| Most common failures | No# failures |
|---|
| Brakes imbalanced across an axle | 26 |
| Rear brake binding | 18 |
| Parking brake: efficiency below requirements |3.7.B.7| | 17 |
| Headlamp aim out of alignment | 11 |
| Parking brake: efficiency below requirements |3.7.C.1b| | 9 |
| Registration plate lamp issues | 9 |
| Service brake: efficiency below requirements |3.7.B.7| | 8 |
| Windscreen wiper does not clear the windscreen effectively | 8 |
| Rear parking brake recording little or no effort | 7 |
| Steering box insecure |2.2.B.1a| | 7 |
| Steering system has excessive free play detected at the steering wheel |steering box fitted| |2.2.A.1a| | 6 |
| Offside Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 6 |
| Nearside Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 6 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 6 |
| Nearside Headlamp not working on dipped beam |1.7.5a| | 5 |
| Offside Headlamp not working on main beam |1.7.5a| | 5 |
| Nearside Stop lamp not working |1.2.1b| | 4 |
| Parking brake lever has no reserve travel |3.1.6b| | 4 |
| Brake pipe excessively corroded | 4 |
| Horn not working |1.6.2a| | 4 |
| Nearside rear brake recording little or no effort |3.7.B.5a| | 4 |
| Offside Headlamp not working on dipped beam |1.7.5a| | 4 |
| Offside Front Upper Suspension arm has excessive play in a pin/bush |2.4.G.2| | 4 |
| Offside rear brake recording little or no effort |3.7.B.5a| | 3 |
| Offside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 3 |
| Exhaust system not adequately supported |7.1.1| | 3 |
| Rear brake application uneven | 3 |
| Offside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 3 |
| Front brake application uneven | 3 |
| Rear Exhaust has a major leak of exhaust gases |7.1.2| | 3 |
| Nearside Front Direction indicator not working |1.4.A.2c| | 3 |
| Brake pedal anti-slip provision missing |3.3.A.1b| | 3 |
| Nearside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 3 |
| Offside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 3 |
| Brake hose has insufficient room to move | 3 |
| Offside Rear Braking system leaking |3.6.A.1| | 2 |
| Offside Rear rear brake recording little or no effort |3.7.B.5a| | 2 |
| Offside Front Brake master cylinder/servo mounting prescribed area is excessively corroded |3.6.C.3| | 2 |
| Offside Front Front wheel bearing rough when rotated |2.5.A.2| | 2 |
| Offside Front wheel bearing rough when rotated |2.5.A.2| | 2 |
| Offside Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 2 |
| Nearside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 2 |
| Brake cable has wires broken and is significantly weakened |3.5.1b| | 2 |
| Brake pipe inadequately supported |3.6.B.1| | 2 |
| Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 2 |
| Nearside Front Front position lamp|s| not working |1.1.A.3b| | 2 |
| Brake pedal creeps down when held under pressure |3.3.B.1a| | 2 |
| Nearside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
| Front Brake pipe inadequately supported |3.6.B.1| | 2 |
| Fuel pipe insecure |7.2.1| | 2 |
| Offside Front Direction indicator not working |1.4.A.2c| | 2 |
| Offside Stop lamp not working |1.2.1b| | 2 |
| Nearside Vehicle structure has excessive corrosion which adversely affects braking or steering |6.1.A.1| | 2 |
| Offside Vehicle structure has excessive corrosion which adversely affects braking or steering |6.1.A.1| | 2 |
| Nearside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
| Battery insecure |1.9.1| | 2 |
| Nearside Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 2 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 2 |
| Nearside Rear Braking system leaking |3.6.A.1| | 2 |
| Nearside Front wheel bearing has excessive play |2.5.A.3c| | 2 |
| Nearside Rear Direction indicator not working |1.4.A.2c| | 2 |
| Nearside Front Direction indicator incorrect colour |1.4.A.2f| | 2 |
| Offside Front Direction indicator incorrect colour |1.4.A.2f| | 2 |
| Offside Front Brake pipe inadequately supported |3.6.B.1| | 2 |
| Service brake: efficiency below requirements |3.7.C.1a| | 2 |
| Front passenger door cannot be opened from inside the vehicle |6.2.B.1b| | 2 |
| Rear Exhaust system not adequately supported |7.1.1| | 2 |
| Offside Front suspension has excessive play in a upper suspension ball joint |2.5.B.1a| | 2 |
| Nearside Rear brake drum contaminated by oil |3.5.1h| | 2 |
| Offside Inner Front Upper Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Parking brake efficiency below requirements |1.4.2 |a| |i|| | 1 |
