1.2 (a)) | 1 |
| Nearside Front Anti-roll bar linkage ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Service brake efficiency below requirements (1.2.2 (a) (i)) | 1 |
| Nearside Front Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Windscreen has a sticker or other obstruction encroaching into the swept area by more than 40mm outside zone `A` |8.3.1e| | 1 |
| Offside Rear Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 1 |
| Nearside Rear Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 1 |
| Nearside Rear Stop lamp not working |1.2.1b| | 1 |
| Nearside rear brake recording little or no effort |3.7.B.5a| | 1 |
| Offside rear brake recording little or no effort |3.7.B.5a| | 1 |
| Offside Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Front brake application uneven | 1 |
| Nearside Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Brake pedal spongy |3.3.B.1b| | 1 |
| Offside Headlamp not working on dipped beam |1.7.5a| | 1 |
| Offside Rear brake drum contaminated by oil |3.5.1h| | 1 |
| Offside Front Braking system leaking |3.6.A.1| | 1 |
| Offside Front Upper Anti-roll bar linkage has excessive play in a ball joint |2.4.G.2| | 1 |
| Nearside Rear Anti-roll bar linkage rubber mounting deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Front constant velocity joint gaiter deteriorated to the extent that it no longer prevents the ingress of dirt etc both front |2.5.C.1a| | 1 |
| Front Direction indicator incorrect colour both |1.4.A.2f| | 1 |
| Anti-roll bar has excessive play in a pin/bush both front drop links |2.4.G.2| | 1 |
| Rear Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| rear brake recording little or no effort |3.7.B.5a| | 1 |
| Rear coil spring broken |2.4.C.1a| | 1 |
| Nearside Rear Seat belt anchorage prescribed area strength or continuity significantly reduced Corrosion |holed| to NSR outer sill within 30cm NSR seatbelt lower mount |7.1.1 |a| |i|| | 1 |
| Nearside Body component insecure Body side step frame excessively corroded and fractured |6.2.1 |a| |i|| | 1 |
| Offside Body component insecure Body side step frame excessively corroded and fractured |6.2.1 |a| |i|| | 1 |
| Nearside Front Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt |6.1.7 |g| |ii|| | 1 |
| Rear Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced Rear chassis cross-member severe corrosion |6.1.1 |c| |i|| | 1 |
| Offside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength OSR chassis rail severe corrosion within 30cm suspension mount |5.3.6 |a| |i|| | 1 |
| Brake performance not tested Brake performance not tested - danger of damage to vehicle or injury to other road users due to excessively worn brake system components |1.2.1 |g|| | 1 |
| Front Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Nearside Rear Coil spring mounting corroded and seriously weakened seat |2.4.C.3c| | 1 |
| Front Front wheel bearing has excessive play both |2.5.A.3c| | 1 |
| Offside Rear brake caliper has restricted free movement seized |3.5.1k| | 1 |
| Nearside Rear Seat belt anchorage prescribed area strength or continuity significantly reduced sill |7.1.1 |a| |i|| | 1 |
| Offside Rear Seat belt anchorage prescribed area strength or continuity significantly reduced |7.1.1 |a| |i|| | 1 |
| Nearside Outer Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt |6.1.7 |g| |ii|| | 1 |
| Nearside Front Lower Suspension arm ball joint dust cover no longer prevents the ingress of dirt |5.3.4 |b| |ii|| | 1 |
| Offside Front Lower Suspension arm ball joint dust cover no longer prevents the ingress of dirt |5.3.4 |b| |ii|| | 1 |
| Nearside Front Headlamp not working on dipped beam |1.7.5a| | 1 |
| Nearside Front suspension has excessive play in a upper suspension ball joint |2.5.B.1a| | 1 |
| Nearside Front Side repeater not working |1.4.A.2c| | 1 |
| Nearside Front Headlamp insecure |1.7.3| | 1 |
| Nearside Front Lower Anti-roll bar has excessive play in a ball joint |2.4.G.2| | 1 |
| Offside Front wheel bearing rough when rotated |2.5.A.2| | 1 |
| Offside Rear Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
| Nearside Front Direction indicator incorrect colour (4.4.3 (a)) | 1 |
| Offside Front Direction indicator incorrect colour (4.4.3 (a)) | 1 |
| Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 1 |
| Rear Exhaust system insecure (6.1.2 (a)) | 1 |
| Emissions not tested due to exhaust system (8.2.1.2 (d)) | 1 |
| Offside Rear Coil spring fractured or broken (5.3.1 (b) (i)) | 1 |
