Most common failures | No# failures |
---|
Headlamp aim out of alignment | 174 |
Parking brake: efficiency below requirements |3.7.B.7| | 165 |
Rear parking brake recording little or no effort | 86 |
Windscreen wiper does not clear the windscreen effectively | 62 |
Rear brake binding | 58 |
Horn not working |1.6.2a| | 55 |
Service brake: efficiency below requirements |3.7.B.7| | 48 |
Registration plate lamp issues | 47 |
Brakes imbalanced across an axle | 43 |
Offside Stop lamp not working |1.2.1b| | 32 |
Nearside Stop lamp not working |1.2.1b| | 28 |
Stop lamp does not illuminate immediately a brake applies |1.3.1a| | 27 |
Registration plate issues | 27 |
Offside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 26 |
Brake pipe excessively corroded | 25 |
Nearside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 23 |
Nearside rear brake recording little or no effort |3.7.B.5a| | 20 |
Nearside Headlamp not working on main beam |1.7.5a| | 19 |
Rear position lamp does not illuminate immediately when it is switched on |1.1.3a| | 19 |
Offside Front position lamp|s| not working |1.1.A.3b| | 18 |
Nearside Headlamp not working on dipped beam |1.7.5a| | 18 |
Offside Headlamp not working on main beam |1.7.5a| | 18 |
Nearside Rear Direction indicator not working |1.4.A.2c| | 18 |
Offside rear brake recording little or no effort |3.7.B.5a| | 17 |
Rear reflector on motorcycle missing |1.4.1| | 16 |
Nearside Front position lamp|s| not working |1.1.A.3b| | 16 |
Exhaust has a major leak of exhaust gases |7.1.2| | 16 |
Offside Rear Stop lamp not working |1.2.1b| | 15 |
Nearside Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 15 |
Offside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 15 |
Rear Stop lamp does not illuminate immediately a brake applies |1.3.1a| | 15 |
Rear Exhaust has a major leak of exhaust gases |7.1.2| | 15 |
Offside Headlamp not working on dipped beam |1.7.5a| | 15 |
Offside Front wheel bearing has excessive play |2.5.A.3c| | 15 |
Nearside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 14 |
Horn not working |1.7.3a| | 13 |
Offside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 13 |
Nearside Rear Stop lamp not working |1.2.1b| | 13 |
Rear Exhaust system not adequately supported |7.1.1| | 13 |
Offside Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 13 |
Offside Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 13 |
Nearside Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 12 |
Brake hose excessively deteriorated | 12 |
Parking brake lever has no reserve travel |3.1.6b| | 12 |
Offside front brake binding |3.7.B.1| | 11 |
Parking brake: efficiency below requirements |3.7.C.1b| | 11 |
Steering column movement between the shaft and steering wheel |2.1.2b| | 11 |
Headlamp at least one does not illuminate on dipped beam |1.2.2a|i|| | 11 |
Rear brake application uneven | 11 |
Nearside Front wheel bearing has excessive play |2.5.A.3c| | 11 |
Offside Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 10 |
Nearside Rear Direction indicators not working |1.4.A.2c| | 10 |
Direction indicators not working |1.4.A.2c| | 9 |
Nearside front brake binding |3.7.B.1| | 9 |
Nearside Steering rack gaiter split |2.2.D.2d| | 9 |
Nearside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 9 |
Offside Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 9 |
Steering headbearing has excessive free play |2.2.2| | 9 |
Offside Rear position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 9 |
Front passenger door cannot be opened from outside the vehicle |6.2.B.1b| | 9 |
Horn not loud enough to be heard by another road user |1.7.3a| | 8 |
Offside Front Direction indicator not working |1.4.A.2c| | 8 |
