| Most common failures | No# failures |
|---|
| Headlamp aim out of alignment | 41 |
| Registration plate lamp issues | 36 |
| Windscreen wiper does not clear the windscreen effectively | 16 |
| Offside Rear coil spring broken |2.4.C.1a| | 12 |
| Engine MIL inoperative or indicates a malfunction (8.2.1.2 (h)) | 12 |
| Horn not working |1.6.2a| | 11 |
| Nearside Rear coil spring broken |2.4.C.1a| | 10 |
| Anti-lock braking system warning lamp indicates an ABS fault | 10 |
| Brakes imbalanced across an axle | 8 |
| Nearside Front coil spring broken |2.4.C.1a| | 8 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 8 |
| Brake pipe excessively corroded | 7 |
| Offside Headlamp not working on dipped beam |1.7.5a| | 7 |
| Nearside Front Coil spring fractured or broken (5.3.1 (b) (i)) | 7 |
| Nearside Stop lamp not working |1.2.1b| | 6 |
| Offside Rear Coil spring fractured or broken (5.3.1 (b) (i)) | 6 |
| Nearside Headlamp not working on dipped beam |1.7.5a| | 6 |
| Offside Front coil spring broken |2.4.C.1a| | 5 |
| Offside Rear Direction indicator incorrect colour |1.4.A.2f| | 5 |
| Offside Stop lamp not working |1.2.1b| | 5 |
| Rear brake disc in such a condition that it is seriously weakened | 5 |
| Offside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 5 |
| Exhaust emissions Lambda reading after 2nd fast idle outside specified limits |7.3.D.3| | 5 |
| Front brake disc in such a condition that it is seriously weakened | 5 |
| Engine MIL inoperative or indicates a malfunction |8.2.1.2 |h|| | 4 |
| Nearside Rear position lamp|s| not working |1.1.A.3b| | 4 |
| Offside Front Coil spring fractured or broken (5.3.1 (b) (i)) | 4 |
| Nearside Rear Direction indicator incorrect colour |1.4.A.2f| | 4 |
| Front brake excessively fluctuating | 4 |
| Nearside Front Anti-roll bar linkage has excessive play in a ball joint |2.4.G.2| | 4 |
| Offside Rear Shock absorbers has a serious fluid leak | 4 |
| Nearside Rear Direction indicator incorrect colour (4.4.3 (a)) | 3 |
| Offside Rear Direction indicator incorrect colour (4.4.3 (a)) | 3 |
| Offside Front Coil spring fractured or broken |5.3.1 |b| |i|| | 3 |
| Registration plate issues | 3 |
| Front Exhaust has a major leak of exhaust gases |7.1.2| | 3 |
| Fuel cap/sealing device missing |7.2.4a| | 3 |
| Nearside Front Coil spring fractured or broken |5.3.1 |b| |i|| | 3 |
| Offside Rear position lamp|s| not working |1.1.A.3b| | 3 |
| Steering system has excessive free play detected at the steering wheel |steering rack fitted| |2.2.A.1b| | 3 |
| Nearside Steering rack gaiter missing or no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 3 |
| Nearside Rear Coil spring fractured or broken (5.3.1 (b) (i)) | 3 |
| Windscreen washer not working | 3 |
| Nearside Rear Parking brake inoperative on one side (1.4.1 (a)) | 3 |
| Parking brake efficiency below requirements (1.4.2 (a) (i)) | 3 |
| Nearside Rear Service brake excessively binding (1.2.1 (f)) | 3 |
| Horn not working (7.7 (a)) | 3 |
| Parking brake: efficiency below requirements |3.7.B.7| | 3 |
| Nearside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 3 |
| Battery insecure |1.9.1| | 3 |
| Nearside Rear Shock absorbers has a serious fluid leak | 3 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 3 |
| Nearside Rear coil spring incomplete |2.4.C.1a| | 2 |
| Nearside Front Front position lamp|s| not working |1.1.A.3b| | 2 |
| Offside Rear Axle swivel pins and bushes swivel pin and/or bush excessively worn (5.1.2 (b) (i)) | 2 |
| Offside Rear coil spring fractured |2.4.C.1a| | 2 |
| Offside Rear fog lamp not working |1.3.2b| | 2 |
| Offside Front Front position lamp|s| not working |1.1.A.3b| | 2 |
| Horn not working |7.7 |a| |ii|| | 2 |
| Offside Rear fog lamp not working (4.5.1 (a) (ii)) | 2 |
| Oil leaking excessively from engine |8.4.1 |a| |i|| | 2 |
