| Most common failures | No# failures |
|---|
| Headlamp aim out of alignment | 24 |
| Brakes imbalanced across an axle | 17 |
| Parking brake: efficiency below requirements |3.7.B.7| | 13 |
| Rear brake binding | 13 |
| Nearside Stop lamp not working |1.2.1b| | 11 |
| Offside Rear Stop lamp not working |1.2.1b| | 7 |
| Horn not working |1.6.2a| | 7 |
| Offside Stop lamp not working |1.2.1b| | 6 |
| Rear parking brake recording little or no effort | 6 |
| Windscreen wiper does not clear the windscreen effectively | 5 |
| Brake hose damaged | 5 |
| Rear brake application uneven | 5 |
| Nearside Rear Stop lamp not working |1.2.1b| | 5 |
| Offside Front wheel bearing has excessive play |2.5.A.3c| | 4 |
| Windscreen wiper not operating automatically when switched on |8.2.1b| | 4 |
| Parking brake lever has no reserve travel |3.1.6b| | 4 |
| Nearside Rear Wheel insecure |4.2.A.1c| | 4 |
| Offside rear brake recording little or no effort |3.7.B.5a| | 3 |
| Nearside Front Front wheel bearing has excessive play |2.5.A.3c| | 3 |
| Steering box has relative movement between sector shaft and the drop arm |2.2.B.1b| | 3 |
| Nearside Front Wheel insecure |4.2.A.1c| | 3 |
| Nearside Front wheel bearing has excessive play |2.5.A.3c| | 3 |
| Nearside Headlamp not working on dipped beam |1.7.5a| | 3 |
| Steering system excessively tight |2.2.D.1| | 3 |
| Fuel system component leaking |7.2.3| | 3 |
| Stop lamp not working |1.2.1b| | 3 |
| Parking brake: efficiency below requirements |3.7.C.1b| | 3 |
| Offside Front Front wheel bearing has excessive play |2.5.A.3c| | 3 |
| Service brake: efficiency below requirements |3.7.B.7| | 3 |
| Offside Front Wheel insecure |4.2.A.1c| | 3 |
| Offside Front Direction indicator not working |1.4.A.2c| | 2 |
| Exhaust has a major leak of exhaust gases |7.1.2| | 2 |
| Centre Exhaust has a major leak of exhaust gases |7.1.2| | 2 |
| Direction indicators not working |1.4.A.2c| | 2 |
| Nearside Rear position lamp|s| not working |1.1.A.3b| | 2 |
| Offside Rear position lamp|s| not working |1.1.A.3b| | 2 |
| Headlamp not working on dipped beam |1.7.5a| | 2 |
| Steering column movement between the shaft and steering wheel |2.1.2b| | 2 |
| Nearside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 2 |
| Fuel tank leaking |7.2.3| | 2 |
| Steering wheel retaining device insecure |2.1.6| | 2 |
| Offside Front front brake binding |3.7.B.1| | 2 |
| Nearside Rear rear brake recording little or no effort |3.7.B.5a| | 2 |
| Nearside Steering rack gaiter split |2.2.D.2d| | 2 |
| Steering system has excessive free play detected at the steering wheel |steering box fitted| |2.2.A.1a| | 2 |
| Nearside Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 2 |
| Offside Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 2 |
| Service brake: efficiency below requirements |3.7.C.1a| | 2 |
| Offside Front Direction indicators not working |1.4.A.2c| | 2 |
| Brake performance not tested |3.7.A.1| | 2 |
| Nearside Rear Braking system leaking |3.6.A.1| | 2 |
| Offside Headlamp not working on dipped beam |1.7.5a| | 2 |
| Nearside Headlamp not working on main beam |1.7.5a| | 2 |
| Offside Front Upper Suspension arm ball joint dust cover insecure so that it no longer prevents the ingress of dirt |2.4.G.2| | 2 |
| Offside Track rod end loose |2.2.B.1d| | 2 |
| Steering column universal joint has excessive play |2.1.5| | 2 |
| Parking brake lever ratchet mechanism is broken |3.1.5| | 2 |
| Offside front brake binding |3.7.B.1| | 2 |
| Registration plate lamp issues | 2 |
