| Most common failures | No# failures |
|---|
| Registration plate lamp issues | 25 |
| Headlamp aim out of alignment | 19 |
| Parking brake: efficiency below requirements |3.7.B.7| | 17 |
| Brake pipe excessively corroded | 12 |
| Rear parking brake recording little or no effort | 11 |
| Windscreen wiper does not clear the windscreen effectively | 11 |
| Nearside Front Track rod end ball joint has excessive play |2.2.B.1f| | 8 |
| Exhaust emissions carbon monoxide content after 2nd fast idle excessive |7.3.D.3| | 7 |
| Battery insecure |1.9.1| | 6 |
| Service brake: efficiency below requirements |3.7.B.7| | 6 |
| Nearside Front Front position lamp|s| not working |1.1.A.3b| | 5 |
| Offside Front Track rod end ball joint has excessive play |2.2.B.1f| | 5 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 5 |
| Offside Rear Brake cable has wires broken and is significantly weakened |3.5.1b| | 4 |
| Nearside Rear Brake cable has wires broken and is significantly weakened |3.5.1b| | 4 |
| Registration plate issues | 4 |
| Nearside Front Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 4 |
| Offside Front Direction indicator not working |1.4.A.2c| | 4 |
| Rear Exhaust has a major leak of exhaust gases |7.1.2| | 3 |
| Exhaust emissions Lambda reading after 2nd fast idle outside specified limits |7.3.D.3| | 3 |
| Nearside Rear Passenger`s seat cannot be secured in the upright position. |6.2.A.2| | 3 |
| Supplementary Restraint System warning lamp indicates a fault |5.4.2| | 3 |
| Offside Headlamp not working on dipped beam |1.7.5a| | 3 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 3 |
| Offside Rear wheel bearing rough when rotated |2.6.1| | 3 |
| Exhaust has a major leak of exhaust gases |7.1.2| | 3 |
| Parking brake efficiency below requirements (1.4.2 (a) (i)) | 3 |
| Brake hose excessively deteriorated | 3 |
| Offside Front coil spring incomplete |2.4.C.1a| | 3 |
| Nearside Front constant velocity joint gaiter insecurely mounted to its housing |2.5.C.1a| | 3 |
| Offside Front constant velocity joint gaiter insecurely mounted to its housing |2.5.C.1a| | 3 |
| Fuel cap/sealing device missing |7.2.4a| | 3 |
| Brakes imbalanced across an axle | 3 |
| Exhaust emissions carbon monoxide content at idle excessive |7.3.D.4| | 3 |
| Nearside Front Inner Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 2 |
| Offside Front Front position lamp|s| not working |1.1.A.3b| | 2 |
| Exhaust emissions hydrocarbon content after 2nd fast idle excessive |7.3.D.3| | 2 |
| Nearside Front Anti-roll bar linkage ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 2 |
| Offside Front coil spring fractured |2.4.C.1a| | 2 |
| Nearside Front Front constant velocity joint gaiter insecurely mounted to its housing |2.5.C.1a| | 2 |
| Parking brake efficiency below requirements |1.4.2 |a| |i|| | 2 |
| Offside Front coil spring broken |2.4.C.1a| | 2 |
| Nearside Outer Front constant velocity joint gaiter insecure to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 2 |
| Centre Rear Seat belt retracting mechanism defective |5.2.5b| | 2 |
| Nearside Rear coil spring broken |2.4.C.1a| | 2 |
| Windscreen has a sticker or other obstruction encroaching into the swept area by more than 40mm outside zone `A` |8.3.1e| | 2 |
| Engine MIL inoperative or indicates a malfunction (8.2.1.2 (h)) | 2 |
| Service brake efficiency below requirements (1.2.2 (a) (i)) | 2 |
| Nearside Inner Front constant velocity joint gaiter deteriorated to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 2 |
| Nearside Headlamp not working on dipped beam |1.7.5a| | 2 |
| Centre Exhaust has a major leak of exhaust gases |7.1.2| | 2 |
| Offside Obligatory mirror missing |8.1.1| | 2 |
| Nearside Brake cable has wires broken and is significantly weakened |3.5.1b| | 2 |
| Offside Rear coil spring broken |2.4.C.1a| | 2 |
| Offside Track rod end ball joint has excessive play |2.2.B.1f| | 2 |
| Offside Front Front constant velocity joint gaiter insecurely mounted to its housing |2.5.C.1a| | 2 |
| Offside Front Anti-roll bar linkage has excessive play in a ball joint |2.4.G.2| | 2 |
| Nearside Front Steering arm has relative movement at its fixings |2.2.B.1h| | 2 |
| Nearside Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 2 |
| Centre Exhaust has part of the system excessively deteriorated |7.1.1a| | 2 |
| Rear Exhaust has part of the system excessively deteriorated |7.1.1a| | 2 |
| Nearside Front Headlamp not working on dipped beam |1.7.5a| | 2 |
| Nearside Front coil spring incomplete |2.4.C.1a| | 2 |
| Nearside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 2 |
