| Most common failures | No# failures |
|---|
| Exhaust emissions carbon monoxide content excessive |7.3.B.1a| | 17 |
| Parking brake: efficiency below requirements |3.7.B.7| | 10 |
| Headlamp aim out of alignment | 9 |
| Registration plate lamp issues | 9 |
| Brakes imbalanced across an axle | 8 |
| Windscreen wiper does not clear the windscreen effectively | 6 |
| Centre Exhaust has a major leak of exhaust gases |7.1.2| | 4 |
| Rear parking brake recording little or no effort | 4 |
| Service brake: efficiency below requirements |3.7.B.7| | 4 |
| Offside Headlamp not working on dipped beam |1.7.5a| | 3 |
| Offside Track rod end ball joint has excessive play |2.2.B.1f| | 3 |
| Nearside Front Subframe mounting prescribed area is excessively corroded |2.4.A.3| | 3 |
| Rear brake binding | 3 |
| Offside Stop lamp not working |1.2.1b| | 3 |
| Parking brake: efficiency below requirements |3.7.C.1b| | 3 |
| Exhaust emissions hydrocarbon content excessive |7.3.B.1b| | 3 |
| Exhaust emissions carbon monoxide content excessive (8.2.1.2 (b)) | 3 |
| Nearside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
| Exhaust system not adequately supported |7.1.1| | 2 |
| Horn not working |1.6.2a| | 2 |
| Nearside Front Shock absorber has a serious fluid leak |2.7.3| | 2 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 2 |
| Offside Front Track rod end ball joint has excessive play |2.2.B.1f| | 2 |
| Steering system excessively tight |2.2.D.1| | 2 |
| Exhaust has a major leak of exhaust gases |7.1.2| | 2 |
| Steering rack insecure |2.2.B.1a| | 2 |
| Steering column movement between the shaft and steering wheel |2.1.2b| | 2 |
| Steering system has excessive free play detected at the steering wheel |steering rack fitted| |2.2.A.1b| | 2 |
| Nearside Stop lamp not working |1.2.1b| | 2 |
| Brake pipe excessively corroded | 2 |
| Steering pivot point has excessive play |2.2.B.1g| | 2 |
| Nearside Front Lower Suspension arm ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 2 |
| Nearside Front wheel bearing has excessive play |2.5.A.3c| | 2 |
| Steering system excessively rough |2.2.D.1| | 2 |
| Offside Headlamp not in good working order adversely affecting beam image |1.2.4a| | 2 |
| Nearside Side repeater not working |1.4.A.2c| | 2 |
| Offside Front Subframe mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Brake pedal has insufficient reserve movement |3.3.A.5| | 1 |
| front brake binding |3.7.B.1| | 1 |
| Fuel cap/sealing device does not fasten securely maintaining the sealing arrangement |7.2.4b| | 1 |
| Windscreen wiper blade insecure | 1 |
| Offside Front Front position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Front Upper Subframe mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Nearside Front Sub-frame attachment bracket/mounting corroded and its strength is seriously reduced |2.4.G.1| | 1 |
| Centre Steering column top mounting bracket insecure |2.1.2d| | 1 |
| Centre Steering rack insecure |2.2.B.1a| | 1 |
| Nearside Front Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
| Nearside Front Ball joint has excessive play |2.2.B.1f| | 1 |
| Offside Front Shock absorber has a serious fluid leak |2.7.3| | 1 |
| Nearside Rear Rear wheel bearing rough when rotated |2.6.1| | 1 |
| Nearside Front Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Nearside Front Inner Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Front Inner Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside rear brake recording little or no effort |3.7.B.5a| | 1 |
| Nearside Front Front suspension has excessive play in a upper suspension ball joint |2.5.B.1a| | 1 |
| Offside Front Front suspension has excessive play in a upper suspension ball joint |2.5.B.1a| | 1 |
| Nearside Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Steering column universal joint has excessive play |2.1.5| | 1 |
| Nearside Rear Exhaust system not adequately supported |7.1.1| | 1 |
| Offside Front Obligatory mirror seriously damaged, affecting the rear view |8.1.2a| | 1 |
| Nearside Front Front suspension has excessive play in an outer ball joint |2.5.B.2a| | 1 |
