| Most common failures | No# failures |
|---|
| Parking brake: efficiency below requirements |3.7.B.7| | 28 |
| Headlamp aim out of alignment | 19 |
| Registration plate lamp issues | 15 |
| Horn not working |1.6.2a| | 15 |
| Rear brake binding | 12 |
| Rear parking brake recording little or no effort | 11 |
| Brakes imbalanced across an axle | 11 |
| Parking brake lever has no reserve travel |3.1.6b| | 8 |
| Windscreen wiper does not clear the windscreen effectively | 8 |
| Brake pipe excessively corroded | 5 |
| Nearside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 5 |
| Offside Headlamp not working on dipped beam |1.7.5a| | 5 |
| Brake pedal spongy |3.3.B.1b| | 5 |
| Nearside Headlamp not working on dipped beam |1.7.5a| | 5 |
| Offside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 4 |
| Offside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 4 |
| Registration plate issues | 4 |
| Rear brake application uneven | 4 |
| Nearside front brake binding |3.7.B.1| | 4 |
| Service brake: efficiency below requirements |3.7.B.7| | 3 |
| Nearside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 3 |
| Fuel system component leaking |7.2.3| | 3 |
| Offside Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 3 |
| Offside Stop lamp not working |1.2.1b| | 3 |
| Offside Front wheel bearing has excessive play |2.5.A.3c| | 3 |
| Offside front brake binding |3.7.B.1| | 3 |
| Nearside rear brake recording little or no effort |3.7.B.5a| | 2 |
| Nearside Front wheel bearing has excessive play |2.5.A.3c| | 2 |
| Nearside Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
| Windscreen washer not working | 2 |
| Offside Body has a sharp edge caused by corrosion |6.1.C.1| | 2 |
| Nearside Steering rack gaiter split |2.2.D.2d| | 2 |
| Nearside Headlamp not working on main beam |1.7.5a| | 2 |
| Indicator tell tale missing |1.4.A.2a| | 2 |
| Steering column top bearing excessively worn |2.1.2c| | 2 |
| Parking brake: efficiency below requirements |3.7.C.1b| | 2 |
| Nearside Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 2 |
| Offside Front Steering arm has relative movement at its fixings |2.2.B.1h| | 2 |
| Offside Front Upper Suspension arm ball joint dust cover missing |2.4.G.2| | 2 |
| Offside Front Headlamp not working on main beam |1.7.5a| | 2 |
| Brake hose has insufficient room to move | 2 |
| Offside Front Seat belt retracting mechanism defective |5.2.5b| | 2 |
| front brake binding |3.7.B.1| | 2 |
| Nearside Stop lamp not working |1.2.1b| | 2 |
| Offside Headlamp not working on main beam |1.7.5a| | 2 |
| Steering column flexible coupling insecure |2.1.5| | 1 |
| Steering wheel weakened by fractures |2.1.1| | 1 |
| Direction indicators adversely affected by the operation of another lamp |1.4.A.2h| | 1 |
| Offside Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Nearside Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
| Offside Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
| Steering wheel has movement relative to the column indicating looseness (2.2.1 (a) (i)) | 1 |
| Nearside Headlamp not working on main beam (4.1.1 (a) (ii)) | 1 |
| Nearside Front Suspension component mounting prescribed area is excessively corroded out rigger |2.4.A.3| | 1 |
| Nearside Rear Direction indicator incorrect colour |1.4.A.2f| | 1 |
| Offside Rear Direction indicator incorrect colour |1.4.A.2f| | 1 |
| Nearside Rear Tie bar/rod attachment bracket/mounting corroded and its strength is seriously reduced |2.4.G.1| | 1 |
| Nearside Front Seat belt locking mechanism does not secure or release |5.2.5a| | 1 |
| Offside Rear rear brake recording little or no effort |3.7.B.5a| | 1 |
| Offside Steering rack gaiter split |2.2.D.2d| | 1 |
| Nearside Upper Front suspension ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Direction indicators not working |1.4.A.2c| | 1 |
| Mechanical brake component has restricted free movement | 1 |
| Nearside Rear Lower Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Front Headlamp not working on dipped beam |1.7.5a| | 1 |
| Centre Front Braking system leaking |3.6.A.1| | 1 |
| Horn not working |7.7 |a| |ii|| | 1 |
| Nearside Seat belt anchorage prescribed area is inadequately repaired |7.1.1 |a| |i|| | 1 |
| Offside Seat belt anchorage prescribed area is inadequately repaired |7.1.1 |a| |i|| | 1 |
| Nearside Rear Seat belt anchorage prescribed area is inadequately repaired floor |7.1.1 |a| |i|| | 1 |