| Rear Exhaust system not adequately supported |7.1.1| | 2 |
| Registration plate issues | 2 |
| Windscreen washer not working | 2 |
| Offside Front Upper Suspension component ball joint excessively worn (5.3.4 (a) (i)) | 2 |
| Parking brake efficiency less than 50% of the required value (1.4.2 (a) (ii)) | 2 |
| Horn not working |7.7 |a| |ii|| | 1 |
| Nearside Steering rack gaiter insecure |2.2.D.2d| | 1 |
| Offside Steering rack gaiter insecure |2.2.D.2d| | 1 |
| Battery insecure |1.9.1| | 1 |
| Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Leaf spring saddle is moving relative to the spring |2.4.B.7a| | 1 |
| Offside Leaf spring saddle is moving relative to the spring |2.4.B.7a| | 1 |
| Nearside Rear Leaf spring anchor bracket corroded and seriously weakened |2.4.B.6d| | 1 |
| Brake hose excessively deteriorated | 1 |
| Windscreen has damage | 1 |
| Fuel cap/sealing device sealing washer deteriorated |7.2.4c| | 1 |
| Nearside Front Upper Suspension arm ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Offside Front Upper Suspension arm ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Nearside Rear brake drum insecure |3.5.1i| | 1 |
| Offside Rear brake drum insecure |3.5.1i| | 1 |
| Offside Front Front position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Front Headlamp not working on main beam |1.7.5a| | 1 |
| Headlamp not working on main beam |1.7.5a| | 1 |
| Brake hose has insufficient room to move | 1 |
| Nearside Front Lower Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Lower Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Front Anti-roll bar fractured |2.4.G.1| | 1 |
| Nearside Windscreen wiper blade deteriorated |8.2.2| | 1 |
| Offside Windscreen wiper blade deteriorated |8.2.2| | 1 |
| Nearside Front Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 1 |
| Suspension arm attachment bracket/mounting insecure |2.4.G.1| | 1 |
| Exhaust emits clearly visible black smoke during acceleration |7.3.A.2c| | 1 |
| Fuel pipe leaking @ REAR JOINT ON PIPE |7.2.3| | 1 |
| Suspension component mounting prescribed area is excessively corroded N/S/R CHASSIS CRACKED |2.4.A.3| | 1 |
| Nearside Front Front wheel bearing rough when rotated |2.5.A.2| | 1 |
| Nearside Rear Leaf spring anchor pin retaining device insecurely fitted |2.4.B.3b| | 1 |
| Offside Front Track rod end ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Nearside Front wheel bearing rough when rotated |2.5.A.2| | 1 |
| Brake pedal functionally incomplete |3.3.A.1a| | 1 |
| Offside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
| Offside Front brake disc contaminated by grease |3.5.1h| | 1 |
| Offside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Wheel insecure |4.2.A.1c| | 1 |
| Offside Front Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
| Offside Rear Direction indicator not working |1.4.A.2c| | 1 |
| Offside Front Anti-roll bar linkage insecure |2.4.G.1| | 1 |
| Nearside Front Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Front Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Nearside Windscreen wiper not working |3.4 |a|| | 1 |
| Offside Windscreen wiper not working |3.4 |a|| | 1 |
| Brake pipe inadequately clipped |3.6.B.1| | 1 |
| Offside Front Headlamp not working on dipped beam |1.7.5a| | 1 |
| Steering pivot point has excessive play |2.2.B.1g| | 1 |
| Steering system has excessive free play detected at the steering wheel |steering rack fitted| |2.2.A.1b| | 1 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Rear brake drum contaminated by oil |3.5.1h| | 1 |