Steering column top bearing excessively worn |2.1.2c| | 8 |
Offside Rear position lamp|s| not working |1.1.A.3b| | 8 |
Stop lamp not working |1.2.1b| | 8 |
Headlamp at least one does not illuminate on main beam |1.2.2a|ii|| | 8 |
Offside Track rod end ball joint has excessive play |2.2.B.1f| | 8 |
Driver`s seat insecure |6.2.A.1| | 7 |
Steering system has excessive free play detected at the steering wheel |steering rack fitted| |2.2.A.1b| | 7 |
Nearside Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 7 |
Offside Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 7 |
Nearside Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 7 |
Offside Steering rack gaiter split |2.2.D.2d| | 7 |
Offside Front Steering rack gaiter split |2.2.D.2d| | 7 |
Rear Stop lamp not working |1.2.1b| | 7 |
Offside Rear Direction indicator not working |1.4.A.2c| | 7 |
Steering rack insecure |2.2.B.1a| | 7 |
Offside Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 7 |
Nearside Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 7 |
Offside Stop lamp adversely affected by the operation of another lamp |1.2.1f| | 7 |
Direction indicators flashing less than 60 times a minute |1.4.A.2g| | 7 |
Offside Front Front position lamp|s| not working |1.1.A.3b| | 7 |
Nearside Rear position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 7 |
Nearside Handlebar handgrip not secure to handlebars. |2.1.1c| | 6 |
Fuel hose leaking |7.2.3| | 6 |
Rear Mechanical brake component has restricted free movement | 6 |
Nearside Rear rear brake recording little or no effort |3.7.B.5a| | 6 |
Front brake application uneven | 6 |
Offside Rear Subframe mounting prescribed area is excessively corroded |2.4.A.3| | 6 |
Front Exhaust has a major leak of exhaust gases |7.1.2| | 6 |
Brake hose has insufficient room to move | 6 |
Nearside Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 6 |
Front Steering headbearing has excessive free play |2.2.2| | 6 |
Front passenger door cannot be opened from inside the vehicle |6.2.B.1b| | 6 |
Nearside Front Front position lamp|s| not working |1.1.A.3b| | 6 |
Nearside Front Direction indicator not working |1.4.A.2c| | 6 |
Nearside Front Front wheel bearing has excessive play |2.5.A.3c| | 6 |
Nearside Front Front wheel bearing rough when rotated |2.5.A.2| | 6 |
Front Windscreen wiper not operating automatically when switched on |8.2.1b| | 6 |
Front passenger seat insecure |6.2.3| | 6 |
Nearside Front Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 6 |
Roller brake test The less effective brake control does not achieve an efficiency of 25%. |3.3.A2b| | 6 |
Nearside Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 6 |
Offside Front Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 6 |
Offside Front Headlamp not working on main beam |1.7.5a| | 6 |
Battery insecure |1.9.1| | 5 |
Parking brake lever has excessive side play in the pivot and may disengage |3.1.4a| | 5 |
Nearside Rear wheel bearing has excessive play |2.6.2| | 5 |
Offside Rear wheel bearing has excessive play |2.6.2| | 5 |
Brake pedal spongy |3.3.B.1b| | 5 |
Nearside Front Steering rack gaiter split |2.2.D.2d| | 5 |
Riders seat insecure |6.2.1a| | 5 |
Nearside Front front brake binding |3.7.B.1| | 5 |
Nearside Rear Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 5 |
All position lamps not working |1.1.A.3b| | 5 |
Rear wheel bearings have excessive free play |2.4.A.2c| | 5 |
Offside Obligatory mirror missing |8.1.1| | 5 |
Wheel alignment incorrect which adversely affects the handling |2.5.1| | 5 |
Steering wheel retaining device insecure |2.1.6| | 5 |
Nearside Stop lamp adversely affected by the operation of another lamp |1.2.1f| | 5 |