| Offside Front Front suspension has excessive play in an outer ball joint |2.5.B.2a| | 1 |
| Nearside Track rod end ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Inner Track rod end ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Rear Exhaust system not adequately supported |7.1.1| | 1 |
| Nearside Vehicle structure has an unsatisfactory modification, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Vehicle structure has excessive corrosion which adversely affects braking or steering |6.1.A.1| | 1 |
| Rear brake application uneven | 1 |
| Fuel cap/sealing device missing |7.2.4a| | 1 |
| Centre Rear Fuel hose leaking |7.2.3| | 1 |
| Nearside Front Suspension component mounting prescribed area is inadequately repaired |2.4.A.3| | 1 |
| Offside Front Suspension component mounting prescribed area is inadequately repaired |2.4.A.3| | 1 |
| Offside Rear Suspension component mounting prescribed area is inadequately repaired |2.4.A.3| | 1 |
| Nearside Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced |6.1.1 |c| |i|| | 1 |
| Nearside Seat belt anchorage prescribed area strength or continuity significantly reduced |7.1.1 |a| |i|| | 1 |
| Nearside Front Subframe mounting prescribed area excessively corroded significantly reducing structural strength |5.3.6 |a| |i|| | 1 |
| Exhaust emissions carbon monoxide content excessive |8.2.1.2 |b|| | 1 |
| Service brake is causing the vehicle to swerve to the nearside |1.2.1 |b| |i|| | 1 |
| Offside Front Lower Front suspension ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Offside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Rear Body has a sharp edge caused by corrosion |6.1.C.1| | 1 |
| Parking brake lever defective so that it cannot be satisfactorily operated |3.1.3c| | 1 |
| Nearside Front Headlamp not working on dipped beam |1.7.5a| | 1 |
| Offside Front Headlamp not working on dipped beam |1.7.5a| | 1 |
| Nearside Front Direction indicators not working |1.4.A.2c| | 1 |
| Nearside Front Direction indicators flashing less than 60 times a minute |1.4.A.2g| | 1 |
| Nearside Front Hazard warning lamps not flashing in phase, with ignition on |1.4.B.1f| | 1 |
| Nearside Front Hazard warning lamps not flashing in phase, with ignition off |1.4.B.1f| | 1 |
| Offside Steering rack gaiter split |2.2.D.2d| | 1 |
| Offside Front Sub-frame attachment bracket/mounting corroded and its strength is seriously reduced |2.4.G.1| | 1 |
| Nearside Front Lower Suspension arm rubber mounting deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Front Lower Suspension arm rubber mounting deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Rear rear brake grabbing severely |3.7.A.5b| | 1 |
| Offside Front Brake pipe leaking |3.6.A.1| | 1 |
| Brake performance not tested |3.7.A.1| | 1 |
| Service brake: efficiency below requirements |3.7.C.1a| | 1 |
| Nearside Headlamp not working on dipped beam |1.7.5a| | 1 |
| Nearside Front passenger door cannot be opened from inside the vehicle |6.2.B.1b| | 1 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Inner Ball joint has excessive play |2.2.B.1f| | 1 |
| Nearside Front Track rod end excessively corroded and unserviceable |2.2.C.1d| | 1 |
| Nearside Inner Front Suspension arm rubber mounting deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Inner Front Suspension arm rubber mounting deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Nearside Front Lower Ball joint excessively corroded and unserviceable |2.2.C.1d| | 1 |
| Offside Front Lower Ball joint excessively corroded and unserviceable |2.2.C.1d| | 1 |
| Nearside Front Upper Suspension arm ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Offside Front Upper Suspension arm ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Offside Front Lower Suspension arm ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Offside Inner Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Front Steering system has excessive free play detected at the steering wheel |steering rack fitted| |2.2.A.1b| | 1 |
| Nearside Front position lamp|s| incorrect colour |1.1.A.3e| | 1 |
| Offside Front position lamp|s| incorrect colour |1.1.A.3e| | 1 |
