| Most common failures | No# failures |
|---|
| Parking brake: efficiency below requirements |3.7.B.7| | 12 |
| Headlamp aim out of alignment | 11 |
| Rear parking brake recording little or no effort | 9 |
| Rear brake binding | 6 |
| Parking brake lever has no reserve travel |3.1.6b| | 3 |
| Windscreen wiper does not clear the windscreen effectively | 3 |
| Parking brake efficiency below requirements (1.4.2 (a) (i)) | 3 |
| Nearside Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 2 |
| Offside Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 2 |
| Bootlid cannot be secured in the closed position |6.4.1| | 2 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 2 |
| Registration plate lamp issues | 2 |
| Nearside Stop lamp not working |1.2.1b| | 2 |
| Nearside Outer Rear Drive shaft uj which forms part of the suspension has excessive play in a universal joint |2.4.G.4b| | 1 |
| Nearside front brake binding |3.7.B.1| | 1 |
| Power steering pump leaking from a failed component |2.3.3b| | 1 |
| Nearside Rear Rear wheel bearing rough when rotated |2.6.1| | 1 |
| Nearside Front Tie bar/rod rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Front Tie bar/rod rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Nearside Front Road wheel distorted |4.2.A.1a| | 1 |
| Nearside Front Upper Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Nearside Rear Rear wheel bearing has excessive play |2.6.2| | 1 |
| Nearside Front Tie bar/rod synthetic bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Front Tie bar/rod synthetic bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Parking brake: efficiency below requirements |3.7.D.4| | 1 |
| Offside Front Headlamp does not operate immediately when selected on main beam |1.7.4a| | 1 |
| Offside Front Headlamp does not operate immediately when selected on dipped beam |1.7.4a| | 1 |
| Nearside Headlamp excessively damaged so that the light output is severely reduced |1.7.5a| | 1 |
| Offside Headlamp excessively damaged so that the light output is severely reduced |1.7.5a| | 1 |
| Offside Steering rack gaiter split |2.2.D.2d| | 1 |
| Offside Steering column universal joint has excessive play |2.1.5| | 1 |
| Nearside Front Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Front Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Front Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Nearside Headlamp missing |1.7.3| | 1 |
| Offside Headlamp missing |1.7.3| | 1 |
| Nearside Front All position lamps not working |1.1.A.3b| | 1 |
| Offside Front All position lamps not working |1.1.A.3b| | 1 |
| Nearside Rear All position lamps not working |1.1.A.3b| | 1 |
| Offside Rear All position lamps not working |1.1.A.3b| | 1 |
| Nearside Front Windscreen wiper blade missing |8.2.2| | 1 |
| Offside Front Windscreen wiper blade missing |8.2.2| | 1 |
| Nearside Front Obligatory mirror missing |8.1.1| | 1 |
| Offside Front Obligatory mirror missing |8.1.1| | 1 |
| Nearside Front Direction indicators not working |1.4.A.2c| | 1 |
| Offside Front Direction indicators not working |1.4.A.2c| | 1 |
| Nearside Front Steering rack gaiter split |2.2.D.2d| | 1 |
| Offside Front Steering rack gaiter split |2.2.D.2d| | 1 |
| Nearside Rear Upper Bonded suspension unit bonding failed and part of unit is likely to become displaced |2.4.F.2| | 1 |
| Nearside Rear Parking brake not fitted on at least two wheels |3.1.1| | 1 |
| Offside Rear Parking brake not fitted on at least two wheels |3.1.1| | 1 |
| Nearside Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Offside front brake binding |3.7.B.1| | 1 |
| Nearside Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
| Horn not working |1.6.2a| | 1 |
| Nearside Rear Seat belt locking mechanism does not secure or release |5.2.5a| | 1 |
| Nearside Exhaust has a part missing |7.1.1a| | 1 |
| Fuel pipe leaking |7.2.3| | 1 |
| Nearside Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Rear Suspension component mounting prescribed area is fractured |2.4.A.3| | 1 |
| Offside Rear Suspension component mounting prescribed area is fractured |2.4.A.3| | 1 |
| Nearside Rear Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Rear Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Rear Trailing arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Rear Drive shaft uj which forms part of the suspension has excessive play in a universal joint |2.4.G.4b| | 1 |
| Offside Rear Suspension arm attachment bracket/mounting insecure |2.4.G.1| | 1 |
| Bonnet cannot be secured in the closed position |8.4.1| | 1 |
| Parking brake: efficiency below requirements |3.7.C.1b| | 1 |
| Nearside Rear Suspension arm attachment bracket/mounting insecure |2.4.G.1| | 1 |
| Nearside Front Front wheel bearing has excessive play |2.5.A.3c| | 1 |
| Nearside Front Lower Suspension arm rubber mounting deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Front Lower Suspension arm rubber mounting deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Nearside Front Upper Seat belt insecurely fixed to the vehicles structure |5.2.1a| | 1 |