| Nearside Rear Stop lamp adversely affected by the operation of another lamp |1.2.1f| | 1 |
| Offside Headlamp insecure |1.7.3| | 1 |
| Indicator tell tale inoperative |1.4.A.2a| | 1 |
| Parking brake lever pawl spring does not push the pawl positively into the ratchet teeth |3.1.5| | 1 |
| Nearside Drag link end ball pin shank loose |2.2.B.1c| | 1 |
| Nearside Rear Leaf spring fractured |2.4.B.1a| | 1 |
| Braking system leaking |3.6.A.1| | 1 |
| Indicator switch insecure |1.4.A.1| | 1 |
| Nearside Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Front Steering rack gaiter missing or no longer prevents the ingress of dirt |2.1.3 |g| |ii|| | 1 |
| Offside Front Steering rack gaiter missing or no longer prevents the ingress of dirt |2.1.3 |g| |ii|| | 1 |
| Steering column shaft has excessive end float |2.1.3| | 1 |
| Nearside Front front brake binding |3.7.B.1| | 1 |
| Nearside Rear Shock absorber insecure |2.7.2b| | 1 |
| Offside Rear Shock absorber insecure |2.7.2b| | 1 |
| Nearside Front Steering arm has relative movement at its fixings |2.2.B.1h| | 1 |
| Offside Front Steering arm has relative movement at its fixings |2.2.B.1h| | 1 |
| Nearside Front Steering rack insecure |2.2.B.1a| | 1 |
| Offside Front Steering rack insecure |2.2.B.1a| | 1 |
| Offside Rear Brake cable locking device insecure |3.5.1l| | 1 |
| Offside Front Upper Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Front Upper Suspension arm attachment bracket/mounting insecure |2.4.G.1| | 1 |
| Stop lamp excessively damaged so that it is not visible from a reasonable distance |1.2.1d| | 1 |
| Offside Front suspension has excessive play in a upper suspension ball joint |2.5.B.1a| | 1 |
| Offside rear brake grabbing severely |3.7.A.5b| | 1 |
| Offside Rear Vehicle structure has an inadequate repair, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Front Brake hose stretched |found during steering lock to lock check| |2.2.D.2b| | 1 |
| Offside Indicator tell tale inoperative |1.4.A.2a| | 1 |
| Offside Direction indicator flashing more than 120 times a minute |1.4.A.2g| | 1 |
| Indicator switch faulty |1.4.A.1| | 1 |
| Nearside Intermediate drop arm pivot housing casing has relative movement to chassis/bodywork |2.1.2 |a| |ii|| | 1 |
| Offside Front Road wheel fixing loose |5.2.1 |a| |i|| | 1 |
| Nearside Front Upper Suspension component ball joint likely to become detached |5.3.4 |a| |ii|| | 1 |
| Offside Front coil spring broken |2.4.C.1a| | 1 |
| Offside Rear position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
| Nearside Front Upper Suspension arm ball joint dust cover insecure so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Driver`s seat insecure |6.2.A.1| | 1 |
| Brake pipe excessively corroded | 1 |
| Offside Steering rack gaiter split |2.2.D.2d| | 1 |
| Offside Front Upper Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Front Front suspension has excessive play in a upper suspension ball joint |2.5.B.1a| | 1 |
| Nearside Rear Direction indicator not working |1.4.A.2c| | 1 |
| Offside Headlamp not working on main beam |1.7.5a| | 1 |
| Nearside Rear Rear wheel bearing rough when rotated |2.6.1| | 1 |
| Front Braking system leaking |3.6.A.1| | 1 |
| Nearside Front Anti-roll bar attachment bracket/mounting fractured |2.4.G.1| | 1 |
| Offside Front Anti-roll bar attachment bracket/mounting fractured |2.4.G.1| | 1 |
| Nearside Headlamp insecure |1.7.3| | 1 |