| Offside Inner Steering system has excessive free play detected at the steering wheel |steering rack fitted| |2.2.A.1b| | 1 |
| Nearside Front Upper Suspension arm ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Nearside Front Lower Suspension arm ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Offside Front Upper Suspension arm ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Offside Front Lower Suspension arm ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Nearside Outer Front Upper Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Offside Outer Front Upper Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Stop lamp not working |1.2.1b| | 1 |
| Offside Track rod end ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Offside Front Front wheel bearing has excessive play |2.5.A.3c| | 1 |
| Steering column universal joint insecure |2.1.5| | 1 |
| Front suspension has excessive play in a upper suspension ball joint |2.5.B.1a| | 1 |
| Offside Headlamp not working on main beam |1.7.5a| | 1 |
| Lower Steering column flexible coupling has excessive play |2.1.5| | 1 |
| Offside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Nearside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Front Track rod end ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Nearside Front Upper Front suspension ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Offside Front front brake binding |3.7.B.1| | 1 |
| Nearside Rear Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Horn not a continuous or uniform sound |1.6.2e| | 1 |
| Nearside Front Lower Subframe mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Front Direction indicators not working |1.4.A.2c| | 1 |
| Offside Front Front position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
| Nearside Rear position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
| Nearside Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
| Nearside Headlamp not working on main beam |1.7.5a| | 1 |
| Nearside Rear wheel cylinder leaking |3.6.A.1| | 1 |
| Nearside Front Upper Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Nearside front brake binding |3.7.B.1| | 1 |
| Offside front brake binding |3.7.B.1| | 1 |
| Direction indicators not working |1.4.A.2c| | 1 |
| Nearside Rear wheel bearing rough when rotated |2.6.1| | 1 |
| Nearside Front Direction indicator not working |1.4.A.2c| | 1 |
| Nearside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Centre Exhaust system not adequately supported |7.1.1| | 1 |
| Offside Front wheel bearing has excessive play |2.5.A.3c| | 1 |
| Nearside Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Nearside Headlamp excessively damaged so that the light output is severely reduced |1.7.5a| | 1 |
| Direction indicators flashing less than 60 times a minute |1.4.A.2g| | 1 |
| Steering column top mounting bracket insecure |2.1.2d| | 1 |
| Steering column universal joint is excessively deteriorated |2.1.5| | 1 |
| Nearside Front Seat belt locking mechanism does not secure or release |5.2.5a| | 1 |
| Driver`s door cannot be opened from outside the vehicle |6.2.B.1b| | 1 |
| Nearside Front Lower Suspension arm ball joint dust cover missing |2.4.G.2| | 1 |
| Offside Front Lower Suspension arm ball joint dust cover missing |2.4.G.2| | 1 |
| Offside Front Upper Suspension arm ball joint dust cover missing |2.4.G.2| | 1 |
| Nearside Track rod end ball joint dust cover missing |2.2.C.1c| | 1 |
| Offside Track rod end ball joint dust cover missing |2.2.C.1c| | 1 |
| Offside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Nearside Suspension component mounting prescribed area is excessively corroded chassis gearbox area |2.4.A.3| | 1 |
| Nearside Front Track rod end ball joint dust cover excessively damaged or deteriorated so that it no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |
| Offside Front Track rod end ball joint dust cover excessively damaged or deteriorated so that it no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |
| Brake hose excessively deteriorated | 1 |
| All direction indicators not working not flashing (4.4.1 (a) (ii)) | 1 |