Fuel cap/sealing device does not fasten securely maintaining the sealing arrangement |7.2.4b| | 5 |
Fuel cap/sealing device sealing washer missing |7.2.4c| | 5 |
Nearside Direction indicators not working |1.4.A.2c| | 5 |
Nearside Front Suspension arm has excessive play in a pin/bush |2.4.G.2| | 5 |
Offside Front Headlamp not working on dipped beam |1.7.5a| | 5 |
Hazard warning switch faulty |1.4.B.1d| | 5 |
Nearside Headlamp not in good working order adversely affecting beam image |1.2.4a| | 4 |
Fuel tank leaking |7.2.3| | 4 |
Offside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 4 |
Nearside Rear position lamp|s| not working |1.1.A.3b| | 4 |
Offside Rear Rear wheel bearing has excessive play |2.6.2| | 4 |
Nearside Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 4 |
Offside Rear Braking system leaking |3.6.A.1| | 4 |
Brake pedal creeps down when held under pressure |3.3.B.1a| | 4 |
Windscreen wiper not operating automatically when switched on |8.2.1b| | 4 |
Nearside Steering arm has relative movement at its fixings |2.2.B.1h| | 4 |
Offside Front front brake binding |3.7.B.1| | 4 |
Drive chain excessively loose |6.2.1d| | 4 |
Mechanical brake component has restricted free movement | 4 |
Offside Windscreen wiper blade deteriorated |8.2.2| | 4 |
Nearside Front Vehicle structure has excessive corrosion which adversely affects braking or steering |6.1.A.1| | 4 |
Rear Rear position lamp does not illuminate immediately when it is switched on |1.1.3a| | 4 |
Rear suspension bush has excessive free play |2.4.A2a|i|| | 4 |
Offside Front Front wheel bearing rough when rotated |2.5.A.2| | 4 |
Front position lamp does not illuminate immediately when switched on |1.1.3a| | 4 |
Nearside Rear Subframe mounting prescribed area is excessively corroded |2.4.A.3| | 4 |
Offside Front Front wheel bearing has excessive play |2.5.A.3c| | 4 |
Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 4 |
Nearside Front Lower Suspension arm has excessive play in a pin/bush |2.4.G.2| | 4 |
Offside Rear rear brake recording little or no effort |3.7.B.5a| | 4 |
Offside Rear Rear position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 4 |
Front Brake lever has inadequate reserve travel |3.1.3b| | 4 |
Steering column top mounting bracket insecure |2.1.2d| | 4 |
Offside Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 4 |
Nearside Front Headlamp not working on dipped beam |1.7.5a| | 4 |
Offside Rear Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 4 |
Service brake: efficiency below requirements |3.7.C.1a| | 4 |
Driver`s door cannot be opened from inside the vehicle |6.2.B.1b| | 4 |
Offside Front Seat belt retracting mechanism defective |5.2.5b| | 4 |
Nearside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 4 |
Offside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 4 |
Windscreen washer not working | 4 |
Nearside Track rod end ball joint has excessive play |2.2.B.1f| | 4 |
Offside Direction indicators not working |1.4.A.2c| | 4 |
Offside Front Track rod end ball joint has excessive play |2.2.B.1f| | 4 |
Hazard warning lamps not flashing in phase, with ignition on |1.4.B.1f| | 4 |
Hazard warning lamps not flashing in phase, with ignition off |1.4.B.1f| | 4 |
Power steering pipe|s| or hose|s| leaking from a joint |2.3.3b| | 4 |
Offside Rear Direction indicators not working |1.4.A.2c| | 4 |
Nearside Front Subframe mounting prescribed area is excessively corroded |2.4.A.3| | 4 |
Nearside Front Headlamp not working on main beam |1.7.5a| | 4 |
Offside Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 4 |
Offside Front wheel bearing rough when rotated |2.5.A.2| | 3 |
Fuel pipe leaking |7.2.3| | 3 |
Offside Handlebar handgrip not secure to handlebars. |2.1.1c| | 3 |
