Most common failures | No# failures |
---|
Brake hose excessively deteriorated | 32 |
Windscreen wiper does not clear the windscreen effectively | 22 |
Headlamp aim out of alignment | 19 |
Registration plate lamp issues | 19 |
Exhaust emissions carbon monoxide content after 2nd fast idle excessive |7.3.D.3| | 18 |
Offside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 16 |
Nearside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 13 |
Registration plate issues | 12 |
Brake load sensing valve linkage seized |3.6.E.3| | 12 |
Parking brake: efficiency below requirements |3.7.B.7| | 12 |
Nearside Headlamp insecure |1.7.3| | 10 |
Horn not working |1.6.2a| | 10 |
Brake pipe excessively corroded | 10 |
Rear parking brake recording little or no effort | 9 |
Emissions not tested |7.0| | 8 |
Rear Exhaust has a major leak of exhaust gases |7.1.2| | 7 |
Nearside Front position lamp|s| not working |1.1.A.3b| | 6 |
Offside Headlamp insecure |1.7.3| | 6 |
Exhaust emissions Lambda reading after 2nd fast idle outside specified limits |7.3.D.3| | 6 |
Nearside Front Front position lamp|s| not working |1.1.A.3b| | 6 |
Parking brake lever has no reserve travel |3.1.6b| | 6 |
Nearside Rear wheel bearing rough when rotated |2.6.1| | 5 |
Rear brake application uneven | 5 |
Offside Rear coil spring incomplete |2.4.C.1a| | 5 |
Offside Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 5 |
Offside Stop lamp not working |1.2.1b| | 5 |
Offside Front Front position lamp|s| not working |1.1.A.3b| | 5 |
Centre Exhaust has a major leak of exhaust gases |7.1.2| | 5 |
Offside Front position lamp|s| not working |1.1.A.3b| | 4 |
Brake master cylinder/servo mounting prescribed area is excessively corroded |3.6.C.3| | 4 |
Offside Front Vehicle structure has excessive corrosion which adversely affects braking or steering |6.1.A.1| | 4 |
Nearside Headlamp not working on dipped beam |1.7.5a| | 4 |
Exhaust has a major leak of exhaust gases |7.1.2| | 4 |
Rear Brake load sensing valve linkage seized |3.6.E.3| | 4 |
Offside Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 4 |
Nearside Rear Rear wheel bearing has excessive play |2.6.2| | 4 |
Nearside Stop lamp not working |1.2.1b| | 4 |
Rear brake binding | 4 |
Fuel tank leaking |7.2.3| | 3 |
Offside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 3 |
Nearside Front brake disc excessively pitted |3.5.1h| | 3 |
Offside Front brake disc excessively pitted |3.5.1h| | 3 |
Nearside Rear coil spring fractured |2.4.C.1a| | 3 |
Offside Rear coil spring fractured |2.4.C.1a| | 3 |
Rear Exhaust system not adequately supported |7.1.1| | 3 |
Exhaust emissions carbon monoxide content at idle excessive |7.3.D.4| | 3 |
Nearside Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 3 |
Offside Front Headlamp not working on dipped beam |1.7.5a| | 3 |
Nearside Rear Brake cable has wires broken and is significantly weakened |3.5.1b| | 3 |
Offside Front Subframe mounting prescribed area is excessively corroded |2.4.A.3| | 3 |
Nearside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 3 |
Fuel cap/sealing device does not fasten securely maintaining the sealing arrangement |7.2.4b| | 3 |
Exhaust emissions hydrocarbon content after 2nd fast idle excessive |7.3.D.3| | 3 |
Offside Rear rear brake recording little or no effort |3.7.B.5a| | 3 |
Nearside Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 3 |
Offside Rear fog lamp not working |1.3.2b| | 3 |
Nearside Headlamp not working on main beam |1.7.5a| | 3 |
Nearside Front Seat belt insecurely fixed to the vehicles structure |5.2.1a| | 2 |
Offside Front Headlamp not in good working order adversely affecting beam image |1.2.4a| | 2 |
rear brakes release unevenly |3.7.B.4| | 2 |
Direction indicators not working |1.4.A.2c| | 2 |
Fuel cap/sealing device does not fasten securely by positive means |7.2.4b| | 2 |
Nearside Front Vehicle structure has excessive corrosion which adversely affects braking or steering |6.1.A.1| | 2 |
