| Most common failures | No# failures |
|---|
| Headlamp aim out of alignment | 32 |
| Brake pipe excessively corroded | 24 |
| Windscreen wiper does not clear the windscreen effectively | 19 |
| Parking brake: efficiency below requirements |3.7.B.7| | 10 |
| Offside Rear fog lamp not working |1.3.2b| | 10 |
| Service brake: efficiency below requirements |3.7.B.7| | 9 |
| Hazard warning switch faulty |1.4.B.1d| | 9 |
| Offside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 9 |
| Brakes imbalanced across an axle | 9 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 7 |
| Registration plate issues | 7 |
| Offside Headlamp not working on dipped beam |1.7.5a| | 6 |
| Front Exhaust has a major leak of exhaust gases |7.1.2| | 6 |
| Offside Headlamp not working on main beam |1.7.5a| | 5 |
| Offside Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 5 |
| Nearside Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 5 |
| Emissions not tested |7.0| | 5 |
| Fuel cap/sealing device does not fasten securely maintaining the sealing arrangement |7.2.4b| | 4 |
| Nearside Front Headlamp not working on dipped beam |1.7.5a| | 4 |
| Offside Front Shock absorber has a serious fluid leak |2.7.3| | 4 |
| Nearside Rear Leaf spring has excessive wear in a shackle pin and/or bush |2.4.B.2| | 4 |
| Nearside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 4 |
| Rear fog lamp not working |1.3.2b| | 4 |
| Rear parking brake recording little or no effort | 4 |
| Registration plate lamp issues | 4 |
| Exhaust emissions carbon monoxide content at idle excessive |7.3.D.4| | 4 |
| Exhaust emissions Lambda reading after 2nd fast idle outside specified limits |7.3.D.3| | 4 |
| Exhaust emissions hydrocarbon content after 2nd fast idle excessive |7.3.D.3| | 4 |
| Exhaust emissions carbon monoxide content after 2nd fast idle excessive |7.3.D.3| | 4 |
| Brake performance not tested |3.7.A.1| | 3 |
| Offside Rear Leaf spring has excessive wear in a shackle pin and/or bush |2.4.B.2| | 3 |
| Nearside Headlamp not working on dipped beam |1.7.5a| | 3 |
| Nearside Front Front position lamp|s| not working |1.1.A.3b| | 3 |
| Offside Obligatory mirror insecure |8.1.1| | 3 |
| Exhaust emissions carbon monoxide content excessive |7.3.B.1a| | 3 |
| Offside Rear Rear fog lamp not working |1.3.2b| | 3 |
| Offside Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 3 |
| Main beam `tell-tale` not working |1.7.4c| | 3 |
| Centre Exhaust has a major leak of exhaust gases |7.1.2| | 3 |
| Exhaust emissions hydrocarbon content excessive |7.3.B.1b| | 3 |
| Nearside Rear Stop lamp not working |1.2.1b| | 3 |
| Offside Front Headlamp not working on dipped beam |1.7.5a| | 3 |
| Windscreen wiper blade insecure | 3 |
| Rear Exhaust has a major leak of exhaust gases |7.1.2| | 3 |
| Offside Rear Vehicle structure has excessive corrosion which adversely affects braking or steering |6.1.A.1| | 3 |
| Nearside Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 3 |
| Exhaust has a major leak of exhaust gases |7.1.2| | 3 |
| Nearside front brake binding |3.7.B.1| | 2 |
| Nearside Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 2 |
| Offside Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 2 |
| Centre Exhaust system not adequately supported |7.1.1| | 2 |
| Nearside Rear Vehicle structure has excessive corrosion which adversely affects braking or steering |6.1.A.1| | 2 |
| Offside Front front brake binding |3.7.B.1| | 2 |
| Offside Front Shock absorber has negligible damping effect |2.7.5| | 2 |
| Offside Rear Stop lamp not working |1.2.1b| | 2 |
| Rear brake application uneven | 2 |
| Offside Headlamp aim not tested |1.8.A.1c| | 2 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 2 |
| Nearside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 2 |
| Rear brake binding | 2 |
| Offside Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 2 |
| Offside front brake binding |3.7.B.1| | 2 |
| Hazard warning lamps not flashing in phase, with ignition on |1.4.B.1f| | 2 |
| Rear Exhaust has part of the system excessively deteriorated |7.1.1a| | 2 |
| Nearside Rear Wheel nut|s| missing |4.2.A.1e| | 2 |
| Exhaust has part of the system excessively deteriorated |7.1.1a| | 2 |
| Nearside Vehicle structure has excessive corrosion which adversely affects braking or steering |6.1.A.1| | 2 |
| Spare wheel carrier insecure |6.4.2| | 2 |
| Nearside Rear Direction indicator incorrect colour |1.4.A.2f| | 2 |
| Rear Exhaust system not adequately supported |7.1.1| | 2 |