Nearside Front Brake pipe inadequately clipped |3.6.B.1| | 3 |
Horn not working (7.7 (a) (ii)) | 3 |
Offside Front Driver`s seat insecure |6.2.A.1| | 3 |
Driver`s seat cannot be secured in the upright position. |6.2.A.2| | 3 |
Nearside Rear Rear wheel bearing rough when rotated |2.6.1| | 3 |
Offside Front Brake hose twisted |found during steering lock to lock check| |2.2.D.2b| | 3 |
Nearside Front All position lamps not working |1.1.A.3b| | 3 |
Nearside Front shock absorber seal failed and leaking oil |2.3.3| | 3 |
Nearside Rear Brake cable locking device insecure |3.5.1l| | 3 |
Offside Headlamp insecure |1.7.3| | 3 |
Nearside front brake juddering severely |3.7.A.2b| | 3 |
Offside front brake juddering severely |3.7.A.2b| | 3 |
Offside Front Subframe mounting prescribed area is excessively corroded |2.4.A.3| | 3 |
Position lamp switch faulty |1.1.A.1| | 3 |
Parking brake lever defective so that it cannot be satisfactorily operated |3.1.3c| | 3 |
Nearside Front Steering arm has relative movement at its fixings |2.2.B.1h| | 3 |
Offside Front Steering rack gaiter insecure |2.2.D.2d| | 3 |
Nearside Rear Braking system leaking |3.6.A.1| | 3 |
Front Headlamp not working on main beam |1.7.5a| | 3 |
Front Front shock absorber seal failed and leaking oil |2.3.3| | 3 |
Indicator switch insecure |1.4.A.1| | 3 |
Nearside Front Direction indicators not working |1.4.A.2c| | 3 |
Fuel system component insecure |7.2.1| | 3 |
Steering column universal joint has excessive play |2.1.5| | 3 |
Front Headlamp not working on dipped beam |1.7.5a| | 3 |
Offside Rear Vehicle structure has excessive corrosion which adversely affects braking or steering |6.1.A.1| | 3 |
Fuel system component leaking |7.2.3| | 3 |
Nearside Steering lock stop ineffective |2.1.3| | 3 |
Headlamp dipped beam affected by the operation of another lamp |1.2.2c| | 3 |
Nearside Front wheel bearing rough when rotated |2.5.A.2| | 3 |
Offside Side repeater not working |1.4.A.2c| | 3 |
Brake lever has inadequate reserve travel |3.1.3b| | 3 |
Throttle has a significant change in engine speed whilst moving the steering from lock to lock |2.1.4| | 3 |
Front suspension has excessive stiffness in the suspension movement. |2.3.6b| | 3 |
Nearside Rear Shock absorber has a serious fluid leak |2.7.3| | 3 |
Brake performance not tested |3.7.A.1| | 3 |
Nearside Track rod end loose |2.2.B.1d| | 3 |
All position lamps do not illuminate immediately when switched on |1.1.3a| | 3 |
Offside Direction indicator flashing less than 60 times a minute |1.4.A.2g| | 3 |
Centre Exhaust has a major leak of exhaust gases |7.1.2| | 3 |
Rear Brake pedal has inadequate reserve travel |3.1.3b| | 3 |
Handlebar mounting clamp loose |2.1.1a| | 3 |
Offside Front Direction indicators not working |1.4.A.2c| | 3 |
Nearside Front Track rod end ball joint has excessive play |2.2.B.1f| | 3 |
Offside Front brake disc excessively pitted |3.5.1h| | 3 |
Windscreen has damage | 3 |
Nearside Front Track rod end ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.2.C.1c| | 3 |
Offside Front Track rod end ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.2.C.1c| | 3 |
Front suspension assembly component cracked |2.3.1| | 3 |
Driver`s door cannot be opened from outside the vehicle |6.2.B.1b| | 3 |
Nearside Front Seat belt locking mechanism does not secure or release |5.2.5a| | 3 |
Offside Front Seat belt locking mechanism does not secure or release |5.2.5a| | 3 |
Handlebar mounting excessively deteriorated |flexible type| |2.1.1d| | 3 |
Nearside Front brake disc excessively pitted |3.5.1h| | 3 |
Horn not loud enough to be heard by another road user |1.6.2b| | 3 |
Offside Track rod end ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.2.C.1c| | 3 |