Nearside Rear Front position lamp|s| not working |1.1.A.3b| | 2 |
Nearside Rear wheel bearing has excessive play |2.6.2| | 2 |
Offside Front Suspension component mounting prescribed area is fractured |2.4.A.3| | 2 |
Nearside Windscreen wiper blade deteriorated |8.2.2| | 2 |
Exhaust system not adequately supported |7.1.1| | 2 |
Nearside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 2 |
Offside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 2 |
Nearside Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 2 |
Nearside Rear coil spring incomplete |2.4.C.1a| | 2 |
Nearside Front Suspension arm has excessive play in a ball joint |2.4.G.2| | 2 |
Offside Rear Stop lamp not working |1.2.1b| | 2 |
Offside Rear Brake cable has wires broken and is significantly weakened |3.5.1b| | 2 |
Fuel system component leaking |7.2.3| | 2 |
Offside Rear Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 2 |
Nearside Front Subframe mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
Nearside Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 2 |
Nearside Front Headlamp insecure |1.7.3| | 2 |
Offside Front Headlamp insecure |1.7.3| | 2 |
Centre Rear Exhaust has a major leak of exhaust gases |7.1.2| | 2 |
Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
Nearside Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
Offside Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
Windscreen has damage | 2 |
Offside Front coil spring fractured |2.4.C.1a| | 2 |
Nearside Front Headlamp not working on dipped beam |1.7.5a| | 2 |
Offside Headlamp not working on dipped beam |1.7.5a| | 2 |
Headlamp aim not tested |1.8.A.1c| | 2 |
Nearside Track rod end ball joint has excessive play |2.2.B.1f| | 2 |
Nearside Front Lower Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
Offside Front Windscreen wiper blade deteriorated |8.2.2| | 2 |
Offside Headlamp incorrect colour |1.7.5b| | 2 |
Nearside Rear rear brake recording little or no effort |3.7.B.5a| | 2 |
Offside Track rod end ball joint has excessive play |2.2.B.1f| | 2 |
Front brake excessively fluctuating | 2 |
Nearside Front Vehicle structure has a modification which adversely affects braking or steering |6.1.A.1| | 1 |
Offside Front Vehicle structure has a modification which adversely affects braking or steering |6.1.A.1| | 1 |
Offside Front Seat belt insecurely fixed to the vehicles structure |5.2.1a| | 1 |
Offside rear brake recording little or no effort |3.7.B.5a| | 1 |
Nearside Rear position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
Offside Rear position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
Nearside Upper Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
Offside Upper Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
Nearside Brake cable has wires broken and is significantly weakened |3.5.1b| | 1 |
Offside Brake cable has wires broken and is significantly weakened |3.5.1b| | 1 |
Brake pedal creeps down when held under pressure |3.3.B.1a| | 1 |
Nearside Front Shock absorber has a serious fluid leak |2.7.3| | 1 |
Offside Front Shock absorber has a serious fluid leak |2.7.3| | 1 |
Front Vehicle structure has damage which adversely affects braking or steering |6.1.A.1| | 1 |
Rear Rear wheel bearing has excessive play |2.6.2| | 1 |
Rear Stop lamp not working |1.2.1b| | 1 |
Nearside Rear Vehicle structure has excessive corrosion which adversely affects braking or steering |6.1.A.1| | 1 |
Brake cable has wires broken and is significantly weakened |3.5.1b| | 1 |
Rear Exhaust has part of the system excessively deteriorated |7.1.1a| | 1 |
Nearside Front Suspension component mounting prescribed area is fractured |2.4.A.3| | 1 |
Nearside Front Upper Seat belt anchorage prescribed area is inadequately repaired |5.2.6| | 1 |
Offside Front Upper Seat belt anchorage prescribed area is inadequately repaired |5.2.6| | 1 |
Offside Windscreen wiper blade deteriorated |8.2.2| | 1 |
Rear Rear position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