| Nearside Front Brake hose connection leaking on an air braking system |1.1.12 |c| |i|| | 1 |
| Nearside Front Front wheel bearing rough when rotated |2.5.A.2| | 1 |
| Windscreen washer not working | 1 |
| An item not tested |Manual| | 1 |
| Nearside Outer Front Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Nearside Front Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Nearside Front Vehicle structure has excessive corrosion which adversely affects braking or steering floor pan / gearbox mounting |6.1.A.1| | 1 |
| Offside Front Steering box insecure |2.2.B.1a| | 1 |
| All direction indicators not working (4.4.1 (a) (ii)) | 1 |
| Steering column top bearing excessively worn |2.1.2c| | 1 |
| Offside Rear Rear position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
| Offside Front Vehicle structure has a fracture which adversely affects braking or steering |6.1.A.1| | 1 |
| Steering component mounting prescribed area is fractured |2.2.C.1h| | 1 |
| Offside Rear front parking brake recording little or no effort |3.7.B.6a| | 1 |
| Rear Body or chassis has an inadequate repair, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Front Steering component mounting prescribed area is excessively corroded |2.2.C.1h| | 1 |
| Offside Front Body has a sharp edge caused by damage |6.1.C.1| | 1 |
| Offside Windscreen wiper blade missing |8.2.2| | 1 |
| Front Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Exhaust engine idle speed too high |7.3.A.2a| | 1 |
| Nearside front brake grabbing severely |3.7.A.2b| | 1 |
| Stop lamp emits other than a steady red light |1.2.1e| | 1 |
| Offside Stop lamp adversely affected by the operation of another lamp |1.2.1f| | 1 |
| Offside Rear position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
| Headlamp not working on dipped beam |1.7.5a| | 1 |
| Headlamp not working on main beam |1.7.5a| | 1 |
| Fuel hose insecure |7.2.1| | 1 |
| Offside Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Nearside Outer Lower Front suspension has excessive movement at a suspension ball joint |2.5.A.1c| | 1 |
| Windscreen wiper blade deteriorated |8.2.2| | 1 |
| Driver`s seat insecure |6.2.A.1| | 1 |
| Steering column cracked and unserviceable |2.2.C.1d| | 1 |
| Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Service brake is causing the vehicle to swerve to the offside |3.7.C.2| | 1 |
| Nearside Front Headlamp excessively damaged so that the light output is severely reduced |1.7.5a| | 1 |
| Offside Direction indicators not working |1.4.A.2c| | 1 |
| Nearside Rear Brake pipe fouled by moving parts |3.6.B.2a| | 1 |
| Nearside Rear Brake pipe inadequately clipped |3.6.B.1| | 1 |
| Brake has no servo assistance |3.3.B.2| | 1 |
| Nearside Front Upper Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Offside Direction indicator not working |1.4.A.2c| | 1 |
| Stop lamp not working |1.2.1b| | 1 |
| Nearside Lower Ball joint has excessive play |2.2.B.1f| | 1 |
| Nearside Front Lower Shock absorber has an excessively worn bush |2.7.4| | 1 |
| Offside Front Lower Shock absorber has an excessively worn bush |2.7.4| | 1 |
| Nearside Track rod end ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Offside Rear passenger door cannot be opened from outside the vehicle |6.2.B.1c| | 1 |
| Offside Front Subframe mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Nearside Track rod end ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Offside Track rod end ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Nearside Front Shock absorber missing |2.7.1b| | 1 |
| Brake cable insecure |3.5.1d| | 1 |
| Brake performance not tested |3.7.A.1| | 1 |
| Offside Front Front suspension has excessive movement at a wishbone pin or bush |2.5.A.1c| | 1 |
| Nearside Rear Braking system leaking back plate area |3.6.A.1| | 1 |
| All position lamps adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
| Nearside Headlamp adversely affected by the operation of another lamp |1.7.5c| | 1 |
| Offside Headlamp adversely affected by the operation of another lamp |1.7.5c| | 1 |
| Fuel pipe excessively chafed |7.2.2| | 1 |
| Nearside Lower Body or chassis has an inadequate repair, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Lower Body or chassis has an inadequate repair, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Front Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 1 |
| Offside Front Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Offside Front Lower Suspension arm pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Parking brake efficiency below requirements (1.4.2 (a) (i)) | 1 |
