| Most common failures | No# failures |
|---|
| Headlamp aim out of alignment | 19 |
| Parking brake lever has no reserve travel |3.1.6b| | 6 |
| Exhaust emissions carbon monoxide content excessive (8.2.1.2 (b)) | 4 |
| Registration plate issues | 4 |
| Rear parking brake recording little or no effort | 3 |
| Parking brake: efficiency below requirements |3.7.B.7| | 3 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 3 |
| Rear brake binding | 3 |
| Centre Exhaust has a major leak of exhaust gases |7.1.2| | 2 |
| Front brake excessively fluctuating | 2 |
| Nearside Front Position lamp not working (4.2.1 (a) (ii)) | 2 |
| Parking brake: efficiency below requirements |3.7.C.1b| | 2 |
| Offside Front Position lamp not working (4.2.1 (a) (ii)) | 2 |
| Offside Rear wheel bearing has excessive play |2.6.2| | 2 |
| Brakes imbalanced across an axle | 2 |
| Exhaust emissions hydrocarbon content excessive |7.3.B.1b| | 2 |
| Offside Front Upper Steering column universal joint retaining device insecure |2.1.6| | 1 |
| Offside Front wheel bearing rough when rotated |2.5.A.2| | 1 |
| Offside Front Front position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
| Nearside Headlamp excessively deteriorated so that the light output is severely reduced |1.7.5a| | 1 |
| Nearside Front Steering system has excessive free play detected at the steering wheel |steering rack fitted| |2.2.A.1b| | 1 |
| Offside Front Steering system has excessive free play detected at the steering wheel |steering rack fitted| |2.2.A.1b| | 1 |
| Offside Rear Shock absorber has a serious fluid leak |2.7.3| | 1 |
| Offside Front Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Nearside Front Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Nearside Headlamp insecure |1.7.3| | 1 |
| Nearside Rear Rear wheel bearing has excessive play |2.6.2| | 1 |
| Offside Rear Rear wheel bearing has excessive play |2.6.2| | 1 |
| Nearside Track rod end loose |2.2.B.1d| | 1 |
| Steering system has excessive free play detected at the steering wheel |steering rack fitted| |2.2.A.1b| | 1 |
| Exhaust system not adequately supported fouling N/S/R drive shaft |7.1.1| | 1 |
| Nearside Front Lower Headlamp not working on main beam |1.7.5a| | 1 |
| Nearside Front Direction indicator not working (4.4.1 (a) (ii)) | 1 |
| Offside Side repeater not working (4.4.1 (a) (ii)) | 1 |
| Nearside Rear Position lamp not working 2x not working (4.2.1 (a) (ii)) | 1 |
| Offside Front Steering rack gaiter missing or no longer prevents the ingress of dirt Split (2.1.3 (g) (ii)) | 1 |
| Nearside Headlamp insecure (4.1.1 (c)) | 1 |
| Nearside Front Headlamp not working on dipped beam |1.7.5a| | 1 |
| Front brake disc excessively pitted |3.5.1h| | 1 |
| Rear brake disc excessively pitted |3.5.1h| | 1 |
| Nearside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Rear fog lamp tell-tale not working (4.9.1 (a) (ii)) | 1 |
| Registration plate lamp issues | 1 |
| Nearside Rear Service brake has no recorded effort at a wheel |1.2.1 |a| |ii|| | 1 |
| Offside Rear Service brake has no recorded effort at a wheel |1.2.1 |a| |ii|| | 1 |
| Exhaust emissions carbon monoxide content excessive |8.2.1.2 |b|| | 1 |
| Service brake efficiency below requirements |1.2.2 |a| |i|| | 1 |
| Exhaust emissions carbon monoxide content excessive |7.3.B.1a| | 1 |
| Offside Headlamp not working on dipped beam |1.7.5a| | 1 |
| Offside Headlamp not working on main beam |1.7.5a| | 1 |
| Offside Front Anti-roll bar rubber bush bonding deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Nearside Front Tie bar/rod has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Front Tie bar/rod has excessive play in a pin/bush |2.4.G.2| | 1 |
| Exhaust emissions hydrocarbon content excessive (8.2.1.2 (b)) | 1 |
| Fuel cap/sealing device ineffective (6.1.3 (b) (i)) | 1 |
| Offside Front Upper Steering column universal joint has excessive play |2.1.5| | 1 |
| Offside Front Track rod end loose |2.2.B.1d| | 1 |
| Rear fog lamp not working (4.5.1 (a) (ii)) | 1 |
| Central Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 1 |
| Offside Front Vehicle structure inadequately repaired such that structural rigidity is significantly reduced outrigger (6.1.1 (d) (i)) | 1 |
| All direction indicators not working (4.4.1 (a) (ii)) | 1 |
| Offside Rear Hazard warning lamps inoperative (4.4.1 (e)) | 1 |
| Hazard warning lamps inoperative (4.4.1 (e)) | 1 |
| Offside Headlamp not working on main beam (4.1.1 (a) (ii)) | 1 |
| Parking brake efficiency below requirements (1.4.2 (a) (i)) | 1 |
| Nearside Headlamp not working on dipped beam |1.7.5a| | 1 |
| Offside Front Direction indicator not working |1.4.A.2c| | 1 |
| Offside Front Upper Suspension arm ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Nearside Front Lower Suspension arm ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Offside Headlamp does not operate immediately when selected on dipped beam |1.7.4a| | 1 |
| Horn not working |1.6.2a| | 1 |
| Driver`s seat insecure |6.2.A.1| | 1 |
| Position lamp switch faulty |1.1.A.1| | 1 |
| Nearside Front Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Front Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Nearside front brake binding |3.7.B.1| | 1 |
| Nearside Rear brake disc contaminated by oil |3.5.1h| | 1 |
| Rear Exhaust system not adequately supported |7.1.1| | 1 |
| Nearside Steering system has excessive free play detected at the steering wheel |steering rack fitted| |2.2.A.1b| | 1 |
| Offside Steering system has excessive free play detected at the steering wheel |steering rack fitted| |2.2.A.1b| | 1 |
| Nearside Front suspension has excessive play in a upper suspension ball joint |2.5.B.1a| | 1 |
| Nearside Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside rear brake recording little or no effort |3.7.B.5a| | 1 |
| Offside rear brake recording little or no effort |3.7.B.5a| | 1 |
| Hazard warning switch faulty |1.4.B.1d| | 1 |
| Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Nearside Side repeater not working |1.4.A.2c| | 1 |
| Nearside Headlamp not working on main beam |1.7.5a| | 1 |
| Offside Rear Drive shaft uj which forms part of the suspension has excessive play in a universal joint |2.4.G.4b| | 1 |