| Offside Rear Seat belt anchorage prescribed area is inadequately repaired floor |7.1.1 |a| |i|| | 1 |
| Position lamp switch insecure |1.1.A.1| | 1 |
| Nearside Rear Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Offside Rear Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Nearside Rear Body or chassis has an unsatisfactory modification, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Rear Body or chassis has an unsatisfactory modification, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Front Body or chassis has an unsatisfactory modification, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Steering column universal joint has excessive play |2.1.5| | 1 |
| Nearside Rear Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Rear Drive shaft uj which forms part of the suspension has excessive play in a universal joint |2.4.G.4b| | 1 |
| Nearside Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Fuel pipe leaking |7.2.3| | 1 |
| Fuel cap/sealing device sealing washer deteriorated |7.2.4c| | 1 |
| Offside Front Lower Suspension arm has excessive play in a pin/bearing trunion |2.4.G.2| | 1 |
| Nearside Steering system has excessive free play detected at the steering wheel |steering rack fitted| |2.2.A.1b| | 1 |
| Offside Steering system has excessive free play detected at the steering wheel |steering rack fitted| |2.2.A.1b| | 1 |
| Offside Front suspension has excessive movement at a wishbone pin or bush |2.5.A.1c| | 1 |
| Nearside Front suspension has excessive movement at a wishbone pin or bush |2.5.A.1c| | 1 |
| Horn control not readily accessible to the driver |1.6.1| | 1 |
| Offside Headlamp aim headlamp not in good working order adversely affecting beam image |1.2.4b| | 1 |
| Parking brake lever defective so that it cannot be satisfactorily operated |3.1.3c| | 1 |
| Vehicle structure has excessive corrosion which adversely affects braking or steering |6.1.A.1| | 1 |
| Fuel cap/sealing device missing (6.1.3 (b) (i)) | 1 |
| Nearside Front Road wheel more than one fixing loose (5.2.1 (a) (ii)) | 1 |
| Offside Front Road wheel more than one fixing loose (5.2.1 (a) (ii)) | 1 |
| Nearside Front Direction indicator not working |1.4.A.2c| | 1 |
| Offside Front Direction indicator not working |1.4.A.2c| | 1 |
| Nearside Front Direction indicator adversely affected by the operation of another lamp |1.4.A.2h| | 1 |
| Offside Front Direction indicator adversely affected by the operation of another lamp |1.4.A.2h| | 1 |
| Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Rear Suspension component mounting prescribed area is inadequately repaired |2.4.A.3| | 1 |
| Offside Rear Suspension component mounting prescribed area is inadequately repaired |2.4.A.3| | 1 |
| Brake performance not tested |3.7.A.1| | 1 |
| Offside Front brake caliper has restricted free movement |3.5.1k| | 1 |
| Nearside Ball joint has excessive play |2.2.B.1f| | 1 |
| Direction indicators not in good working order |function impaired| |1.5.A1b| | 1 |
| Offside Front Upper Seat belt insecurely fixed to the vehicles structure |5.2.1a| | 1 |
| Windscreen wiper not operating over a large enough area to give an adequate view |8.2.1c| | 1 |
| Nearside Drag link end ball joint has excessive play |2.2.B.1f| | 1 |
| Centre Front Exhaust system not adequately supported |7.1.1| | 1 |
| Offside Outer Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Front Anti-roll bar attachment bracket/mounting corroded and its strength is seriously reduced |2.4.G.1| | 1 |
| Nearside Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Body has a sharp edge caused by corrosion |6.1.C.1| | 1 |
| Nearside Front Wheel nut|s| missing |4.2.A.1e| | 1 |
| Nearside Rear Wheel nut|s| missing |4.2.A.1e| | 1 |
| Offside Rear Service brake grabbing severely |3.7.C.2| | 1 |
| Nearside Front Steering column shaft has excessive end float |2.1.3| | 1 |
| Offside Front Steering column shaft has excessive end float |2.1.3| | 1 |
| Offside Front Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Nearside Headlamp not working on main beam |4.1.1 |a| |ii|| | 1 |
| Front front brake binding Both |3.7.B.1| | 1 |
| Offside rear brake recording little or no effort |3.7.B.5a| | 1 |
| Nearside Rear Braking system leaking union to flexible hose. |3.6.A.1| | 1 |
| Nearside Front Upper Suspension arm ball joint dust cover missing |2.4.G.2| | 1 |