| Nearside Outer Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 2 |
| Offside Outer Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 2 |
| Nearside Inner Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 2 |
| Nearside Front Inner Front constant velocity joint gaiter deteriorated to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Nearside Front Anti-roll bar linkage has excessive play in a ball joint |2.4.G.2| | 1 |
| Offside Front Lower Anti-roll bar linkage ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt droplink |2.4.G.2| | 1 |
| Nearside Front Upper Anti-roll bar linkage ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt droplink |2.4.G.2| | 1 |
| Nearside Front Lower Anti-roll bar linkage ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt droplink |2.4.G.2| | 1 |
| Offside Rear Rear fog lamp excessively damaged so that it is not visible from a reasonable distance |1.3.2d| | 1 |
| Nearside Front Steering system has excessive free play detected at the steering wheel |steering rack fitted| |2.2.A.1b| | 1 |
| Offside Rear Coil spring fractured or broken |5.3.1 |b| |i|| | 1 |
| Nearside Front Tie bar/rod ball joint dust cover missing |2.4.G.2| | 1 |
| Offside Rear Front constant velocity joint gaiter insecurely mounted to its housing |2.5.C.1a| | 1 |
| Rear brake binding | 1 |
| Brake pedal anti-slip provision missing (1.1.2 (c)) | 1 |
| Exhaust has a major leak of exhaust gases flexy (6.1.2 (a)) | 1 |
| Nearside Front Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 1 |
| Parking brake efficiency less than 50% of the required value (1.4.2 (a) (ii)) | 1 |
| Offside Rear Parking brake inoperative on one side |1.4.1 |a|| | 1 |
| Nearside Rear Service brake excessively binding |1.2.1 |f|| | 1 |
| Offside Rear Service brake excessively binding |1.2.1 |f|| | 1 |
| Steering wheel has movement relative to the column indicating looseness |2.2.1 |a| |i|| | 1 |
| Nearside Front Inner Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt |6.1.7 |g| |ii|| | 1 |
| Nearside Front Inner Steering linkage ball joint has excessive play |2.1.3 |b| |i|| | 1 |
| Oil leaking excessively from engine |8.4.1 |a| |i|| | 1 |
| Windscreen has damage | 1 |
| Offside Front Lower Anti-roll bar linkage has excessive play in a ball joint |2.4.G.2| | 1 |
| Nearside Front Suspension arm pin or bush excessively worn rear (5.3.4 (a) (i)) | 1 |
| Offside Front Suspension arm pin or bush excessively worn rear (5.3.4 (a) (i)) | 1 |
| Nearside Front Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Windscreen damaged and affecting the drivers view of the road (3.2 (a) (ii)) | 1 |
| Rear Passengers seat backrest cannot be secured in the upright position. (6.2.6 (a) (i)) | 1 |
| Nearside Rear Brake hose excessively twisted (1.1.12 (b) (ii)) | 1 |
| Central Rear Seat belt not functioning as intended (7.1.2 (c)) | 1 |
| Nearside Rear Stop lamp not working |1.2.1b| | 1 |
| Offside Rear passenger seat cannot be secured in the upright position. |6.2.3| | 1 |
| Offside Rear Passenger`s seat cannot be secured in the upright position. |6.2.A.2| | 1 |
| Nearside Front coil spring cracked |2.4.C.1a| | 1 |
| Offside Front constant velocity joint is insecure |2.5.C.1b| | 1 |
| Offside Front coil spring cracked |2.4.C.1a| | 1 |
| Steering column locking device insecure |2.1.6| | 1 |
| Offside Brake cable has wires broken and is significantly weakened |3.5.1b| | 1 |
| Semaphore indicator switch faulty |1.4.C.1c| | 1 |
| Nearside Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
| Offside Rear Coil spring fractured or broken (5.3.1 (b) (i)) | 1 |
| Nearside Front Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Exhaust Lambda reading after 2nd fast idle outside specified limits (8.2.1.2 (c)) | 1 |
| Front Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 1 |
| Nearside Front Anti-roll bar ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Offside Front Coil spring fractured or broken (5.3.1 (b) (i)) | 1 |
| Offside Front Brake pipe seriously damaged |found during steering lock to lock check| |2.2.D.2b| | 1 |
| Nearside Brake cable damaged park (1.1.15 (a)) | 1 |
| Nearside Ball joint has excessive play |2.2.B.1f| | 1 |
| Offside Rear fog lamp insecure |1.3.2a| | 1 |
| Nearside Front Ball joint has excessive play |2.2.B.1f| | 1 |
| Rear Exhaust system not adequately supported |7.1.1| | 1 |
| Offside Outer Front constant velocity joint gaiter deteriorated to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Offside Front wheel bearing rough when rotated |2.5.A.2| | 1 |
