Most common failures | No# failures |
---|
Headlamp aim out of alignment | 18 |
Parking brake: efficiency below requirements |3.7.B.7| | 15 |
Brakes imbalanced across an axle | 11 |
Windscreen wiper does not clear the windscreen effectively | 10 |
Rear parking brake recording little or no effort | 9 |
Horn not working |1.6.2a| | 8 |
Nearside Track rod end ball joint has excessive play |2.2.B.1f| | 7 |
Rear brake binding | 7 |
Registration plate lamp issues | 7 |
Offside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 7 |
Offside Stop lamp not working |1.2.1b| | 6 |
Brake pipe excessively corroded | 5 |
Service brake: efficiency below requirements |3.7.B.7| | 5 |
Exhaust has a major leak of exhaust gases |7.1.2| | 4 |
Nearside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 4 |
Offside Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 4 |
Nearside Stop lamp not working |1.2.1b| | 4 |
Nearside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 3 |
Driver`s seat insecure |6.2.A.1| | 3 |
Offside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 3 |
Offside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 3 |
Offside Track rod end ball joint has excessive play |2.2.B.1f| | 3 |
Rear brake application uneven | 3 |
Nearside front brake binding |3.7.B.1| | 3 |
Parking brake lever has no reserve travel |3.1.6b| | 3 |
Offside Rear rear brake recording little or no effort |3.7.B.5a| | 3 |
Battery insecure |1.9.1| | 2 |
Offside Front wheel bearing has excessive play |2.5.A.3c| | 2 |
Nearside Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 2 |
Nearside Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
Nearside Headlamp not working on main beam |1.7.5a| | 2 |
Nearside Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 2 |
Offside Steering rack gaiter split |2.2.D.2d| | 2 |
Nearside Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 2 |
Offside rear brake recording little or no effort |3.7.B.5a| | 2 |
Windscreen washer not working | 2 |
Nearside Rear Suspension component mounting prescribed area is inadequately repaired (5.3.6 (a) (i)) | 2 |
Offside Rear Suspension component mounting prescribed area is inadequately repaired (5.3.6 (a) (i)) | 2 |
Offside Front Subframe mounting prescribed area is inadequately repaired rear mount (5.3.6 (a) (i)) | 2 |
Offside Rear Service brake excessively fluctuating (1.2.1 (e)) | 2 |
Nearside Front Subframe mounting prescribed area is inadequately repaired rear mount (5.3.6 (a) (i)) | 2 |
Steering system has excessive free play detected at the steering wheel |steering rack fitted| |2.2.A.1b| | 2 |
Nearside Front Headlamp not working on dipped beam |1.7.5a| | 2 |
Offside Front Upper Suspension arm has excessive play in a ball joint |2.4.G.2| | 2 |
Rear Exhaust has a major leak of exhaust gases |7.1.2| | 2 |
Nearside Rear rear brake recording little or no effort |3.7.B.5a| | 2 |
Nearside Front wheel bearing rough when rotated |2.5.A.2| | 2 |
Offside Front Sub-frame attachment bracket/mounting insecure |2.4.G.1| | 2 |
Nearside rear brake recording little or no effort |3.7.B.5a| | 2 |
Nearside Front Shock absorber has a serious fluid leak |2.7.3| | 2 |
Parking brake: efficiency below requirements |3.7.C.1b| | 2 |
Nearside Front Direction indicator not working |1.4.A.2c| | 2 |
rear brake recording little or no effort |3.7.B.5a| | 2 |
Front brake application uneven | 2 |
Offside Rear Direction indicator adversely affected by the operation of another lamp |1.4.A.2h| | 2 |
Front Exhaust has a major leak of exhaust gases |7.1.2| | 2 |
Nearside Headlamp not working on dipped beam |1.7.5a| | 2 |
Offside Front position lamp|s| not working |1.1.A.3b| | 2 |
Offside Headlamp not working on dipped beam |1.7.5a| | 2 |
Centre Exhaust has a major leak of exhaust gases |7.1.2| | 2 |
Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
Nearside Front Lower Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
Offside Front Lower Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
Offside Rear Lower Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
Nearside Front Upper Front suspension ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
Offside Front Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
Nearside Rear Tie bar/rod has excessive play in a ball joint |2.4.G.2| | 1 |
Offside Rear Tie bar/rod has excessive play in a ball joint |2.4.G.2| | 1 |
Nearside Ball joint has excessive play |2.2.B.1f| | 1 |
Lower Steering column flexible coupling has excessive play |2.1.5| | 1 |
Nearside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Offside Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Offside Front Seat belt has a cut which has significantly weakened the webbing |5.2.2a| | 1 |
Fuel pipe leaking |7.2.3| | 1 |
Exhaust system not adequately supported |7.1.1| | 1 |
rear brakes release unevenly |3.7.B.4| | 1 |
Offside Front Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Rear Fuel pipe leaking |7.2.3| | 1 |
Nearside Steering locking device missing |2.2.C.1g| | 1 |
Offside Steering locking device missing |2.2.C.1g| | 1 |
Nearside Passenger`s seat insecure |6.2.A.1| | 1 |
Offside Front Suspension component mounting prescribed area is inadequately repaired |2.4.A.3| | 1 |
Nearside Headlamp insecure |1.7.3| | 1 |
Offside Front Shock absorber has a serious fluid leak |2.7.3| | 1 |
Position lamp switch does not illuminate the front and rear position lamps with a single operation |1.1.A.2| | 1 |
Offside Rear Suspension arm corroded and seriously weakened |2.4.G.1| | 1 |
Offside Front Brake hose leaking |3.6.A.1| | 1 |
Nearside Inner Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Nearside Front Brake pipe leaking on a hydraulic braking system (1.1.11 (b) (ii)) | 1 |
Parking (secondary brake) on a single line braking system imbalanced across an axle Axle 1 (1.3.1 (b) (i)) | 1 |
Offside Headlamp not working on main beam |1.7.5a| | 1 |
Nearside Rear coil spring damaged by excessive heat |2.4.C.1c| | 1 |
Steering system excessively rough |2.2.D.1| | 1 |
Steering rack gaiter split |2.2.D.2d| | 1 |
Offside Front Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
Nearside Front Mechanical brake component locking device insecure LOWER BRAKE CALIPER BOLT |3.5.1l| | 1 |
Nearside Front position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
Nearside Front Steering rack gaiter split |2.2.D.2d| | 1 |
Offside Front Direction indicator excessively damaged so that it is not visible from a reasonable distance |1.4.A.2e| | 1 |
Hazard warning lamps not flashing in phase, with ignition off |1.4.B.1f| | 1 |
Nearside Front front brake binding |3.7.B.1| | 1 |
Brake hose has insufficient room to move | 1 |
Offside Front Upper Suspension component ball joint excessively worn |5.3.4 |a| |i|| | 1 |
Offside Front Upper Suspension component ball joint dust cover missing |5.3.4 |b| |ii|| | 1 |
Offside Rear Service brake lagging in operation |1.2.1 |d|| | 1 |
Nearside Seat belt insecurely fixed to the vehicles structure |5.2.1a| | 1 |
Nearside Front Upper Front suspension ball joint dust cover missing |2.4.G.2| | 1 |
Registration plate issues | 1 |
Nearside Rear Lower Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
Front Exhaust has part of the system excessively deteriorated |7.1.1a| | 1 |
Nearside Rear brake drum contaminated by oil |3.5.1h| | 1 |
Offside Front Seat belt damaged sufficient to obstruct correct operation of the belt |5.2.2a| | 1 |
Windscreen wiper not operating automatically when switched on motor nut loose on mechanism |8.2.1b| | 1 |
Offside Rear Stop lamp not working |1.2.1b| | 1 |
Steering wheel locking device missing |2.1.6| | 1 |
Nearside Rear Sub-frame has excessive play in a pin/bush |2.4.G.2| | 1 |
Offside Rear Sub-frame has excessive play in a pin/bush |2.4.G.2| | 1 |
Nearside Front Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
Offside Front Lower Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
Nearside Front position lamp|s| not working |1.1.A.3b| | 1 |
Nearside Front Anti-roll bar pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
Offside Front Anti-roll bar pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
Nearside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength (5.3.6 (a) (i)) | 1 |
Nearside Rear Brake lever has restricted free movement |3.5.1k| | 1 |
Offside Rear Brake lever has restricted free movement |3.5.1k| | 1 |
Offside Rear Parking brake inoperative on one side (1.4.1 (a)) | 1 |
Parking brake efficiency below requirements (1.4.2 (a) (i)) | 1 |
Offside Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
Nearside Front Sub-frame attachment bracket/mounting insecure |2.4.G.1| | 1 |
Nearside Front Sub-frame attachment rubber mounting deteriorated resulting in excessive movement |2.4.G.2| | 1 |
Offside Front Sub-frame attachment rubber mounting deteriorated resulting in excessive movement |2.4.G.2| | 1 |
Nearside Panhard rod attachment bracket/mounting insecure |2.4.G.1| | 1 |
Nearside Rear Panhard rod attachment bracket/mounting insecure |2.4.G.1| | 1 |
Nearside Front Tie bar/rod attachment bracket inappropriately repaired |2.4.A.2| | 1 |
Offside Front Shock absorber has negligible damping effect |2.7.5| | 1 |
Offside Rear Suspension component mounting prescribed area is fractured |2.4.A.3| | 1 |
Nearside Front Vehicle structure has an inadequate repair which adversely affects braking or steering |6.1.A.1| | 1 |
Offside Track rod end loose |2.2.B.1d| | 1 |
Nearside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Offside Vehicle structure has a fracture which adversely affects braking or steering |6.1.A.1| | 1 |