| Offside Obligatory mirror missing |8.1.1| | 1 |
| Parking brake efficiency below requirements (1.4.2 (a) (i)) | 1 |
| Front Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Offside Rear Suspension arm has excessive play in a pin/bearing outer trunion |2.4.G.2| | 1 |
| All direction indicators not working all (4.4.1 (a) (ii)) | 1 |
| Parking brake efficiency below requirements |1.4.2 |a| |i|| | 1 |
| Parking |secondary brake| on a single line braking system imbalanced across an axle Axle 1 |1.3.1 |b| |i|| | 1 |
| Nearside Rear Brake cable has wires broken and is significantly weakened |3.5.1b| | 1 |
| Offside Track rod end ball joint has excessive play (2.1.3 (b) (i)) | 1 |
| All position lamps adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
| Offside Front Upper Front suspension ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Nearside Front passenger door cannot be opened from outside the vehicle |6.2.B.1b| | 1 |
| Nearside Front Track rod end ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Offside Front Steering rack gaiter split |2.2.D.2d| | 1 |
| Direction indicators flashing more than 120 times a minute |1.4.A.2g| | 1 |
| Rear Exhaust system not adequately supported |7.1.1| | 1 |
| rear brakes release unevenly |3.7.B.4| | 1 |
| Offside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Rear Vehicle structure has an inadequate repair, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Centre Exhaust system not adequately supported |7.1.1| | 1 |
| Nearside Rear Shock absorber has a serious fluid leak |2.7.3| | 1 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Upper Front suspension ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Nearside Track rod end ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Service brake: efficiency below requirements |3.7.C.1a| | 1 |
| Nearside Front Lower Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Rear Mechanical brake component has restricted free movement | 1 |
| Centre Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Rear Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Offside Rear front brake recording little or no effort |3.7.B.5a| | 1 |
| Offside Rear front parking brake recording little or no effort |3.7.B.6a| | 1 |
| Rear Subframe mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Rear wheel cylinder leaking |3.6.A.1| | 1 |
| Subframe mounting prescribed area is inadequately repaired |2.4.A.3| | 1 |
| Braking system leaking |3.6.A.1| | 1 |
| Offside Front front brake binding |3.7.B.1| | 1 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 1 |
| Front All direction indicators obviously incorrectly positioned both sides working opposite to rear and wrong way round (4.4.3 (a)) | 1 |
| Offside Rear Tie bar/rod attachment bracket/mounting nut missing |2.4.G.1| | 1 |
| Nearside Track rod end ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Offside Headlamp adversely affected by the operation of another lamp |1.7.5c| | 1 |
| Offside Rear Service brake lagging in operation (1.2.1 (d)) | 1 |
| Drivers door does not latch securely closed (6.2.3 (a)) | 1 |
| Central Parking brake lever insecure of vehicle |3.1.3b| | 1 |
| Parking brake is not capable of being maintained in operation by direct mechanical action only |3.1.2| | 1 |
| Parking brake lever ratchet mechanism is excessively worn |3.1.5| | 1 |
| Windscreen washer jets misaligned and not providing sufficient fluid to the windscreen (3.5 (a)) | 1 |
| Nearside Front Wheel insecure |4.2.A.1c| | 1 |
| Offside Front Front wheel bearing has excessive play |2.5.A.3c| | 1 |
| Nearside Rear Braking system leaking |3.6.A.1| | 1 |
| Brake hose damaged | 1 |
| Nearside Front Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting |6.2.2 |d| |i|| | 1 |
| Offside Front Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting |6.2.2 |d| |i|| | 1 |
| Nearside Front wheel bearing rough when rotated |2.5.A.2| | 1 |
| Offside Lower Steering column universal joint has excessive play |2.1.5| | 1 |
| Nearside Front Lower Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
| Offside Front Lower Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
| Rear Stop lamp not working |1.2.1b| | 1 |
| Offside Inner Front Lower Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Outer Front Lower Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |