| Most common failures | No# failures |
|---|
| Headlamp aim out of alignment | 18 |
| Registration plate lamp issues | 11 |
| Supplementary Restraint System warning lamp indicates a fault |5.4.2| | 7 |
| Windscreen wiper does not clear the windscreen effectively | 6 |
| Parking brake lever has no reserve travel |3.1.6b| | 5 |
| Nearside Rear Coil spring fractured or broken (5.3.1 (b) (i)) | 5 |
| Nearside Stop lamp not working |1.2.1b| | 4 |
| Offside Stop lamp not working |1.2.1b| | 4 |
| Offside Front Position lamp not working (4.2.1 (a) (ii)) | 4 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 3 |
| Nearside Rear Stop lamp not working |1.2.1b| | 3 |
| Nearside Front Outer Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 3 |
| Supplementary restraint system warning lamp indicates a fault |7.1.6 |a|| | 3 |
| Supplementary restraint system warning lamp indicates a fault (7.1.6 (a)) | 3 |
| Nearside Front Anti-roll bar linkage ball joint excessively worn (5.3.4 (a) (i)) | 3 |
| Offside Front Anti-roll bar linkage ball joint excessively worn (5.3.4 (a) (i)) | 3 |
| Nearside Rear Stop lamp|s| all not working |4.3.1 |a| |iii|| | 2 |
| Windscreen has a sticker or other obstruction encroaching into the swept area by more than 40mm outside zone `A` |8.3.1e| | 2 |
| Driver`s airbag obviously defective |5.4.1| | 2 |
| Nearside Rear coil spring broken |2.4.C.1a| | 2 |
| Rear fog lamp not working |1.3.2b| | 2 |
| Rear Exhaust has a major leak of exhaust gases |7.1.2| | 2 |
| Exhaust emissions Lambda reading after 2nd fast idle outside specified limits |7.3.D.3| | 2 |
| Offside Front Shock absorber has a serious fluid leak |2.7.3| | 2 |
| Nearside Front Position lamp not working |4.2.1 |a|| | 2 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 2 |
| Brakes imbalanced across an axle | 2 |
| Nearside Front Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 2 |
| Offside Front Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 2 |
| Nearside Rear Coil spring fractured or broken |5.3.1 |b| |i|| | 2 |
| Nearside Stop lamp(s) not working (4.3.1 (a) (ii)) | 2 |
| Offside Front Outer Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 2 |
| Parking brake lever has excessive movement indicating incorrect adjustment (1.1.6 (c)) | 2 |
| Nearside Front Front position lamp|s| not working |1.1.A.3b| | 2 |
| Offside Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 2 |
| Offside Front Front position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Front Direction indicator not working |1.4.A.2c| | 1 |
| Offside Rear Shock absorber has a serious fluid leak |2.7.3| | 1 |
| Nearside Windscreen wiper not operating automatically when switched on |8.2.1b| | 1 |
| Offside Windscreen wiper not operating automatically when switched on |8.2.1b| | 1 |
| Nearside Front Suspension arm pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Front Suspension arm pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Service brake: efficiency below requirements |3.7.C.1a| | 1 |
| Nearside Towbar retaining device insecure |6.6.3a| | 1 |
| Nearside Front Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Nearside Front Drive shaft joint constant velocity boot missing (6.1.7 (g) (ii)) | 1 |
| Nearside Front Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 1 |
| Nearside Front Headlamp aim not tested (4.1.2 (b)) | 1 |
| Nearside Rear Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
| Front Brake disc significantly and obviously worn (1.1.14 (a) (i)) | 1 |
| Parking brake efficiency less than 50% of the required value (1.4.2 (a) (ii)) | 1 |
| Stop lamp|s| adversely affected by the operation of another lamp side lamps |4.3.3 |b|| | 1 |
| Position lamp adversely affected by the operation of another lamp stop lamps |4.2.3 |c|| | 1 |
| Windscreen has damage | 1 |
| Exhaust system insecure front, centre and rear mounts rusted and broken (6.1.2 (a)) | 1 |
| Offside Rear Stop lamp not working |1.2.1b| | 1 |
| Nearside Front Anti-roll bar linkage ball joint excessively worn |5.3.4 |a| |i|| | 1 |
| Nearside Rear Bumper damaged and likely to cause injury when grazed or contacted Temp repair done (6.1.4 (a) (i)) | 1 |
| Front Steering rack insecure |2.2.B.1a| | 1 |
| Rear Stop lamp not working |1.2.1b| | 1 |
| Front Front suspension retaining device missing |2.5.A.4| | 1 |
| Nearside Rear Shock absorbers has a serious fluid leak | 1 |
| Exhaust has a major leak of exhaust gases front pipe |7.1.2| | 1 |