| Nearside Rear Lower Anti-roll bar linkage pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Rear Lower Anti-roll bar linkage pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Nearside Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt |6.1.7 |g| |ii|| | 1 |
| Offside Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt |6.1.7 |g| |ii|| | 1 |
| Offside Rear coil spring cracked |2.4.C.1a| | 1 |
| Nearside Front Lower Suspension arm ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Nearside Front wheel bearing has excessive play |2.5.A.3c| | 1 |
| Offside Front brake caliper has restricted free movement |3.5.1k| | 1 |
| Offside Rear brake disc excessively pitted |3.5.1h| | 1 |
| Nearside Rear Seat belt has a cut which has significantly weakened the webbing |5.2.2a| | 1 |
| Nearside Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
| Offside Front Hydraulic brake calliper leaking (1.1.16 (b) (i)) | 1 |
| Brake performance not tested Due to leak in braking system (1.2.1 (g)) | 1 |
| Nearside Rear reflector defective or damaged by more than 50% of the reflecting surface (4.8.1 (a) (ii)) | 1 |
| Offside Rear reflector defective or damaged by more than 50% of the reflecting surface (4.8.1 (a) (ii)) | 1 |
| Steering column has excessive movement up and down (2.2.2 (a)) | 1 |
| Front Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 1 |
| Stop lamp not working both side |1.2.1b| | 1 |
| Nearside Rear Shock absorber has a serious fluid leak |2.7.3| | 1 |
| Upper Stop lamp has less than 50% of the light sources illuminating |1.2.1b| | 1 |
| Nearside Rear Anti-roll bar pin or bush excessively worn |5.3.4 |a| |i|| | 1 |
| Offside Front Anti-roll bar pin or bush excessively worn |5.3.4 |a| |i|| | 1 |
| Nearside Front Anti-roll bar linkage ball joint excessively worn |5.3.4 |a| |i|| | 1 |
| Offside Front Anti-roll bar linkage ball joint excessively worn |5.3.4 |a| |i|| | 1 |
| Nearside Front Direction indicator incorrect colour |1.4.A.2f| | 1 |
| Offside Front Direction indicator incorrect colour |1.4.A.2f| | 1 |
| Offside Rear rear brake recording little or no effort |3.7.B.5a| | 1 |
| Rear fog lamp not working |1.3.2b| | 1 |
| Centre Exhaust system not adequately supported |7.1.1| | 1 |
| Nearside Front Anti-roll bar linkage has excessive play in a ball joint |2.4.G.2| | 1 |
| Exhaust system not adequately supported |7.1.1| | 1 |
| Nearside Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings sill |6.1.B.2| | 1 |
| Offside Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings sill |6.1.B.2| | 1 |
| Windscreen washer control is inaccessible to the driver |8.2.1a| | 1 |
| Horn sound not in accordance with requirements (7.7 (c)) | 1 |
| Offside Front Position lamp not working |4.2.1 |a|| | 1 |
| Rear Brake pipe leaking on a hydraulic braking system |1.1.11 |b| |ii|| | 1 |
| Offside Front Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Exhaust has a major leak of exhaust gases exhaust manifold |6.1.2 |a|| | 1 |
| Nearside Seat belt anchorage prescribed area strength or continuity significantly reduced outer sill |7.1.1 |a| |i|| | 1 |
| Steering column top mounting bracket insecure excess movement |2.1.2d| | 1 |
| Offside Front Anti-roll bar has excessive play in a ball joint link |2.4.G.2| | 1 |
| Centre Exhaust has a major leak of exhaust gases box |7.1.2| | 1 |
| Nearside Front Anti-roll bar has excessive play in a ball joint link |2.4.G.2| | 1 |
| Offside Front Brake pipe leaking on a hydraulic braking system inner side of chassis (1.1.11 (b) (ii)) | 1 |
| Exhaust Lambda reading after 2nd fast idle outside specified limits (8.2.1.2 (c)) | 1 |
| Brake performance unable to be tested (1.2.1 (g)) | 1 |
| Offside front brake binding |3.7.B.1| | 1 |
| Offside Headlamp not working on main beam |1.7.5a| | 1 |
| Offside Rear Upper Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced CHASSIS |6.1.1 |c| |i|| | 1 |
| Offside Rear Vehicle structure has excessive corrosion which adversely affects braking or steering CHASSIS AT EXHAUST MOUNTING AT TOP AND BOTTOM |6.1.1 |c| |ii|| | 1 |
| Nearside Rear Vehicle structure is fractured and structural rigidity is significantly reduced AT SUSPENSION MOUNTING POINT |6.1.1 |a| |i|| | 1 |
| Nearside Rear Vehicle structure has excessive corrosion which adversely affects braking or steering CHASSIS HOLED |6.1.1 |c| |ii|| | 1 |
| Exhaust has a major leak of exhaust gases MANIFOLD CRACKED |6.1.2 |a|| | 1 |