| Offside Front Anti-roll bar linkage ball joint excessively worn (5.3.4 (a) (i)) | 2 |
| Exhaust Lambda reading after 2nd fast idle outside specified limits (8.2.1.2 (c)) | 2 |
| Exhaust emissions carbon monoxide content after 2nd fast idle excessive |7.3.D.3| | 2 |
| Offside Front Anti-roll bar linkage has excessive play in a ball joint |2.4.G.2| | 2 |
| Nearside Front Steering system has excessive free play detected at the steering wheel |steering rack fitted| |2.2.A.1b| | 2 |
| Offside Front Steering system has excessive free play detected at the steering wheel |steering rack fitted| |2.2.A.1b| | 2 |
| Parking brake efficiency below requirements |1.4.2 |a| |i|| | 2 |
| Nearside Rear Stop lamp not working |1.2.1b| | 2 |
| Offside Headlamp not working on main beam |1.7.5a| | 2 |
| Exhaust hydrocarbon content after 2nd fast idle exceeds manufacturers specified limits (8.2.1.2 (a)) | 2 |
| Exhaust carbon monoxide content at idle exceeds default limits (8.2.1.2 (b)) | 2 |
| Offside Obligatory mirror missing |8.1.1| | 2 |
| Exhaust emissions hydrocarbon content after 2nd fast idle excessive |7.3.D.3| | 2 |
| Exhaust has a major leak of exhaust gases |7.1.2| | 2 |
| Nearside Front Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 2 |
| Nearside Front Position lamp not working (4.2.1 (a) (ii)) | 2 |
| Exhaust Lambda reading after 2nd fast idle outside specified limits |8.2.1.2 |c|| | 2 |
| Parking brake efficiency less than 50% of the required value (1.4.2 (a) (ii)) | 2 |
| Offside Rear Trailing arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 2 |
| Nearside Front Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 2 |
| Offside Front Headlamp not working on dipped beam |1.7.5a| | 1 |
| Nearside Headlamp aim projected beam image is obviously incorrect |4.1.2 |c|| | 1 |
| Nearside Front front brake binding |3.7.B.1| | 1 |
| Nearside Rear Suspension component pin or bush excessively worn axle bush (5.3.4 (a) (i)) | 1 |
| Offside Rear Direction indicator incorrect colour |4.4.3 |a|| | 1 |
| Offside Front Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 1 |
| Offside Front Track rod end ball joint has excessive play |2.1.3 |b| |i|| | 1 |
| Nearside Rear Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
| Offside Rear Front suspension has excessive movement at a wishbone pin or bush |2.5.A.1c| | 1 |
| Nearside Front Front position lamp|s| has less than 50% of the light sources illuminating |1.1.A.3b| | 1 |
| Nearside Rear Suspension has inadequate clearance with the bump stop |2.4.A.1a| | 1 |
| Offside Front Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
| Nearside Front position lamp|s| not working s/light |1.1.A.3b| | 1 |
| engine mounting bracket insecure and likely to fail bottom front |6.1.D.1b| | 1 |
| Offside Front Upper Subframe mounting prescribed area excessively corroded significantly reducing structural strength subframe mounting (5.3.6 (a) (i)) | 1 |
| Offside Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Offside Rear Braking system leaking caliper banjo bolt |3.6.A.1| | 1 |
| Nearside Steering system has excessive free play detected at the steering wheel |steering rack fitted| rack end |2.2.A.1b| | 1 |
| Offside Steering system has excessive free play detected at the steering wheel |steering rack fitted| rack end |2.2.A.1b| | 1 |
| Nearside Front Suspension arm has excessive play in a pin/bush rear bush |2.4.G.2| | 1 |
| Fuel cap/sealing device does not fasten securely by positive means |7.2.4b| | 1 |
| Offside Front Headlamp insecure |1.7.3| | 1 |
| Nearside Rear Seat belt anchorage prescribed area strength or continuity significantly reduced outer sill (7.1.1 (a) (i)) | 1 |
| Nearside Rear Seat belt anchorage prescribed area strength or continuity significantly reduced inner arch (7.1.1 (a) (i)) | 1 |
| Offside Vehicle Identification Number has more than one different number displayed door shut (0.2 (c)) | 1 |