| Nearside Front position lamp|s| has less than 50% of the light sources illuminating |1.1.A.3b| | 1 |
| rear brake recording little or no effort |3.7.B.5a| | 1 |
| Offside Front constant velocity joint gaiter deteriorated to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Offside Front Anti-roll bar has excessive play in a ball joint drop link |2.4.G.2| | 1 |
| Nearside Front Anti-roll bar ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt drop link |2.4.G.2| | 1 |
| Front Steering system has excessive free play detected at the steering wheel |steering rack fitted| |2.2.A.1b| | 1 |
| Nearside Front Steering arm has relative movement at its fixings rack arm |2.2.B.1h| | 1 |
| Offside Front Steering arm has relative movement at its fixings rack arm |2.2.B.1h| | 1 |
| Offside Rear Rear wheel bearing rough when rotated |2.6.1| | 1 |
| Anti-lock braking system warning lamp does not illuminate |3.4.1b| | 1 |
| Offside Front Steering arm has relative movement at its fixings |2.2.B.1h| | 1 |
| Offside Front Tie bar/rod has excessive play in a ball joint |2.4.G.2| | 1 |
| Windscreen has a sticker or other obstruction encroaching by more than 10mm within zone `A` |8.3.1b| | 1 |
| Offside Front Hazard warning lamps inoperative |1.4.B.1b| | 1 |
| Nearside Front Road wheel bead rim badly distorted |4.2.A.1a| | 1 |
| Steering system has excessive free play detected at the steering wheel |steering rack fitted| |2.2.A.1b| | 1 |
| Windscreen wiper blade insecure | 1 |
| Offside Rear coil spring incomplete |2.4.C.1a| | 1 |
| Nearside Rear Parking brake lever has no reserve travel |3.1.6b| | 1 |
| Offside Rear Parking brake lever has no reserve travel |3.1.6b| | 1 |
| Steering column movement between the shaft and steering wheel |2.1.2b| | 1 |
| Indicator switch faulty |1.4.A.1| | 1 |
| Seat belt retracting mechanism defective |5.2.5b| | 1 |
| Hazard warning switch insecure |1.4.B.1d| | 1 |
| Offside Front Headlamp not working on dipped beam |1.7.5a| | 1 |
| Nearside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
| Offside Rear Stop lamp not working |1.2.1b| | 1 |
| Offside Front Obligatory mirror missing |8.1.1| | 1 |
| Rear brake application uneven | 1 |
| Front Body insecure and dangerous to other road users bumper |6.1.B.1b| | 1 |
| Nearside Front Direction indicator not working |1.4.A.2c| | 1 |
| Front brake disc in such a condition that it is seriously weakened | 1 |
| Offside Front Wheel bolt|s| missing 3 studs missing |4.2.A.1e| | 1 |
| Nearside Front Anti-roll bar linkage has excessive play in a ball joint link bar |2.4.G.2| | 1 |
| Nearside Rear Seat belt insecurely fixed to the vehicles structure |5.2.1a| | 1 |
| Nearside Rear Wheel bolt|s| missing |4.2.A.1e| | 1 |
| Offside Front Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Nearside Front Anti-roll bar ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Nearside Front Front suspension ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Nearside Stop lamp not working |1.2.1b| | 1 |
| Offside Front Front constant velocity joint is insecure |2.5.C.1b| | 1 |
| Nearside Front Macpherson strut has excessive movement at the upper attachment |2.5.A.1c| | 1 |
| Engine MIL inoperative or indicates a malfunction |8.2.1.2 |h|| | 1 |
| Front Brake disc significantly and obviously worn both sides |1.1.14 |a| |i|| | 1 |
| Nearside Front Lower Suspension arm ball joint dust cover no longer prevents the ingress of dirt |5.3.4 |b| |ii|| | 1 |
| Offside Front constant velocity joint gaiter insecure to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Offside Track rod end ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Parking brake lever has no reserve travel |3.1.6b| | 1 |
| Brake cable has wires broken and is significantly weakened |3.5.1b| | 1 |
| Nearside Headlamp aim aimed so that it dazzles other road users |1.8.A.1a| | 1 |
| Nearside Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Nearside Front coil spring fractured |2.4.C.1a| | 1 |
| Offside Front Anti-roll bar linkage ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Nearside Front Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Fuel system component leaking |7.2.3| | 1 |
| Nearside Front brake disc excessively pitted |3.5.1h| | 1 |
| Offside Front brake disc excessively pitted |3.5.1h| | 1 |
| Nearside Front constant velocity joint gaiter split |2.5.C.1a| | 1 |
| Offside Front constant velocity joint gaiter split |2.5.C.1a| | 1 |
| Front Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Nearside Front Direction indicator incorrect colour |1.4.A.2f| | 1 |
| An item not tested |Manual| | 1 |