| Most common failures | No# failures |
|---|
| Brake pipe excessively corroded | 3095 |
| Registration plate lamp issues | 1378 |
| Windscreen wiper does not clear the windscreen effectively | 1028 |
| Headlamp aim out of alignment | 916 |
| Service brake: efficiency below requirements |3.7.B.7| | 728 |
| Registration plate issues | 451 |
| Nearside Front constant velocity joint gaiter split |2.5.C.1a| | 398 |
| Offside Front constant velocity joint gaiter split |2.5.C.1a| | 373 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 351 |
| Nearside Front Anti-roll bar linkage has excessive play in a ball joint |2.4.G.2| | 334 |
| Offside Front Anti-roll bar linkage has excessive play in a ball joint |2.4.G.2| | 317 |
| Brakes imbalanced across an axle | 310 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 306 |
| Nearside Stop lamp not working |1.2.1b| | 305 |
| Offside Stop lamp not working |1.2.1b| | 287 |
| Parking brake: efficiency below requirements |3.7.B.7| | 245 |
| Nearside Front Front constant velocity joint gaiter split |2.5.C.1a| | 235 |
| Offside Front Front constant velocity joint gaiter split |2.5.C.1a| | 227 |
| Anti-lock braking system warning lamp indicates an ABS fault | 218 |
| Nearside Front wheel bearing has excessive play |2.5.A.3c| | 213 |
| Supplementary Restraint System warning lamp indicates a fault |5.4.2| | 197 |
| Centre Exhaust has a major leak of exhaust gases |7.1.2| | 193 |
| Exhaust has a major leak of exhaust gases |7.1.2| | 192 |
| Offside Front Track rod end ball joint has excessive play |2.2.B.1f| | 191 |
| Rear brake binding | 185 |
| Exhaust emits an excessive level of metered smoke for a turbo charged engine |7.4.B.3b| | 181 |
| Rear parking brake recording little or no effort | 176 |
| Offside Front wheel bearing has excessive play |2.5.A.3c| | 174 |
| Offside Track rod end ball joint has excessive play |2.2.B.1f| | 166 |
| Nearside rear brake recording little or no effort |3.7.B.5a| | 154 |
| Nearside Front Track rod end ball joint has excessive play |2.2.B.1f| | 143 |
| Offside rear brake recording little or no effort |3.7.B.5a| | 141 |
| Nearside Track rod end ball joint has excessive play |2.2.B.1f| | 131 |
| Offside Front Direction indicator incorrect colour |1.4.A.2f| | 130 |
| Nearside Front Front position lamp|s| not working |1.1.A.3b| | 127 |
| Nearside Rear Anti-roll bar linkage has excessive play in a pin/bush |2.4.G.2| | 126 |
| Offside Rear Anti-roll bar linkage has excessive play in a pin/bush |2.4.G.2| | 126 |
| Rear Exhaust has a major leak of exhaust gases |7.1.2| | 125 |
| Nearside Rear Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 125 |
| Offside Rear Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 124 |
| Nearside Front Front wheel bearing has excessive play |2.5.A.3c| | 122 |
| Nearside Front Direction indicator incorrect colour |1.4.A.2f| | 119 |
| Steering column top bearing excessively worn |2.1.2c| | 117 |
| Offside Rear Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 116 |
| Offside Rear Stop lamp not working |1.2.1b| | 115 |
| Offside Front Front position lamp|s| not working |1.1.A.3b| | 112 |
| Nearside Rear Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 110 |
| Offside Front Front wheel bearing has excessive play |2.5.A.3c| | 109 |
| Nearside Rear Stop lamp not working |1.2.1b| | 96 |
| Nearside Outer Front constant velocity joint gaiter split |2.5.C.1a| | 94 |
| Steering column top mounting bracket insecure |2.1.2d| | 94 |
| Offside Outer Front constant velocity joint gaiter split |2.5.C.1a| | 93 |
| Emissions not tested |7.0| | 92 |
| Rear brake disc in such a condition that it is seriously weakened | 87 |
| Offside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 83 |
| Windscreen has damage | 81 |
| Nearside front brake binding |3.7.B.1| | 78 |
| Parking brake: efficiency below requirements |3.7.C.1b| | 78 |
| Nearside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 77 |
| Offside Front Anti-roll bar linkage has excessive play in a pin/bush |2.4.G.2| | 76 |
| Brake hose excessively deteriorated | 76 |
| Nearside Front Anti-roll bar linkage has excessive play in a pin/bush |2.4.G.2| | 75 |
| Nearside Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 75 |
| Nearside Rear Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 73 |
| Offside Rear fog lamp not working |1.3.2b| | 73 |
| Offside Rear Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 70 |
| Parking brake lever has no reserve travel |3.1.6b| | 70 |
| Offside Rear rear brake recording little or no effort |3.7.B.5a| | 68 |
| Rear brake application uneven | 68 |
| Nearside Front Anti-roll bar has excessive play in a ball joint |2.4.G.2| | 67 |
| Nearside Rear rear brake recording little or no effort |3.7.B.5a| | 63 |
| Offside Front Anti-roll bar has excessive play in a ball joint |2.4.G.2| | 63 |
| Offside Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 58 |
| Service brake: efficiency below requirements |3.7.C.1a| | 57 |
| Battery insecure |1.9.1| | 54 |
| Nearside Rear Anti-roll bar linkage rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 52 |
| Offside Rear Anti-roll bar linkage rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 52 |
| Front brake application uneven | 52 |
| Brake performance not tested |3.7.A.1| | 51 |
| Steering column movement between the shaft and steering wheel |2.1.2b| | 51 |
| Nearside Front Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 50 |
| Brake pedal spongy |3.3.B.1b| | 50 |
| Fuel tank leaking |7.2.3| | 48 |
| Offside Front Wheel nut|s| missing |4.2.A.1e| | 47 |
| Brake hydraulic reservoir fluid level below minimum level |3.6.G.1b| | 45 |
| Offside Windscreen wiper blade deteriorated |8.2.2| | 45 |
| Offside Front Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 45 |
| Windscreen has a sticker or other obstruction encroaching into the swept area by more than 40mm outside zone `A` |8.3.1e| | 43 |
| Offside Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 42 |
| Nearside Front constant velocity joint gaiter deteriorated to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 42 |
| Nearside Windscreen wiper blade deteriorated |8.2.2| | 42 |
| Horn not working |1.6.2a| | 42 |
| Offside Front constant velocity joint gaiter deteriorated to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 42 |
| Nearside Front Lower Suspension arm ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 41 |
| Nearside Headlamp not working on dipped beam |1.7.5a| | 41 |
| Offside Headlamp not working on dipped beam |1.7.5a| | 40 |
| Offside front brake binding |3.7.B.1| | 40 |
| Nearside Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 40 |
| Offside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 39 |
| Rear Mechanical brake component has restricted free movement | 38 |
| Offside Front Anti-roll bar linkage insecure |2.4.G.1| | 37 |
| Nearside Front Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 37 |
| Offside Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 37 |
| Offside Front Lower Suspension arm ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 36 |
| Offside Front Lower Suspension arm ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 36 |
| Hazard warning switch faulty |1.4.B.1d| | 35 |
| Centre Exhaust has part of the system excessively deteriorated |7.1.1a| | 34 |
| Power steering pipe|s| or hose|s| leaking |2.3.3b| | 34 |
| Offside Front Direction indicators incorrect colour |1.4.A.2f| | 33 |
| Offside Front Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 33 |
| Nearside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 32 |
| Windscreen wiper blade insecure | 32 |
| Brake pipe inadequately clipped |3.6.B.1| | 32 |
| Front brake disc in such a condition that it is seriously weakened | 31 |
| Nearside Front Lower Suspension arm ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 31 |
| Nearside Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 31 |
| Offside Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 30 |
| Nearside Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 30 |
| Nearside Rear Anti-roll bar linkage rubber mounting deteriorated resulting in excessive movement |2.4.G.2| | 30 |
| Offside Rear Anti-roll bar linkage rubber mounting deteriorated resulting in excessive movement |2.4.G.2| | 30 |
| Offside Rear Wheel nut|s| missing |4.2.A.1e| | 30 |
| Nearside Front Direction indicators incorrect colour |1.4.A.2f| | 30 |
| Front constant velocity joint gaiter split |2.5.C.1a| | 29 |
| Offside Front Anti-roll bar linkage fractured |2.4.G.1| | 29 |
| Nearside Rear brake disc excessively pitted |3.5.1h| | 29 |
| Nearside Front Wheel nut|s| missing |4.2.A.1e| | 28 |
| Exhaust has part of the system excessively deteriorated |7.1.1a| | 28 |
| Offside Rear Anti-roll bar rubber mounting deteriorated resulting in excessive movement |2.4.G.2| | 28 |
| Nearside rear brake juddering severely |3.7.A.5b| | 28 |
| Front Front constant velocity joint gaiter split |2.5.C.1a| | 27 |
| Nearside Rear Wheel nut|s| missing |4.2.A.1e| | 27 |
| Rear Exhaust has part of the system excessively deteriorated |7.1.1a| | 26 |
| Offside Front Windscreen wiper blade deteriorated |8.2.2| | 26 |
| Offside Obligatory mirror seriously damaged, affecting the rear view |8.1.2a| | 26 |
| Offside Rear brake disc excessively pitted |3.5.1h| | 26 |
| Nearside Rear Anti-roll bar rubber mounting deteriorated resulting in excessive movement |2.4.G.2| | 26 |
| Fuel system component leaking |7.2.3| | 25 |
| Offside Outer Front Front constant velocity joint gaiter split |2.5.C.1a| | 25 |
| Steering system has excessive free play detected at the steering wheel |steering rack fitted| |2.2.A.1b| | 25 |
| Rear Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 25 |
| Rear Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 25 |
| Nearside Front Anti-roll bar linkage insecure |2.4.G.1| | 24 |
| Mechanical brake component has restricted free movement | 24 |
| Hazard warning lamps not flashing in phase, with ignition on |1.4.B.1f| | 24 |
| Nearside Outer Front constant velocity joint gaiter deteriorated to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 24 |
| Nearside Rear coil spring fractured |2.4.C.1a| | 23 |
| Offside Outer Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 23 |
| Nearside Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 23 |
| Nearside Outer Front Front constant velocity joint gaiter split |2.5.C.1a| | 23 |
| rear brake recording little or no effort |3.7.B.5a| | 23 |
| Nearside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 23 |
| Fuel cap/sealing device does not fasten securely maintaining the sealing arrangement |7.2.4b| | 23 |