| Offside Headlamp not working on main beam (4.1.1 (a) (ii)) | 1 |
| Power steering ram|s| leaking from a failed joint |2.3.3b| | 1 |
| Nearside Front Anti-roll bar linkage ball joint excessively worn |5.3.4 |a| |i|| | 1 |
| Nearside Rear Direction indicator incorrect colour and o/s rear (4.4.3 (a)) | 1 |
| Offside Front Body component damaged and likely to cause injury wing mirror cover missing (6.2.1 (a) (i)) | 1 |
| Nearside Front Upper Subframe mounting prescribed area excessively corroded significantly reducing structural strength (5.3.6 (a) (i)) | 1 |
| Offside Rear Subframe mounting prescribed area excessively corroded significantly reducing structural strength Axle securing bracket (5.3.6 (a) (i)) | 1 |
| Offside Front Upper Subframe mounting prescribed area excessively corroded significantly reducing structural strength (5.3.6 (a) (i)) | 1 |
| Nearside Front Anti-roll bar linkage ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Rear fog lamp not working |1.3.2b| | 1 |
| Anti-roll bar linkage ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt both |2.4.G.2| | 1 |
| Exhaust has a major leak of exhaust gases rear joint (6.1.2 (a)) | 1 |
| Nearside Rear Suspension component pin or bush excessively worn axle |5.3.4 |a| |i|| | 1 |
| Offside Rear Suspension component pin or bush excessively worn axle |5.3.4 |a| |i|| | 1 |
| Nearside Body has a sharp edge caused by damage mirror |6.1.C.1| | 1 |
| Fuel system component insecure lpg unit under bonnett |7.2.1| | 1 |
| Nearside Rear Suspension arm pin or bush excessively worn Trailing arm anchor bush . (5.3.4 (a) (i)) | 1 |
| Fuel system component leaking bleed hose on lpg system on rocker cover leaking (6.1.3 (b) (i)) | 1 |
| Front Service brake imbalanced across an axle note : nsf is much lower than offside front (1.2.1 (b) (i)) | 1 |
| Offside Rear coil spring corroded so that its cross sectional area is reduced and seriously weakened |2.4.C.1b| | 1 |
| Offside Rear Parking brake inoperative on one side (1.4.1 (a)) | 1 |
| Offside Front Service brake excessively fluctuating (1.2.1 (e)) | 1 |
| Offside Rear fog lamp not working |4.5.1 |a| |ii|| | 1 |
| Spare wheel insecure |6.4.2| | 1 |
| Nearside Body has a sharp edge caused by damage |6.1.C.1| | 1 |
| Offside Body has a sharp edge caused by damage |6.1.C.1| | 1 |
| Nearside Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Exhaust has a major leak of exhaust gases down pipe flexible |7.1.2| | 1 |
| Offside Front Steering rack gaiter missing or no longer prevents the ingress of dirt |2.1.3 |g| |ii|| | 1 |
| Exhaust emissions hydrocarbon content excessive (8.2.1.2 (b)) | 1 |
| Exhaust carbon monoxide content after 2nd fast idle exceeds manufacturers specified limits (8.2.1.2 (a)) | 1 |
| Steering column has excessive movement up and down (2.2.2 (a)) | 1 |
| Offside Front Body panel damaged and likely to cause injury Wing (6.2.1 (a) (i)) | 1 |
| Battery insecure and likely to cause a short circuit (4.13 (a) (ii)) | 1 |
| Nearside Front Suspension arm pin or bush excessively worn Rear bush (5.3.4 (a) (i)) | 1 |
| Offside Front Suspension arm pin or bush excessively worn Rear bush (5.3.4 (a) (i)) | 1 |
| Offside Front Anti-roll bar linkage ball joint dust cover no longer prevents the ingress of dirt Lower (5.3.4 (b) (ii)) | 1 |
| Offside Outer Front Brake lining|s| less than 1.5 mm thick |3.5.1g| | 1 |
| Exhaust carbon monoxide content after 2nd fast idle exceeds manufacturer`s specified limits |8.2.1.2 |a|| | 1 |
| Exhaust hydrocarbon content after 2nd fast idle exceeds manufacturer`s specified limits |8.2.1.2 |a|| | 1 |
| Offside Headlamp aim aimed so that it dazzles other road users |1.8.A.1a| | 1 |
| Nearside Rear brake caliper leaking |3.6.A.1| | 1 |
| Offside Anti-roll bar insecure |2.4.G.1| | 1 |
| Nearside Headlamp aim beam image obviously incorrect bulb not fitted right |1.8.A.1b| | 1 |
