| Most common failures | No# failures |
|---|
| Headlamp aim out of alignment | 19 |
| Registration plate issues | 13 |
| Brake pipe excessively corroded | 13 |
| Windscreen wiper does not clear the windscreen effectively | 10 |
| Registration plate lamp issues | 8 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 6 |
| Parking brake: efficiency below requirements |3.7.B.7| | 5 |
| Nearside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 5 |
| Offside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 4 |
| Rear parking brake recording little or no effort | 4 |
| Battery insecure |1.9.1| | 4 |
| Exhaust emissions Lambda reading after 2nd fast idle outside specified limits |7.3.D.3| | 4 |
| Offside Front Anti-roll bar linkage has excessive play in a ball joint |2.4.G.2| | 3 |
| Brakes imbalanced across an axle | 3 |
| Rear Exhaust has a major leak of exhaust gases |7.1.2| | 3 |
| Nearside Rear coil spring incomplete |2.4.C.1a| | 2 |
| Offside Front Front position lamp|s| not working |1.1.A.3b| | 2 |
| Nearside Front Headlamp aim beam image obviously incorrect |1.8.A.1b| | 2 |
| Nearside Stop lamp not working |1.2.1b| | 2 |
| Offside Rear Shock absorber has a serious fluid leak |2.7.3| | 2 |
| Offside Front Shock absorber has a serious fluid leak |2.7.3| | 2 |
| Exhaust has a major leak of exhaust gases |7.1.2| | 2 |
| Offside Headlamp not working on dipped beam |1.7.5a| | 2 |
| Nearside Front Anti-roll bar linkage ball joint excessively worn (5.3.4 (a) (i)) | 2 |
| Offside Rear Stop lamp not working |1.2.1b| | 2 |
| Horn not working |1.6.2a| | 2 |
| Nearside Front Tie bar/rod has excessive play in a ball joint |2.4.G.2| | 1 |
| Offside Front Obligatory mirror seriously damaged, affecting the rear view |8.1.2a| | 1 |
| Nearside Rear Exhaust has part of the system excessively deteriorated |7.1.1a| | 1 |
| Nearside Rear Exhaust system not adequately supported |7.1.1| | 1 |
| Nearside Front Outer Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Nearside Rear position lamp|s| excessively damaged so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Emissions not tested due to exhaust broken |7.3.A.1| | 1 |
| Brake load sensing valve seized |3.6.E.3| | 1 |
| Nearside Headlamp aim beam image kick up to the offside |1.8| | 1 |
| Offside Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
| Nearside Front Ball joint has excessive play BBJ |2.2.B.1f| | 1 |
| Nearside Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Rear Wheel stud|s| missing |4.2.A.1e| | 1 |
| Nearside Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Offside Front Anti-roll bar fractured |2.4.G.1| | 1 |
| Nearside Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Bonnet retaining device ineffective |8.4.2| | 1 |
| Nearside Front Shock absorber has a serious fluid leak |2.7.3| | 1 |
| Front position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Front Macpherson strut has excessive movement in the upper support bearing assembly |2.5.B.1b| | 1 |
| Offside Side repeater incomplete |1.5.A1b| | 1 |
| Nearside Windscreen wiper blade deteriorated |8.2.2| | 1 |
| Offside Windscreen wiper blade deteriorated |8.2.2| | 1 |
| Offside Rear Passenger`s seat cannot be secured in the upright position. |6.2.A.2| | 1 |
| Nearside Front Anti-roll bar linkage has excessive play in a ball joint |2.4.G.2| | 1 |
| Front position lamp|s| incorrect colour |1.1.A.3e| | 1 |
| Rear Exhaust has part of the system excessively deteriorated |7.1.1a| | 1 |
| Offside Front coil spring fractured |2.4.C.1a| | 1 |
| Driver`s seat insecure |6.2.A.1| | 1 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Front Front constant velocity joint gaiter split |2.5.C.1a| | 1 |
| Offside Rear Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
| Engine MIL inoperative or indicates a malfunction (8.2.1.2 (h)) | 1 |
| Offside Rear coil spring broken |2.4.C.1a| | 1 |
| Offside Front All position lamps not working |1.1.A.3b| | 1 |
| Nearside Front Subframe mounting prescribed area fractured significantly reducing structural strength (5.3.6 (a) (i)) | 1 |
| Nearside Front Subframe mounting prescribed area excessively corroded significantly reducing structural strength (5.3.6 (a) (i)) | 1 |
| Nearside Rear Inner Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced sill (6.1.1 (c) (i)) | 1 |
| Offside Rear Inner Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced sill (6.1.1 (c) (i)) | 1 |
| Nearside Rear Outer Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced sill (6.1.1 (c) (i)) | 1 |
| Offside Rear Outer Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced sill (6.1.1 (c) (i)) | 1 |
| Nearside Front Prop shaft joint constant velocity boot no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 1 |
| Nearside Front Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
| Offside Front Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
| Fuel system component leaking |7.2.3| | 1 |
| Offside Rear Shock absorber has negligible damping effect |2.7.5| | 1 |
| Offside Rear Hydraulic brake calliper leaking |1.1.16 |b| |i|| | 1 |
| Anti-lock braking system warning lamp indicates an ABS fault | 1 |
| Front brake excessively fluctuating | 1 |
| Nearside Braking system leaking |3.6.A.1| | 1 |
| Brake performance not tested |3.7.A.1| | 1 |
| Service brake: efficiency below requirements |3.7.B.7| | 1 |
| Parking brake efficiency below requirements (1.4.2 (a) (i)) | 1 |
| Offside Rear Parking brake inoperative on one side (1.4.1 (a)) | 1 |
| Front Headlamp light source and lamp not compatible hid conversion fitted + o/s not working (4.1.4 (c)) | 1 |
| Nearside Front Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 1 |
| Front Anti-roll bar ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt outer links n/s and o/s |2.4.G.2| | 1 |
| Exhaust emissions carbon monoxide content after 2nd fast idle excessive |7.3.D.3| | 1 |
| Offside Front Headlamp aim beam image obviously incorrect kick up to right |1.8.A.1b| | 1 |
| Offside Front Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Nearside Rear Stop lamp|s| not working |4.3.1 |a| |ii|| | 1 |
| Rear rear brake recording little or no effort |3.7.B.5a| | 1 |
| Rear brake application uneven | 1 |
| Nearside Rear Stop lamp not working |1.2.1b| | 1 |
| Front Anti-roll bar linkage has excessive play in a ball joint |2.4.G.2| | 1 |
| Exhaust system not adequately supported |7.1.1| | 1 |
| Offside Stop lamp not working |1.2.1b| | 1 |
| Rear Exhaust has a major leak of exhaust gases box |7.1.2| | 1 |
| Horn not loud enough to be heard by another road user |1.6.2b| | 1 |