| Steering wheel retaining device missing |2.1.6| | 1 |
| Nearside Rear wheel cylinder has restricted free movement |3.5.1k| | 1 |
| Brake pedal anti-slip provision missing |3.3.A.1b| | 1 |
| Nearside Front All position lamps not working |1.1.A.3b| | 1 |
| Nearside Rear Leaf spring to axle securing nut insecure |2.4.B.7b| | 1 |
| Offside Rear Leaf spring to axle securing nut insecure |2.4.B.7b| | 1 |
| Fuel cap/sealing device sealing washer missing |7.2.4c| | 1 |
| Nearside Steering pivot point has excessive play |2.2.B.1g| | 1 |
| Nearside Front suspension has excessive play in a upper suspension ball joint |2.5.B.1a| | 1 |
| front brake binding |3.7.B.1| | 1 |
| Direction indicators flashing less than 60 times a minute |1.4.A.2g| | 1 |
| Steering wheel locking device insecure |2.1.6| | 1 |
| Nearside front brake binding |3.7.B.1| | 1 |
| Nearside Front Upper Suspension arm attachment bracket/mounting insecure |2.4.G.1| | 1 |
| Offside Front Wheel nut|s| loose |4.2.A.1e| | 1 |
| Offside Rear Wheel nut|s| loose |4.2.A.1e| | 1 |
| Nearside Front Steering rack gaiter split |2.2.D.2d| | 1 |
| Offside Front Steering rack gaiter split |2.2.D.2d| | 1 |
| Offside Front Ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Nearside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Front Seat belt anchorage prescribed area is fractured |5.2.6| | 1 |
| Offside Body or chassis is cracked, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Body or chassis is cracked, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Front Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Offside Front Upper Front suspension locking device missing |2.5.A.4| | 1 |
| Nearside rear brake recording little or no effort |3.7.B.5a| | 1 |
| Offside Front Brake hose twisted |found during steering lock to lock check| |2.2.D.2b| | 1 |
| Nearside Front Lower Suspension arm has excessive play in a pin/bearing |2.4.G.2| | 1 |
| Nearside Front Suspension arm has excessive play in a pin/bearing |2.4.G.2| | 1 |
| Parking brake lever releases when knocked |3.1.6a| | 1 |
| Nearside Front Suspension arm locating pin locking device not properly locked |2.4.G.3b| | 1 |
| Offside Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Headlamp aim beam image obviously incorrect tested on main beam |1.8.A.1b| | 1 |
| Nearside Steering system has excessive free play detected at the steering wheel |steering box fitted| steering idler arm |2.2.A.1a| | 1 |
| Nearside Track rod end loose |2.2.B.1d| | 1 |
| Nearside Wheel insecure |4.2.A.1c| | 1 |
| Fuel pipe union leaking |7.2.3| | 1 |
| Windscreen washer control missing |8.2.1a| | 1 |
| Nearside Front Front suspension locking device missing upper ball joint split pin missing |2.5.A.4| | 1 |
| Offside Front Front suspension locking device missing upper ball joint split pin missing |2.5.A.4| | 1 |
| Rear Brake hose leaking |3.6.A.1| | 1 |
| Headlamp not working on dipped beam o/s n/s |1.7.5a| | 1 |
| Headlamp not working on main beam o/s n/s |1.7.5a| | 1 |
| Offside Front Brake hose leaking on a hydraulic braking system caliper |1.1.12 |c| |ii|| | 1 |
| Nearside Front Steering locking device ineffective track rod end |2.1.3 |d|| | 1 |
| Offside Steering locking device ineffective track rod end |2.1.3 |d|| | 1 |
| Offside Front Suspension arm mounting modified so the suspension is likely to fail other components brake flexi rubbing on wishbone |5.3.3 |c| |ii|| | 1 |
| Nearside Front Lower Suspension arm attachment bracket/mounting insecure arm split pins missing |5.3.3 |a| |i|| | 1 |
