| Most common failures | No# failures |
|---|
| Headlamp aim out of alignment | 12 |
| Registration plate lamp issues | 8 |
| Windscreen washer not working | 4 |
| Windscreen wiper does not clear the windscreen effectively | 4 |
| Offside Rear Service brake excessively binding (1.2.1 (f)) | 3 |
| Brakes imbalanced across an axle | 3 |
| Parking brake: efficiency below requirements |3.7.B.7| | 3 |
| Nearside Rear Direction indicator not working |1.4.A.2c| | 2 |
| Registration plate issues | 2 |
| Offside Rear Direction indicator not working (4.4.1 (a) (ii)) | 2 |
| Offside Rear Position lamp not working (4.2.1 (a) (ii)) | 2 |
| Horn not working |1.6.2a| | 2 |
| Nearside Stop lamp(s) not working (4.3.1 (a) (ii)) | 2 |
| Nearside Front Service brake excessively binding (1.2.1 (f)) | 2 |
| Nearside Rear Service brake excessively binding (1.2.1 (f)) | 2 |
| Parking brake efficiency below requirements (1.4.2 (a) (i)) | 2 |
| Horn not working (7.7 (a)) | 2 |
| Service brake efficiency below requirements (1.2.2 (a) (i)) | 2 |
| Front passenger door cannot be opened from outside the vehicle |6.2.B.1b| | 1 |
| Offside Front Wheel nut|s| missing |4.2.A.1e| | 1 |
| Service brake: efficiency below requirements |3.7.B.7| | 1 |
| Nearside Rear Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Direction indicators flashing less than 60 times a minute not flashing at all |1.4.A.2g| | 1 |
| Nearside Rear Subframe mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Rear Subframe mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Nearside Front Tie bar/rod cracked |2.4.G.1| | 1 |
| Nearside Front Lower Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Nearside Direction indicator not working (4.4.1 (a) (ii)) | 1 |
| Position lamp switch does not operate in accordance with the requirements (4.2.2 (a)) | 1 |
| Brake master cylinder defective but brake still operating creep on brake pedal (1.1.10 (b) (i)) | 1 |
| Headlamp aim projected beam image is obviously incorrect main beam on @ dip position,wired incorrect? (4.1.2 (c)) | 1 |
| Offside Front Lower Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Brake pedal has insufficient reserve travel (1.1.2 (a)) | 1 |
| Offside Front Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
| Drivers seat backrest cannot be secured in the upright position. (6.2.5 (b) (ii)) | 1 |
| Stop lamp(s) all not working (4.3.1 (a) (iii)) | 1 |
| Nearside Front Anti-roll bar linkage insecurely attached (5.3.3 (a) (i)) | 1 |
| Nearside Front Lower Suspension arm pin or bush excessively worn front (5.3.4 (a) (i)) | 1 |
| Offside Front Lower Suspension arm pin or bush excessively worn front (5.3.4 (a) (i)) | 1 |
| Offside Front Lower Suspension arm pin or bush excessively worn rear (5.3.4 (a) (i)) | 1 |
| Nearside Headlamp not working on main beam |1.7.5a| | 1 |
| Power steering component leaking |2.1.5 |a|| | 1 |
| Nearside Front Wheel bearing rough when rotated |5.1.3 |b| |i|| | 1 |
| Offside Front Wheel bearing rough when rotated |5.1.3 |b| |i|| | 1 |
| Front Integral body structure is deformed and structural rigidity is significantly reduced both side floor pan inadequately repaired |6.1.1 |a| |i|| | 1 |
| Rear Integral body structure is deformed and structural rigidity is significantly reduced both side floor pan inadequately repaired |6.1.1 |a| |i|| | 1 |
| Nearside Front Lower Suspension arm pin or bush excessively worn control arm |5.3.4 |a| |i|| | 1 |
| Offside Front Lower Suspension arm pin or bush excessively worn control arm |5.3.4 |a| |i|| | 1 |
| Steering rack has excessive free play detected at the steering wheel |steering rack fitted| |2.3 |a| |i|| | 1 |
| Offside Rear Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
| Nearside Rear Direction indicator not working (4.4.1 (a) (ii)) | 1 |
| Steering wheel has movement relative to the column such that there is a serious risk of detachment (2.2.1 (a) (ii)) | 1 |
| Nearside Front Wheel bearing rough when rotated (5.1.3 (b) (i)) | 1 |
| Offside Front Wheel bearing rough when rotated (5.1.3 (b) (i)) | 1 |
| Driver`s seat fore and aft adjustment mechanism not functioning as intended. doesn`t lock |6.2.5 |b| |i|| | 1 |
| Driver`s seat backrest cannot be secured in the upright position. |6.2.5 |b| |ii|| | 1 |
| Front Wheel insecure x2 |4.2.A.1c| | 1 |
| Offside Rear Wheel insecure |4.2.A.1c| | 1 |
| Offside Front Service brake excessively binding (1.2.1 (f)) | 1 |
| Offside Front Drivers seat backrest cannot be secured in the upright position. (6.2.5 (b) (ii)) | 1 |