| Nearside Outer Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Nearside Front Lower Suspension arm pin or bush excessively worn rear (5.3.4 (a) (i)) | 1 |
| Offside Front Lower Suspension arm pin or bush excessively worn rear (5.3.4 (a) (i)) | 1 |
| Brake pipe excessively corroded | 1 |
| Offside Front Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 1 |
| Offside Rear Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
| Rear Service brake excessively binding Both (1.2.1 (f)) | 1 |
| Offside Front Anti-roll bar linkage ball joint likely to become detached (5.3.4 (a) (ii)) | 1 |
| Rear Service brake grabbing severely (1.2.1 (c)) | 1 |
| Offside Rear Coil spring fractured or broken (5.3.1 (b) (i)) | 1 |
| Nearside Front Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Front Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Rear Anti-roll bar linkage pin or bush excessively worn N/s off/s rear (5.3.4 (a) (i)) | 1 |
| Offside Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
| Offside Front Position lamp light intensity significantly reduced (4.2.3 (a) (ii)) | 1 |
| Offside Headlamp insecure (4.1.1 (c)) | 1 |
| Brake pedal has insufficient reserve travel (1.1.2 (a)) | 1 |
| Nearside Rear Anti-roll bar linkage pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Rear Anti-roll bar linkage pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Exhaust has a major leak of exhaust gases at front flexi pipe |7.1.2| | 1 |
| Offside Front Suspension arm pin or bush excessively worn rear bush chalked in yellow (5.3.4 (a) (i)) | 1 |
| Offside Front Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 1 |
| Brake pedal anti-slip provision incomplete |3.3.A.1b| | 1 |
| Steering rack has excessive free play detected at the steering wheel (steering rack fitted) (2.3 (a) (i)) | 1 |
| Windscreen has a sticker or other obstruction encroaching by more than 10mm within zone `A` |8.3.1b| | 1 |
| Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 1 |
| Offside Front suspension has a suspension lower ball joint securing nut not locked |2.5.B.1a| | 1 |
| Headlamp aim so that beam "kick up" is not visible on the screen both front |4.1.2 |a|| | 1 |
| Brake fluid contaminated |1.8 |a|| | 1 |
| Exhaust emissions likely to be affected by an exhaust leak flexi pipe leaking |8.2.2.1 |b|| | 1 |
| Offside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Battery insecure |1.9.1| | 1 |
| Offside Front Anti-roll bar has excessive play in a ball joint |2.4.G.2| | 1 |
| Nearside Front Outer Front constant velocity joint gaiter insecure to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Front brake disc in such a condition that it is seriously weakened | 1 |
| Rear brake disc in such a condition that it is seriously weakened | 1 |
| Front Outer Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt o/s n/s (6.1.7 (g) (ii)) | 1 |
| Centre Exhaust system not adequately supported |7.1.1| | 1 |
| Nearside Rear Position lamp not working |4.2.1 |a|| | 1 |
| Nearside Rear Brake linkage has restricted free movement |3.5.1k| | 1 |
| Offside Front Wheel nut|s| missing |4.2.A.1e| | 1 |
| Offside Front Position lamp not working |4.2.1 |a|| | 1 |
| Offside Front Anti-roll bar ball joint excessively worn |5.3.4 |a| |i|| | 1 |
| Central Exhaust system insecure (6.1.2 (a)) | 1 |
| Emissions not tested (8.2.1.2 (d)) | 1 |
| Exhaust emissions likely to be affected by an exhaust leak (8.2.2.1 (b)) | 1 |
| Nearside Windscreen washer jets misaligned and not providing sufficient fluid to the windscreen (3.5 (a)) | 1 |
| Offside Rear Road wheel fixing missing |5.2.1 |a| |i|| | 1 |
| Nearside Front Anti-roll bar linkage has excessive play in a ball joint |2.4.G.2| | 1 |
| Offside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
| Parking brake efficiency below requirements (1.4.2 (a) (i)) | 1 |
| Nearside Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
| Parking brake lever defective so that it cannot be satisfactorily operated (1.1.6 (d)) | 1 |
| Offside Headlamp not working on main beam |1.7.5a| | 1 |
| Front Exhaust has a major leak of exhaust gases flexible pipe broken |7.1.2| | 1 |
| Offside Rear Direction indicator not working |4.4.1 |a| |ii|| | 1 |
| Nearside Front Lower Suspension arm rubber bush bonding deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Engine MIL inoperative or indicates a malfunction (8.2.1.2 (h)) | 1 |
| Nearside Rear Anti-roll bar linkage likely to become detached (5.3.3 (a) (ii)) | 1 |