| Most common failures | No# failures |
|---|
| Headlamp aim out of alignment | 25 |
| Rear parking brake recording little or no effort | 18 |
| Parking brake: efficiency below requirements |3.7.B.7| | 16 |
| Windscreen wiper does not clear the windscreen effectively | 8 |
| Rear brake binding | 8 |
| Exhaust emissions carbon monoxide content excessive |7.3.B.1a| | 7 |
| Battery insecure |1.9.1| | 6 |
| Exhaust emissions hydrocarbon content excessive |7.3.B.1b| | 6 |
| Registration plate lamp issues | 6 |
| Parking brake lever has no reserve travel |3.1.6b| | 6 |
| Brake pipe excessively corroded | 5 |
| Rear fog lamp tell tale not working |1.3.1b| | 5 |
| Offside Rear fog lamp not working |1.3.2b| | 4 |
| Parking brake: efficiency below requirements |3.7.C.1b| | 4 |
| Horn not working |1.6.2a| | 3 |
| Brakes imbalanced across an axle | 3 |
| Nearside Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 3 |
| Nearside Front Track rod end ball joint has excessive play |2.2.B.1f| | 3 |
| Nearside front brake binding |3.7.B.1| | 3 |
| All position lamps not working |1.1.A.3b| | 3 |
| Service brake: efficiency below requirements |3.7.B.7| | 3 |
| Nearside Headlamp not working on dipped beam |1.7.5a| | 3 |
| Nearside Headlamp not in good working order adversely affecting beam image |1.2.4a| | 2 |
| Offside Headlamp not in good working order adversely affecting beam image |1.2.4a| | 2 |
| Steering system has excessive free play detected at the steering wheel |steering rack fitted| |2.2.A.1b| | 2 |
| Nearside Rear brake disc contaminated by oil |3.5.1h| | 2 |
| Offside Rear brake disc contaminated by oil |3.5.1h| | 2 |
| Centre Exhaust system not adequately supported |7.1.1| | 2 |
| Rear Stop lamp not working |1.2.1b| | 2 |
| Front brake application uneven | 2 |
| Direction indicators not working |1.4.A.2c| | 2 |
| Steering pivot point has excessive play |2.2.B.1g| | 2 |
| Nearside Rear Direction indicator not working |1.4.A.2c| | 2 |
| Driver`s seat insecure |6.2.A.1| | 2 |
| Nearside Headlamp not working on main beam |1.7.5a| | 2 |
| Front passenger door cannot be opened from outside the vehicle |6.2.B.1b| | 2 |
| Nearside Front Steering rack gaiter split |2.2.D.2d| | 2 |
| Offside Headlamp not working on main beam |1.7.5a| | 2 |
| Rear fog lamp not working |1.3.2b| | 2 |
| Exhaust system not adequately supported |7.1.1| | 2 |
| Fuel system component insecure |7.2.1| | 2 |
| Steering system excessively tight |2.2.D.1| | 2 |
| Emissions not tested (8.2.1.2 (d)) | 2 |
| Centre Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Nearside Rear Trailing arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Nearside Front passenger door cannot be opened from outside the vehicle |6.2.B.1b| | 1 |
| Registration plate issues | 1 |
| Offside Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Nearside Upper Front suspension has excessive movement at a wishbone pin or bush |2.5.A.1c| | 1 |
| Nearside Front Service brake excessively binding |1.2.1 |f|| | 1 |
| Parking brake efficiency below requirements |1.4.2 |a| |i|| | 1 |
| Electrical wiring insecure |1.9.2a| | 1 |
| Steering component is not secure to the vehicle structure |2.2.B.1a| | 1 |
| Centre Windscreen wiper not operating over a large enough area to give an adequate view |8.2.1c| | 1 |
| Offside Front Anti-roll bar attachment bracket/mounting insecure |2.4.G.1| | 1 |
| Parking brake efficiency less than 50% of the required value |1.4.2 |a| |ii|| | 1 |
| Offside Rear Brake pipe excessively chafed |3.6.B.2c| | 1 |
| Rear Exhaust system not adequately supported |7.1.1| | 1 |
| Steering column universal joint has excessive play |2.1.5| | 1 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Brake pipe leaking |3.6.A.1| | 1 |
| Nearside Exhaust system not adequately supported |7.1.1| | 1 |