Nearside Rear Coil spring mounting corroded and seriously weakened |2.4.C.3c| | 1 |
Offside Rear Coil spring mounting corroded and seriously weakened |2.4.C.3c| | 1 |
Nearside Rear Exhaust system not adequately supported |7.1.1| | 1 |
Nearside Front Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
Offside Seat belt anchorage prescribed area is fractured |5.2.6| | 1 |
Offside Front Wheel nut|s| missing |4.2.A.1e| | 1 |
Nearside Front Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
Nearside Rear Rear reflector missing |1.5.1a| | 1 |
Offside Rear Rear reflector missing |1.5.1a| | 1 |
Brake cable has restricted free movement |3.5.1k| | 1 |
Front position lamp|s| not working |1.1.A.3b| | 1 |
Brake pedal has insufficient reserve movement |3.3.A.5| | 1 |
Driver`s seat insecure |6.2.A.1| | 1 |
Fuel cap/sealing device sealing washer missing |7.2.4c| | 1 |
Offside Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Rear Tailgate cannot be secured in the closed position |6.4.1| | 1 |
Brake pedal anti-slip provision missing |3.3.A.1b| | 1 |
Offside Front front brake binding |3.7.B.1| | 1 |
Nearside Rear Trailing arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
Offside Rear Trailing arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
Nearside Rear Shock absorber has negligible damping effect |2.7.5| | 1 |
Offside Rear Shock absorber has negligible damping effect |2.7.5| | 1 |
Nearside Front brake disc excessively scored |3.5.1h| | 1 |
Offside Front brake disc excessively scored |3.5.1h| | 1 |
Body has a sharp edge caused by damage |6.1.C.1| | 1 |
Nearside Front Lower Ball joint has excessive play |2.2.B.1f| | 1 |
Fuel system component insecure |7.2.1| | 1 |
Offside Front Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
Offside Front Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
Rear Brake load sensing valve linkage defective and function impaired |3.6.E.3| | 1 |
Rear Parking brake lever has no reserve travel |3.1.6b| | 1 |
Centre Rear passenger seat cannot be secured in the upright position. |6.2.3| | 1 |
Front Rear wheel bearing rough when rotated |2.6.1| | 1 |
Offside Windscreen has a sticker or other obstruction encroaching into the swept area by more than 40mm outside zone `A` |8.3.1e| | 1 |
Nearside Obligatory mirror seriously damaged, affecting the rear view |8.1.2a| | 1 |
Nearside Inner Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Offside Inner Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Offside Outer Seat belt anchorage prescribed area is excessively corroded sill panel |5.2.6| | 1 |
Nearside Front Suspension component mounting prescribed area is excessively corroded chassis |2.4.A.3| | 1 |
Offside Front Suspension component mounting prescribed area is excessively corroded chassis |2.4.A.3| | 1 |
Nearside Inner Front Upper Subframe mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Offside Inner Front Lower Subframe mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Offside Inner Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
Offside Inner Front Lower Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Nearside Front Lower Ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
Brake load sensing valve seized |3.6.E.3| | 1 |
All position lamps not working |1.1.A.3b| | 1 |
Exhaust emissions carbon monoxide content excessive |7.3.B.1a| | 1 |
Nearside Rear Seat belt insecurely fixed to the vehicles structure |5.2.1a| | 1 |
Offside Rear Seat belt insecurely fixed to the vehicles structure |5.2.1a| | 1 |
Nearside Front Headlamp aim not tested |1.8.A.1c| | 1 |
Hazard warning tell tale not working correctly |1.4.B.1e| | 1 |
Offside Front Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
Nearside Front Brake master cylinder/servo mounting prescribed area is excessively corroded |3.6.C.3| | 1 |
Offside Front Lower Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Nearside Front Windscreen wiper blade deteriorated |8.2.2| | 1 |