| Offside Rear Inner Integral body structure or chassis has excessive corrosion to the extent that overall security or stability of the body is impaired SILL AREA AS MARKED |6.2.2 |d| |ii|| | 1 |
| Parking brake efficiency below requirements |1.4.2 |a| |i|| | 1 |
| Nearside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
| Brake load sensing valve seized |3.6.E.3| | 1 |
| Nearside Rear brake caliper has restricted free movement |3.5.1k| | 1 |
| Service brake efficiency below requirements |1.2.2 |a| |i|| | 1 |
| Nearside Rear Service brake effort inadequate at a wheel |1.2.1 |a| |i|| | 1 |
| Offside Rear Service brake effort inadequate at a wheel |1.2.1 |a| |i|| | 1 |
| Nearside Rear Seat belt anchorage prescribed area strength or continuity significantly reduced outer/innerlower sill panels |7.1.1 |a| |i|| | 1 |
| Offside Seat belt anchorage prescribed area strength or continuity significantly reduced outer sill/innerlower sill panels |7.1.1 |a| |i|| | 1 |
| Nearside Rear Anti-roll bar linkage rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Rear Anti-roll bar linkage rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Front Anti-roll bar linkage has excessive play in a pin/bush |2.4.G.2| | 1 |
| Nearside Headlamp not working on dipped beam |1.7.5a| | 1 |
| Nearside Rear Seat belt locking mechanism does not secure or release |5.2.5a| | 1 |
| Nearside Rear Outer Seat belt anchorage prescribed area is excessively corroded Sill |5.2.6| | 1 |
| Front Anti-roll bar has excessive play in a pin/bush D types |Both| |2.4.G.2| | 1 |
| Offside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
| Nearside Rear Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Rear Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Obligatory mirror missing |8.1.1| | 1 |
| Parking brake: efficiency below requirements |3.7.C.1b| | 1 |
| Brake load sensing valve linkage seized |3.6.E.3| | 1 |
| Exhaust emissions carbon monoxide content at idle excessive |7.3.D.4| | 1 |
| Exhaust emissions carbon monoxide content after 2nd fast idle excessive |7.3.D.3| | 1 |
| Exhaust emits excessive dense blue smoke during acceleration |7.3.A.2c| | 1 |
| Exhaust emits dense blue smoke at idle |7.3.A.2b| | 1 |
| Windscreen wiper blade insecure | 1 |
| Nearside Front Position lamp light intensity significantly reduced (4.2.3 (a) (ii)) | 1 |
| Offside Front Position lamp light intensity significantly reduced (4.2.3 (a) (ii)) | 1 |
| Nearside Front Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 1 |
| Nearside Front Suspension component ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Nearside Front Track rod end ball joint has excessive play (2.1.3 (b) (i)) | 1 |
| Brake load sensing valve seized but ABS functioning (1.1.17 (c) (i)) | 1 |
| Nearside Front Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Offside Outer Suspension component mounting prescribed area is inadequately repaired sill (5.3.6 (a) (i)) | 1 |
| Offside Outer Seat belt anchorage prescribed area is inadequately repaired sill (7.1.1 (a) (i)) | 1 |
| Front Steering column has excessive movement up and down (2.2.2 (a)) | 1 |
| Rear Anti-roll bar linkage pin or bush excessively worn both link bushes worn (5.3.4 (a) (i)) | 1 |
| Offside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength (5.3.6 (a) (i)) | 1 |
| Nearside Front Anti-roll bar linkage insecure |2.4.G.1| | 1 |
| Nearside Front wheel bearing rough when rotated |2.5.A.2| | 1 |
| Offside Front Service brake excessively binding (1.2.1 (f)) | 1 |
| Offside Front Front position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Front Outer Suspension component mounting prescribed area excessively corroded significantly reducing structural strength chassis rail. (5.3.6 (a) (i)) | 1 |
| Nearside Front Service brake excessively binding (1.2.1 (f)) | 1 |
| Offside Rear Brake pipe leaking on a hydraulic braking system (1.1.11 (b) (ii)) | 1 |
| Brake performance unable to be tested due to fluid leak (1.2.1 (g)) | 1 |
| Nearside Rear Outer Seat belt anchorage prescribed area strength or continuity significantly reduced sill (7.1.1 (a) (i)) | 1 |
| Nearside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength chassis (5.3.6 (a) (i)) | 1 |
| Windscreen washer not working | 1 |
| Offside Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Exhaust has a major leak of exhaust gases manifold area (6.1.2 (a)) | 1 |
| Nearside Front Obligatory mirror seriously damaged, affecting the rear view |8.1.2a| | 1 |
| Nearside Front front brake binding |3.7.B.1| | 1 |
| Steering column top mounting bracket insecure |2.1.2d| | 1 |