| Fuel cap/sealing device missing LPG System |7.2.4a| | 1 |
| Offside Front Headlamp has a product on the lens so that the light output is severely reduced (4.1.4 (b)) | 1 |
| Nearside Front Headlamp has a product on the lens so that the light output is severely reduced (4.1.4 (b)) | 1 |
| Exhaust emissions test not completed because smoke levels are significantly in excess of the specified limit values (8.2.2.2 (f)) | 1 |
| Supplementary Restraint System warning lamp indicates a fault |5.4.2| | 1 |
| Nearside Front Anti-roll bar linkage ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Offside Front Track rod end ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Nearside Ball joint has excessive play |2.2.B.1f| | 1 |
| Offside Ball joint has excessive play |2.2.B.1f| | 1 |
| Offside Front Track rod end ball joint dust cover excessively damaged or deteriorated so that it no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |
| Offside Front Headlamp not working on main beam (4.1.1 (a) (ii)) | 1 |
| Rear Rear fog lamp not working (4.5.1 (a) (ii)) | 1 |
| Driver`s seat insecure |6.2.5 |a| |ii|| | 1 |
| Nearside Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
| Offside Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
| Nearside Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 1 |
| Windscreen has a sticker or other obstruction encroaching into the swept area by more than 40mm outside zone `A` |8.3.1e| | 1 |
| Offside Steering arm has relative movement at its fixings |2.2.B.1h| | 1 |
| Offside Windscreen washer control is inaccessible to the driver |8.2.1a| | 1 |
| Nearside Front Lower Anti-roll bar linkage has excessive play in a ball joint |2.4.G.2| | 1 |
| Offside Front Lower Anti-roll bar linkage has excessive play in a ball joint |2.4.G.2| | 1 |
| Offside Body has a sharp edge caused by damage door mirror |6.1.C.1| | 1 |
| Rear fog lamp switch inoperative (4.5.3 (a)) | 1 |
| Rear fog lamp tell-tale not working (4.9.1 (a) (ii)) | 1 |
| Front Service brake lagging in operation (1.2.1 (d)) | 1 |
| Nearside Front Electrical wiring likely to touch hot or rotating parts wheel arch (4.11 (a) (iii)) | 1 |
| Nearside Front Electrical wiring connectors for braking disconnected abs sensor (4.11 (a) (iii)) | 1 |
| Offside Front Steering arm has relative movement at its fixings |2.2.B.1h| | 1 |
| Front Service brake excessively fluctuating discs corroded |1.2.1 |e|| | 1 |
| Exhaust hydrocarbon content after 2nd fast idle exceeds default limits |8.2.1.2 |b|| | 1 |
| Exhaust carbon monoxide content after 2nd fast idle exceeds default limits |8.2.1.2 |b|| | 1 |
| Offside Rear Shock absorber has a serious fluid leak |2.7.3| | 1 |
| Offside Rear Stop lamp not working |1.2.1b| | 1 |
| Headlamp has a product on the lens so that the light output is severely reduced both (4.1.4 (b)) | 1 |
| Nearside Rear Trailing arm rubber mounting deteriorated resulting in excessive movement axle |2.4.G.2| | 1 |
| Offside Rear Trailing arm rubber mounting deteriorated resulting in excessive movement axle |2.4.G.2| | 1 |
| Central Front engine mounting deteriorated resulting in excessive movement to gearbox |6.1.D.1a| | 1 |
| Nearside Rear Seat belt locking mechanism does not secure or release |5.2.5a| | 1 |
| Nearside Front Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Emissions not tested (8.2.1.2 (d)) | 1 |
| Exhaust catalytic converter missing where one was fitted as standard (8.2.1.1 (a)) | 1 |
| Exhaust noise is clearly in excess of that emitted by a similar vehicle fitted with a standard silencer in average condition (8.1.1 (a)) | 1 |
| Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 1 |
| Oil leaking excessively from engine looks like oil filter (8.4.1 (a) (i)) | 1 |
| Nearside Rear Service brake lagging in operation possible calliper seized (1.2.1 (d)) | 1 |
