Most common failures | No# failures |
---|
Headlamp aim out of alignment | 33 |
Parking brake: efficiency below requirements |3.7.B.7| | 21 |
Horn not working |1.6.2a| | 17 |
Brakes imbalanced across an axle | 16 |
Windscreen wiper does not clear the windscreen effectively | 15 |
Registration plate lamp issues | 12 |
Service brake: efficiency below requirements |3.7.B.7| | 10 |
Rear brake binding | 10 |
Rear parking brake recording little or no effort | 8 |
Offside Stop lamp not working |1.2.1b| | 7 |
Nearside Stop lamp not working |1.2.1b| | 6 |
Offside Headlamp not working on dipped beam |1.7.5a| | 5 |
Offside Front position lamp|s| not working |1.1.A.3b| | 5 |
Offside Front wheel bearing has excessive play |2.5.A.3c| | 5 |
Direction indicators not working |1.4.A.2c| | 4 |
Nearside Front wheel bearing has excessive play |2.5.A.3c| | 4 |
Nearside Headlamp aim beam image kick up to the offside |1.8| | 4 |
Offside Headlamp aim beam image kick up to the offside |1.8| | 4 |
Nearside Front Front wheel bearing has excessive play |2.5.A.3c| | 3 |
Nearside Headlamp not working on dipped beam |1.7.5a| | 3 |
Steering system has excessive free play detected at the steering wheel |steering rack fitted| |2.2.A.1b| | 3 |
Registration plate issues | 3 |
Battery insecure |1.9.1| | 3 |
Nearside Steering rack gaiter split |2.2.D.2d| | 3 |
Nearside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 3 |
Nearside Rear wheel bearing has excessive play |2.6.2| | 3 |
Nearside Rear Shock absorber has a serious fluid leak |2.7.3| | 3 |
Offside Steering rack gaiter split |2.2.D.2d| | 2 |
Offside rear brake recording little or no effort |3.7.B.5a| | 2 |
Brake pedal creeps down while the pedal is held under pressure |3.3.B.1a| | 2 |
Nearside Front Headlamp not working on main beam |1.7.5a| | 2 |
Offside Front Headlamp not working on main beam |1.7.5a| | 2 |
Offside Rear Shock absorber has a serious fluid leak |2.7.3| | 2 |
Front Windscreen wiper not operating over a large enough area to give an adequate view |8.2.1c| | 2 |
All position lamps not working |1.1.A.3b| | 2 |
Nearside Steering arm has relative movement at its fixings |2.2.B.1h| | 2 |
Fuel system component leaking |7.2.3| | 2 |
Windscreen wiper not operating automatically when switched on |8.2.1b| | 2 |
Horn not loud enough to be heard by another road user |1.6.2b| | 2 |
Front Exhaust has a major leak of exhaust gases |7.1.2| | 2 |
Offside Front Steering rack gaiter split |2.2.D.2d| | 2 |
Exhaust has a major leak of exhaust gases |7.1.2| | 2 |
Offside Track rod end loose |2.2.B.1d| | 2 |
Offside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
Nearside Front position lamp|s| not working |1.1.A.3b| | 2 |
Front Windscreen wiper not operating automatically when switched on |8.2.1b| | 2 |
Offside Side repeater not working |1.4.A.2c| | 2 |
Nearside rear brake recording little or no effort |3.7.B.5a| | 2 |
Offside Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 2 |
Stop lamp not working |1.2.1b| | 2 |
Nearside Front Side repeater not working |1.4.A.2c| | 2 |
Driver`s seat insecure |6.2.A.1| | 2 |
Offside Front Lower Front suspension has excessive movement at a wishbone pin or bush |2.5.A.1c| | 2 |
Steering column movement between the shaft and steering wheel |2.1.2b| | 2 |
Steering column flexible coupling insecure |2.1.5| | 2 |
Brake pedal spongy |3.3.B.1b| | 2 |
Brake hose excessively deteriorated | 2 |
Nearside Track rod end ball pin shank loose |2.2.B.1c| | 2 |
Nearside Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 2 |
Offside Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 2 |
Windscreen wiper not working (3.4 (a)) | 2 |
Stop lamp(s) all not working (4.3.1 (a) (iii)) | 2 |
Nearside Front Steering rack gaiter missing or no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 2 |
Parking brake efficiency less than 50% of the required value (1.4.2 (a) (ii)) | 2 |
Parking brake efficiency below requirements (1.4.2 (a) (i)) | 2 |
Nearside Front front brake binding |3.7.B.1| | 1 |
Brake cable locking device missing |3.5.1l| | 1 |
Offside Front Seat belt insecurely fixed to the vehicles structure |5.2.1a| | 1 |
Nearside Rear Braking system leaking |3.6.A.1| | 1 |
Nearside Front Seat belt retracting mechanism defective |5.2.5b| | 1 |
Parking brake lever pawl spring does not push the pawl positively into the ratchet teeth |3.1.5| | 1 |
Offside Rear Inner Road wheel spoke excessively loose all spokes loose |4.2.A.1b| | 1 |
Nearside front brake binding |3.7.B.1| | 1 |
Nearside Front Lower Suspension arm has excessive play in a pin/bearing |2.4.G.2| | 1 |
Steering column top bearing excessively worn |2.1.2c| | 1 |
Steering system excessively tight |2.2.D.1| | 1 |
Nearside Stub axle has excessive vertical movement between stub axle and axle beam |2.5.A.1a| | 1 |
Nearside Rear Brake pipe excessively damaged |3.6.B.2c| | 1 |
Steering rack deformed and unserviceable |2.2.C.1d| | 1 |
Nearside Front brake disc contaminated by oil |3.5.1h| | 1 |
Offside Rear Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
Nearside Rear Exhaust system not adequately supported |7.1.1| | 1 |
Offside Front position lamp|s| missing |1.1.A.3a| | 1 |
Offside Front Headlamp aim not tested |1.8.A.1c| | 1 |
Nearside Front Headlamp not working on dipped beam |1.7.5a| | 1 |
Offside Front Headlamp not working on dipped beam |1.7.5a| | 1 |
Nearside Front Brake pipe inadequately clipped |3.6.B.1| | 1 |
Front Brake pipe inadequately clipped |3.6.B.1| | 1 |
Rear Brake pipe inadequately clipped |3.6.B.1| | 1 |
Offside Rear Inner Drive shaft securing bolt loose plus bolt missing |6.1.7 |a| |i|| | 1 |
Main beam `tell-tale` not working |1.7.4c| | 1 |
Offside Front Lower Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
Offside Front An item not tested |Manual| | 1 |
Offside Rear An item not tested |Manual| | 1 |
Rear Rear wheel bearing has excessive play |2.6.2| | 1 |
Offside Rear Brake pipe fouled by moving parts |3.6.B.2a| | 1 |
Parking brake lever is located so that it cannot be satisfactorily operated from the driver`s seat |3.1.3c| | 1 |
Nearside Front Anti-roll bar linkage attachment bracket/mounting fractured |5.3.3 |b| |ii|| | 1 |
Offside Front Anti-roll bar linkage attachment bracket/mounting fractured |5.3.3 |b| |ii|| | 1 |
Front Anti-roll bar attachment bracket/mounting insecure |2.4.G.1| | 1 |
Nearside Front Upper Suspension arm ball joint dust cover missing |2.4.G.2| | 1 |
Nearside Rear Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
Nearside Front brake disc contaminated by grease |3.5.1h| | 1 |
Steering rack damaged and unserviceable |2.2.C.1d| | 1 |
Nearside Rear Brake valve insecurely mounted |3.6.A.2a| | 1 |
Offside Front Upper Suspension arm ball joint dust cover insecure so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
Headlamp switch faulty not keeping main beam on |1.7.1| | 1 |
Offside Rear wheel bearing has excessive play |2.6.2| | 1 |
Nearside Rear Trailing arm severely distorted |2.4.G.1| | 1 |
Nearside front brake grabbing severely |3.7.A.2b| | 1 |
Offside front brake grabbing severely |3.7.A.2b| | 1 |
Nearside Front Braking system leaking |3.6.A.1| | 1 |
Nearside Front Body insecure and dangerous to other road users |6.1.B.1b| | 1 |
Nearside Front Suspension arm attachment bracket/mounting nut missing |2.4.G.1| | 1 |
Nearside Headlamp not working on main beam |1.7.5a| | 1 |
Offside Headlamp not working on main beam |1.7.5a| | 1 |
Nearside Rear Direction indicator incorrect colour |1.4.A.2f| | 1 |
Offside Rear Direction indicator incorrect colour |1.4.A.2f| | 1 |
Offside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
Offside Front Brake hose excessively damaged |1.1.12 |b| |ii|| | 1 |
Nearside Front Service brake excessively binding |1.2.1 |f|| | 1 |
Offside Front Service brake excessively binding |1.2.1 |f|| | 1 |
Nearside Front Service brake effort inadequate at a wheel |1.2.1 |a| |i|| | 1 |
Offside Front Service brake effort inadequate at a wheel |1.2.1 |a| |i|| | 1 |
Nearside Rear Parking |secondary brake| on a single line braking system has inadequate effort at a wheel |1.3.1 |a| |i|| | 1 |
Offside Rear Parking |secondary brake| on a single line braking system has inadequate effort at a wheel |1.3.1 |a| |i|| | 1 |
Offside Front Fuel hose leaking CARB LEAKING |6.1.3 |b| |i|| | 1 |
Service brake efficiency below requirements |1.2.2 |a| |i|| | 1 |
Parking brake efficiency below requirements |1.4.2 |a| |i|| | 1 |
Rear Stop lamp not working |1.2.1b| | 1 |
Nearside Front Shock absorber has negligible damping effect |2.7.5| | 1 |
Windscreen wiper blade insecure | 1 |
Lower Steering column shaft locking device insecure |2.1.6| | 1 |
Offside Windscreen wiper not operating over a large enough area to give an adequate view |8.2.1c| | 1 |
Centre Intermediate drop arm insecure |2.2.B.1a| | 1 |
Offside Front Lower Suspension arm attachment bracket inappropriately repaired |2.4.A.2| | 1 |
Rear brake application uneven | 1 |
Nearside Front passenger door cannot be opened from outside the vehicle |6.2.B.1b| | 1 |
Offside Rear Track rod end ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
Nearside Front Track rod end ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
Nearside Front Steering rack gaiter split |2.2.D.2d| | 1 |
Offside Rear Drive shaft which forms part of the suspension coupling gaiter insecure to the extent that it no longer prevents the ingress of dirt etc |2.4.G.4e| | 1 |
Exhaust emits excessive dense blue smoke during acceleration |7.3.A.2c| | 1 |
Indicator tell tale inoperative |1.4.A.2a| | 1 |
Nearside Front Upper Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
Offside Front Upper Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
Nearside Rear Road wheel badly distorted change for spare wheel spokes loose |5.2.2 |c| |i|| | 1 |
Boot lid cannot be secured in the closed position adjusted catch |6.2.1 |e|| | 1 |
Nearside Rear position lamp|s| not working |1.1.A.3b| | 1 |
Nearside Front Front position lamp|s| not working |1.1.A.3b| | 1 |
Nearside Rear Vehicle structure has an inadequate repair, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Offside Rear Vehicle structure has an inadequate repair, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Nearside Headlamp excessively damaged so that the light output is severely reduced |1.7.5a| | 1 |
Fuel cap/sealing device sealing washer deteriorated |7.2.4c| | 1 |
Offside Front Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
Offside Front Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
Nearside Front Lower Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
Nearside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
Offside Front Steering system has excessive free play detected at the steering wheel |steering rack fitted| |2.2.A.1b| | 1 |
Nearside Rear Shock absorber has negligible damping effect |2.7.5| | 1 |
Offside Rear Shock absorber has negligible damping effect |2.7.5| | 1 |
Rear Fuel system component insecure |7.2.1| | 1 |
Offside Rear Road wheel spoke cracked |4.2.A.1b| | 1 |
Brake pedal has insufficient reserve movement |3.3.A.5| | 1 |
Nearside Front Brake hose leaking |3.6.A.1| | 1 |
Driver`s door does not latch securely closed |6.2.B.1a| | 1 |
Lower Steering column flexible coupling insecure |2.1.5| | 1 |
Steering column universal joint insecure |2.1.5| | 1 |
Nearside Front Steering lock stop loose |2.2.D.2c| | 1 |
Front suspension locking device ineffective |2.5.A.4| | 1 |
Nearside Front suspension has excessive movement at a wishbone pin or bush |2.5.A.1c| | 1 |
Anti-roll bar linkage insecure |2.4.G.1| | 1 |
Nearside Front Upper Direction indicators not working |1.4.A.2c| | 1 |
Offside Front Upper Direction indicators not working |1.4.A.2c| | 1 |
Nearside Rear Upper Direction indicators not working |1.4.A.2c| | 1 |
Offside Rear Upper Direction indicators not working |1.4.A.2c| | 1 |
Nearside Windscreen wiper not operating automatically when switched on |8.2.1b| | 1 |
Offside Windscreen wiper not operating automatically when switched on |8.2.1b| | 1 |
Nearside Front Lower Seat belt anchorage prescribed area is inadequately repaired |5.2.6| | 1 |
Offside Front Lower Seat belt anchorage prescribed area is inadequately repaired |5.2.6| | 1 |
Brake hose has insufficient room to move | 1 |
Steering column shaft retaining device insecure |2.1.6| | 1 |
Offside Front Upper Suspension arm ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
Fuel pipe insecure at the rear |7.2.1| | 1 |
Nearside Front Driver`s seat insecure |6.2.A.1| | 1 |
Offside Front Driver`s seat insecure |6.2.A.1| | 1 |
Bonnet cannot be secured in the closed position |8.4.1| | 1 |
Nearside Rear Direction indicator not working |1.4.A.2c| | 1 |
Nearside Rear Direction indicator adversely affected by the operation of another lamp |1.4.A.2h| | 1 |
Nearside Rear position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
Nearside Front Driver`s door cannot be opened from inside the vehicle |6.2.B.1b| | 1 |
Offside Upper Front suspension ball joint dust cover missing |2.4.G.2| | 1 |
Brake performance not tested |3.7.A.1| | 1 |
Passenger`s seat insecure |6.2.A.1| | 1 |
Nearside Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Nearside Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings floor |6.1.B.2| | 1 |
Offside Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings floor |6.1.B.2| | 1 |
Nearside Rear Outer Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Offside Rear Inner Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Nearside Front Upper Front suspension locking device ineffective inner |2.5.A.4| | 1 |
Nearside Front Upper Front suspension locking device ineffective outer |2.5.A.4| | 1 |
Offside Front Upper Front suspension locking device ineffective inner |2.5.A.4| | 1 |
Offside Front Upper Front suspension locking device ineffective outer |2.5.A.4| | 1 |
Windscreen wiper control missing |8.2.1a| | 1 |
Nearside Front Upper Suspension arm locating pin retaining device missing |2.4.G.3b| | 1 |
Offside Front Upper Suspension arm locating pin retaining device missing |2.4.G.3b| | 1 |
Nearside Front Lower Suspension arm locating pin retaining device missing |2.4.G.3b| | 1 |
Offside Front Lower Suspension arm locating pin retaining device missing |2.4.G.3b| | 1 |
Suspension arm locating pin locking device not properly locked upper lower suspension locking nuts |2.4.G.3b| | 1 |
Statutory seat belt missing all |5.1.1| | 1 |
Nearside Front Track rod end ball joint dust cover insecure so that it no longer prevents the ingress of dirt |2.1.3 |g| |ii|| | 1 |
Offside Front Track rod end ball joint dust cover insecure so that it no longer prevents the ingress of dirt |2.1.3 |g| |ii|| | 1 |
Parking brake lever has no reserve travel |3.1.6b| | 1 |
Offside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
Electrical wiring inadequately supported under bonnet |1.9.2a| | 1 |
Nearside Track rod end loose lock nut |2.2.B.1d| | 1 |
Offside Track rod end loose lock nut |2.2.B.1d| | 1 |
Nearside Front Wheel insecure |4.2.A.1c| | 1 |
Offside Front Wheel insecure |4.2.A.1c| | 1 |
Nearside Rear Brake pipe inadequately clipped |3.6.B.1| | 1 |
Offside Track rod end ball pin shank loose |2.2.B.1c| | 1 |
Offside Front Front wheel bearing has excessive play |2.5.A.3c| | 1 |
Steering column locking device insecure |2.1.6| | 1 |
Headlamp not working on dipped beam Both |1.7.5a| | 1 |
Headlamp not working on main beam Both |1.7.5a| | 1 |
Horn not working (7.7 (a) (ii)) | 1 |
Electrical wiring insecure and connectors likely to become disconnected under bonnet (4.11 (a) (ii)) | 1 |
Battery insecure and likely to fall from carrier (4.13 (a) (ii)) | 1 |
Exhaust emissions carbon monoxide content excessive (8.2.1.2 (b)) | 1 |
Brake lever has restricted free movement (1.1.15 (e)) | 1 |
Brake rod insecure under bonnet brake pedal lever (1.1.15 (c)) | 1 |
Passengers seat insecure (6.2.6 (a) (ii)) | 1 |
Nearside Front Suspension arm insecurely attached kingpin nut lock pin missing (5.3.3 (a) (i)) | 1 |
Offside Front Suspension arm insecurely attached kingpin nut lock pin missing (5.3.3 (a) (i)) | 1 |
Nearside Front Upper Suspension arm insecurely attached securing nut lock pin missing (5.3.3 (a) (i)) | 1 |
Offside Front Upper Suspension arm insecurely attached securing nut lock pin missing (5.3.3 (a) (i)) | 1 |
Fuel pipe insecure along chassis (6.1.3 (a) (i)) | 1 |
Offside Front Road wheel fixing loose (5.2.1 (a) (i)) | 1 |
Nearside Front Road wheel fixing loose (5.2.1 (a) (i)) | 1 |
Front Service brake excessively binding (1.2.1 (f)) | 1 |
All direction indicators not working (4.4.1 (a) (ii)) | 1 |
Service brake efficiency less than 50% of the required value (1.2.2 (a) (ii)) | 1 |
Steering wheel has movement relative to the column indicating looseness (2.2.1 (a) (i)) | 1 |
Brake pedal pivot has excessive wear or free play and bolt is loose. Nut is missing (1.1.1 (b)) | 1 |
Boot lid component insecure nearside hinge (6.2.1 (a) (i)) | 1 |
Nearside Front Upper Suspension arm pin or bush excessively worn rearmost (5.3.4 (a) (i)) | 1 |
Parking (secondary brake) on a single line braking system imbalanced across an axle Axle 1 (1.3.1 (b) (i)) | 1 |
Brake pedal has insufficient reserve travel (1.1.2 (a)) | 1 |
Bonnet cannot be secured in the closed position (3.1 (b) (i)) | 1 |
Rear Fuel system component leaking carburetor (6.1.3 (b) (i)) | 1 |
Front Oil leaking continuously from engine posing a serious risk to road safety (8.4.1 (a) (ii)) | 1 |
Nearside Front Position lamp not working (4.2.1 (a) (ii)) | 1 |
Rear Stop lamp(s) adversely affected by the operation of another lamp (4.3.3 (b)) | 1 |
Rear Stop lamp(s) light intensity significantly reduced both (4.3.3 (a) (ii)) | 1 |
Nearside Rear Fuel hose leaking (6.1.3 (b) (i)) | 1 |
Nearside Front Wheel bearing has excessive play (5.1.3 (a) (i)) | 1 |
Offside Front Lower Shock absorbers has an excessively worn bush (5.3.2 (c)) | 1 |
Nearside Front Shock absorbers insecurely attached (5.3.2 (a) (i)) | 1 |
Nearside Front Lower Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 1 |
Offside Rear Suspension arm insecurely attached (5.3.3 (a) (i)) | 1 |
Offside Rear Service brake effort inadequate at a wheel (1.2.1 (a) (i)) | 1 |
Rear Fuel hose leaking (6.1.3 (b) (i)) | 1 |
Nearside Service brake excessively binding (1.2.1 (f)) | 1 |
Service brake efficiency below requirements (1.2.2 (a) (i)) | 1 |
Offside Front Wheel bearing has excessive play (5.1.3 (a) (i)) | 1 |
Offside Front Seat belt anchorage prescribed area strength or continuity significantly reduced (7.1.1 (a) (i)) | 1 |
Windscreen washer not working | 1 |
Nearside Rear Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 1 |
Offside Rear Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 1 |
Rear Stop lamp(s) all not working (4.3.1 (a) (iii)) | 1 |
Horn not working (7.7 (a)) | 1 |
Offside Front Upper Suspension arm ball joint dust cover missing (5.3.4 (b) (ii)) | 1 |
Steering column has excessive movement up and down (2.2.2 (a)) | 1 |