Nearside Front Macpherson strut has excessive movement at the upper attachment |2.5.A.1c| | 1 |
Exhaust emits excessive dense blue smoke during acceleration |7.3.A.2c| | 1 |
Offside Front Headlamp not working on main beam |1.7.5a| | 1 |
Service brake: efficiency below requirements |3.7.B.7| | 1 |
Nearside Front suspension ball joint dust cover missing |2.4.G.2| | 1 |
Offside Rear Rear wheel bearing has excessive play |2.6.2| | 1 |
Offside Headlamps matched pair are not the same colour |1.7.6| | 1 |
Hazard warning switch faulty |1.4.B.1d| | 1 |
Exhaust has a part missing |7.1.1a| | 1 |
Offside Front Body has a projection caused by damage |6.1.C.1| | 1 |
Windscreen wiper blade insecure | 1 |
Offside Rear Rear reflector not red in colour |1.5.1d| | 1 |
Offside Rear position lamp|s| incorrect colour |1.1.A.3e| | 1 |
Nearside Front constant velocity joint gaiter split |2.5.C.1a| | 1 |
Offside Front Macpherson strut insecure |2.4.G.1| | 1 |
Offside Rear Coil spring not correctly located |2.4.C.2| | 1 |
Offside front brake binding |3.7.B.1| | 1 |
Offside Front Front constant velocity joint gaiter split |2.5.C.1a| | 1 |
Offside Front Direction indicator not working |1.4.A.2c| | 1 |
Offside Rear Rear fog lamp not working |1.3.2b| | 1 |
Seat belt locking mechanism does not secure or release |5.2.5a| | 1 |
Nearside Obligatory mirror missing |8.1.1| | 1 |
Offside Front Steering rack gaiter split |2.2.D.2d| | 1 |
Brake pedal spongy |3.3.B.1b| | 1 |
Nearside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
An item not tested |Manual| | 1 |
Offside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
Offside Upper Seat belt anchorage prescribed area is fractured |5.2.6| | 1 |
Offside Rear Braking system leaking |3.6.A.1| | 1 |
Front Upper Seat belt anchorage prescribed area is fractured |5.2.6| | 1 |
Offside Front Upper Seat belt anchorage prescribed area is fractured |5.2.6| | 1 |
Front brake disc excessively pitted |3.5.1h| | 1 |
Front brake application uneven | 1 |
Nearside Rear Rear position lamp|s| incomplete |1.1.4a| | 1 |
Nearside Rear Stop lamp not working |1.2.1b| | 1 |
brake disc excessively scored |3.5.1h| | 1 |
Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Centre Brake pipe leaking |3.6.A.1| | 1 |
Offside Front Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Rear Mechanical brake component has restricted free movement | 1 |
Mechanical brake component has restricted free movement | 1 |
Stop lamp not working |1.2.1b| | 1 |
Rear Exhaust mounting missing |7.1.1b| | 1 |
Offside Front Macpherson strut has excessive movement at the upper attachment |2.5.A.1c| | 1 |
Offside Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
Nearside Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Offside Front Headlamp excessively damaged so that the light output is severely reduced |1.7.5a| | 1 |
Offside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
Offside Rear Rear fog lamp excessively damaged so that it is not visible from a reasonable distance |1.3.2d| | 1 |
Hazard warning lamps operated by more than one switch |1.4.B.1c| | 1 |
Hazard warning lamps not flashing in phase, with ignition on |1.4.B.1f| | 1 |
Hazard warning lamps not flashing in phase, with ignition off |1.4.B.1f| | 1 |
Front All position lamps not working |1.1.A.3b| | 1 |
Rear All position lamps not working |1.1.A.3b| | 1 |
Offside Front Body has a sharp edge caused by damage |6.1.C.1| | 1 |
Nearside Front Body has a sharp edge caused by corrosion |6.1.C.1| | 1 |
Offside Side repeater insecure |1.4.A.2b| | 1 |
Nearside Front coil spring fractured |2.4.C.1a| | 1 |
Nearside Rear Body has a sharp edge caused by corrosion |6.1.C.1| | 1 |
Rear Body has a sharp edge caused by damage |6.1.C.1| | 1 |
Offside Windscreen wiper not operating over a large enough area to give an adequate view |8.2.1c| | 1 |
Windscreen wiper blade deteriorated |8.2.2| | 1 |
Seat belt anchorage prescribed area is fractured |5.2.6| | 1 |
Nearside Front wheel bearing rough when rotated |2.5.A.2| | 1 |