Offside Rear brake disc contaminated by oil |3.5.1h| | 1 |
Nearside Front Lower Suspension arm attachment bracket/mounting fractured |2.4.G.1| | 1 |
Offside Front Lower Suspension arm attachment bracket/mounting fractured |2.4.G.1| | 1 |
Front Horn not working |1.6.2a| | 1 |
Offside Front Headlamp not working on main beam |1.7.5a| | 1 |
Rear Exhaust system not adequately supported |7.1.1| | 1 |
Rear Parking brake lever has no reserve travel |3.1.6b| | 1 |
Offside Front Steering rack gaiter split |2.2.D.2d| | 1 |
Nearside Front Upper Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
Front Upper Ball joint has excessive play |2.2.B.1f| | 1 |
Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Offside Front Direction indicators not working |1.4.A.2c| | 1 |
Windscreen has a sticker or other obstruction encroaching by more than 10mm within zone `A` |8.3.1b| | 1 |
Brake has no servo assistance |3.3.B.2| | 1 |
Brake servo modified and seriously weakened |3.6.A.3| | 1 |
Nearside Stop lamp adversely affected by the operation of another lamp |1.2.1f| | 1 |
Offside Stop lamp adversely affected by the operation of another lamp |1.2.1f| | 1 |
Nearside Rear Direction indicator adversely affected by the operation of another lamp |1.4.A.2h| | 1 |
Nearside Rear position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
Offside Rear position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
Service brake: efficiency below requirements |3.7.C.1a| | 1 |
Headlamp not working on dipped beam |1.7.5a| | 1 |
Headlamp not working on main beam |1.7.5a| | 1 |
Nearside Front Subframe mounting prescribed area is severely distorted |2.4.A.3| | 1 |
Offside Front Subframe mounting prescribed area is severely distorted |2.4.A.3| | 1 |
Mechanical brake component has restricted free movement | 1 |
Rear Mechanical brake component has restricted free movement | 1 |
Nearside Front Front position lamp|s| not working |1.1.A.3b| | 1 |
Shock absorber has negligible damping effect |2.7.5| | 1 |
Direction indicators not working all indicators DO NOT FLASH |1.4.A.2c| | 1 |
Central Rear Suspension component mounting prescribed area is excessively corroded boot floor at spare wheel well |2.4.A.3| | 1 |
Nearside Rear Suspension component mounting prescribed area is excessively corroded boot floor |2.4.A.3| | 1 |
Nearside Rear Outer Suspension component mounting prescribed area is excessively corroded sill |2.4.A.3| | 1 |
Offside Rear Outer Suspension component mounting prescribed area is excessively corroded sill |2.4.A.3| | 1 |
Steering column top mounting bracket insecure |2.1.2d| | 1 |
Nearside Front suspension has excessive play in a upper suspension ball joint |2.5.B.1a| | 1 |
Offside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
Brake pedal has no servo assistance |3.3.B.2| | 1 |
Offside front brake binding |3.7.B.1| | 1 |
Nearside Lower Front suspension locking device missing |2.5.A.4| | 1 |
Offside Front Headlamp adversely affected by the operation of another lamp |1.7.5c| | 1 |
Nearside Front Suspension arm corroded and seriously weakened |2.4.G.1| | 1 |
Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Steering wheel retaining device insecure |2.1.6| | 1 |
Nearside Rear Direction indicator not working |1.4.A.2c| | 1 |
Rear Fuel hose leaking |7.2.3| | 1 |
Offside Rear Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
Nearside Rear Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
Steering system fouling |2.2.D.2a| | 1 |
Nearside Rear position lamp|s| not working |1.1.A.3b| | 1 |
Offside Rear position lamp|s| not working |1.1.A.3b| | 1 |
Offside Track rod end ball joint dust cover missing |2.2.C.1c| | 1 |
Nearside Rear Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
Offside Rear Direction indicator not working (4.4.1 (a) (ii)) | 1 |
Nearside Front Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 1 |
Nearside Front Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
Rear Brake pipe inadequately supported |3.6.B.1| | 1 |
Offside Front Body has a projection caused by corrosion |6.1.C.1| | 1 |
Direction indicators not working |1.4.A.2c| | 1 |
Front passenger door cannot be opened from outside the vehicle |6.2.B.1b| | 1 |
Front passenger seat insecure |6.2.3| | 1 |
An item not tested |Manual| | 1 |
Nearside Front Subframe mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Offside Front Subframe mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Front Headlamp not working on dipped beam |1.7.5a| | 1 |
Front Headlamp not working on main beam |1.7.5a| | 1 |
Anti-lock braking system warning lamp indicates an ABS fault | 1 |
Front Windscreen wiper not operating over a large enough area to give an adequate view |8.2.1c| | 1 |
Rear Seat belt affected by an insecure seat fixing |5.2.1b| | 1 |