| Nearside Rear Leaf spring to axle fixing bolt insecure split pin missing |5.3.1 |a| |i|| | 1 |
| Offside Rear Leaf spring to axle fixing bolt insecure split missing |5.3.1 |a| |i|| | 1 |
| Nearside Rear Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
| Nearside Steering rack gaiter missing or no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |
| Nearside Stop lamp not working (1.2.1b) | 1 |
| Offside Stop lamp not working (1.2.1b) | 1 |
| Brake linkage has abnormal movement of levers indicating excessive wear (3.5.1f) | 1 |
| Steering box insecure (2.2.B.1a) | 1 |
| Offside Rear wheel bearing has excessive play (2.6.2) | 1 |
| Nearside Inner Drag link end ball joint has excessive play (2.1.3 (b) (i)) | 1 |
| Nearside Rear Position lamp adversely affected by the operation of another lamp (4.2.3 (c)) | 1 |
| Nearside Stop lamp(s) adversely affected by the operation of another lamp (4.3.3 (b)) | 1 |
| Parking (secondary brake) on a single line braking system imbalanced across an axle Axle 1 (1.3.1 (b) (i)) | 1 |
| Offside Front Service brake excessively binding (1.2.1 (f)) | 1 |
| Steering wheel has movement relative to the column indicating looseness (2.2.1 (a) (i)) | 1 |
| Rear Stop lamp(s) all not working (4.3.1 (a) (iii)) | 1 |
| All direction indicators not working (4.4.1 (a) (ii)) | 1 |
| Front Service brake excessively fluctuating (1.2.1 (e)) | 1 |
| Front Windscreen wiper not working both (3.4 (a)) | 1 |
| Nearside Front Windscreen wiper not working wiper arm insecure (3.4 (a)) | 1 |
| Headlamp aim projected beam image is obviously incorrect both (4.1.2 (c)) | 1 |
| Brake pedal anti-slip provision missing (1.1.2 (c)) | 1 |
| Parking brake lever is not capable of being maintained in operation by direct mechanical action only lever ratchet defective (1.1.6 (f)) | 1 |
| Offside Front Track rod end ball joint dust cover excessively damaged or deteriorated so that it no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |
| Exhaust has a major leak of exhaust gases silencer has a hole (6.1.2 (a)) | 1 |
| Horn not working (7.7 (a) (ii)) | 1 |
| Nearside Rear Hydraulic fluid leaking excessively wheel cylinder leaking from brake drum (8.4.1 (a) (i)) | 1 |
| Nearside Windscreen washer jets misaligned and not providing sufficient fluid to the windscreen (3.5 (a)) | 1 |
| Offside Front Headlamp light intensity severely reduced (4.1.4 (a)) | 1 |
| Windscreen washer jets misaligned and not providing sufficient fluid to the windscreen (3.5 (a)) | 1 |
| Steering box has excessive free play detected at the steering wheel (steering box fitted) (2.3 (a) (i)) | 1 |
| Service brake efficiency less than 50% of the required value (1.2.2 (a) (ii)) | 1 |
| Nearside Front Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 1 |
| Offside Front Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 1 |
| Nearside Front Headlamp not working on main beam (4.1.1 (a) (ii)) | 1 |
| Offside Front Headlamp not working on main beam (4.1.1 (a) (ii)) | 1 |
| Nearside Front Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Front Windscreen wiper missing (3.4 (a)) | 1 |
| Nearside Front Direction indicator not working (4.4.1 (a) (ii)) | 1 |
| Offside Rear Direction indicator not working (4.4.1 (a) (ii)) | 1 |
| Offside Rear Hydraulic brake cylinder leaking and braking performance affected (1.1.16 (b) (ii)) | 1 |
| Nearside Front Wheel bearing has excessive play (5.1.3 (a) (i)) | 1 |
| Parking brake efficiency below requirements (1.4.2 (a) (i)) | 1 |