| Brake pedal anti-slip provision missing (1.1.2 (c)) | 1 |
| Offside Front Lower Suspension arm pin or bush excessively worn inner (5.3.4 (a) (i)) | 1 |
| Offside Track rod end ball joint has excessive play (2.1.3 (b) (i)) | 1 |
| Offside Front Wheel bearing has excessive play (5.1.3 (a) (i)) | 1 |
| Nearside Front Track rod end ball joint dust cover excessively damaged or deteriorated so that it no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |
| Nearside Front Power steering component leaking rack (2.1.5 (a)) | 1 |
| Emissions unable to be completed stopped and will not restart (8.2.1.2 (d)) | 1 |
| Brake performance unable to be tested not running (1.2.1 (g)) | 1 |
| Nearside Steering locking device ineffective (2.1.3 (d)) | 1 |
| Offside Rear Service brake excessively binding |1.2.1 |f|| | 1 |
| Nearside Rear Service brake excessively binding |1.2.1 |f|| | 1 |
| Central Front Speedometer cannot be illuminated (7.8 (c) (ii)) | 1 |
| Nearside Front Inner Suspension arm insecurely attached (5.3.3 (a) (i)) | 1 |
| Offside Front Inner Suspension arm insecurely attached (5.3.3 (a) (i)) | 1 |
| Nearside Front Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
| Offside Front Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
| Nearside Stop lamp not working |1.2.1b| | 1 |
| Nearside Rear position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
| Steering column top mounting bracket insecure |2.1.2d| | 1 |
| Nearside Steering rack insecure |2.2.B.1a| | 1 |
| Nearside Rear Brake hose porous (1.1.12 (e)) | 1 |
| Nearside Rear Service brake lagging in operation (1.2.1 (d)) | 1 |
| Nearside Front Front passenger door cannot be opened from outside the vehicle (6.2.3 (a)) | 1 |
| Position lamp adversely affected by the operation of another lamp Goes out when brake light activated (4.2.3 (c)) | 1 |
| Offside Rear Stop lamp(s) all not working (4.3.1 (a) (iii)) | 1 |
| Nearside Rear Service brake has no recorded effort at a wheel Foot brake (1.2.1 (a) (ii)) | 1 |
| Offside Front Brake hose bulging under pressure (1.1.12 (d)) | 1 |
| Offside Front Oil leaking excessively from engine (8.4.1 (a) (i)) | 1 |
| Offside Front Inner Electrical wiring likely to touch hot or rotating parts engine bay area (4.11 (a) (iii)) | 1 |
| Brake hose excessively deteriorated | 1 |
| Nearside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
| Offside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
| Parking brake lever has no reserve travel |3.1.6b| | 1 |
| Windscreen wiper not operating automatically when switched on |8.2.1b| | 1 |
| Offside Front Electrical wiring deteriorated and bare wires exposed next to screenwash bottle |1.9.2c| | 1 |
| Nearside Rear Sub-frame rubber bush bonding deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Rear Sub-frame rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Nearside Front Brake pipe inadequately supported |3.6.B.1| | 1 |
| Offside Front Headlamp aim so that beam "kick up" is not visible on the screen no pattern |4.1.2 |a|| | 1 |
| Nearside Front Suspension arm rubber mounting deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Front Suspension arm rubber mounting deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Nearside Front Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Offside Front Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Stop lamp not working |1.2.1b| | 1 |
| Offside Rear Lower Shock absorbers has an excessively worn bush (5.3.2 (c)) | 1 |
| Obligatory mirror missing central (3.3 (a)) | 1 |
| Nearside Windscreen wiper missing (3.4 (a)) | 1 |
| Offside Stop lamp(s) adversely affected by the operation of another lamp (4.3.3 (b)) | 1 |
| Boot lid corroded and likely to cause injury (6.2.1 (a) (i)) | 1 |
| Nearside Front Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced Chassis (6.1.1 (c) (i)) | 1 |
| Offside Front Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced floor (6.1.1 (c) (i)) | 1 |
| Steering wheel has movement relative to the column indicating looseness |2.2.1 |a| |i|| | 1 |
| Windscreen washer jets misaligned and not providing sufficient fluid to the windscreen |3.5 |a|| | 1 |
| Offside Front Suspension arm ball joint dust cover no longer prevents the ingress of dirt |5.3.4 |b| |ii|| | 1 |
| Nearside Front Drag link end ball joint has excessive play |2.1.3 |b| |i|| | 1 |
| Offside Front Drag link end ball joint has excessive play |2.1.3 |b| |i|| | 1 |
| Offside Rear Wheel bearing has excessive play |5.1.3 |a| |i|| | 1 |
| Offside Rear Direction indicator not working holder adrift (4.4.1 (a) (ii)) | 1 |