| Rear brake application uneven | 1 |
| Nearside Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Steering column shaft has excessive end float |2.1.3| | 1 |
| Offside Front Lower Suspension arm ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Nearside Steering rack gaiter split |2.2.D.2d| | 1 |
| Offside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
| Nearside Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Rear Shock absorber missing |2.7.1b| | 1 |
| Centre Obligatory mirror insecure |8.1.1| | 1 |
| Offside Obligatory mirror insecure |8.1.1| | 1 |
| Offside Front position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
| Nearside Headlamp adversely affected by the operation of another lamp |1.7.5c| | 1 |
| Offside Headlamp adversely affected by the operation of another lamp |1.7.5c| | 1 |
| Offside Rear Suspension arm has excessive play in a pin/bearing |2.4.G.2| | 1 |
| Rear brake disc in such a condition that it is seriously weakened | 1 |
| Windscreen wiper not operating automatically when switched on |8.2.1b| | 1 |
| Rear Parking brake lever has no reserve travel |3.1.6b| | 1 |
| Offside rear brake recording little or no effort |3.7.B.5a| | 1 |
| Nearside rear brake recording little or no effort |3.7.B.5a| | 1 |
| Nearside Rear Mechanical brake component locking device missing |3.5.1l| | 1 |
| Offside Rear Fuel hose leaking |7.2.3| | 1 |
| Offside Rear brake caliper securing device missing |3.5.1j| | 1 |
| Nearside Rear brake disc contaminated by grease |3.5.1h| | 1 |
| Offside Headlamp not working on dipped beam |1.7.5a| | 1 |
| Lower Steering column movement between the shaft and steering wheel |2.1.2b| | 1 |
| Offside Front Lower Mechanical brake component locking device insecure |3.5.1l| | 1 |
| Offside Stop lamp not working |1.2.1b| | 1 |
| Nearside Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Offside Front Direction indicator adversely affected by the operation of another lamp |1.4.A.2h| | 1 |
| Offside Front Direction indicator not working |1.4.A.2c| | 1 |
| Offside Front Front position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
| Nearside Front Torque/reaction arm has a deteriorated rubber bush resulting in excessive movement |2.4.G.2| | 1 |
| Offside Front Torque/reaction arm has a deteriorated rubber bush resulting in excessive movement |2.4.G.2| | 1 |
| Emissions not tested |7.0| | 1 |
| Centre Rear Fuel pipe insecure |7.2.1| | 1 |
| Mechanical brake component has restricted free movement | 1 |
| Driver`s seat cannot be secured in the upright position. |6.2.A.2| | 1 |
| Offside Front Steering rack gaiter split |2.2.D.2d| | 1 |
| Brake hose excessively deteriorated | 1 |
| Offside Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Offside Rear Vehicle structure has an inadequate repair, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Rear fog lamp switch faulty |1.3.1a| | 1 |
| Offside Inner Front Lower Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Steering locking device insecure |2.2.C.1g| | 1 |
| Power steering malfunctioning |2.3.3a| | 1 |
| Nearside Rear Lower Trailing arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Front Upper Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Nearside Front passenger door cannot be opened from inside the vehicle |6.2.B.1b| | 1 |
| Offside Front Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Nearside Front front brake binding |3.7.B.1| | 1 |
| Offside Rear front brake binding |3.7.B.1| | 1 |
| Offside Front coil spring incomplete |2.4.C.1a| | 1 |
| Offside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Nearside Vehicle structure has excessive corrosion which adversely affects braking or steering |6.1.A.1| | 1 |
| Nearside Service brake grabbing severely |3.7.C.2| | 1 |