| Offside Inner Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 1 |
| Fuel pipe leaking lpg |7.2.3| | 1 |
| Nearside Front Position lamp not working |4.2.1 |a|| | 1 |
| Offside Front Position lamp not working |4.2.1 |a|| | 1 |
| Nearside Headlamp insecure |1.7.3| | 1 |
| Nearside Front Shock absorber has a serious fluid leak |2.7.3| | 1 |
| Nearside Rear Trailing arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Nearside Rear coil spring fractured |2.4.C.1a| | 1 |
| Nearside Front Anti-roll bar has excessive play in a ball joint |2.4.G.2| | 1 |
| Offside Rear Other passenger door cannot be opened from outside the vehicle |6.2.3 |a|| | 1 |
| Nearside Rear Sub-frame pin or bush excessively worn front bush |5.3.4 |a| |i|| | 1 |
| Offside Rear Sub-frame pin or bush excessively worn front bush |5.3.4 |a| |i|| | 1 |
| Nearside Parking brake inoperative on one side |1.4.1 |a|| | 1 |
| Offside Rear passenger door cannot be opened from outside the vehicle |6.2.B.1c| | 1 |
| Nearside Rear Shock absorber has a serious fluid leak |2.7.3| | 1 |
| Offside Front Headlamp aim beam image obviously incorrect dip beam |1.8.A.1b| | 1 |
| Nearside Rear Trailing arm rubber bush deteriorated resulting in excessive movement axle |2.4.G.2| | 1 |
| Offside Front Brake pipe connection leaking on a hydraulic braking system (1.1.11 (b) (ii)) | 1 |
| Brake hose excessively deteriorated | 1 |
| Nearside Front Suspension arm corroded and seriously weakened (5.3.3 (b) (i)) | 1 |
| Nearside Front Suspension arm pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Nearside Front Vehicle structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting sill (6.2.2 (d) (i)) | 1 |
| Offside Rear Vehicle structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting sill (6.2.2 (d) (i)) | 1 |
| Service brake efficiency below requirements (1.2.2 (a) (i)) | 1 |
| Parking brake lever has no reserve travel |3.1.6b| | 1 |
| Nearside Rear Trailing arm synthetic bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Rear Trailing arm synthetic bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Nearside Front Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Nearside Rear Brake back plate|s| securing device excessively deteriorated |3.5.1j| | 1 |
| Offside Rear Brake back plate|s| securing device excessively deteriorated |3.5.1j| | 1 |
| Nearside Rear wheel bearing rough when rotated |2.6.1| | 1 |
| Nearside Front Inner Ball joint has excessive play rack end |2.2.B.1f| | 1 |
| Offside Rear coil spring incomplete |2.4.C.1a| | 1 |
| Nearside Rear Sub-frame rubber bush deteriorated resulting in excessive movement subframe bush |2.4.G.2| | 1 |
| Exhaust emits excessive dense blue smoke during acceleration |7.3.A.2c| | 1 |
| Offside Front Anti-roll bar linkage fractured (5.3.3 (b) (ii)) | 1 |
| Offside Front Position lamp not working |4.2.1 |a| |ii|| | 1 |
| Nearside Windscreen damaged and affecting the driver`s view of the road |3.2 |a| |ii|| | 1 |
| Offside Front Shock absorbers has a serious fluid leak | 1 |
| Nearside Rear Parking |secondary brake| on a single line braking system has inadequate effort at a wheel |1.3.1 |a| |i|| | 1 |
| Nearside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Offside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Central Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 1 |
| Exhaust emits dense blue smoke at idle (8.2.1.2 (f)) | 1 |
| Braking system leaking |3.6.A.1| | 1 |
| Parking brake lever has excessive movement indicating incorrect adjustment (1.1.6 (c)) | 1 |
| Nearside Rear Coil spring fractured or broken |5.3.1 |b| |i|| | 1 |
| Front Fuel system component leaking pump joint (6.1.3 (b) (i)) | 1 |
| Offside Front Suspension arm pin or bush excessively worn rear bush |5.3.4 |a| |i|| | 1 |
| Nearside Obligatory mirror seriously damaged, affecting the rear view |8.1.2a| | 1 |