| Offside Front Upper Seat belt insecurely fixed to the vehicles structure |5.2.1a| | 1 |
| Rear Rear fog lamp not working |1.3.2b| | 1 |
| Direction indicators not working |1.4.A.2c| | 1 |
| Hazard warning switch faulty |1.4.B.1d| | 1 |
| Centre Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Nearside Rear Exhaust has part of the system excessively deteriorated |7.1.1a| | 1 |
| Centre Exhaust has part of the system excessively deteriorated |7.1.1a| | 1 |
| Nearside Rear Lower Shock absorber has an excessively worn bush |2.7.4| | 1 |
| Offside Rear Lower Shock absorber has an excessively worn bush |2.7.4| | 1 |
| Nearside Inner Rear Tie bar/rod has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Inner Rear Tie bar/rod has excessive play in a pin/bush |2.4.G.2| | 1 |
| Rear Parking brake lever has no reserve travel |3.1.6b| | 1 |
| Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Offside Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
| Offside Rear Inner Drive shaft joint excessively worn Universal joint |6.1.7 |c| |i|| | 1 |
| Brake performance not tested |1.2.1 |g|| | 1 |
| Hazard warning lamps inoperative |1.4.B.1b| | 1 |
| Offside Stop lamp not working |1.2.1b| | 1 |
| Rear fog lamp not working |1.3.2b| | 1 |
| Offside Rear position lamp|s| insecure |1.1.A.3a| | 1 |
| Offside Stop lamp insecure |1.2.1a| | 1 |
| Offside Rear fog lamp insecure |1.3.2a| | 1 |
| Offside Rear Direction indicator insecure |1.4.A.2b| | 1 |
| Central Exhaust has a major leak of exhaust gases left |7.1.2| | 1 |
| Offside Front Lower Suspension arm locating pin retaining device missing split pin |2.4.G.3b| | 1 |
| Offside Stop lamp adversely affected by the operation of another lamp |1.2.1f| | 1 |
| Offside Front Tie bar/rod has excessive play in a pin/bush |2.4.G.2| | 1 |
| Steering column universal joint has excessive play |2.1.5| | 1 |
| Nearside Rear Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Offside Front Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Rear Fuel hose leaking |7.2.3| | 1 |
| Nearside Front Shock absorber has negligible damping effect |2.7.5| | 1 |
| Offside Front Shock absorber has negligible damping effect |2.7.5| | 1 |
| Nearside Front Upper Suspension arm locating pin locking device not properly locked |2.4.G.3b| | 1 |
| Nearside Front Lower Suspension arm locating pin locking device not properly locked |2.4.G.3b| | 1 |
| Offside Front Upper Suspension arm locating pin locking device not properly locked |2.4.G.3b| | 1 |
| Front Exhaust has a major leak of exhaust gases manifold area |7.1.2| | 1 |
| Centre Exhaust system not adequately supported |7.1.1| | 1 |
| Exhaust emissions hydrocarbon content excessive |7.3.B.1b| | 1 |
| Centre Exhaust mounting missing |7.1.1b| | 1 |
| Offside Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Power steering component|s| leaking |2.3.3b| | 1 |
| Offside Front Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
| Offside Front Lower Suspension arm ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Nearside Front Wheel bearing play so excessive it is likely to break up (5.1.3 (a) (ii)) | 1 |
| Boot lid cannot be secured in the closed position (6.2.1 (e)) | 1 |
| Dipswitch operation does not deflect all main beam headlamps to make them dipped beams (4.1.3 (b)) | 1 |
| Steering column has excessive movement up and down (2.2.2 (a)) | 1 |
| Nearside Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced front and centre of outrigger (6.1.1 (c) (i)) | 1 |
| Lower Steering column has excessive movement up and down (2.2.2 (a)) | 1 |
| Offside Parking brake inoperative on one side (1.4.1 (a)) | 1 |
| Front Anti-roll bar missing (5.3.3 (a) (ii)) | 1 |
| Direction indicator not working (4.4.1 (a) (ii)) | 1 |
| Offside Front Position lamp adversely affected by the operation of another lamp (4.2.3 (c)) | 1 |
| Nearside Rear Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Nearside Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
| Brake master cylinder insecure (1.1.10 (c)) | 1 |
| Oil leaking excessively from engine (8.4.1 (a) (i)) | 1 |
| Nearside Front Shock absorbers has negligible damping effect (5.3.2 (d)) | 1 |
| Offside Front Shock absorbers has negligible damping effect (5.3.2 (d)) | 1 |
| Nearside Rear Drive shaft securing bolt missing (6.1.7 (a) (i)) | 1 |
| Exhaust emissions - engine idle speed too high (8.2.1.2 (e)) | 1 |
| Parking (secondary brake) on a single line braking system imbalanced across an axle Axle 1 (1.3.1 (b) (i)) | 1 |
| Nearside Front Steering rack gaiter missing or no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |
| Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 1 |
| Nearside Rear Service brake excessively binding (1.2.1 (f)) | 1 |
| Offside Rear Service brake excessively binding (1.2.1 (f)) | 1 |