| Front Ball joint has excessive play |2.2.B.1f| | 1 |
| Offside Headlamp aim aimed so that it dazzles other road users |1.8.A.1a| | 1 |
| Offside Front Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
| Body has a sharp edge caused by damage |6.1.C.1| | 1 |
| passenger door does not latch securely closed |6.2.B.1a| | 1 |
| Exhaust system not adequately supported |7.1.1| | 1 |
| Front brake disc excessively pitted |3.5.1h| | 1 |
| Brake hydraulic reservoir cap missing |3.6.G.1a| | 1 |
| Exhaust mounting missing |7.1.1b| | 1 |
| Nearside Front Steering pivot point has excessive play |2.2.B.1g| | 1 |
| Centre Rear Body has a sharp edge caused by corrosion |6.1.C.1| | 1 |
| Offside Rear Body has a sharp edge caused by corrosion |6.1.C.1| | 1 |
| Offside Front Drag link end ball joint has excessive play |2.2.B.1f| | 1 |
| Direction indicators not working |1.4.A.2c| | 1 |
| Rear Mechanical brake component has restricted free movement | 1 |
| Exhaust engine idle speed too high |7.3.A.2a| | 1 |
| Nearside Headlamp aim beam image too far to the right |1.6.B4| | 1 |
| Offside Rear fog lamp insecure |1.3.2a| | 1 |
| Nearside Rear Leaf spring has a deteriorated anchor pin rubber bush resulting in excessive movement |2.4.B.2| | 1 |
| Nearside Outer Front Front position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Rear fog lamp does not emit a steady red light |1.3.2e| | 1 |
| Offside Rear Braking system leaking |3.6.A.1| | 1 |
| Nearside Rear wheel bearing has excessive play |2.6.2| | 1 |
| Nearside Front front brake binding |3.7.B.1| | 1 |
| Nearside Front Shock absorber has negligible damping effect |2.7.5| | 1 |
| Braking system leaking |3.6.A.1| | 1 |
| Offside Front Front position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Obligatory mirror is incapable of being adjusted to provide an adequate view to the rear |8.1.2b| | 1 |
| Emissions not tested |7.3.A.1| | 1 |
| Windscreen has a sticker or other obstruction encroaching by more than 10mm within zone `A` sun strip |8.3.1b| | 1 |
| An item not tested |Manual| | 1 |
| Offside Rear fog lamp missing |1.3.2a| | 1 |
| Headlamp not working on dipped beam |1.7.5a| | 1 |
| Headlamp not working on main beam |1.7.5a| | 1 |
| Driver`s door hinge deteriorated so the door cannot be readily opened or closed |6.2.B.2| | 1 |
| Nearside Rear position lamp|s| insecure and damaged |1.1.A.3a| | 1 |
| Driver`s door hinge insecure |6.2.B.2| | 1 |
| Horn not working |1.6.2a| | 1 |
| Parking brake lever has no reserve travel |3.1.6b| | 1 |
| Nearside Rear Leaf spring has a deteriorated shackle pin rubber bush resulting in excessive movement |2.4.B.2| | 1 |
| Offside Leaf spring has a deteriorated shackle pin rubber bush resulting in excessive movement |2.4.B.2| | 1 |
| Nearside Stop lamp not working |1.2.1b| | 1 |
| Nearside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Offside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Nearside Front Seat belt damaged sufficient to obstruct correct operation of the belt |5.2.2a| | 1 |
| Nearside Rear Lower Leaf spring has excessive wear in a shackle pin and/or bush |2.4.B.2| | 1 |
| Offside Rear Lower Leaf spring has excessive wear in a shackle pin and/or bush |2.4.B.2| | 1 |
| Nearside Seat belt anchorage prescribed area strength or continuity significantly reduced sill (7.1.1 (a) (i)) | 1 |
| Nearside Headlamp not working on main beam |1.7.5a| | 1 |
| Emissions not tested misfire at revs (8.2.1.2 (d)) | 1 |
| Rear Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting tipping bar |6.2.2 |d| |i|| | 1 |
| Nearside Rear Rear position lamp|s| incomplete |1.1.4a| | 1 |
| Offside Direction indicators not working |1.4.A.2c| | 1 |
| Position lamp not working all four side lights not working (4.2.1 (a) (ii)) | 1 |
| Offside Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Nearside Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Rear Vehicle structure has excessive corrosion which adversely affects braking or steering |6.1.A.1| | 1 |
| Offside Vehicle structure has excessive corrosion which adversely affects braking or steering |6.1.A.1| | 1 |
| Offside Rear Brake actuating linkage mounting prescribed area is excessively corroded |3.3.A.2| | 1 |
| Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Front brake disc excessively scored |3.5.1h| | 1 |
| Offside Braking system leaking |3.6.A.1| | 1 |
| Rear Shock absorber has a serious fluid leak |2.7.3| | 1 |