| Offside Lower Headlamp not working on main beam |1.7.5a| | 1 |
| Steering column top bearing excessively worn |2.1.2c| | 1 |
| Nearside Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Rear Exhaust has part of the system excessively deteriorated |7.1.1a| | 1 |
| Lower Steering column shaft has excessive end float |2.1.3| | 1 |
| Nearside Rear Stop lamp not working |1.2.1b| | 1 |
| Offside Rear Stop lamp not working |1.2.1b| | 1 |
| Stop lamp not working |1.2.1b| | 1 |
| Nearside Fuel hose insecure |7.2.1| | 1 |
| Fuel system component leaking |7.2.3| | 1 |
| Nearside Front Tie bar/rod has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Front Tie bar/rod has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Rear Drive shaft uj which forms part of the suspension has excessive play in a universal joint |2.4.G.4b| | 1 |
| Rear Mechanical brake component has restricted free movement | 1 |
| Steering column retaining device insecure |2.1.6| | 1 |
| Offside Front Steering system fouling |2.2.D.2a| | 1 |
| Offside Side repeater adversely affected by the operation of another lamp |1.4.A.2h| | 1 |
| Nearside Side repeater not working |1.4.A.2c| | 1 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 1 |
| Hazard warning switch insecure |1.4.B.1d| | 1 |
| Offside Inner Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Offside Front Anti-roll bar rubber mounting deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside front brake binding |3.7.B.1| | 1 |
| Offside Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Rear Direction indicators not working |1.4.A.2c| | 1 |
| Power steering inoperative |2.3.3a| | 1 |
| Offside engine mounting deteriorated resulting in excessive movement |6.1.D.1a| | 1 |
| Steering system fouling |2.2.D.2a| | 1 |
| Front Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 1 |
| Offside Rear Direction indicator not working (4.4.1 (a) (ii)) | 1 |
| Steering rack has excessive free play detected at the steering wheel (steering rack fitted) (2.3 (a) (i)) | 1 |
| Steering component mounting prescribed area is excessively corroded front chassis (2.1.2 (e) (i)) | 1 |
| Parking brake lever defective so that it cannot be satisfactorily operated (1.1.6 (d)) | 1 |
| Nearside Rear Drive shaft joint excessively worn u.j seized (6.1.7 (c) (i)) | 1 |
| Offside Rear Drive shaft joint excessively worn u.j seized (6.1.7 (c) (i)) | 1 |
| Drivers seat insecure Nut missing from inner rear mounting stud. (6.2.5 (a) (ii)) | 1 |
| Passengers seat insecure Nut loose on outer rear mounting stud. (6.2.6 (a) (ii)) | 1 |
| Offside Seat belt retracting mechanism defective (7.1.2 (e)) | 1 |
| Nearside Stop lamp(s) light intensity significantly reduced (4.3.3 (a) (ii)) | 1 |
| Nearside Stop lamp(s) adversely affected by the operation of another lamp Goes out when position lamps turned on. (4.3.3 (b)) | 1 |
| Headlamp aim not tested (4.1.2 (b)) | 1 |
| Dipswitch operation does not extinguish all main beam headlamps leaving at least one pair of dipped beam headlamps (4.1.3 (b)) | 1 |
| Rear fog lamp not working (4.5.1 (a) (ii)) | 1 |
| Offside Rear Service brake excessively binding (1.2.1 (f)) | 1 |
| Nearside Rear Fuel pipe damaged Plastic fuel pipe rubbing on sharp edge of a body component and cut. (6.1.3 (c) (ii)) | 1 |
| Brake performance not tested (1.2.1 (g)) | 1 |
| Power steering pipe/hose leaking connection to steering rack (2.1.5 (a)) | 1 |
| Offside Parking brake inoperative on one side (1.4.1 (a)) | 1 |
| Windscreen washer not working | 1 |
| Offside Front Lower Suspension arm ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Offside Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
| Steering column universal joint has excessive wear or play (2.2.2 (c)) | 1 |
| Steering column has excessive movement up and down (2.2.2 (a)) | 1 |