| Rear Stop lamp not working |1.2.1b| | 1 |
| Electrical wiring insecure under bonnet |1.9.2a| | 1 |
| Nearside Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Offside Front suspension has excessive movement at a wishbone pin or bush |2.5.A.1c| | 1 |
| Nearside Front Front wheel bearing has excessive play |2.5.A.3c| | 1 |
| Offside Front Front wheel bearing has excessive play |2.5.A.3c| | 1 |
| Offside Headlamp excessively damaged so that the light output is severely reduced |1.7.5a| | 1 |
| Offside Headlamp does not operate immediately when selected on main beam |1.7.4a| | 1 |
| Offside Steering pivot point has excessive play |2.2.B.1g| | 1 |
| Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Front Windscreen wiper not operating over a large enough area to give an adequate view |8.2.1c| | 1 |
| Offside Front Front position lamp|s| not working |1.1.A.3b| | 1 |
| Rear Mechanical brake component has restricted free movement | 1 |
| Nearside Suspension component mounting prescribed area is excessively corroded Inner sill |2.4.A.3| | 1 |
| Offside Front Suspension component mounting prescribed area is excessively corroded Wheel arch |2.4.A.3| | 1 |
| Nearside Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings wing inner rear |6.1.B.2| | 1 |
| Offside Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings wing rear inner |6.1.B.2| | 1 |
| Offside Front Vehicle structure has excessive corrosion which adversely affects braking or steering |6.1.A.1| | 1 |
| Nearside Inner Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Nearside Inner Front Upper Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Nearside Front Upper Bonded suspension unit deteriorated and cannot function as intended |2.4.F.3| | 1 |
| Offside Front Upper Bonded suspension unit deteriorated and cannot function as intended |2.4.F.3| | 1 |
| Offside Steering arm has relative movement at its fixings |2.2.B.1h| | 1 |
| Nearside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings floor pan area by gearbox mount |6.1.B.2| | 1 |
| Offside Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings outer sill |6.1.B.2| | 1 |
| Offside Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings inside wheel arch |6.1.B.2| | 1 |
| Nearside Front Shock absorber has a serious fluid leak |2.7.3| | 1 |
| Nearside Front Upper Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Driver`s seat fore and aft adjustment mechanism not functioning as intended. |6.2.A.3| | 1 |
| Offside Obligatory mirror missing |8.1.1| | 1 |
| Registration plate issues | 1 |
| Offside Front Headlamp not working on dipped beam |1.7.5a| | 1 |
| Nearside Front Shock absorber insecure |2.7.2b| | 1 |
| Offside Front Shock absorber insecure |2.7.2b| | 1 |
| Offside Front Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Nearside Direction indicators not working |1.4.A.2c| | 1 |
| Nearside Front Seat belt locking mechanism does not secure or release |5.2.5a| | 1 |
| Offside Front Seat belt locking mechanism does not secure or release |5.2.5a| | 1 |
| Front Service brake is causing the steering wheel to severely pull one way |3.7.C.2| | 1 |
| Offside Front Seat belt anchorage prescribed area is excessively corroded floor |5.2.6| | 1 |
| Offside Front Seat belt anchorage prescribed area is excessively corroded floor to chassis |5.2.6| | 1 |
| Nearside Rear Seat belt anchorage prescribed area is excessively corroded inner sill |5.2.6| | 1 |
| Offside Rear Suspension spring mounting prescribed area is excessively corroded leaf |2.4.A.3| | 1 |
| Offside Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Steering box has relative movement between sector shaft and the drop arm |2.2.B.1b| | 1 |
| Offside Position lamp not working |4.2.1 |a|| | 1 |
| Nearside Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Front Windscreen wiper not operating automatically when switched on |8.2.1b| | 1 |
| Nearside Rear Service brake grabbing severely |3.7.C.2| | 1 |
| Fuel cap/sealing device does not fasten securely maintaining the sealing arrangement |7.2.4b| | 1 |
| Nearside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Nearside Front brake caliper leaking |3.6.A.1| | 1 |
| Offside Rear Brake hose bulging under pressure |3.6.B.3| | 1 |
| Offside Rear Leaf spring has excessive side play at eye |shackle| |2.4.B.4| | 1 |
| Offside Front Service brake juddering severely |3.7.C.2| | 1 |
| Parking brake lever defective so that it cannot be satisfactorily operated |3.1.3c| | 1 |
| Nearside Front Lower Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Nearside Rear Brake pipe excessively damaged |3.6.B.2c| | 1 |
| Offside Rear Brake pipe excessively damaged |3.6.B.2c| | 1 |
| Offside Rear Parking brake not fitted on at least two wheels |3.1.1| | 1 |
| Nearside Rear Parking brake not fitted on at least two wheels |3.1.1| | 1 |
| Nearside Brake performance not tested |3.7.A.1| | 1 |
| Offside Brake performance not tested |3.7.A.1| | 1 |
| Nearside Upper Front suspension has excessive movement at a wishbone pin or bush |2.5.A.1c| | 1 |
| Nearside Front brake drum contaminated by brake fluid |3.5.1h| | 1 |
| Offside Rear brake drum contaminated by brake fluid |3.5.1h| | 1 |
| Nearside front brake recording little or no effort |3.7.B.5a| | 1 |
| Offside Rear Suspension spring mounting prescribed area is inadequately repaired |2.4.A.3| | 1 |
| Service brake is causing the vehicle to swerve to the nearside |3.7.C.2| | 1 |
| Steering wheel retaining device insecure |2.1.6| | 1 |
| Nearside Front Brake pipe inadequately supported |3.6.B.1| | 1 |
| Offside Track rod end ball joint has excessive play (2.1.3 (b) (i)) | 1 |
| Nearside Front Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 1 |
| Offside Front Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 1 |
| Offside Front Headlamp not working on main beam (4.1.1 (a) (ii)) | 1 |
| Nearside Front Headlamp aim not tested (4.1.2 (b)) | 1 |
| Offside Front Headlamp aim not tested (4.1.2 (b)) | 1 |
| Brake fluid significantly below minimum mark (1.1.10 (d) (ii)) | 1 |
| Offside Brake pipe leaking on a hydraulic braking system front to centre (1.1.11 (b) (ii)) | 1 |
| Service brake efficiency below requirements (1.2.2 (a) (i)) | 1 |
| Speedometer clearly inoperative (7.8 (b) (ii)) | 1 |
| Nearside Rear Direction indicator not working (4.4.1 (a) (ii)) | 1 |
| Nearside Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Windscreen has a sticker or other obstruction encroaching into the swept area by more than 40mm outside zone `A` |8.3.1e| | 1 |
| Offside Front Front suspension has excessive play in a upper wishbone bearing |2.5.B.1a| | 1 |
| Offside Headlamp excessively deteriorated so that the light output is severely reduced |1.7.5a| | 1 |
| Nearside Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Front Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Nearside Headlamp not working on main beam |1.7.5a| | 1 |
| Nearside Rear Parking (secondary brake) on a single line braking system has inadequate effort at a wheel (1.3.1 (a) (i)) | 1 |
| Offside Front coil spring fractured |2.4.C.1a| | 1 |
| Nearside Rear Brake back plate|s| securing device loose |3.5.1j| | 1 |
| Offside Service brake is causing the steering wheel to severely pull one way |3.7.C.2| | 1 |
| Parking brake lever is fouling adjacent parts of the vehicle |3.1.6b| | 1 |
| Offside Rear Brake clevis joint locking device insecure |3.5.1l| | 1 |
| Offside Front Body or chassis is cracked, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Steering system excessively tight |2.2.D.1| | 1 |
| Offside Front Seat belt anchorage prescribed area is fractured |5.2.6| | 1 |
| Nearside Front Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Nearside Front Front position lamp|s| incorrect colour |1.1.A.3e| | 1 |
| Offside Front Front position lamp|s| incorrect colour |1.1.A.3e| | 1 |
| Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Offside Front Brake hose excessively damaged |3.6.B.4d| | 1 |
| Fuel system component leaking |7.2.3| | 1 |
| Offside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside front brake binding |3.7.B.1| | 1 |
| Nearside Rear Braking system leaking cylinder
|3.6.A.1| | 1 |
| Front Brake pipe inadequately clipped from master to axle valve |3.6.B.1| | 1 |
| Front Headlamp not working on dipped beam |1.7.5a| | 1 |
| Nearside Front suspension has excessive play in a upper suspension ball joint |2.5.B.1a| | 1 |
| Centre Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Offside Front Lower Front suspension retaining device ineffective |2.5.A.4| | 1 |
| Nearside front brake binding |3.7.B.1| | 1 |
| Parking brake efficiency less than 50% of the required value (1.4.2 (a) (ii)) | 1 |
| Offside Rear Service brake excessively binding (1.2.1 (f)) | 1 |
| Offside Rear Service brake effort inadequate at a wheel (1.2.1 (a) (i)) | 1 |
| Offside Rear Parking brake inoperative on one side (1.4.1 (a)) | 1 |
| Nearside Rear Parking brake inoperative on one side (1.4.1 (a)) | 1 |