| Nearside Front Anti-roll bar fractured |2.4.G.1| | 1 |
| Rear rear brake recording little or no effort |3.7.B.5a| | 1 |
| Nearside Rear fog lamp not working |1.3.2b| | 1 |
| Steering system has excessive free play detected at the steering wheel |steering box fitted| |2.2.A.1a| | 1 |
| Offside Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Leaf spring has excessive wear in a shackle pin and/or bush |2.4.B.2| | 1 |
| Exhaust has a major leak of exhaust gases mid section |7.1.2| | 1 |
| Exhaust has a major leak of exhaust gases mid to rear flange joint |7.1.2| | 1 |
| Nearside Obligatory mirror insecure |8.1.1| | 1 |
| Rear Braking system leaking |3.6.A.1| | 1 |
| Offside Rear Vehicle structure has an unsatisfactory modification, seriously affecting its strength within 30cm of the body mountings holed inner and outer |6.1.B.2| | 1 |
| Exhaust has a major leak of exhaust gases mid sections |7.1.2| | 1 |
| Hazard warning lamps inoperative all |1.4.B.1b| | 1 |
| Rear Rear fog lamp not working |1.3.2b| | 1 |
| Offside Rear Rear position lamp|s| insecure |1.1.A.3a| | 1 |
| Offside Front Direction indicator not working |1.4.A.2c| | 1 |
| Offside Rear Direction indicator not working |1.4.A.2c| | 1 |
| Nearside Front Position lamp not working |4.2.1 |a| |ii|| | 1 |
| Nearside Front Service brake excessively binding |1.2.1 |f|| | 1 |
| Offside Front Service brake excessively binding |1.2.1 |f|| | 1 |
| Fuel tank leaking excessively or a risk of fire |6.1.3 |b| |ii|| | 1 |
| Offside Rear Fuel hose leaking |6.1.3 |b| |i|| | 1 |
| Offside Rear Outer Vehicle structure is deformed and structural rigidity is significantly reduced |6.1.1 |a| |i|| | 1 |
| Nearside Rear Outer Vehicle structure is deformed and structural rigidity is significantly reduced |6.1.1 |a| |i|| | 1 |
| Nearside Rear Inner Vehicle structure is deformed and structural rigidity is significantly reduced |6.1.1 |a| |i|| | 1 |
| Rear fog lamp insecure |1.3.2a| | 1 |
| Exhaust noise is clearly in excess of that emitted by a similar vehicle fitted with a standard silencer in average condition |7.1.4| | 1 |
| Trailer electrical socket damaged so that lead cannot be securely connected |1.9.3b| | 1 |
| Brake load sensing valve linkage seized |3.6.E.3| | 1 |
| Front Vehicle structure has excessive corrosion which adversely affects braking or steering |6.1.A.1| | 1 |
| Position lamp switch faulty |1.1.A.1| | 1 |
| Headlamp switch faulty |1.7.1| | 1 |
| Offside Front Obligatory mirror missing |8.1.1| | 1 |
| Nearside Front Headlamp aim not tested |1.8.A.1c| | 1 |
| Hazard warning lamps inoperative |1.4.B.1b| | 1 |
| Offside Rear Upper Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Driver`s door pillar missing |6.2.B.2| | 1 |
| Offside Rear fog lamp excessively damaged so that it is not visible from a reasonable distance |1.3.2d| | 1 |
| Nearside Headlamp insecure |1.7.3| | 1 |
| Offside Front Obligatory mirror seriously damaged, affecting the rear view |8.1.2a| | 1 |
| Centre Exhaust mounting missing |7.1.1b| | 1 |
| Steering column shaft has excessive end float |2.1.3| | 1 |
| Nearside Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
| Offside Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
| Headlamp aim not tested |1.8.A.1c| | 1 |
| Nearside Direction indicator incomplete |1.5.A1b| | 1 |
| Rear Body has a sharp edge caused by corrosion |6.1.C.1| | 1 |
| Nearside Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Offside Front Tie bar/rod fractured |2.4.G.1| | 1 |
| Nearside Front Tie bar/rod fractured |2.4.G.1| | 1 |
| Offside Front Steering component mounting prescribed area is excessively corroded |2.2.C.1h| | 1 |
| Offside Rear Direction indicator incorrect colour |1.4.A.2f| | 1 |
| Offside Front Direction indicator incorrect colour |1.4.A.2f| | 1 |
| Offside Rear Shock absorber detached |2.7.2b| | 1 |
| Offside Front Headlamp not in a clean condition affecting beam image |1.2.4a| | 1 |
| Rear Brake pivot has restricted free movement |3.5.1k| | 1 |
| Hazard warning lamps not flashing in phase, with ignition off |1.4.B.1f| | 1 |
| Offside Brake pipe leaking |3.6.A.1| | 1 |
| All position lamps not working |1.1.A.3b| | 1 |
| Exhaust tailpipe not capable of allowing the emission probe to be inserted |7.3.D.1| | 1 |
| Front Brake cable has wires broken and is significantly weakened |3.5.1b| | 1 |
| Offside Rear Brake linkage excessively corroded and seriously weakened |3.5.1e| | 1 |
| Centre Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |